radiator CHEVROLET BLAZER 1998 2.G User Guide

Downloaded from www.Manualslib.com manuals search engine 1 Radiator Pressure Cap
lhrning the radiator pressure cap when the
engine and radiator are hot can allow steam and
scalding liquids
to blow out and burn you badly.
With the coolant recovery tank, you will almost
never have to add coolant at the radiator.
Never turn the radiator pressure cap
-- even a
little
-- when the engine and radiator are hot.
Add coolant mixture at the recovery tank, but be careful
not
to spill it.
- v:
You can be burned if you spill coolant on hot
engine parts. Coolant contains ethylene glycol,
and it will burn if the engine parts are hot
enough. Don’t spill coolant on
a hot engine.
I NOTICE:
Your radiator cap is a 15 psi (105 kPa)
pressure-type cap and must be tightly installed to
prevent coolant
loss and possible engine damage
from overheating. Be sure the arrows on the cap
line up with the overflow tube
on the radiator
filler neck.
6-26

Downloaded from www.Manualslib.com manuals search engine Thermostat
Engine coolant temperature is controlled by a thermostat
in the engine coolant system. The thermostat stops the
flow
of coolant through the radiator until the coolant
reaches a preset temperature.
Power Steering Fluid
When to Check Power Steering Fluid
It is not necessary to regularly check power steering
fluid unless
you suspect there is a leak in the system or
you hear an unusual noise.
A fluid loss in this system
could indicate a problem. Have the system inspected
and repaired.
How To Check Power Steering Fluid
When the engine compartment is cool, wipe the cap and
the top
of the reservoir clean, then unscrew the cap and
wipe the dipstick with a clean rag. Replace the cap and
completely tighten it. Then remove the cap again and
look at the fluid level
on the dipstick.
The level should be between
the ADD and FULL marks.
If necessary, add only enough fluid to bring the level up
1 to the proper range.
What to Use
To determine what kind of fluid to use, see
“Recommended Fluids and Lubricants” in the Index.
Always use the proper fluid. Failure to use the proper
fluid can cause leaks and damage hoses and seals.
6-27

Downloaded from www.Manualslib.com manuals search engine I Short Trip/City Maintenance Schedule I
99,000 Miles (165 000 km) (Continued)
0 Lubricate chassis co )on ts (or every 3 months, whichever occurs first).
0 Check readfront axle fluid level and add fluid as needed. Check constant
(See footnote
#.)
velocity
joints and axle seals for leaking. (See footnote **.)
100,000 Miles (166 000 km)
0 Inspect spark plug wires.
0 Replace spark plugs.
0 If you haven’t used your vehicle under severe service conditions listed
An Emission Control Service,
An Emission Control Service.
previously and, therefore, haven’t changed your automatic transmission
fluid, change both the fluid and filter. Manual transmission fluid doesn’t
require change.
An Emission Control Service.
0 Inspect Positive Crankcase Ventilation (PCV) valve.
150,000 Miles (240 000 km)
0 Drain, flush and refill cooling system (or every 60 months since last service,
whichever occurs first). See “Engine Coolant” in the Index for what
to use.
Inspect hoses. Clean radiator, condenser, pressure cap and neck. Pressure test
cooling system and pressure cap.
An Emission Control Service.
DATE
I MILEAGE ACTUAL I SERVICEDBY: I
DATE I
MILEAGE
7-26

Downloaded from www.Manualslib.com manuals search engine I Long Trip/Highway Maintenance Schedule
100,000 Miles (166 000 km)
0 Inspect spark plug wires.
0 Replace spark plugs.
0 If you haven’t used your vehicle under severe service conditions lis\
ted
An Emission Control Service.
An Emission Control Service.
previously and, therefore, haven’t changed your automatic tran\
smission
fluid, change both the fluid and filter. Manual transmission fluid doesn’t
require change.
An Emission Contrul Service.
0 Inspect Positive Crankcase Ventilation (PCV) valve.
150,000 Miles (240 000 km)
0 Drain, flush and refill cooling system (or every 60 months since last service,
whichever occurs first). See “Engine Coolant” in the Index for what to use.
Inspect hoses. Clean radiator, condenser, pressure cap and neck. Pressure test
the cooling system and pressure cap.
An Emission Control Service.
I DATE I
ACTUAL
I MILEAGE I SERVrCEDBy I
DATE I
I MILEAGE ACTUAL I SERVICEDBY I
7-38

Downloaded from www.Manualslib.com manuals search engine Part C: Periodic Maintenance
Inspections
Listed below are inspections and services which should
be performed at least twice a year (for instance, each
spring and fall).
You should let your dealer’s service
department
or other qualified service center do these
jobs. Make sure any necessary repairs are completed
at once.
Proper procedures to perform these services may be
found in a service manual. See “Service and Owner
Publications” in the Index.
Steering, Suspension and Front Drive Axle
Boot and Seal Inspection
Inspect the front and rear suspension and steering
system for damaged,
loose or missing parts, signs of
wear or lack of lubrication. Inspect the power steering
lines and hoses for proper hook-up, binding, leaks,
cracks, chafing, etc. Clean and then inspect the drive
axle boot seals for damage, tears or leakage. Replace
seals if necessary.
Exhaust System Inspection
Inspect the complete exhaust system. Inspect the body
near the exhaust system. Look for broken, damaged,
missing or out-of-position parts as well as open seams,
holes,
loose connections or other conditions which could
cause a heat build-up in the
floor pan or could let
exhaust fumes into the vehicle. See “Engine Exhaust” in
the Index.
Engine Cooling System Inspection
Inspect the hoses and have them replaced if they are
cracked, swollen or deteriorated. Inspect all pipes, fittings
and clamps; replace as needed. Clean the outside of the
radiator and air conditioning condenser.
To help ensure
proper operation, a pressure test of the cooling system and
pressure cap is recommended at least once a year.
Throttle System Inspection
Inspect the throttle system for interference or binding,
and for damaged or missing parts. Replace parts as
needed. Replace any components that have high effort
or excessive wear.
Do not lubricate accelerator and
cruise control cables.
7-43

Downloaded from www.Manualslib.com manuals search engine Odometer .................................... 2-67
Off-Road Driving
.............................. 4- 14
Off-Road Recovery
............................. 4- 11
Oil. Engine
.................................... 6-10
Opener. Garage
Door ....................... 2.47. 2.60
Ordering Owner and Service Publications
....... 8- 1 1. 8. 12
Outside Mirror ManualAdjust
............................... 2-45
Power Remote Control
......................... 2-45
Convex
..................................... 2-46
Overhead Console
.............................. 2-46
Overheating Engine
............................. 5- 12
Owner Checks and Services
....................... 7-39
Owner Publications
........................ 8- 1 1. 8- 12
Paint Spotting. Chemical
........................ 6-56
Park Automatic Transmission
....................... 2- 18
Shifting Into
................................. 2-23
Shifting Out of
............................... 2-26
AtNight
.................................... 2-12
Brake
...................................... 2-22
Brake Mechanism Check
....................... 7-42
Lots
....................................... 2-12
On Hills with a Trailer
......................... 4-49
Over Things That
Burn ........................ 2-27
Your Vehicle. Manual Transmission
.............. 2-26
Passing
....................................... 4-11
Passlock"
.................................... 2-12
Payload
....................................... 4-42
Periodic Maintenance Inspections .................. 7-43
Parking Power
Accessory Outlets
............................ 2-58
Door Locks ................................... 2-5
Remote Control Mirror
........................ 2-45
Steering
..................................... 4-9
Steering Fluid
................................ 6-27
Windows
................................... 2-31
Power Seat
..................................... 1-3
Lumbar Controls
.............................. 1-4
Pregnancy. Use of Safety Belts
.................... 1-22
Problems on the Road
............................ 5-1
Publications. Service and Owner
.............. 8- 1 1. 8- 12
Radiator. Adding Coolant
....................... 5-17
Radiator Pressure Cap
........................... 6-26
Radio Reception
................................ 3-28
Radios
AM-€34 Stereo .............................. 3-10
Cassette Tape Player
..................... 3- 12. 3. 15
Cassette Tape Player Care
................. 3.29. 7.39
Compact Disc Player
.......................... 3-20
Compact Disc Player Care
...................... 3-30
Remote Cassette Player
........................ 3-24
Setting the Clock
............................. 3-10
Theft-Deterrent Feature
........................ 3-26
Rain. Driving
.................................. 4-28
Rear RAP
......................................... 2-16
Axle
....................................... 6-21
Door Security Locks
........................... 2-5
Safety Belt
Comfort Guides ..................... 1-35
Seat Passengers
.............................. 1-32
Seats
........................................ 1-8
9-7