engine coolant BMW MOTORRAD K 1200 R 2004 Rider's Manual (in English)

i3Introduction
6 Maintenance ............. 87
Toolkit .......................... 89
Engine oil ..................... 89
Coolant ........................ 92
Brakes .......................... 93
Clutch .......................... 96
Wheels ......................... 98
Front-wheel stand ...... 107
Rear wheel stand ....... 108
Bulbs .......................... 109
Jump starting ............. 115
Battery ....................... 116
Spray guard ................ 120
7 Care ......................... 121
Cleaning and care ...... 122
Laying up ................... 124
Restoring to use ......... 125
8 Technical data ........ 127
Threaded fasteners .... 128
Tyre pressures ........... 130
Engine ........................ 131
Power transmission .... 132
Frame and suspension 133
Wheels and tyres ........ 135Fuel and lubricants ..... 136
Electrical system ......... 138
Dimensions and
weights ....................... 140
Riding specifications .. 141
9 Service ..................... 143
BMW Motorrad
service ........................ 144
Confirmation of
maintenance work ...... 147
Confirmation of
service ........................ 151
i Index ......................... 155

Status indicators222
Overview
The warnings are listed in the table below, along with the page numbers of the pages you can
refer to for more information. Light Symbol Meaning Explanations
Ignition key not authorised. (
b
24)
Low-beam headlight, high-beam
headlight, parking light or turn signal
lamp defective. (
b
26)
Defective lamp. (
b
26)
yellow Fuel reserve reached. (
b
24)
yellow Fault in the engine electronics. (
b
25)
yellow Rear light or brake light lamp
defective. (
b
26)
red Coolant temperature too high. (
b
24)
red Engine-oil pressure too low. (
b
25)

Status indicators224
Electronic immobiliser
(EWS)
Immobiliser symbol is
displayed.
The key being used is not
authorised for starting, or
communication between the
key and engine electronics is
disrupted.
• Remove all other vehicle keys from the same keyring
as the ignition key (
b
34).
• Use the reserve key.
• Have the defective key replaced, preferably by an
authorised BMW motorcycle
dealer (
b
36).
Fuel reserve
General warning light
lights up yellow.
Fuel reserve symbol is
displayed and flashes
10 times. The fuel tank contains a fuel
reserve of a maximum of
4 litres. The Tripmaster com-
puter shows the estimated
residual operating range
(b
38).
Lack of fuel can result in
the engine cutting out un-
expectedly and this could re-
sult in a hazardous situation.
Do not run the fuel tank dry. c
Lack of fuel can result in
misfiring and this in turn
could damage the catalytic
converter.
Do not run the fuel tank dry. c
•Refuel.
Coolant temperature
General warning light
lights up red.
Coolant temperature
indicator flashes
10 times.
Coolant temperature too high.
Continuing to ride with
the engine overheated
can result in engine damage.
You must comply with the in-
structions below. c
• Check coolant level, top up if necessary.
• If possible, ride in the part-
load range to cool down the
engine.
• In traffic jams, switch off the
engine, but keep the ignition
on so that the radiator fan
continues to operate.

687Maintenance
Toolkit ............................................ 89
Engine oil ...................................... 89
Coolant .......................................... 92
Brakes ........................................... 93
Clutch ............................................ 96
Wheels ........................................... 98
Front-wheel stand ...................... 107
Rear wheel stand ....................... 108
Bulbs ............................................ 109
Jump starting .............................. 115
Battery ......................................... 116
Spray guard ................................ 120Maintenance

Maintenance692
Coolant Checking coolant levelCheck the coolant level at reg-
ular intervals. 1 Display for coolant level
Check the coolant level in
coolant indicator 1.
2 Maximum coolant level
3 Minimum coolant level
The coolant level must be
between the MIN and
MAX marks.
If the coolant level is below the
MIN mark:
Top up the coolant.
Topping up coolant
Do not open the cooling
system while the engine
is hot, otherwise you may
scald yourself on the resultant
coolant steam. c
Remove the cap from cool- ant filler neck 1.
Add coolant.
Check the coolant level.
Repeat the filling and check-
ing procedure until the cool-
ant level is between the MIN
and MAX marks.

Indexi156
CCareCare products, 122
Chrome, 123
Paint, 123
Plastics, 123
Protective wax coating, 124
Radiator, 123
Rubber, 124
Touching up, 124
Washing the motorcycle, 122
Windscreen, 123
Cases Adapting, 84
Adjusting the volume, 86
Closing, 85
Correct loading, 83
Fitting, 83
Opening, 85
Removing, 84
Catalytic converter, safety
information, 54 Centre stand
Extending, 71
Retracting, 73
Checklist, 56
Clock Adjusting, 16
Display, 20
Setting, 39
Clutch Checking operation, 96
Checking the fluid level, 97
Fluid reservoir, 9
Coolant Checking the level, 92
Filler neck, 9
Temperature display, 20
Temperature gauge, 20
Temperature warning, 24
Topping up, 92
Currency, 5
EElectronic engine-management system
Tampering with control unit, 55
Electronic immobiliser Display, 24
Explanations, 35
Engine, 136
Engine electronics Warning indicator, 25
Engine oil
Checking the oil level, 11, 89
Draining off, 91
Technical data, 136
Topping up, 91
Warning indicator for oil
pressure, 25
Engine, technical data, 131
ESA Adjusting spring preload, 50
Adjusting the shock
absorbers, 49