CHEVROLET ASTRO CARGO VAN 2003 2.G Owners Manual

CHEVROLET ASTRO CARGO VAN 2003 2.G Owners Manual ASTRO CARGO VAN 2003 2.G CHEVROLET CHEVROLET https://www.carmanualsonline.info/img/24/8003/w960_8003-0.png CHEVROLET ASTRO CARGO VAN 2003 2.G Owners Manual
Trending: ESP, oil, transmission, service schedule, headrest, air suspension, trunk

Page 231 of 382

CHEVROLET ASTRO CARGO VAN 2003 2.G Owners Manual A. Windshield Washer Fluid
B. Engine Coolant
C. Engine Oil Dipstick
D. Transmission Dipstick
E. Engine Air Cleaner/Filter
F. Engine Oil Fill
G. Brake Master Cylinder Reservoir
H. Power Steering Fluid

Page 232 of 382

CHEVROLET ASTRO CARGO VAN 2003 2.G Owners Manual When to Add Engine Oil
If the oil is at or below the ADD line, then youll need to
add at least one quart of oil. But you must use the
right kind. This part explains what kind of oil to use.
For engin

Page 233 of 382

CHEVROLET ASTRO CARGO VAN 2003 2.G Owners Manual What Kind of Engine Oil to Use
Oils recommended for your vehicle can be identi®ed by
looking for the starburst symbol.
This symbol indicates that the oil has been certi®ed by
the American Petroleum

Page 234 of 382

CHEVROLET ASTRO CARGO VAN 2003 2.G Owners Manual As in the chart shown previously, SAE 5W-30 is the
only viscosity grade recommended for your vehicle.
You should look for and use only oils which have the
API Starburst symbol and which are also ident

Page 235 of 382

CHEVROLET ASTRO CARGO VAN 2003 2.G Owners Manual Driving under these conditions causes engine oil to
break down sooner. If any one of these is true for your
vehicle, then you need to change your oil and ®lter
every 3,000 miles (5 000 km) or 3 month

Page 236 of 382

CHEVROLET ASTRO CARGO VAN 2003 2.G Owners Manual Engine Cover
Removing the Engine Cover
1. Move both front seats as far back as they will go.
2. Remove the instrument panel extension by
removing the two nuts that secure it in place. The
nuts are loc

Page 237 of 382

CHEVROLET ASTRO CARGO VAN 2003 2.G Owners Manual 3. Remove the screws located near the top on each
side of the extension. Grasp the extension from
both sides and gently remove it.4. Disconnect the electrical connectors and set the
extension aside.
5

Page 238 of 382

CHEVROLET ASTRO CARGO VAN 2003 2.G Owners Manual 5. Grasp the top of the heater duct and pull down
gently to remove it.6. Loosen the two bolts on the engine cover. The
bolts are not supposed to come out of the cover,
only from the front of the dash.

Page 239 of 382

CHEVROLET ASTRO CARGO VAN 2003 2.G Owners Manual 8. Grasp the bottom of the cover and slide it rearward.
Then, lift it up and out of the vehicle.
If the seal does not release, use the pull strap on
the drivers side above the rear mount.
Reinstallin

Page 240 of 382

CHEVROLET ASTRO CARGO VAN 2003 2.G Owners Manual Engine Air Cleaner/Filter
SeeEngine Compartment Overview on page 5-14for
the location of the engine air cleaner/®lter.
When to Inspect the Engine Air
Cleaner/Filter
Inspect the engine air cleaner/®l
Trending: automatic transmission, adding oil, length, display, wheel size, change time, jacking