warning light BMW MOTORRAD R 1150 R 2002 Rider's Manual (in English)

i
2
Introduction
General information and
controls
General view, left side ........... 4
General view, right side ......... 5
Cockpit ................................. 6
Telltale and warning lights ..... 7
Ignition switch and steering
lock .................................... 8-9
Left handlebar fitting ........... 10
Right handlebar fitting ......... 11
Hazard warning flashers ...... 12
Seat/helmet holder .............. 13
Seats ............................. 14-15
System case .................. 16-18Safety check
Checklist ............................. 19
Engine oil ....................... 20-21
Fuel ................................ 22-23
Handlebar levers ............ 24-25
Brake system -
general........................... 26-27
Brake system - without
BMW Integral ABS ......... 28-30
Brake system - with
BMW Integral ABS ......... 31-34
Clutch ................................. 35
Lights ............................. 36-39
Shock-absorber
adjustment .......................... 40
Suspension
spring preload ..................... 41
Wheels ........................... 42-43
Accessories and loads ... 44-45
Contents
10r28FUNbkg1.book Seite 2 Dienstag, 24. Januar 2006 9:31 09

3
i
Introduction
Starting – Riding – Parking
Your first journey ........... 46-47
Important notes ............. 48-49
Side stand ..................... 50-51
Centre stand ................. 52-53
Running in ..................... 54-55
Before you start ............. 56-57
Starting ......................... 58-59
Telltale and warning
lights ............................. 60-61
Riding, gear shifts.......... 62-63
Brake system
- general ........................ 64-65
Brake system - with
BMW Integral ABS......... 66-72
BMW Integral ABS
- Fault table ......................... 73Arrive safely
Reliability ........................74-75
Service worldwide ............... 76
Environmental protection .... 77
BMW rider's equipment ....... 78
BMW motorcycle
equipment ........................... 79
Training means extra
safety .................................. 80
Concluding thoughts ........... 81
Contents
10r28FUNbkg1.book Seite 3 Dienstag, 24. Januar 2006 9:31 09

1
General information and controls
6
1Telltale and warning lights
(
b 7)
2 Speedometer
3 Odometer
4 Trip meter
5 Trip meter reset knob
6 Rev. counter (
b 62) 7
Warning light, fuel level/with
approx. 5 litres (1. 1 Imp. gal)
in reserve yellow
m
(
b 23, 60)
8 Warning light, engine oil
pressure red
p (b 60)
9 Ignition switch and steering
lock (
b 8)
( ) Figures in brackets bpage number
for description
321
7
45
8
6
9
Cockpit
10r28FUNbkg1.book Seite 6 Dienstag, 24. Januar 2006 9:31 09

1
General information and controls
7
1Telltale light, left turn indica-
tor repeater green
s
2 Warning light, battery
charge current red
r
(
b 61)
3 Telltale light, high (main)
beam blue
q
4Telltale light, neutral green
k (b 57)
5 Telltale light, right turn indi-
cator repeater green
t
( ) Figures in brackets bpage number
for description
6 Clock
Adjust by pressing with a
ballpoint pen or similar
object at
point A(minutes) or
point B (hours)
7 Warning light, general red
e (b 61)
8 Telltale light, Warning light
ABS
l OE (b 61)
OEOptional extra
* depending on national-market speci- fication
12435
8*7B6A
Telltale and warning lights
10r28FUNbkg1.book Seite 7 Dienstag, 24. Januar 2006 9:31 09

1
General information and controls
9
Ignition switch and steering lock
Key positions
d Warning:
Never turn the key to OFF or
I while riding the
motorcycle!
ON Operating position,
ignition, ligh ts and all
electrical circuits
switched on
R * Ignition and lights off,
steering lock disengaged
(handlebars can be turned
freely to left or right)
* The key can be removed in these
positions
• Turn the handlebars to full left lock.
e Attention:
Engage the steer ing lock with
the handlebars in this position
only.
OFF* Ignition and lights off,
steering locked
I**Parking light on,
steering locked
L Note:
Switch the parking light on
only for limited periods. Note
state of battery charge.
10r28FUNbkg1.book Seite 9 Dienstag, 24. Januar 2006 9:31 09

1
General information and controls
10
5
4
2
3
1
d Warning:
To prevent air from entering
the clutch system:
• Do not turn the fitting on the handlebar.
• Do not turn the handlebars
in the clamping blocks.
1 Cold start choke lever
(increased engine speed)
(
b 59)
2 Hazard warning flashers
switch (
b 12) 3
Horn button
4 Left turn indicator switch
•Press
– Turn indicators flash
To switch off:
• Press turn indicator cancel
switch 9
5 Headlight
FHigh (main) beam
GLow (dipped) beam
FHeadlight flasher
Left handlebar fitting
10r28FUNbkg1.book Seite 10 Dienstag, 24. Januar 2006 9:31 09

1
General information and controls
12
Hazard warning lights
L Note:
You cannot activate the hazard
warning flashers if the ignition is
switched off.
Do not use the hazard warning
flashers for longer than abso-
lutely necessary.
Note state of battery charge.
Switching on the hazard
warning lights:
• Switching on the ignition
– Hazard warning switch lights up • Operate hazard warning lights
switch 1
– Hazard warning lights in oper- ation
– The left/right flashing turn indicator repeater on the tell-
tale light panel (
b 7) flashes
• Switch off the ignition
– The hazard warning lights
continue to operate
– The light in the hazard warn- ing flasher switch goes out
Switching off the hazard
warning lights:
• Operate hazard warning lights switch 1
– Hazard warning lights switch off
– Left/right flashing turn indica- tor repeater on the telltale
light panel (
b 7) off
1
Hazard warning flashers
10r28FUNbkg1.book Seite 12 Dienstag, 24. Januar 2006 9:31 09

2
19
2
Safety check
Checklist
Use the safety checklist –
before every journey
Please perform the safety
check accurately. If your motor-
cycle needs any routine mainte-
nance, you can then attend to it
before the journey starts
(
b Maintenance Instructions),
or, for example have it carried
out by your authorised BMW
motorcycle dealer.
This is to ensure that your
motorcycle corresponds with
road-vehicle use and safety
laws.
Your vehicle must be in perfect
technical order: this is a basic
prerequisite for your safety and
the safety of other road users.
For this reason, check the
details in the following sections
before you start the journey:
– Engine oil level
–Fuel level
– Positions of the handlebar- lever fittings
– Brake fluid level
– Clutch fluid level
–Brakes – Warning lights and telltale
lights
–Lights
– Shock-absorber setting and spring preload
– Condition of wheels and tyres, tread depth and tyre
pressures
– Load, gross weight
– Check at regular intervals as described in the following
sections
(each time you stop for refuel-
ling):
– Engine oil level (every second or third time
you stop for refuelling):
– Brake pads
If you encounter any problems
or difficulties, it is always best to
contact your authorised BMW
Motorrad dealer.
He will provide the necessary
advice and assistance.
10r28FUNbkg1.book Seite 19 Dienstag, 24. Januar 2006 9:31 09

2
21
2
Safety check
MAXMIN1
2
• Check oil level at sight glass: MAX Upper edge
Ring marking
MIN Lower edge
Ring marking
– The difference between the two marks is approx. 0.5 litres
(0.88 Imp. pints)
• If necessary, unscrew the oil filler screw 2 and top up the
engine oil through the engine
oil filler 1
• Then retighten the oil filler screw 2
e Attention:
Warning light, engine oil pres-
sure red
p (b 6) indicates no
(or very little) oil pressure in
the lube-oil system; this light
must not be regarded as an oil
level check. Oil pressure
builds up after 1-2 seconds
and the warning light goes out
– the red engine oil pressure
warning light
p should remain
off while the engine is running.
Engine oil
BMW recommends Castrol
10r28FUNbkg1.book Seite 21 Dienstag, 24. Januar 2006 9:31 09

2
23
2
Safety check
1
•Refuel
– Refuel only with super (premium) grade fuel to
DIN 51607 standard or equiv-
alent, minimum octane
number 95 (RON) or
85 (MON)
• Close the fuel filler cap
Capacity
L Note:
The fuel gauge does not oper-
ate unless the ignition is
switched on.
– Usable tank capacity 20.4 litres (4.5 Imp. gal)
– When the reserve fuel quantity is reached
(approx. 5 litres/1.1 Imp. gal),
the yellow warning light 1
comes on
Fuel
10r28FUNbkg1.book Seite 23 Dienstag, 24. Januar 2006 9:31 09