light BMW MOTORRAD R 1150 R 2002 Rider's Manual (in English)

i
2
Introduction
General information and
controls
General view, left side ........... 4
General view, right side ......... 5
Cockpit ................................. 6
Telltale and warning lights ..... 7
Ignition switch and steering
lock .................................... 8-9
Left handlebar fitting ........... 10
Right handlebar fitting ......... 11
Hazard warning flashers ...... 12
Seat/helmet holder .............. 13
Seats ............................. 14-15
System case .................. 16-18Safety check
Checklist ............................. 19
Engine oil ....................... 20-21
Fuel ................................ 22-23
Handlebar levers ............ 24-25
Brake system -
general........................... 26-27
Brake system - without
BMW Integral ABS ......... 28-30
Brake system - with
BMW Integral ABS ......... 31-34
Clutch ................................. 35
Lights ............................. 36-39
Shock-absorber
adjustment .......................... 40
Suspension
spring preload ..................... 41
Wheels ........................... 42-43
Accessories and loads ... 44-45
Contents
10r28FUNbkg1.book Seite 2 Dienstag, 24. Januar 2006 9:31 09

3
i
Introduction
Starting – Riding – Parking
Your first journey ........... 46-47
Important notes ............. 48-49
Side stand ..................... 50-51
Centre stand ................. 52-53
Running in ..................... 54-55
Before you start ............. 56-57
Starting ......................... 58-59
Telltale and warning
lights ............................. 60-61
Riding, gear shifts.......... 62-63
Brake system
- general ........................ 64-65
Brake system - with
BMW Integral ABS......... 66-72
BMW Integral ABS
- Fault table ......................... 73Arrive safely
Reliability ........................74-75
Service worldwide ............... 76
Environmental protection .... 77
BMW rider's equipment ....... 78
BMW motorcycle
equipment ........................... 79
Training means extra
safety .................................. 80
Concluding thoughts ........... 81
Contents
10r28FUNbkg1.book Seite 3 Dienstag, 24. Januar 2006 9:31 09

1
General information and controls
4
1Main (high) beam headlight
(
b 36-39)
2 Driving light (
b 36-39)
3 Front suspension strut,
shock absorber adjustment
(
b 40)
4 Reservoir for clutch fluid
(
b 35)
5 Engine oil filler (
b 21)
6 Rear spring strut,
spring preload (
b 41)
OEOptional equipment
7Rear spring strut,
shock absorber adjustment
(
b 40)
8 Power socket, 12 V
Provision for connecting
additional equipment –
max. load 5 A
9 Primary spark plug, left
10 Secondary spark plug, left
11 Main stand
OE (b 52, 53)
12 Oil level sight glass, engine
(
b 21)
( ) Figure in brackets
bpage number with explanation
General view, left side
1243657
8910
1112
10r28FUNbkg1.book Seite 4 Dienstag, 24. Januar 2006 9:31 09

1
General information and controls
6
1Telltale and warning lights
(
b 7)
2 Speedometer
3 Odometer
4 Trip meter
5 Trip meter reset knob
6 Rev. counter (
b 62) 7
Warning light, fuel level/with
approx. 5 litres (1. 1 Imp. gal)
in reserve yellow
m
(
b 23, 60)
8 Warning light, engine oil
pressure red
p (b 60)
9 Ignition switch and steering
lock (
b 8)
( ) Figures in brackets bpage number
for description
321
7
45
8
6
9
Cockpit
10r28FUNbkg1.book Seite 6 Dienstag, 24. Januar 2006 9:31 09

1
General information and controls
7
1Telltale light, left turn indica-
tor repeater green
s
2 Warning light, battery
charge current red
r
(
b 61)
3 Telltale light, high (main)
beam blue
q
4Telltale light, neutral green
k (b 57)
5 Telltale light, right turn indi-
cator repeater green
t
( ) Figures in brackets bpage number
for description
6 Clock
Adjust by pressing with a
ballpoint pen or similar
object at
point A(minutes) or
point B (hours)
7 Warning light, general red
e (b 61)
8 Telltale light, Warning light
ABS
l OE (b 61)
OEOptional extra
* depending on national-market speci- fication
12435
8*7B6A
Telltale and warning lights
10r28FUNbkg1.book Seite 7 Dienstag, 24. Januar 2006 9:31 09

1
General information and controls
9
Ignition switch and steering lock
Key positions
d Warning:
Never turn the key to OFF or
I while riding the
motorcycle!
ON Operating position,
ignition, ligh ts and all
electrical circuits
switched on
R * Ignition and lights off,
steering lock disengaged
(handlebars can be turned
freely to left or right)
* The key can be removed in these
positions
• Turn the handlebars to full left lock.
e Attention:
Engage the steer ing lock with
the handlebars in this position
only.
OFF* Ignition and lights off,
steering locked
I**Parking light on,
steering locked
L Note:
Switch the parking light on
only for limited periods. Note
state of battery charge.
10r28FUNbkg1.book Seite 9 Dienstag, 24. Januar 2006 9:31 09

1
General information and controls
10
5
4
2
3
1
d Warning:
To prevent air from entering
the clutch system:
• Do not turn the fitting on the handlebar.
• Do not turn the handlebars
in the clamping blocks.
1 Cold start choke lever
(increased engine speed)
(
b 59)
2 Hazard warning flashers
switch (
b 12) 3
Horn button
4 Left turn indicator switch
•Press
– Turn indicators flash
To switch off:
• Press turn indicator cancel
switch 9
5 Headlight
FHigh (main) beam
GLow (dipped) beam
FHeadlight flasher
Left handlebar fitting
10r28FUNbkg1.book Seite 10 Dienstag, 24. Januar 2006 9:31 09

1
General information and controls
12
Hazard warning lights
L Note:
You cannot activate the hazard
warning flashers if the ignition is
switched off.
Do not use the hazard warning
flashers for longer than abso-
lutely necessary.
Note state of battery charge.
Switching on the hazard
warning lights:
• Switching on the ignition
– Hazard warning switch lights up • Operate hazard warning lights
switch 1
– Hazard warning lights in oper- ation
– The left/right flashing turn indicator repeater on the tell-
tale light panel (
b 7) flashes
• Switch off the ignition
– The hazard warning lights
continue to operate
– The light in the hazard warn- ing flasher switch goes out
Switching off the hazard
warning lights:
• Operate hazard warning lights switch 1
– Hazard warning lights switch off
– Left/right flashing turn indica- tor repeater on the telltale
light panel (
b 7) off
1
Hazard warning flashers
10r28FUNbkg1.book Seite 12 Dienstag, 24. Januar 2006 9:31 09

1
General information and controls
13A
B
2
1
D
Helmet holder
• Turn key in helmet/seat lock to position B.
• The helmet holder 2 is open
• Close the helmet holder by pressing it lightly into the hel-
met/seat lock until it engages
Removing cover of
stowage compartment:
• Turn the key in the helmet/seat lock to position A
•Cover 1 is released from its
holder •Remove cover
1 in direction
indicated by arrow C
– You now have access to the toolkit and the on-board doc-
umentation. You can also
remove the front seat
• Lift off the front seat in the direction indicated by arrow D
– You now have access to the fuses (
b Maintenance
Instructions, Chapter 2)
Seat/helmet holder
C
10r28FUNbkg1.book Seite 13 Dienstag, 24. Januar 2006 9:31 09

1
General information and controls
14
54
3
1
2
Locking cover of stowage
compartment:
e Caution:
When installing, make sure the
cover is firmly seated.
• Engage the front seat in catches 5 and 4 on left and
right and push it into guide 1• Push the cover to the rear into
lock 2 and engage the seat
holder 3 by
pressing it lightly
Seats
10r28FUNbkg1.book Seite 14 Dienstag, 24. Januar 2006 9:31 09