warning light CHEVROLET KODIAK 2007 Service Manual

Power Steering Fluid
SeeScheduled Maintenance on page 363to
determine when to check your power steering fluid.
How To Check Power Steering Fluid
Check your power steering fluid only when the
engine is warm. If the engine is not warm, you
probably will not get an accurate reading.
If the fluid level is between the MIN (Minimum) and
MAX (Maximum) marks, you have enough. If you
need fluid, add only enough of the proper fluid to
bring it in between the MIN and MAX marks.
If your power steering fluid level is low, this can
cause the brake or service brakes soon warning
lights to come on. In addition, the steering
effort and emergency brake distance could
increase.If either light remains on after you have added
power steering fluid to the proper level, then shut
off the engine for 10 seconds. This should
reset the brake warning lights. If one or both lights
stay on, see “Hydraulic Brake System Warning
Lights” underBrake System Warning Light
on page 169for more information.
What to Use
To determine what kind of fluid to use, see
Part C: Recommended Fluids and Lubricants on
page 397.
Notice:When adding power steering uid or
making a complete uid change, always
use the proper uid. Failure to use the proper
uid can cause leaks and damage hoses
and seals.
295

Fuse Usage
7 Hazard Warning Flashers
8 Power Post
9 Courtesy Lamps
10 Warning Lights, Gages and Indicators
11 Starter
12 Rear Axle/Four-Wheel-Drive
13Trailer Turn Signals/Hazard Warning
Flashers
14 Radio/Chime
15 Daytime Running Lamps
16 Airbag System
17 Exterior/Interior Lamps
18 Parking Brake
19 Accessory Power
20 Ignition 4
21 Sidemarker Lamps
22 Turn Signal/Backup Lamps
23 TransmissionFuse Usage
24 Hydraulics/Air Brake
A Spare
B Spare
Fuse Usage
Blank Not Used
BRK Brake Warning Lamp
RT PRK Passenger’s Side Parking Lamps
Blank Not Used
Blank Not Used
LT PARK Driver’s Side Parking Lamps
RT REAR
TRN/STOPPassenger’s Side Rear Turn
Signal/Stoplamp
LT REAR
TRN/STOPDriver’s Side Rear Turn
Signal/Stoplamp
RADIO Radio
Blank Not Used
Blank Not Used
PWR WNDW Power Windows
343

Fuse Usage
NOTE 3L18 Fuel, LG4 Powertrain Control
Valve, LG5 Electronic Control
Module
STUD A Spare
STUD B Spare
Relay Usage
NOTE 1LLY/L18 Fuel Pump Relay, LG4/LG5
Heated Fuel Relay
IGN B Ignition Relay
STARTER Starter Relay
HORN Horn Relay
IGN A Ignition Relay
PTO/ECU*Power Take-Off/Engine Control Unit
(*Diesel 7.8L LG4)
REVERSE Reverse Relay
NEUTRAL
STARTNeutral Start (LG4 Allison Automatic
Transmission Series 3000/3500)
Fuse Usage
IGN 1 Ignition 1
IGN 4 Ignition 4
IGN 3 Ignition 3
BATT/HAZ Battery/Hazard Warning Flashers
HEADLAMP Headlamps
LIGHTING Interior/Exterior Lamps
HVAC Climate Control System
NOTEC4/C5 Electric Brake,
C6/C7/C8 Brake Lamps Secondary Underhood
Fuse Block
346

Lamps Check
Check panel lighting, warning lights, indicator
lights, and interior lamps. On the outside,
check: license plate lamps, sidemarker lamps,
reflectors or lights on outside mirrors, headlamps,
parking lamps, identification and clearance
lamps, taillamps, brake lamps, turn signals,
backup lamps, and hazard warning flashers.
Have headlamp aim checked at once if beams
seem improperly aimed.
Glass, Mirrors, Lamps and/or
Reectors Condition Check
Look for broken, scratched, dirty, or damaged
glass, mirrors, lamps, or reflectors that could
reduce the view or visibility or cause injury.
Replace, clean or repair promptly.
Door Latches Check
Check that doors close, latch, and lock tightly.
Check for broken, damaged, or missing parts that
might prevent tight latching.
Hood Latches Check
Check that the hood closes firmly. Check for
broken, damaged, loose, or missing parts
that might prevent tight latching. Make sure the
secondary latch (if equipped) keeps the hood
from opening all the way when the primary latch
is released.
Fluid Leaks Check
Check for fuel, coolant, oil, or other fluid leaks by
looking at the surface beneath the vehicle after
it has been parked for awhile.
395

A
Accessory Power Outlet(s).......................... 156
Adding a Snow Plow or Similar
Equipment................................................ 240
Adding Equipment to Your Airbag-Equipped
Vehicle....................................................... 81
Additives, Fuel............................................ 252
Add-On Electrical Equipment....................... 340
Air Cleaner/Filter, Engine............................. 280
Air Conditioning........................................... 157
Air Conditioning System.............................. 320
Air Pressure Gage...................................... 183
Air Shift Control........................................... 114
Air Suspension............................................ 129
Air Suspension Seats.................................... 13
Airbag
Off Light.................................................. 166
Readiness Light....................................... 165
Airbag Sensing and Diagnostic
Module (SDM).......................................... 409
Airbag System............................................... 68
Adding Equipment to Your
Airbag-Equipped Vehicle......................... 81
Airbag Off Switch....................................... 76
How Does an Airbag Restrain?.................. 73
Servicing Your Airbag-Equipped Vehicle..... 80Airbag System (cont.)
What Makes an Airbag Inflate?.................. 73
What Will You See After an Airbag
Inflates?................................................. 74
When Should an Airbag Inflate?................. 72
Where Are the Airbags?............................. 70
AM-FM Radio.............................................. 186
Antenna, Fixed Mast................................... 204
Anti-Lock Brake System (ABS).................... 212
Anti-Lock Brake, System Warning Light....... 172
Anti-Lock Brakes, Trailer System
Warning Light........................................... 172
Appearance Care
Aluminum or Chrome-Plated Wheels........ 337
Care of Safety Belts................................ 334
Chemical Paint Spotting........................... 338
Cleaning Exterior Lamps/Lenses.............. 335
Cleaning the Inside of Your Vehicle.......... 331
Fabric/Carpet........................................... 333
Finish Care.............................................. 335
Finish Damage......................................... 338
Instrument Panel, Vinyl, and Other
Plastic Surfaces.................................... 334
Sheet Metal Damage............................... 337
Tires........................................................ 337
Underbody Maintenance........................... 338
Vehicle Care/Appearance Materials.......... 339
417

Appearance Care (cont.)
Washing Your Vehicle.............................. 335
Weatherstrips........................................... 334
Windshield and Wiper Blades................... 336
Ashtray(s).................................................... 157
Audio System(s).......................................... 184
AM-FM Radio.......................................... 186
Care of Your Cassette Tape Player.......... 202
Care of Your CD Player........................... 204
Care of Your CDs.................................... 203
Chime Level Adjustment........................... 204
Fixed Mast Antenna................................. 204
Radio with Cassette................................. 189
Radio with CD......................................... 195
Setting the Time...................................... 185
Theft-Deterrent Feature............................ 201
Understanding Radio Reception............... 201
Automatic Ether Injection System................ 318
Automatic Transmission
Fluid........................................................ 282
Operation................................................. 115
Axle, Two-Speed Rear Axle Electric Shift
Control..................................................... 113B
Battery........................................................ 304
Bench Seat, Split.......................................... 13
Brake
Anti-Lock Brake System (ABS)................. 212
Diesel Engine Exhaust............................. 112
Emergencies............................................ 213
Exhaust Indicator Light............................. 178
Hydraulic Systems................................... 211
Parking...........................................125, 126
System Warning Light.............................. 169
Trailer Hand Control Valve....................... 214
Brakes........................................................ 297
Parking Brake Burnish Procedure............. 128
Braking....................................................... 210
Braking in Emergencies............................... 213
Break-In, New Vehicle................................... 95
Bucket Seats.................................................. 9
Bulb Replacement....................................... 315
C
California Proposition 65 Warning................ 248
Canadian Owners........................................... 3
Capacities and Specifications...................... 347
Carbon Monoxide...............................131, 231
418

Care of
Safety Belts............................................. 334
Your Cassette Tape Player....................... 202
Your CD Player........................................ 204
Your CDs ................................................. 203
Center Console Storage Area...................... 135
Center Passenger Position, Safety Belts........ 37
Charging System Light................................ 167
Check
Engine Light............................................ 174
Gages Warning Light............................... 180
Checking Things Under the Hood................ 266
Chemical Paint Spotting.............................. 338
Child Restraints
Child Restraint Systems............................. 49
Infants and Young Children........................ 45
Lower Anchors and Tethers for Children..... 57
Older Children........................................... 42
Securing a Child Restraint in a Rear
Outside Seat Position............................. 58
Securing a Child Restraint in the Center
Rear Seat Position (Crew Cab) or
Center Front Position.............................. 60
Securing a Child Restraint in the Right
Front Seat Position................................. 63
Where to Put the Restraint................. 54, 55
Chime Level Adjustment.............................. 204Cigarette Lighter.......................................... 157
Cleaning
Aluminum or Chrome-Plated Wheels........ 337
Exterior Lamps/Lenses............................. 335
Fabric/Carpet........................................... 333
Finish Care.............................................. 335
Inside of Your Vehicle .............................. 331
Instrument Panel, Vinyl, and Other
Plastic Surfaces.................................... 334
Tires........................................................ 337
Underbody Maintenance........................... 338
Washing Your Vehicle .............................. 335
Weatherstrips........................................... 334
Windshield and Wiper Blades................... 336
Climate Control System............................... 157
Outlet Adjustment..................................... 160
Rear Heating System............................... 161
Collision Damage Repair............................. 410
Control of a Vehicle..................................... 210
Coolant
Engine Temperature Gage........................ 173
Heater, Engine......................................... 111
Low Warning Light................................... 173
Surge Tank Pressure Cap........................ 288
Cooling System........................................... 290
Cruise Control............................................. 146
419

E
Electrical System
Add-On Equipment................................... 340
Fuses and Circuit Breakers...................... 341
Fusible Links............................................ 341
Headlamp Wiring..................................... 341
Instrument Panel Fuse Block................... 342
Power Windows and Other Power
Options................................................. 341
Underhood Fuse Block............................. 344
Windshield Wiper Fuses........................... 341
Engine
Air Cleaner/Filter...................................... 280
Alarm and Automatic Shutdown................ 104
Battery..................................................... 304
Change Engine Oil Light.......................... 176
Check and Service Engine Soon Light..... 174
Checks Before Operating......................... 109
Coolant...........................................284, 287
Coolant Heater......................................... 111
Coolant Temperature Gage...................... 173
Diesel Engine Exhaust Brake................... 112
Drive Belt Routing.................................... 355
Exhaust................................................... 131
Exhaust Restrictor.................................... 108
Fan Breakage.......................................... 250Engine (cont.)
Fan Noise................................................ 294
High Idle System..................................... 106
Oil ...................................................268, 272
Oil Life System.......................276, 278, 279
Overheating............................................. 288
Overspeed Warning Light......................... 177
Reduced Power Light............................... 179
Shutdown Warning Light.......................... 177
Speed Limiter.......................................... 164
Starter Over-Crank Protection.................... 97
Starting Your Diesel................................. 100
Starting Your Gasoline............................... 97
Entry Lighting.............................................. 154
Event Data Recorders (EDR)...................... 409
Exhaust Brake Indicator Light...................... 178
Exhaust Restrictor....................................... 108
Extender, Safety Belt..................................... 41
Exterior Lamps............................................ 150
F
Filter
Engine Air Cleaner................................... 280
Filter Minder Gage...................................... 182
Finish Damage............................................ 338
Fixed Mast Antenna.................................... 204
421

Flashers, Hazard Warning........................... 142
Flat Tire...................................................... 330
Fluid
Automatic Transmission............................ 282
Manual Transmission................................ 283
Power Steering........................................ 295
Windshield Washer.................................. 296
Four-Wheel Drive...............................119, 312
Front Axle................................................... 313
Front Wheel Bearings with Oil-Filled Hubs ... 319
Fuel............................................................ 251
Additives.................................................. 252
Diesel Engine Fuel................................... 253
Filling a Portable Fuel Container.............. 266
Filling Your Tank...................................... 264
Filter........................................................ 317
Filter Replacement................................... 263
Fuels in Foreign Countries....................... 264
Gage....................................................... 181
Gasoline Octane...................................... 251
Gasoline Specifications............................ 251
Primary Filter and Water Separator.......... 317
Running Out of Fuel................................ 262
Secondary Filter and Water Separator/
Heater.................................................. 318
Very Cold Weather Operation................... 256
Water in Fuel........................................... 256Fuel (cont.)
Water in Warning Light............................ 182
What Fuel to Use.................................... 253
Fuses
Fuses and Circuit Breakers...................... 341
Instrument Panel Fuse Block................... 342
Underhood Fuse Block............................. 344
Windshield Wiper..................................... 341
G
Gage
Air Pressure............................................. 183
Check Gages Warning Light..................... 180
Engine Coolant Temperature.................... 173
Filter Minder............................................ 182
Fuel......................................................... 181
Hourmeter................................................ 183
Oil Pressure............................................. 175
Speedometer........................................... 163
Tachometer.............................................. 163
Transmission Temperature........................ 178
Voltmeter Gage........................................ 168
Gasoline
Octane..................................................... 251
Specifications........................................... 251
Gasoline Engine, Starting.............................. 97
GM Mobility Reimbursement Program.......... 407
422

H
Hazard Warning Flashers............................ 142
Headlamp Wiring......................................... 341
Headlamps
Bulb Replacement.................................... 315
Daytime Running Lamps.......................... 151
High/Low Beam Changer......................... 144
On Reminder........................................... 150
Heater......................................................... 157
High Idle System......................................... 106
Highbeam On Light..................................... 179
Highway Hypnosis....................................... 229
Hill and Mountain Roads............................. 230
Hood
Checking Things Under............................ 266
Latches.................................................... 267
Horn............................................................ 142
Hourmeter Gage.......................................... 183
How to Use This Manual................................ 4
How to Wear Safety Belts Properly............... 26
Hydraulic Brake Systems............................. 211
I
Ignition Positions........................................... 96
Infants and Young Children, Restraints .......... 45
Inflation - Tire Pressure............................... 322
Instrument Panel
Overview.................................................. 140
Switchbank.............................................. 154
Instrument Panel (I/P)
Brightness................................................ 152
Cluster..................................................... 162
J
Jump Starting.............................................. 305
K
Keyless Entry System................................... 87
Keys............................................................. 86
423