wiring CHEVROLET CRUZE LIMITED 2016 2.G Warranty Guide

Chevrolet Limited Warranty and Owner Assistance Information (GMNA-
Localizing-U.S-9159214) - 2016 - crc - 8/17/15
New Vehicle Limited Warranty 5
replacement procedure are covered
until the first scheduled
maintenance interval.
Diesel Components Coverage
includes:Parts of the Emissions
Reduction System such as the
emissions reduction fluid tank,
injectors, sensors including NOx
and exhaust, and the Exhaust
Particulate Filter. Glow Plug Control
System: Control/glow plug
assembly, glow plugs, cold advance
relay, and engine control module.
The fuel injection control module,
integral oil cooler, transmission
adapter plate, common fuel rails,
fuel filter assembly, fuel temperature
sensor, and function block.
Exclusions: Excluded from the
powertrain coverage are sensors,
wiring, connectors, engine radiator,
coolant hoses, coolant, and heater
core. Coverage on the engine
cooling system begins at the inlet to
the water pump and ends with the
thermostat housing and/or outlet
that attaches to the return hose.
Also excluded is the starter motor,
entire pressurized fuel system
(in-tank fuel pump, pressure lines, fuel rail(s), regulator, injectors, and
return line) as well as the Engine/
Powertrain Control Module and/or
module programming.
Transmission/Transaxle Coverage
includes:
All internally lubricated
parts, case, torque converter,
mounts, seals, and gaskets as well
as any electrical components
internal to the transmission/
transaxle. Also covered are any
actuators directly connected to the
transmission (slave cylinder, etc.).
Exclusions: Excluded from the
powertrain coverage are
transmission cooling lines, hoses,
radiator, sensors, wiring, and
electrical connectors. Also excluded
are the clutch and pressure plate as
well as any Transmission Control
Module and/or module
programming.
Transfer Case Coverage includes:
All internally lubricated parts, case,
mounts, seals, and gaskets as well
as any electrical components
internal to the transfer case. Also covered are any actuators directly
connected to the transfer case as
well as encoder motor.
Exclusions:
Excluded from the
powertrain coverage are transfer
case cooling lines, hoses, radiator,
sensors, wiring, and electrical
connectors as well as the transfer
case control module and/or module
programming.
Drive Systems Coverage
includes: All internally lubricated
parts, final drive housings, axle
shafts and bearings, constant
velocity joints, propeller shafts and
universal joints. All mounts,
supports, seals, and gaskets as well
as any electrical components
internal to the drive axle. Also
covered are any actuators directly
connected to the drive axle (e.g.,
front differential actuator).
Exclusions: Excluded from the
powertrain coverage are all wheel
bearings, drive wheel front and rear
hub bearings, locking hubs, drive
system cooling, lines, hoses,
radiator, sensors, wiring, and
electrical connectors related to drive

Chevrolet Limited Warranty and Owner Assistance Information (GMNA-
Localizing-U.S-9159214) - 2016 - crc - 8/17/15
14 New Vehicle Limited Warranty
Vehicle Limited Warranty" are not
extended or altered because of this
special Hybrid Component
Warranty.
What Is Covered
This warranty covers repairs to
Hybrid specific component defect
related to materials or workmanship
occurring during the 8 year or
160 000 kilometers (100,000 miles)
term for the following:
Towing
During the 8 year or
160 000 kilometers (100,000 miles)
Hybrid warranty period, towing is
covered to the nearest Chevrolet
servicing dealer if your vehicle
cannot be driven because of a
warranted Hybrid specific defect.
Contact the GM Roadside
Assistance Center for towing. Refer
to the Owner's Manual for details.Drive Motor Battery Coverage
Propulsion Battery Warranty
Policy (Chevrolet Volt and
Spark EV)
Like all batteries, the amount of
energy that the high voltage
“propulsion”battery can store will
decrease with time and miles
driven. Depending on use, the
battery may degrade as little as
10% to as much as 40% of capacity
over the warranty period. If there
are questions pertaining to battery
capacity, a dealer service technician
could determine if the vehicle is
within parameters.
Hybrid Battery (Malibu Hybrid)
Content Under Heading: Battery and
Internal Components, Modules,
and Fan
Repair (If Necessary)
Chevrolet has a network of Volt,
Spark EV, and Malibu Hybrid
dealers who are trained to perform
repairs, if your vehicle needs battery
service. Replace (If Necessary)
If warranty repair requires
replacement, the high voltage
battery may be replaced with either
a new or factory refurbished high
voltage battery with an energy
capacity (kWh storage) level at or
within approximately 10% of that of
the original battery at the time of
warranty repair.
Your Electric Propulsion battery
warranty replacement may not
return your vehicle to an
“as new”
condition, but it will make your
vehicles fully operational
appropriate to its age and mileage.
Other Electric/Hybrid Components
High Voltage Wiring, Hybrid
Powertrain and Battery Control
Modules, Air Compressor Control
Module (Except Malibu Hybrid),
Accessory DC Power Control
Module, High Voltage Battery
Disconnect Control Module, Drive
Motor Generator Power Invertor
Module, Battery Charger Control
Module.

Chevrolet Limited Warranty and Owner Assistance Information (GMNA-
Localizing-U.S-9159214) - 2016 - crc - 8/17/15
28 Emission Warranty Parts List
Grommets
Hoses
Housings
Mounting Hardware
Pipes
Pulleys
Sealing Devices
Springs
Tubes
Wiring and Relays
Tires (Heavy Duty Applications only
2 yr/24,000 mile Federal Emission
Defect Warranty)
Parts specified in your maintenance
schedule that require scheduled
replacement are covered up to their
first replacement interval or the
applicable emission warranty
coverage period, whichever comes
first. If failure of one of these parts
results in failure of another part,
both will be covered under the
Emission Control System Warranty.For detailed information concerning
specific parts covered by these
emission control system warranties,
ask your dealer.
Replacement Parts
The emission control systems of
your vehicle were designed, built,
and tested using genuine GM parts*
and the vehicle is certified as being
in conformity with applicable federal
and California emission
requirements.
Accordingly, it is
recommended that any
replacement parts used for
maintenance or for the repair of
emission control systems be new,
genuine GM parts.
The warranty obligations are not
dependent upon the use of any
particular brand of replacement
parts. The owner may elect to use
non-genuine GM parts for
replacement purposes. Use of
replacement parts which are not of
equivalent quality may impair the
effectiveness of emission control
systems. If other than new, genuine GM parts
are used for maintenance
replacements or for the repair of
parts affecting emission control, the
owner should assure himself/herself
that such parts are warranted by
their manufacturer to be equivalent
to genuine GM parts in performance
and durability.
*
“Genuine GM parts,” when used in
connection with GM vehicles,
means parts manufactured by or for
GM, designed for use on GM
vehicles, and distributed by any
division or subsidiary of GM.
Maintenance and Repairs
Maintenance and repairs can be
performed by any qualified service
outlet; however, warranty repairs
must be performed by an authorized
dealer except in a situation where
the vehicle owner is significantly
inconvenienced and when a
warranted part or a warranty station
is not reasonably available to the
vehicle owner.
In a situation where the vehicle
owner is significantly
inconvenienced, and an authorized