heating CHEVROLET CAVALIER 1997 3.G User Guide

Downloaded from www.Manualslib.com manuals search engine How to Check
You do not need to check the fluid level unless you
suspect
a clutch problem. To check the fluid level, take
the cap
off. If the fluid reaches the step inside the
reservoir, the fluid level
is correct.
Engine Coolant
The cooling system in your vehicle is filled
with DEX-COOL@ engine coolant. This coolant
is designed to remain in your vehicle for
5 years or
150,000 miles (240 000 km), whichever occurs first,
if you add only DEX-COOL@ extended life coolant.
The following explains your cooling system and how to add
coolant when it is low.
If you have a problem with engine
overheating, see “Engine Overheating”
in the Index.
A 50/50 mixture of water and DEX-COOL@ coolant will:
0 Give freezing protection down to -34°F (-37°C).
0 Give boiling protection up to 265 “F (129°C).
0 Protect against rust and corrosion.
0 Help keep the proper engine temperature.
Let the warning lights and gages work as
they should.
NOTICE:
I
When adding coolant, it is important that you
use only
DEX-COOL@ (silicate-free) coolant.
If coolant other than
DEX-COOL’ is added
to the system, premature engine, heater core or
radiator corrosion may result. In addition, the
engine coolant will require change sooner
-- at
30,000 miles (50 000 km) or 24 months, whichever
occurs
first. Damage caused by the use of coolant
other than
DEX-COOL@ is not covered by your
new vehicle warranty.

Downloaded from www.Manualslib.com manuals search engine Adding Coolant
If you need more coolant, add the proper DEX-COOL@
coolant mixture at the surge tank, but only when the
engine
is cool.
~~
A CAUTION:
You can be burned if you spill coolant on hot
engine parts. Coolant contains ethylene glycol,
and it will burn
if the engine parts are hot
enough. Don’t spill coolant
on a hot engine.
When replacing the pressure cap, make sure it is tight.
Surge Tank Pressure Cap
NOTICE:
Your surge tank cap is a 15 psi (105 kPa)
pressure-type cap and must be tightly installed
to
prevent coolant loss and possible engine damage
from overheating.
When you replace your surge tank pressure cap,
a
GM cap is recommended.
Thermostat
Engine coolant temperature is controlled by a thermostat
in the engine coolant system. The thermostat stops the
flow of coolant through the radiator until the coolant
reaches a preset temperature.
When you replace your thermostat, an
AC@ thermostat
is recommended.

Downloaded from www.Manualslib.com manuals search engine Windshield Wiper Blade Replacement
Replacement blades come in different types and are
removed in different ways. For the proper type and
length, see “Capacities and Specifications” in the Index.
Here’s how to remove the Sheppard’s Hook type:
1. Pull the windshield wiper arm away from
the windshield.
2. Push the release lever and slide the wiper assembly
3. Install a new blade by reversing Steps 1 and 2.
toward the driver’s side of the vehicle.
Tires
Your new Chevrolet comes with high-quality tires
made by
a leading tire manufacturer. If you ever have
questions about your tire warranty and where to obtain
service, see your Chevrolet Warranty booklet for details.
I A CAUTION:
Poorly maintained and improperly used tires
are dangerous.
Overloading your tires can cause
overheating as
a result of too much friction.
You could have an air-out and a serious
accident. See “Loading
Your Vehicle” in
the Index.
CAUTION: (Continued)

Downloaded from www.Manualslib.com manuals search engine Driving City
........................................ 4-21
Defensive
.................................... 4-2
Drunken
..................................... 4-2
Freeway
.................................... 4-22
InaBlizzard
................................. 4-28
In Foreign Countries
........................... 6-5
In the Rain
.................................. 4- 18
Night
...................................... 4-16
OnCurves
.................................. 4-10
On Grades While Towing a Trailer
............... 4-42
On Hill and Mountain Roads
.................... 4-24
OnSnowandIce
............................. 4-27
Throughwater
............................... 4-20
WetRoads
.................................. 4-18
Winter
...................................... 4-26
With a Trailer
................................ 4-40
DrunkenDriving
................................ 4-2
Easy Entry Seat ................................ 1-6
Electrical Equipment. Adding ...... 2-15.2-16.3-23. 6-58
Electrical System
............................... 6-58
Engine
.................................. 6-10. 6-11
Coolant
..................................... 6-25
Coolant Heater
............................... 2- 17
Coolant Level Check
.......................... 7-41
Coolant Temperature Gage
..................... 2-72
Exhaust
..................................... 2-30
Fuse Block
.................................. 6-62
Identification
................................ 6-58
OilLevelCheck
.............................. 7-41
Overheating
................................. 5-14
Running While Parked
......................... 2-31 Specifications
................................ 6-64
Starting Your
...................... 2.14.2.15. 2.16
Engineoil
.................................... 6-12
Adding
..................................... 6-13
Additives
................................... 6-16
Checking
................................... 6-13
Used
....................................... 6-16
What
To Use ................................. 6-14
When to Change
.............................. 6-16
Enhanced Traction System Operation
................ 4-9
Enhanced Traction System Active Light
......... 2.72. 4.9
Enhanced Traction System Warning Light
....... 2.71. 4.9
Ethanol
........................................ 6-5
ETS Active Light ........................... 2.72. 4.9
ETS Warning Light
......................... 2.71. 4.9
Exhaust. Engine
................................ 2-30
Fabric Cleaning
............................... 6-49
Fifth Gear. Manual Transaxle
..................... 2-24
Filling Your Tank ................................ 6-6
Filter. Air
..................................... 6-17
Finishcare
.................................... 6-53
Finish Damage
................................. 6-56
First Gear. Automatic Transaxle
.............. 2.21. 2.23
First Gear. Manual Transaxle
...................... 2-24
Flashers. Hazard Warning
......................... 5-2
Flat Tire. Changing
............................. 5-23
Fluids and Lubricants
............................ 7-48
FOgLmps
.................................... 2-43
Foreign Countries. Fuel
........................... 6-5
Fourth Gear. Manual Transaxle .................... 2-24
French Language Manual
11 1. ...........................
Front Reading Lamps ............................ 2-45

Downloaded from www.Manualslib.com manuals search engine FrontTowing .................................. 5-10
Fuel .......................................... 6-3
Filling Your Tank
.............................. 6-6
Gage ....................................... 2-78
In Foreign Countries
........................... 6-5
Fuses and Circuit Breakers ....................... 6-59
Gages Engine Coolant Temperature
.................... 2-72
Fuel
....................................... 2-78
Speedometer
....................... 2-64.2-65. 2.66
Tachometer
............................. 2.65. 2.67
GAWR
....................................... 4-34
Gear Positions. Automatic Transaxle
................ 2- 19
Gear Positions. Manual Transaxle
.................. 2-23
Gross Axle Weight Rating
........................ 4-34
Gross Vehicle Weight Rating
...................... 4-34
Guide en Frangais
11 .. .................................
GVWR ....................................... 4-34
Halogen Bulbs
................................ 6-35
Hazard Warning Flashers
.......................... 5-2
Head Restraints
................................. 1-5
Headlamps .................................... 2-42
Bulb Replacement
............................ 6-36
High/Low Beamchanger
...................... 2-35
OnReminder
................................ 2-42
Wiring
..................................... 6-59
Hearing Impaired. Customer Assistance
.............. 8-4
High-Beam Headlamps
.......................... 2-35
Highway Hypnosis
.............................. 4-24
Hill and Mountain Roads
......................... 4-24
Heating
........................................ 3-5 Hitches.
Trailer 4-39
Hood Checking Things Under
......................... 6-8
Release ...................................... 6-8
Hydraulic Clutch ............................... 6-24
Fluid
....................................... 6-24
..
.................................
Prop ........................................ 6-9
Horn ......................................... 2-32
System Check
................................ 7-42
Hydroplaning
.................................. 4-20
Ignition Positions
.............................. 2-12
Ignition Transaxle Lock Check
.................... 7-44
Inflation, Tire
.................................. 6-41
Inside Daymight Rearview Mirror
................. 2-46
Inspections Brakesystem
................................ 7-47
Caliper/Knuckle
.............................. 7-47
Exhaust Systems
............................. 7-46
Front-Wheel-Drive Axle Boot
.................. 7-46
Front-Wheel-Drive Axle Seal
................... 7-46
Radiator and Heater Hose
...................... 7-46
Steering
.................................... 7-46
Suspension
.................................. 7-46
Throttle Linkage
.............................. 7-46
InstrumentPanel
............................... 2-62
Brightness Control
............................ 2-44
Cleaning
.................................... 6-51
Cluster
................................ 2-64, 2-65
FuseBlock
.................................. 6-60
Interior Lamps ................................. 2-44
Bulb Replacement ............................ 6-39
Illuminated Entry
............................... 2-44
Installing the Boot
.............................. 2-52
9-5

Downloaded from www.Manualslib.com manuals search engine Maintenance. Underbody ......................... 6-56
Maintenance When Trailer Towing
................. 4-43
Malfunction Indicator Lamp
...................... 2-73
Manual Front Seat
............................... 1-2
Manual Lumbar Support
.......................... 1-3
Manual Remote Control Mirror .................... 2-47
Manual Transaxle Check
...................................... 7-42
Fluid
....................................... 6-22
Gear Positions
............................... 2-23
Operation
................................... 2-23
Shifting
..................................... 2-23
Starting Your Engine
.......................... 2-14
Methanol
...................................... 6-5
Mirrors
....................................... 2-46
Convex Outside
.............................. 2-48
Inside Daymight Rearview
..................... 2-46
Manual Remote Control
........................ 2-47
Power Remote Control
......................... 2-47
MountainRoads
................................ 4-24
Multifunction Lever
............................. 2-33
Neutral. Automatic Transaxle
.................... 2-20
Neutral. Manual Transaxle
........................ 2-24
New Vehicle “Break-In”
......................... 2-12
Nightvision
................................... 4-17
Odometer
.................................... 2-66
Odometer. Trip
................................. 2-66
Off-Road Recovery
............................. 4- 12
Oil. Engine
.................................... 6-12
Oil Pressure Warning Light
....................... 2-76
Overdrive. Automatic Transaxle
................... 2-22 Overheating Engine
............................. 5-14
Owner Checks and Services
....................... 7-41
Owner Publications. Ordering
..................... 8-12
Paint Spotting. Chemical
........................ 6-56
Park
Automatic -:ansaxle
.......................... 2-19
Shifting Into
................................. 2-27
Shifting Out of
............................... 2-29
Parking AtNight
.................................... 2-11
Brake
...................................... 2-26
Brake Mechanism Check
....................... 7-45
Lots
....................................... 2-11
Over Things That Burn
........................ 2-30
With a Trailer
................................ 4-42
Your Vehicle. Manual Transaxle
................. 2-29
Passenger Position
.................... 1-22. 1-28. 1-33
Passing
....................................... 4-13
With a Trailer ................................ 4-40
Passlock
” .................................... 2-11
Periodic Maintenance Inspections
.................. 7-46
Power
DoorLocks
................................... 2-5
Option Fuses
................................ 6-59
Remote Control Mirror
........................ 2-47
Steering
............................... 4.10. 6.29
Windows
................................... 2-32
Pregnancy. Use of Safety Belts
.................... 1-21
Problems on the Road
............................ 5-1
Publications. Service and Owner
................... 8-12
Passlock”
Warning Light
........................ 2-77
Steering Fluid
................................ 6-29
9-7