door lock CHEVROLET COLORADO 2021 Duramax Diesel Supplement

Chevrolet/GMC 2.8L Duramax Diesel Engine Supplement (GMNA-Localizing-
U.S./Canada-14465442) - 2021 - CRC - 2/3/20
Driving and Operating 23
Filling the DEF Tank
DEF Fill–Van Model Shown, 4-Cylinder
Pickups Similar
The blue DEF cap is behind the fuel/DEF
door. Do not remove the fuel and DEF caps
at the same time. Fill diesel fuel and DEF
independently. Turn the DEF cap
counterclockwise to remove.
In cold conditions DEF can freeze in the DEF
fill pipe opening. If this prevents the filling
of the DEF tank, place the vehicle in a warm
garage overnight.
Fill the DEF tank on level ground and with
the vehicle off. When adding DEF, it is
recommended to fully fill the DEF tank. For DEF tank capacity see
Capacities and
Specifications 082. When adding DEF to an
empty or very low tank, always add at least
7.5L (2 gal) of fluid to release the vehicle
from speed limitation.
When fluid reaches the top of the DEF fill
pipe, stop filling. Do not top off the DEF
tank. If using a bottle or jug to refill DEF,
follow the instructions on the container
label and use a dedicated fill aid.
Caution
Do not overfill the DEF tank and do not
allow DEF to contact the finished surfaces
of the vehicle, as it could damage the
vehicle finish. If DEF is spilled during
filling, wipe any affected surface with a
damp cloth.
Make sure the cap is fully installed.
Push the fuel/DEF door closed.
DEF Low
As the DEF level drops, warnings will
automatically be displayed in the Driver
Information Center (DIC). Select Vehicle
Information in the DIC to view DEF level
status. See Driver Information Center (DIC)
0 10. Refill the DEF tank at the first opportunity
after a low warning indication to avoid
vehicle speed limitations.
It may take some time for the vehicle to
detect that DEF has been added. If there
was a vehicle speed limitation, it will be
removed gradually and it may take several
kilometers/miles for the DIC message to
update.
If DEF is added under freezing conditions,
especially if DEF level is low and frozen, up
to several hours of drive time may be
required to remove the speed limitation.
It is recommended to ensure the DEF tank
level is 30% or higher during winter time.
The DEF range DIC message first displays at
approximately 1 600 km (1,000 mi). This
message appears again at approximately
500 km (300 mi) of remaining range before
the exhaust fluid tank becomes empty.
As the fluid level nears empty, these
messages appear every time the vehicle is
started.
If the DEF low warnings are ignored and the
DEF tank becomes empty, the DIC will
display messages that describe the action
needed and distance until vehicle speed is

Chevrolet/GMC 2.8L Duramax Diesel Engine Supplement (GMNA-Localizing-
U.S./Canada-14465442) - 2021 - CRC - 2/3/20
Driving and Operating 33
The green fuel cap is behind a hinged door
on the driver side of the vehicle. The blue
Diesel Exhaust Fluid cap is also behind the
fuel door. Do not remove both caps at the
same time.
Turn the fuel cap counterclockwise to
remove. When refueling, hang the fuel cap
from the hook on the fuel door. Fully insert
and latch the fill nozzle, begin fueling.
{Warning
Overfilling the fuel tank by more than
three clicks of a standard fill nozzle may
cause:
.Vehicle performance issues, including
engine stalling and damage to the fuel
system.
.Fuel spills.
.Under certain conditions, fuel fires.Diesel fuel can foam when filling the tank.
The automatic pump nozzle may shut off,
even if the tank is not full. Wait for the
foaming to stop, and then fill the tank more
slowly. Be careful not to spill fuel. Wait
five seconds after pumping before removing
the fill nozzle. Clean fuel from painted
surfaces as soon as possible. See
Exterior
Care 071.
Reinstall the cap by turning it clockwise
until it clicks. Push the fuel door closed.
{Warning
If a fire starts while you are refueling, do
not remove the fill nozzle. Shut off the
flow of fuel by shutting off the pump or
by notifying the station attendant. Leave
the area immediately.
Caution
If a new fuel cap is needed, be sure to
get the right type of cap from your
dealer. The wrong type of fuel cap may
not fit properly and could damage the
fuel system.
Accidental Refueling with Gasoline
Caution
If the vehicle is accidentally refueled with
gasoline, do not continue driving the
vehicle except to get to a location where
it can be stopped safely. Driving the
vehicle will damage the engine. Tow the
vehicle for service. Have the gasoline
removed from the tank and fuel system.