wheel CHEVROLET KODIAK 2005 Manual Online

Starter Switch Check
{CAUTION:
When you are doing this inspection, the
vehicle could move suddenly. If the vehicle
moves, you or others could be injured.
1. Before you start, be sure you have enough room
around the vehicle.
2. Firmly apply both the parking brake and the
regular brakes.
Do not use the accelerator pedal, and be ready to
turn off the engine immediately if it starts.
3. On automatic transmission vehicles, try to start the
engine in each gear. The starter should work only
in PARK (P), if equipped, or NEUTRAL (N). If
the starter works in any other position, your vehicle
needs service. On manual transmission vehicles,
the starter should work only when the clutch pedal is
all the way down.
Automatic Transmission Shift
Indicator Check
Check that the indicator points to the gear chosen.
Steering Check
Be alert for any changes in steering action, abnormal
front tire wear or steering wheel position. An inspection
or service is needed when the steering wheel is
harder to turn or has too much free play, or if there are
strange sounds when turning or parking.
Brake System Check
Be alert to illumination of the low air warning lamp or for
the tone alarm, or changes in braking action, such as
repeated pulling to one side, unusual sounds when
braking or increased brake pedal travel. Make sure air
brake system reservoirs are drained daily with full
system air pressure, and check system for leaks. Any of
these conditions could indicate the need for brake
system inspection and/or service.
6-29

Usage Fluid/Lubricant
Manual
Transmission
(ZF 6-Speed)Synthetic Transmission Fluid
approved to Allison Transmission
®
specification TES-295
(GM Part No. U.S. 12378515, in
Canada 88900701).
Automatic
TransmissionSee the Allison Transmission
®
Operator’s Manual for correct
transmission fluid.
Key Lock
CylindersMulti-Purpose Lubricant, Superlube
(GM Part No. U.S. 12346241, in
Canada 10953474).
Chassis
LubricationChassis Lubricant
(GM Part No. U.S. 12377985, in
Canada 88901242) or lubricant
meeting requirements of NLGI #2,
Category LB or GC-LB.
Front Wheel
Bearings
(Except Oil
Filled Hubs)Wheel bearing lubricant meeting
requirements of NLGI #2,
Category GC or GC-LB
(GM Part No. U.S. 1051344, in
Canada 993037).
Front Wheel
Bearings with
Oil Filled HubsSAE 75W-90 Synthetic Axle
Lubricant for Medium Duty Trucks
(GM Part No. U.S. 89021675, in
Canada 10953512).
Transfer Case
(Four-Wheel
Drive)DEXRON
®-III Automatic
Transmission Fluid. Look for
“Approved for the H-Specification”
on the label.
Usage Fluid/Lubricant
Front Axle
(Four-Wheel
Drive)SAE 75W-90 Synthetic Axle
Lubricant for Medium Duty Trucks
(GM Part No. U.S. 89021675, in
Canada 10953512).
Rear Axle and
Rear HubsSAE 75W-90 Synthetic Axle
Lubricant for Medium Duty Trucks
(GM Part No. U.S. 89021675, in
Canada 10953512).
Rear Axle Shift
Motor LubricantRefrigerant Oil
(GM Part No. U.S. 5416939, in
Canada 10953496).
Propshafts and
SplinesWheel bearing lubricant meeting
requirements of NLGI #2,
Category GC or GC-LB
(GM Part No. U.S. 1051344, in
Canada 993037).
Cab — Door
Hinges and
LatchesMulti-Purpose Lubricant, Superlube
(GM Part No. U.S. 12346241, in
Canada 10953474).
Weatherstrip
ConditioningDielectric Silicone Grease
(GM Part No. U.S. 12345579, in
Canada 992887).
Weatherstrip
SqueaksSynthetic Grease with
Teflon, Superlube
(GM Part No. U.S. 12371287, in
Canada 10953437).
6-33

GM Mobility Reimbursement
Program
This program, available to qualified applicants, can
reimburse you up to $1,000 of the cost of eligible
aftermarket adaptive equipment required for your vehicle,
such as hand controls or a wheelchair/scooter lift.
The offer is available for a very limited period of time
from the date of vehicle purchase/lease. For more
details, or to determine your vehicle’s eligibility, visit
gmmobility.com or call the GM Mobility Assistance
Center at 1-800-323-9935. Text telephone (TTY) users,
call 1-800-833-9935.
GM of Canada also has a Mobility Program. Call
1-800-GM-DRIVE (463-7483) for details. TTY users
call 1-800-263-3830.
Roadside Assistance Program
GM Medium Duty Truck’s Roadside Assistance
provides stranded owners with towing service for
disabled vehicles.
This service combines the efforts of trained telephone
representatives with a network of GM Medium Duty
Truck’s dealer services.
Just dial GM Medium Duty Truck Roadside Assistance
at 1-800-862-4389 to reach a qualified representative
who can assist you in a repair or arrange a tow. Other
recommended services can also be arranged for
situations such as retrieving locked in keys, changing a
tire, or delivering gasoline, at a charge to the customer.
We also provide dealer information at no charge,
such as location of the nearest authorized medium duty
GM Truck dealer and their hours of operation.
Roadside Assistance is available 24 hours a day,
7 days a week, 365 days a year. Should you have any
questions about Roadside Assistance, call the GM
Medium Duty Truck Roadside Assistance Center
or contact your dealer.
7-5

Canadian Roadside Assistance
In Canada, Medium Duty trucks are not eligible for
Roadside Assistance services. However,
owners/operators who contact Roadside Assistance by
calling 1-800-268-6800 may have a tow arranged
for them at the owner/operator expense.
If a Medium Duty truck is towed to a General Motors
dealership and the towing was necessary due to failure
of a warranted part, the dealer will accept the towing
charges and submit them as part of the warranty claim.
Vehicle Data Collection and Event
Data Recorders
Your vehicle, like other modern motor vehicles, has a
number of sophisticated computer systems that monitor
and control several aspects of the vehicle’s performance.
Your vehicle uses on-board vehicle computers to monitor
emission control components to optimize fuel economy,
to monitor conditions for airbag deployment and, if so
equipped, to provide anti-lock braking and to help the
driver control the vehicle in difficult driving situations.
Some information may be stored during regular
operations to facilitate repair of detected malfunctions;
other information is stored only in a crash event by
computer systems, such as those commonly called event
data recorders (EDR).In a crash event, computer systems, such as the Airbag
Sensing and Diagnostic Module (SDM) in your vehicle
may record information about the condition of the vehicle
and how it was operated, such as data related to
engine speed, brake application, throttle position, vehicle
speed, safety belt usage, airbag readiness, airbag
performance, and the severity of a collision. If your
vehicle is equipped with Quadrasteer, steering
performance, including yaw rate, steering wheel angle,
and lateral acceleration, is also recorded. This
information has been used to improve vehicle crash
performance and may be used to improve crash
performance of future vehicles and driving safety. Unlike
the data recorders on many airplanes, these on-board
systems do not record sounds, such as conversation of
vehicle occupants.
To read this information, special equipment is needed
and access to the vehicle or the device that stores
the data is required. GM will not access information
about a crash event or share it with others other than:
•with the consent of the vehicle owner or, if the
vehicle is leased, with the consent of the lessee,
•in response to an official request of police or similar
government office,
•as part of GM’s defense of litigation through the
discovery process, or
•as required by law.
7-6

A
Accessory Power Outlets.................................3-19
Adding a Snow Plow or Similar Equipment.........4-34
Adding Equipment to Your Airbag-Equipped
Vehicle.......................................................1-59
Additives, Fuel................................................. 5-6
Add-On Electrical Equipment............................5-88
Air Brake.......................................................2-40
Air Cleaner/Filter, Engine.................................5-33
Air Conditioning..............................................3-20
Air Conditioning System...................................5-70
Air Pressure Gage..........................................3-44
Air Shift Control..............................................2-27
Air Suspension...............................................2-42
Air Suspension Seats........................................ 1-6
Airbag
Off Light.....................................................3-28
Readiness Light..........................................3-27
Airbag Sensing and Diagnostic Module (SDM)...... 7-6
Airbag System................................................1-48
Adding Equipment to Your Airbag-Equipped
Vehicle...................................................1-59
Airbag Off Switch........................................1-56
How Does an Airbag Restrain?......................1-54
Servicing Your Airbag-Equipped Vehicle..........1-59
What Makes an Airbag Inflate?......................1-54
What Will You See After an Airbag Inflates?....1-54Airbag System (cont.)
When Should an Airbag Inflate?....................1-53
Where Are the Airbags?...............................1-52
AM-FM Radio.................................................3-45
Antenna, Fixed Mast.......................................3-59
Anti-Lock Brake System (ABS)........................... 4-6
Anti-Lock Brake, System Warning Light..............3-34
Anti-Lock Brakes, Trailer System
Warning Light.............................................3-34
Appearance Care............................................5-79
Aluminum or Chrome-Plated Wheels..............5-84
Care of Safety Belts....................................5-82
Chemical Paint Spotting...............................5-85
Cleaning Exterior Lamps/Lenses....................5-83
Cleaning the Inside of Your Vehicle................5-80
Fabric/Carpet..............................................5-81
Finish Care.................................................5-83
Finish Damage............................................5-85
Instrument Panel, Vinyl, and Other Plastic
Surfaces.................................................5-82
Sheet Metal Damage...................................5-85
Tires..........................................................5-85
Underbody Maintenance...............................5-85
Vehicle Care/Appearance Materials................5-86
Washing Your Vehicle...................................5-83
Weatherstrips..............................................5-82
Windshield and Wiper Blades........................5-84
Ashtrays........................................................3-20
1

C
Canadian Owners................................................ ii
Capacities and Specifications............................5-95
Carbon Monoxide...................................2-43, 4-26
Care of
Safety Belts................................................5-82
Your Cassette Tape Player............................3-58
Your CD Player...........................................3-59
Your CDs ...................................................3-59
Center Console Storage Area...........................2-47
Center Passenger Position, Safety Belts.............1-22
Charging System Light....................................3-30
Check
Engine Light...............................................3-36
Gages Warning Light...................................3-42
Checking Things Under the Hood......................5-20
Chemical Paint Spotting...................................5-85
Child Restraints
Child Restraint Systems...............................1-33
Infants and Young Children...........................1-30
Older Children.............................................1-27
Securing a Child Restraint in a Rear
Outside Seat Position...............................1-40Child Restraints (cont.)
Securing a Child Restraint in the Center
Rear Seat Position (Crew Cab) or
Center Front Position................................1-42
Securing a Child Restraint in the Right
Front Seat Position...................................1-44
Top Strap...................................................1-39
Where to Put the Restraint...................1-36, 1-38
Chime Level Adjustment..................................3-59
Cigarette Lighter.............................................3-20
Cleaning
Aluminum or Chrome-Plated Wheels..............5-84
Exterior Lamps/Lenses.................................5-83
Fabric/Carpet..............................................5-81
Finish Care.................................................5-83
Inside of Your Vehicle..................................5-80
Instrument Panel, Vinyl, and Other
Plastic Surfaces.......................................5-82
Tires..........................................................5-85
Underbody Maintenance...............................5-85
Washing Your Vehicle...................................5-83
Weatherstrips..............................................5-82
Windshield and Wiper Blades........................5-84
3

F
Filter
Engine Air Cleaner......................................5-33
Filter Minder Gage..........................................3-43
Finish Damage...............................................5-85
Fixed Mast Antenna........................................3-59
Flat Tire........................................................5-78
Fluid
Automatic Transmission................................5-34
Manual Transmission....................................5-35
Power Steering...........................................5-45
Windshield Washer......................................5-46
Four-Wheel Drive....................................2-33, 5-62
Front Axle......................................................5-63
Front Wheel Bearings with Oil-Filled Hubs..........5-69
Fuel............................................................... 5-6
Additives...................................................... 5-6
Diesel Engine Fuel........................................ 5-7
Filling a Portable Fuel Container....................5-19
Filling Your Tank..........................................5-18
Filter..........................................................5-66
Filter Replacement.......................................5-16Fuel (cont.)
Fuels in Foreign Countries............................5-17
Gage.........................................................3-42
Gasoline Octane........................................... 5-6
Gasoline Specifications.................................. 5-6
Primary Filter and Water Separator................5-67
Running Out of Fuel....................................5-15
Secondary Filter and Water
Separator/Heater......................................5-68
Very Cold Weather Operation........................5-10
Water in Fuel..............................................5-10
Water in Warning Light.................................3-43
What Fuel to Use.......................................... 5-8
Fuses
Fuses and Circuit Breakers...........................5-89
Instrument Panel Fuse Block.........................5-89
Underhood Fuse Block.................................5-92
Windshield Wiper.........................................5-88
6

M
Maintenance, Normal Replacement Parts..........5-100
Maintenance Schedule
At Each Fuel Fill.........................................6-27
At Least Once a Year..................................6-31
At Least Twice a Year..................................6-28
How This Section is Organized....................... 6-3
Introduction.................................................. 6-2
Maintenance Requirements............................. 6-2
Part A - Scheduled Maintenance Services......... 6-4
Part B - Owner Checks and Services.............6-27
Part C - Recommended Fluids and
Lubricants...............................................6-32
Part D - Maintenance Record........................6-34
Scheduled Maintenance................................. 6-5
Scheduled Maintenance Supplements............... 6-5
Using.......................................................... 6-4
Your Vehicle and the Environment................... 6-2
Malfunction Indicator Light................................3-36
Manual Seats................................................... 1-2
Manual Transmission
Fluid..........................................................5-35
Operation...................................................2-29
Manual Windows.............................................. 2-8
Marker Lamps................................................3-16
Mirrors
Manual Rearview Mirror................................2-45
Outside Convex Mirrors................................2-46
Outside Heated Mirrors................................2-46Mirrors (cont.)
Outside Manual Mirrors................................2-45
Outside Power Mirrors..................................2-45
MyGMLink.com................................................ 7-3
N
New Vehicle Break-In......................................2-11
Noise Control System, Tampering......................5-64
Normal Maintenance Replacement Parts...........5-100
O
Odometer......................................................3-26
Odometer, Trip...............................................3-26
Off-Road Recovery..........................................4-13
Oil
Change Engine Oil Light...............................3-38
Engine...............................................5-22, 5-26
Low Oil Level Light......................................3-38
Pressure Gage............................................3-37
Oil, Engine Oil Life System..............5-29, 5-31, 5-32
Older Children, Restraints................................1-27
Online Owner Center........................................ 7-3
Other Service Items
Air Conditioning System...............................5-70
Automatic Ether Injection System...................5-68
Front Wheel Bearings with Oil-Filled Hubs.......5-69
Fuel Filter...................................................5-66
9

Securing a Child Restraint
Center Rear Seat Position (Crew Cab) or
Center Front Position................................1-42
Rear Outside Seat Position...........................1-40
Right Front Seat Position..............................1-44
Service........................................................... 5-3
Doing Your Own Work................................... 5-4
Engine Soon Light.......................................3-36
Publications Ordering Information..................... 7-8
Transmission Warning Light..........................3-31
Two Safety Cautions about Engine Fan
Breakage.................................................. 5-5
Servicing Your Airbag-Equipped Vehicle..............1-59
Setting the Time.............................................3-45
Sheet Metal Damage.......................................5-85
Shoulder Belt Height Adjuster...........................1-21
Signals, Turn and Lane-Change.......................... 3-8
Sliding Rear Windows.....................................2-10
Snow Plow....................................................4-34
Specifications, Capacities.................................5-95
Speedometer..................................................3-26
Split Bench Seat.............................................. 1-6
Starting Your Diesel Engine..............................2-14
Starting Your Gasoline Engine..........................2-12
Steering........................................................4-11
Steering Wheel, Tilt Wheel................................. 3-7Storage Areas................................................2-47
Center Console Storage Area........................2-47
Stuck in Sand, Mud, Ice or Snow......................4-30
Sun Visors.....................................................2-10
Suspension, Air..............................................2-42
Switchbanks, Instrument Panel..........................3-18
T
Tachometer....................................................3-26
Theft-Deterrent, Radio.....................................3-57
Tilt Wheel........................................................ 3-7
Tires.............................................................5-70
Aluminum or Chrome-Plated Wheels,
Cleaning.................................................5-84
Cleaning....................................................5-85
Dual Tire Operation.....................................5-72
If a Tire Goes Flat.......................................5-78
Inflation -- Tire Pressure...............................5-71
Tightening the Wheel Nuts............................5-73
Wheel Alignment and Tire Balance.................5-73
Wheel Loading............................................5-71
Wheel Replacement.....................................5-77
When It Is Time for New Tires......................5-72
Top Strap......................................................1-39
Tow Hooks.....................................................4-31
12

W
Wait to Start Indicator......................................3-36
Warning Lights, Gages and Indicators................3-24
Warnings
Hazard Warning Flashers............................... 3-6
Other Warning Devices.................................. 3-6
Safety and Symbols......................................... iii
Vehicle Damage.............................................. iv
Washer Fluid, Low Warning Light......................3-42
Water
Fuel..........................................................5-10
Water in Fuel Warning Light.............................3-43
What Fuel to Use............................................. 5-8
Wheels
Alignment and Tire Balance..........................5-73
Front Bearings with Oil-Filled Hubs................5-69
Loading......................................................5-71
Replacement...............................................5-77
Tightening the Wheel Nuts............................5-73Where to Put the Restraint.......................1-36, 1-38
Windows......................................................... 2-8
Manual........................................................ 2-8
Power......................................................... 2-9
Sliding Rear................................................2-10
Windshield
Wiper Blades, Cleaning................................5-84
Windshield Washer.........................................3-10
Fluid..........................................................5-46
Windshield Wiper
Blade Replacement......................................5-65
Fuses........................................................5-88
Windshield Wipers......................................... 3-9
Winter Driving................................................4-26
Y
Your Vehicle and the Environment....................... 6-2
14