wheel CHEVROLET CAVALIER 1996 3.G Repair Manual
[x] Cancel search | Manufacturer: CHEVROLET, Model Year: 1996, Model line: CAVALIER, Model: CHEVROLET CAVALIER 1996 3.GPages: 372, PDF Size: 19.73 MB
Page 340 of 372

Downloaded from www.Manualslib.com manuals search engine Part C: Periodic Maintenance
Inspections
Listed below are inspections and services which should be
performed at least twice a year (for instance, each spring
and
fall). You should let your GM dealer’s service
department or other qualified service center do these jobs.
Make sure any necessary repairs are completed at once.
Proper procedures to perform these services may be
found
in a Chevrolet service manual. See “Service and
Owner Publications” in the Index.
Steering, Suspension and Front-Wheel-Drive
Axle
Boot and Seal Inspection
Inspect the front and rear suspension and steering system
for damaged, loose or missing parts, signs
of wear, or lack
of lubrication. Inspect the power steering lines and hoses
for proper hook-up, binding, leaks, cracks, chafing, etc.
Clean and then inspect the drive axle boot seals for
damage, tears or leakage. Replace seals
if necessary.
Exhaust System Inspection
Inspect the complete exhaust system. Inspect the body near
the exhaust system. Look for broken, damaged, missing or
out-of-position
parts as well as open seams, holes, loose
connections, or other conditions
which could cause a heat build-up in the floor pan or could let exhaust fumes into
the vehicle, See “Engine Exhaust”
in the Index.
Radiator and Heater Hose Inspection
Inspect the hoses and have them replaced if they are
cracked, swollen or deteriorated. Inspect all pipes,
fittings and clamps; replace as needed.
Throttle Linkage Inspection
Inspect the throttle linkage for interference or binding,
and for damage or missing parts. Replace parts as
needed. Replace any cables that have high effort or
excessive wear.
Do not lubricate accelerator and cruise
control cables.
Brake System Inspection
Inspect the complete system. Inspect brake lines and
hoses for proper hookup, binding, leaks, cracks, chafing, etc. Inspect disc brake pads for wear and rotors for
surface condition.
Also inspect drum brake linings for
wear and cracks. Inspect other brake parts, including
drums, wheel cylinders, calipers, parking brake, etc.
Check parking brake adjustment. You may need to have
your brakes inspected more often if your driving habits
or conditions result
in frequent braking.
7-42
Page 359 of 372

Downloaded from www.Manualslib.com manuals search engine 0 Section 9 Index
Adapter Kits. CD .............................. 3-16
AirBag
....................................... 1-19
How Does it Restrain
.......................... 1-23
How it Works
................................ 1-21
Location
.................................... 1-21
Readiness Light
......................... 1.20. 2.66
Servicing
................................... 1-24
What Makes
it Inflate .......................... 1-22
What Will You See After it Inflates
............... 1-23
When Should
it Inflate ......................... 1-22
Air Cleaner
.................................... 6- 15
Air Conditioning
................................ 3-4
Alignment and Balance. Tire
...................... 6-41
Aluminum Wheels. Cleaning
...................... 6-49
Antenna. Fixed
................................. 3-24
Anti-Lock Brake System Warning Light
................ 2.68. 4.6
Brakes
...................................... 4-6
Anti.Theft. Radio
.............................. 3-20
Antifreeze
..................................... 6-22
Appearance Care Materials
....................... 6-5 1
Air Conditioning Refrigerants ..................... 6-58
Appearancecare
............................... 6-43
Arbitration Program .............................. 8-7
Audio Equipment. Adding
........................ 3-23
Audio Systems
.................................. 3-7
Auto-Down Window
............................ 2-29
Automatic Overdrive
............................ 2-19
Automatic Transaxle Check
...................................... 7-39
Fluid
.................................. 6.17. 6.19
Operation
................................... 2-16
Park Mechanism Check
........................ 7-41
Shifting
..................................... 2-16
Startine Your Engine
.......................... 2-12
Ashtrays
...................................... 2-47
Battery
...................................... 6.3 1
Charging System Light ........................ 2-66
Jump Starting
................................. 5-2
Replacement. Keyless Entry
..................... 2-6
Saver
...................................... 2-43
Warnings
.................................... 5-2
BBB Auto Line
................................. 8-7
9-1
Page 360 of 372

Downloaded from www.Manualslib.com manuals search engine Better Business Bureau Mediation ................... 8-7
Brake Adjustment
.................................. 6-3 1
Master Cylinder ............................... 6-28
Parking
..................................... 2-23
System Warning Light
......................... 2-67
Fluid
....................................... 6-28
Pedal Travel
.................................. 6-3 1
Replacing System Parts ........................ 6-31
Trailer
...................................... 4-37
Transaxle Shift Interlock Check
.................. 7-40
Wear
....................................... 6-30
Brakes. Anti-Lock
............................... 4-6
Braking
........................................ 4-5
Braking in Emergencies
........................... 4-9
Break-In. New Vehicle
........................... 2-9
BTSICheck
................................... 7-40
Bulb Replacement
...... .................. 6-32. 6-57
Brightness Control
.............................. 2-41
Canadian Roadside Assistance
.................... 8-6
Capacities and Specifications
...................... 6-58
Carbon Monoxide
............... 2.27.2.28.4.28. 4.37
Cassette Deck Service
........................... 7-38
Cassette Tape Player ....................... 3.10. 3.12
Cassette Tape Player Care
........................ 3-24
CD Adapter Kits
............................... 3- 16
CD Player Theft-Deterrent Feature ................. 3-20
Center Console Storage Area
...................... 2-45
Center Rear Passenger Position
.................... 1-31
Certification Label
.............................. 4-32
Certificatiooire Label
.................. ; ....... 4-31
Chains. Safety
................................. 4-37
Chains. Tire
................................... 6-43
Changing a Flat Tire
............................. 5-21
Check Engine Light
............................. 2-71
CheckGagesLight
.............................. 2-75
CheckOilLight
................................ 2-74
Checking
Your Restraint Systems .................. 1-46
Chemical Paint Spotting
.......................... 6-50
Child Restraints
................................ 1-35
Securing in a Rear Outside Seat Position
........... 1-37
Securing
in the Center Rear Seat Position .......... 1-39
Securing
in the Passenger Seat Position ........... 1-40
Securing in the Right Front Seat Position
.......... 1-40
TopStrap
................................... 1-36
WheretoPut
................................ 1-35
Cigarette Lighter
............................... 2-47
Circuit Breakers
and Fuses ....................... 6-53
Cleaner. Air ................................... 6-15
Cleaning
...................................... 6-43
Aluminum Wheels
............................ 6-49
Convertible
Top .............................. 6-48
Fabric ...................................... 6-44
Glass
....................................... 6-47
9-2 .
Page 361 of 372

Downloaded from www.Manualslib.com manuals search engine Inside of Your Chevrolet ....................... 6-44
Instrument Panel
............................. 6-46
Outside of Your Chevrolet
...................... 6-47
Special Problems
............................. 6-45
Stains
...................................... 6-45
Tires
....................................... 6-49
Vinyl
....................................... 6-46
Wheels
..................................... 6-49
Windshield and Wiper Blades
................... 6-47
Climate Control System. Standard
................... 3-1
Climate Control System with Air Conditioning
......... 3-3
Clock. Setting the
................................ 3-7
Clutch. Hydraulic
............................... 6-21
Clutch Fluid. Hydraulic
.......................... 6-21
Comfort Controls
................................ 3- 1
Compact Disc Adapter Kits ....................... 3- 16
Compact Disc Care
............................. 3-24
Compact Disc Player
............................ 3- 16
Compact Disc Player Errors
....................... 3- 19
Compact Spare Tire
............................. 5-32
Control of a Vehicle
.............................. 4-5
Convenience Net ............................... 2-46
Convertible Top
Cleaning
.................................... 6-48
Lowering
................................... 2-49
Lowering Manually ........................... 2-57
Raising Manually
............................. 2-57
Raising
..................................... 2-53 Convex Outside Mirror
.......................... 2-45
Coolant
....................................... 6-22
Heater. Engine
............................... 2-14
Surge Tank Pressure Cap
....................... 6-25
Cooling System
................................ 5-17
Courtesy Transportation
........................... 8-6
Cruise Control
................................. 2-35
Cupholders
.................................... 2-46
Customer Assistance for Text Telephone Users
......... 8-3
Customer Assistance Information
................... 8-1
Customer Satisfaction Procedure
.................... 8-1
SurgeTank
.................................. 5-17
Damage. Finish
............................... 6-50
Damage. Sheet Metal
............................ 6-49
Daytime Running Lamps
......................... 2-40
Dead Battery
................................... 5-2
Defects. Reporting Safety
......................... 8-8
Defensive Driving
............................... 4-1
Defogger. Rear Window
.......................... 3-7
Defogging
..................................... 3-6
Defrosting
..................................... 3-6
Dimensions. Vehicle
............................ 6-60
DoorLocks
..................................... 2-3
Drive. Automatic Transaxle
....................... 2-18
DriverPosition
................................. 1-11
Dolby@ B Noise Reduction ....................... 3-15
Page 364 of 372

Downloaded from www.Manualslib.com manuals search engine Ignition Switch ................................ 2-10
Illuminated Entry
............................... 2-42
Inflation. Tire
.................................. 6-37
Inside Daymight Rearview Mirror
................. 2-43
Inspections
Brakesystem
................................ 7-42
Exhaust Systems
............................. 7-42
Front-Wheel-Drive Axle Boot
.................. 7-42
Front-Wheel-Drive Axle Seal
................... 7-42
Radiator and Heater Hose
...................... 7-42
Steering
.................................... 7-42
Suspension
.................................. 7-42
Throttle Linkage
.............................. 7-42
Instrument Panel
............................... 2-60
Brightness Control
............................. 2-4 1
Cleaning
.................................... 6-46
Cluster
................................ 2-62. 2-63
FuseBlock
.................................. 6-54
Interior Lamps
................................. 2-41
Jack. Tire
.................................... 5-21
Jump Starting
................................... 5-2
Key Lock Cylinders Service
..................... 7-39
Key Release Button
............................. 2- 11
Keyless Entry System ............................ 2-5
Keys .......................................... 2-1 Labels
.................................. 4.31. 6.52
Certification
................................. 4-32
CertificationEire
............................. 4-31
Service Parts Identification
..................... 6-52
Tire-Loading Information
...................... 4-31
Vehicle Identification Number
................... 6-52
Lamps
........................................ 2-39
Fog
........................................ 2-41
Interior
..................................... 2-41
On Reminder ................................ 2-39
Latches. Seatback
................................ 1-4
Leaving Your Vehicle
............................. 2-5
Leaving Your Vehicle with the Engine Running ....... 2-25
Lighter
....................................... 2-47
Lights Air Bag Readiness
....................... 1-20. 2-66
Anti-Lock Brake System Warning
............ 2-68. 4-6
Brake System Warning
......................... 2-67
Charging System
............................. 2-66
CheckEngine
................................ 2-71
CheckGages
................................ 2-75
CheckOil
.................................... 2-74
Enhanced Traction System Active
............ 2-69. 4-8
Enhanced Traction System Warning Light
..... 2-68. 4-9
ETS Active
.............................. 2-69. 4-8
ETS Warning
............................. 2-68. 4-9
Interior
..................................... 2-41
Low Coolant Warning
......................... 2-70
9-6
Page 367 of 372

Downloaded from www.Manualslib.com manuals search engine Replacement Bulbs
...................................... 6-57
Parts
....................................... 6-60
Wheel
...................................... 6-41
Replacing Safety Belts
........................... 1-46
Reporting Safety Defects
.......................... 8-8
Restraints Checking
................................... 1-46
Child
....................................... 1-35
Head
........................................ 1-4
Replacing Parts After a Crash
................... 1-46
Systemcheck
................................ 7-38
Reverse, Automatic Transaxle
..................... 2- 17
Reverse, Manual Transaxle
....................... 2-21
Right Front Passenger Position
.................... 1-25
Roadside Assistance
.............................. 8-4
Roadside Assistance, Canadian
..................... 8-6
Rocking Your Vehicle ........................... 5-33
Rotation, Tires
................................. 6-38
Safety Belt Extender
............................ 1-46
Safety Belts
.................................... 1-6
Adults
...................................... 1-11
Care
....................................... 6-46
Center Rear Passenger Position
.................. 1-3 1
Children .................................... 1-33
Driver Position
............................... 1 - 1 1
Extender
.................................... 1-46
How to Wear Properly
......................... 1 - 1 1
Incorrect Usage
.................... 1-15, 1-44, 1-45 Lap Belt
.................................... 1-3 1
Lap-Shoulder
........................... 1 . 1 1. 1-26
Larger Children
.............................. 1-43
Passenger Position
............................ 1-25
Questions and Answers
........................ 1 . 10
Rear Comfort Guides
.......................... 1-29
Rear Seat Outside Passenger Positions
............ 1-26
Rear Seat Passengers
.......................... 1-25
Reminder Light
.......................... 1.6. 2.65
Replacing After a Crash
........................ 1-46
Right Front Passenger Position
.................. 1-25
Shoulder Belt Height Adjuster
................... 1 . 14
Smaller Children and Babies
.................... 1-33
Use During Pregnancy
......................... 1-25
WhyTheyWork
............................... 1-7
Safety Chains
.................................. 4-37
Safety Defects. Reporting
......................... 8-8
Safety Warnings and Symbols ....................... vi
Scheduled Maintenance Services
.................... 7-3
Seatback
Latches
...................................... 1-4
Reclining Front
............................... 1-2
Easy Entry
................................... 1-4
ManualFront
................................. 1-1
Rear
........................................ 1-5
Restraint Systems
.............................. 1 . 1
Seat Controls
................................. 1-1
Securing a Child Restraint
...................... 1-36
Seats
Manual Lumbar Support
........................ 1-2
9-9
Page 368 of 372

Downloaded from www.Manualslib.com manuals search engine Second Gear. Automatic Transaxle ............ 2- 18. 2. 19
Second Gear. Manual Transaxle ................... 2-21
Security System
................................. 2-9
Service
........................................ 6-1
Bulletins. Ordering
............................. 8-9
Manuals. Ordering
............................. 8-9
Parts Identification Label
....................... 6-52
Publications. Ordering
.......................... 8-9
Work. Doing
Your Own ......................... 6- 1
Service and Appearance Care ...................... 6-1
Service and Owner Publications
.................... 8-9
Service Publications
.............................. 8-9
Servicing Your Air Bag-Equipped Chevrolet
......... 1-24
Sheet Metal Damage
............................ 6-49
Shift Lever
............................... 2- 16. 2-20
Shift Light
............................... 2-22. 2-75
Shiftspeeds
................................... 2-22
Shifting
Automatic Transaxle
.......................... 2- 16
Into Park (P)
................................. 2-24
OutofPUk
.................................. 2-26
Shifting. Manual Transaxle
....................... 2-20
Shoulder Belt Height Adjuster
..................... 1-14
Skidding
...................................... 4-14
Sound Equipment. Adding
........................ 3-23
Spare Tire. Compact
............................. 5-32
Specifications and Capacities
...................... 6-58
Specifications. Engine
........................... 6-59
SignalingTurns
................................ 2-31 Speech Impaired. Customer Assistance
............... 8-3
Speedometer
................................... 2-63
Stains. Cleaning
................................ 6-45
Starter Switch Check
............................ 7-39
Starting Your Engine
.................. 2.12.2.13. 2.14
Steam
........................................ 5-13
Steering
....................................... 4-9
Column Lock Check
.......................... 7-40
In Emergencies
............................... 4-11
Power
.................................. 4.9. 6.26
Tips
........................................ 4-10
Wheel. Tilt
.................................. 2-30
Storage Compartments
........................... 2-45
Storage. Vehicle
................................ 6-32
Stuck:
In Sand. Mud. Ice or Snow .................. 5-33
Sunvisors
.................................... 2-48
Sunroof
....................................... 2-48
Supplemental Restraint System
.................... 1 . 19
Surge
Tank. Coolant ............................. 5-17
Surge Tank Pressure Cap ......................... 6-25
Symbols. Vehicle
................................ viii
Tachometer
.................................. 2-64
Taillamp Bulb Replacement
....................... 6-34
TapePlayerCare
............................... 3-24
Theft
.......................................... 2-8
Theft-Deterrent Feature. CD Player
................ 3-20
SRS ......................................... 1-19
Page 369 of 372

Downloaded from www.Manualslib.com manuals search engine THEFTLOCK” ................................ 3-20
Thermostat
.................................... 6-26
Third Gear. Automatic Transaxle
................... 2- 19
Third Gear. Manual Transaxle
..................... 2-21
Tilt Steering Wheel
............................. 2-30
Time. Setting the
................................ 3-7
Tire Chains
.................................... 6-43
TireLoading
................................... 4-31
Tire-Loading Information Label
................... 4-3 1
Tires
......................................... 6-36
Alignment and Balance
........................ 6-41
BuyingNew
................................. 6-39
Chains
..................................... 6-43
Changing a Flat
.............................. 5-21
Cleaning
.................................... 6-49
Compact Spare
............................... 5-32
Inflation
.................................... 6-37
Inflation Check
............................... 7-38
Inspection and Rotation
........................ 6-38
Pressure
.................................... 6-37
Temperature
................................. 6-4 1
Traction
.................................... 6-40
Treadwe ar
................................... 6-40
Uniform Quality Grading
....................... 6-40
Used Replacement Wheel
...................... 6-42
Wear Indicators
.............................. 6-39
Wheel Replacement
........................... 6-41
When
It’s Time for New ....................... 6-39
Loading
.................................... 4-31 TopStrap
..................................... 1-36
Torque Lock
................................... 2-25
Torque, Wheel Nut
......................... 5-29, 6-58
Towing From the Front
............................... 4-29
From the Rear
............................... 4-31
Front
........................................ 5-9
Rear ....................................... 5-11
Recreational Vehicle
.......................... 4-29
Towing a Trailer
........................... 4-33. 4-40
Towing Your Vehicle
............................. 5-7
Towing Your Vehicle From the Front
............... 4-29
Towing Your Vehicle From the Rear
................ 4-31
Trailer Brakes
..................................... 4-37
Driving on Grades
............................ 4-39
Driving with
................................. 4-38
Hitches
..................................... 4-37
Maintenance When Towing
..................... 4-40
Parking on Hills
.............................. 4-39
Safety Chains
................................ 4-37
Tongueweight
............................... 4-36
Total Weight on Tires
.......................... 4-36
Towing
................................ 4-33, 4-40
Turnsignals
................................. 4-39
Weight
..................................... 4-35
Automatic
.............................. 6-17. 6-19
Manual
..................................... 6-19
Transaxle Fluid
9-11
Page 370 of 372

Downloaded from www.Manualslib.com manuals search engine Transmitters. Keyless Entry ........................ 2-5
Transportation. Courtesy .......................... 8-6
Trip Odometer ................................. 2-64
Trunk Lock ..................................... 2-7
TTYUsers ...................................... 8-3
Turn Signal and Lane Change Signals ............... 2-3 1
Turn SignaVMultifunction Lever ................... 2-30
Turn Signals When Towing a Trailer ................ 4-39
Underbody Flushing Service ..................... 7-41
Underbody Maintenance ......................... 6-50
Up-Shift Light ................................. 2-75
Vehicle
Control
...................................... 4-5
Damage Warnings .............................. vii
Dimensions
................................. 6-60
Identification Number ......................... 6-52
Loading .................................... 4-31
Storage ..................................... 6-32
Ventilation System ............................... 3-5
Visors. Sun .................................... 2-48
warning Devices ; .............................. 5-2
Warning Lights. Gages and Indicators ............... 2-65
Washer Fluid. Windshield ........................ 6-27
Washing Your Vehicle ........................... 6-47
Wheel Weatherstrips
.................................. 6-47
Alignment .................................. 6-41
Nut Torque ............................. 5-29. 6-58
Replacement ................................. 6-41
Used Replacement ............................ 6-42
Wrench ..................................... 5-21
Windows ..................................... 2-29
Auto-Down ................................. 2-29
Power ...................................... 2-29
Windshield Washer ............................. 2-34
Fluid ................................... 2-34. 6-27
FluidLevelCheck ............................ 7-38
Windshield Wiper .............................. 2-32
Blade Replacement ........................... 6-35
Fuse ....................................... 6-53
Winter Driving ................................. 4-25
Wiring. Headlamp .............................. 6-53
WreckerTowing ................................. 5-7
Wrench. Wheel ................................. 5-21
9-12