battery CHEVROLET CORVETTE 1996 4.G Owner's Manual

Downloaded from www.Manualslib.com manuals search engine 7. Don't let the other end
touch metal. Connect
it to the positive
(+)
terminal of the good
battery. Use a remote
positive
(+) terminal if
the vehicle has one.
I
8. Now connect the black
negative
(-) cable to
the good battery's negative
(-) terminal.
Don't let the other end
touch anything until the
next step.
9.
10.
The other end of the negative cable doesn't go to
the dead battery. It goes to a heavy, unpainted metal
part on the engine of the vehicle with the dead
battery. Attach the cable at least
18 inches (45 cm)
away from the dead battery, but not near engine
parts that move. The electrical connection is
just as
good there, but the chance of sparks getting back to
the battery is much less.
Now start the vehicle with the good battery and run
the engine for a while.
5-5

Downloaded from www.Manualslib.com manuals search engine 11. Try to start the vehicle with the dead battery.
If it won’t start after a few tries, it probably
needs service.
12. Remove the cables in reverse order to prevent
electrical shorting. Take care that they don’t touch
each other or any other metal.
I
AI
A. Heavy Metal Engine Part
B. Good Battery
C. Dead Battery
Towing Your Vehicle
Try to have a Chevrolet dealer or a professional towing
service tow your Corvette. They can provide the right
equipment and know how to tow your vehicle without
damage. See “Roadside Assistance” in the Index.
If your vehicle has been changed or modified since it
was factory new by adding aftermarket items like fog
lamps, aero skirting, or special tires and wbeels, these
instructions and illustrations may not be cbrrect.
Before you do anything, turn on the hazard
warning flashers.
When you call, tell the towing service:
That your vehicle cannot be towed from the rear with
That your vehicle has rear-wheel drive.
The make, model and year of your vehicle.
Whether you can still move the shift lever.
If there was an accident, what was damaged.
When the towing service arrives, let the tow operator
know that this manual contains detailed towing
instructions and illustrations. The operator may want to
see them.
sling-type equipment.
5-6

Downloaded from www.Manualslib.com manuals search engine LT1 Engine Shown, LT4 Engine Similar You’ll
see the following when you open the hood with
the
LT1 engine:
A. Hydraulic Clutch Fluid Reservoir
(if equipped)
B. Brake Fluid Reservoir
C. Battery
D. Electric Engine Fan
E. Air Cleaner
E Coolant Recovery Tank
G. Power Steering Fluid Reservoir
H. Engine Oil Fill Cap
I. Engine Oil Dipstick
J. Coolant High Fill Reservoir
K. Automatic Transmission Dipstick (if equipped)
L. Windshield Washer Fluid Reservoir
6-8

Downloaded from www.Manualslib.com manuals search engine When to Check and What to Use How To Check and Add Fluid
The clutch master cylinder is under the Powertrain
Control Module (PCM) in the left rear area of the engine
compartment.
To check the fluid, look at the area between the PCM
and the battery.
To add fluid, remove the PCM unit.
I
1
Refer to the Maintenance Schedule to determine how
often you should check the fluid level in your clutch
master cylinder reservoir and for the proper fluid. See
“Owner Checks and Services” and “Recommended
Fluids and Lubricants” in the Index.
You must loosen and remove the two screws before the
PCM unit will lift out.
6-23

Downloaded from www.Manualslib.com manuals search engine Replacing Brake System Parts
The braking system on a modern vehicle is complex.
Its many parts have to be of top quality and work well
together if the vehicle is to have really good braking.
Vehicles we design and test have top-quality GM brake
parts in them, as your Corvette does when it
is new.
When you replace parts of your braking system
-- for
example, when your brake linings wear down and you
have to have new ones put in
-- be sure you get new
genuine GM replacement parts. If you don’t, your
brakes may no longer work properly. For example, if
someone puts in brake linings that are wrong for your
vehicle, the balance between your front and rear brakes
can change
-- for the worse. The braking performance
you’ve come to expect can change in many other ways if
someone puts in the wrong replacement brake parts.
Battery
Every new Corvette has a Delco Freedom’ battery. You
never have to add water to one of these. When it’s time
for a new battery, we recommend a Delco Freedom
battery. Get one that has the replacement number shown
on the original battery’s label. For battery replacement,
see your dealer
or the Corvette Service Manual. To
purchase a service manual, see “Service and Owner
Publications” in the Index.
Vehicle Storage
If you’re not going to drive your vehicle for 25 days
or more, take
off the black, negative (-) cable from
the battery. This will help keep your battery from
running down.
Batteries have acid that can burn you and gas
that can explode. You can be badly hurt if
you
aren’t careful. See “Jump Starting” in the Index
for tips on working around a battery without getting hurt.
Contact your dealer to learn how to prepare your vehicle
for longer storage periods.

Downloaded from www.Manualslib.com manuals search engine t'
1c 7 21 7 3c 7 4c 7 5c 7 NC MDL BTSI WIPER RDO IGN. HTD MIR CIRCUIT
6C 7 71. 7 8C 7 9c 71oc 7 TAIL HORN STOP/HAZ CRANK CRANK
CLUTCH AIR BAG P/N
11c 7 12c 7 131 7 l4C 7 151 7
15c 7 171 7 18C 7 19c 7c 7
RH ILLUM LH ILLUM CNSL ILLUM F.P. 1 A/TRANS
CCMB GENERATOR A/C UTlLllY OXYGEN SEN
CLUTCH
ZC 7=c 7 =C 724c 725c 7
=c 727c 728C 7c 7c 7
ENG2 lNJl INJ 2 TURN COIL
P.K.E. CLUSTER BACKUP FAN ENG
1
31c 7-c 7=c 7c IbC 7
=E 7 37c 7 =c 7 391 74oc 7
4lC 742C 7C JC 7
PWR MIRROR CRUISE E.C.M. AIR BAG CCMl
RHCTSY LHCTSY L.C.D. CCMP RDOBATT
SPORT SEAT PWR LOCK NC PROG CIGAR HATCH
BREAKERS

ml
POWER SEAT
Two maxi -fuse blocks
are located under hood
near battery.
POWER WINDOW
N
P
6-66

Downloaded from www.Manualslib.com manuals search engine Fuse
26 27
28
29
30
31
32
33
Usage
Passive Keyless Entry Module
Instrument Cluster, Driver
Information Center, Air Bag System
Back-up Lamps Switch,
Transmission Position Switch,
One to Four Shift Solenoid
Cooling Fan Relay Coil #1
, 2,3
Canister Purge Solenoid, EGR
Circuit (LTl), Mass Airflow
Sensor, One to Four Shift Relay,
Brake Switch (Automatic), Air
Pump Relay
Power Mirror Adjuster Control,
Lighted Rearview Mirror, Visor
Vanity Mirrors
Cruise Control Engage Switch,
Daytime Running Lamps Module,
Low Tire Pressure Warning
Module, Cruise Control Cut-off
Relay
Engine Control Module
Fuse
34
35
36
37
38
39
40
41 42
43
Usage
Air Bag System
Central Control Module
Footwell Courtesy Lamps, Door Courtesy Lamps, Glove
Compartment Lamps, Lighted
Rearview Mirror
Bose Amplifier Relay, Power
Antenna Relay, Cargo Compartment Lamps
Instrument Cluster, Tone
Generator, Dome Lamp Relay
Central Control Module
Radio Receiver (Battery), Radio
Control Head, Passive Keyless
Entry Module
Sport Seats
Power Door Lock Switches,
Driver Information Center, Passive Keyless Entry Module
Heater and A/C Programmer
6-68

Downloaded from www.Manualslib.com manuals search engine Underhood Lamps Fuse
Your Corvette has one
I single fuse underhood for
the underhood lamps.
The
fuse is under the hood on
the driver’s sidemarker
lamp assembly.
Leaving your
hood open and your underhood lamps on
can
drain your battery. If you need to keep the hood
open for an extended period of time, remove the
underhood lamps fuse.
Ride Control Fuse
Vehicles equipped with the
optional Real Time
Damping ride control
system are fuse protected
with a fuse located in the
ABS compartment behind
the driver’s seat.
To access this fuse, pull back the carpet, remove the
screw and lift the cover.
6-72

Downloaded from www.Manualslib.com manuals search engine Replacement Parts
Air Cleaner Filter ..................................................... A 1097C
GM Part
No. 25096933 or equivalent
Battery
.............................................................. 75B-72
Coolant High Fill Reservoir Cap
........................................... RC27
15 psi (105 kPa)
GM Part
No. 6410782 or equivalent
Crankcase Ventilation Valve
........................................... CV895C
Engine Oil Filter
....................................................... PF52
GM Part
No. 25010908 or equivalent
Flat Ratchet Wrench (Convertible Hardtop
Only) ...... GM Part No. 101 37741 or equivalent
PCV Valve
.................................................. AC Type CV895C
Serpentine Belt
................................ GM Part No. 10230259 or equivalent
Spark Plug
............................................ .4 1-943 (0.050 inch Gap)
GM Part
No. 5614244 or equivalent
Thermostat
................................... GM Part No. 10223370 or equivalent
Tom@ Wrench
................................ GM Part No. 1017231 1 or equivalent
Windshield Wiper Blade Length
...................... .......................... 20 inches (508 mm)
Type ................................................. 0.'25 inch (6.35 mm) pin
Wheel Nuts
Wheel Nut Torque .......... ......... ................... 100 lb-ft (140 N-m)
6-75

Downloaded from www.Manualslib.com manuals search engine Back-up Lamp Bulb Replacement ................. 6-43
Battery
....................................... 6-35
Jump Starting
................................. 5-2
Replacement, Passive Keyless Entry
............... 2-8
BBB Auto Line
.................................. 8-7
Belt, Engine Accessory
.......................... 6-79
Better Business Bureau Mediation
................... 8-7
Brake Warnings
................................ 5-2, 5-4
Adjustment
................................ 6-34
Fluid
....................................... 6-32
Master Cylinder
.............................. 6-32
Parking
..................................... 2-28
PedalTravel
................................. 6-3 4
Replacing System Parts
........................ 6-35
System Warning Light
......................... 2-78
Transmission Shift Interlock
.................... 2-3 1
Wear ....................................... 6-34
Brakes, Anti-Lock
............................... 4-6
Brake-Transmission Shift Interlock Check
........... 7-42
Braking
........................................ 4-5
Braking in Emergencies
........................... 4-9
Break-In, New Vehicle
.......................... 2- 15
BTSI
......................................... 2-31
BTSICheck
................................... 7-42
Bulb Replacement
.............................. 6-36
Bulbs, Replacement
........................... 6-73 Canadian
Roadside Assistance
.................... 8-6
Capacities and Specifications
...................... 6-74
Cassette Deck Service
........................... 7-40
Cassette Tape Player
.................. 3-1 1.3.13. 3.15
Cassette Tape Player Care
........................ 3-19
Center Console
................................. 2-48
Center High-Mounted Stoplamp Bulb Replacement
.... 6-41
Certification Label
.............................. 4-28
Chains. Tire
................................... 6-53
Changing a Flat Tire
............................. 5-22
Charging System Indicator Light
................... 2-76
Check Gauges Light
............................. 2-93
Checking Your Restraint Systems
.................. 1-31
Chemical Paint Spotting
.......................... 6-61
Child Restraints
................................ 1-26
Securing in the Passenger Seat Position
........... 1-26
TopStrap
................................... 1-26
WheretoPut
................................ l-26
Cigarette Lighter ............................... 2-50
Circuit Breakers and Fuses
....................... 6-65
Cleaner, Air
................................... 6-15
Cleaning Aluminum Wheels
.......................... 6-60
Coated Moldings
............................. 6-55
Convertible Hardtop
........................... 6-60
Convertible Top
.............................. 6-59
CarbonMonoxide
......................... 2.32. 4.27
9-2
~