heater CHEVROLET LOW CAB FORWARD 2017 Owner's Guide

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
306 Vehicle Care
Relay locations (1):No. Description
1 STARTER
2 PM SENSOR
3 NOX & DEF SENSOR
4 A/C COMPRESSOR
5 CONDENSER FAN
6 RR DOME LIGHT
7 SCR HEATER VALVE
8 MARKER LIGHT
9 –
10 –
11 FUEL HEATER
Gasoline Engine Fuse and Relay Location
Fuse locations (2): No. Description Rating
1 MARKER LIGHT 20A

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
Vehicle Care 307
No. Description Rating2 TAIL MAIN 20A
3 PCM 1 15A
4 PCM 2 20A
5 PCM 3 15A
6 POWER SOURCE 15A
7 CONDENSER FAN 20A
8 A/C COMPRESSOR 10A
Relay locations (1): No. Description
1 STARTER
2 A/C COMPRESSOR
3 CONDENSER FAN
4 FUEL PUMP
5 RR DOME LAMP
6 MARKER LAMP
7 PCM MAIN
8 –
9 A/C No. Description
10 –
11 FUEL HEATER
When Slow-blow Fuses Blow Out
Slow-blow fuses protect the
electrical circuits, and they are
installed so that they can be quickly
replaced if there is a malfunction.
If an overload exists in the circuit
from the battery, the slow-blow fuse
will blow out before the wiring
harness is damaged to protect the
electrical circuitry. Inspection
When the headlights and other
devices in the electrical system do
not work, but there is no problem
with the fuses, check the
slow-blow fuse.
The slow-blow fuse is blown if it
looks like the illustration.
Immediately contact the nearest
dealer.

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
Service and Maintenance 351
Remarks
(1)In case this column is blank,
follow kilometers (miles).
(2) An Emission Control Service.
(3) Initial check at 1 040 km
(650 miles) is required.
(4) See Severe Driving Condition.
(5) A Noise Emission Control
Service.
(6) The California Air Resources
Board has determined that the
failure to perform this maintenance
item will not nullify the emission
warranty or limit recall liability prior
to the completion of vehicle useful
life. GM, however, urges that all
recommended maintenance
services be performed at the
indicated intervals.
Explanation of Complete
Vehicle Maintenance Schedule
(Gasoline Vehicles)
The following is a brief explanation
of each of the services listed in the
preceding Complete Vehicle
Maintenance Schedule for gasoline
vehicles. 1. ENGINE OIL :
Change at
intervals noted below depending
upon driving conditions.
• NORMAL SERVICE - Change
every 12 000 km (7,500 miles) or
12 months whichever occurs first.
• SEVERE SERVICE- Change every
4 800 km (3,000 miles) or 3 months
if you often drive under one or more
of these conditions (a) driving in
dusty areas, (b) frequent idling or
idling for long periods, (c) driving
6 km (4 miles) or less in freezing
weather, or other short trips in cold
weather, where the engine does not
thoroughly warm up. Change oil and
filter as soon as you can after
driving in a dust storm.
2. OIL FILTER : Change at intervals
noted below depending upon driving
conditions.
• NORMAL SERVICE - Change
every 12 000 km (7,500 miles) or
12 months whichever occurs first.
• SEVERE SERVICE- Change every
4 800 km (3,000 miles) or 3 months
whichever occurs first. 3. COOLING SYSTEM SERVICE :
At 24 months or 48 000 km
(30,000 miles) intervals, wash
radiator cap and filler neck with
clean water, pressure test system
and radiator cap for proper pressure
holding capacity, tighten hose
clamps and inspect condition of all
cooling and heater hoses. Replace
hoses if cracked, swollen or
otherwise deteriorated.
Also each 24 months or 48 000 km
(30,000 miles), clean exterior of
radiator core.
4. ENGINE COOLANT :
Every
80 000 km (50,000 miles), drain the
engine coolant by opening the drain
plug at the bottom of the radiator
core, flush and refill the engine
cooling system with a new 50/50
engine coolant solution.
5. AIR CLEANER FILTER : Change
every 48 000 km (30,000 miles).
6. POSITIVE CRANKCASE
VENTILATION (PCV) SYSTEM :
Check that PCV system works
properly. Replace the valve and any
worn, plugged or collapsed hoses
as necessary.

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
364 Service and Maintenance
conforms to this maintenance
schedule. (Recommended oil: CK-4
(API designations))
4. Fuel Filter :Replace the fuel
filter every 24 000 km (15,000 miles)
or more frequently if clogged or
replace when the fuel filter indicator
light comes on (if equipped).
5. Pre-Fuel Filter/Water
separator : Replace the fuel filter
every 24 000 km (15,000 miles) or
more frequently if clogged or
replace when the fuel filter indicator
light comes on (if equipped).
6. Air Cleaner Filter : The level of
dirt in the air cleaner element can
be checked against the indicator.
Replace the air cleaner filter when
the multi-information display (MID)
shows "CHECK AIR FILTER".
7. Damage to Air Intake Ducts and
Hoses : Check for damage of air
intake ducts and hoses and that
those are correctly installed every
24 000 km (15,000 miles) or
12 months. Replace or adjust those
if necessary. 8. Drive Belts :
Check belt driving
the fan, alternator or A/C
compressor every 16 000 km
(10,000 miles). Look for cracks,
fraying, wear, and proper tension.
9. Engine Bolt Torques : Loosened
bolts result in lower engine output.
Check and adjust manifold
mounting, and injectors to correct
torque every 80 000 km
(50,000 miles).
10. Rotate Tires : To equalize wear,
rotate tires and adjust tire pressures
every 10 400 km (6,500 miles). See
Tire Rotation 0323.
11. Engine Cooling System : At
12 months or 16 000 km
(10,000 miles) intervals, wash
radiator cap and filler neck with
clean water, pressure test system
and radiator cap for proper pressure
holding capacity, tighten hose
clamps and inspect condition of all
cooling and heater hoses. Replace
hoses if cracked, swollen or
otherwise deteriorated. Have the
hoses replaced by your authorized
dealer. 12. Engine Coolant :
Inspect the
engine coolant every 12 months.
Replace the engine coolant every
24 months, drain the engine coolant
by opening the drain plug at the
bottom of the radiator core, flush
and refill the engine cooling system
with a new engine coolant. Refer to
"Preparing Engine Coolant" in
Engine Coolant 0263. Have the
Engine Coolant replaced by your
authorized dealer.
13. Exhaust System : Check the
complete exhaust system every
16 000 km (10,000 miles). Check
body areas near the exhaust
system. Look for broken, damaged,
missing, or out-of-position parts.
Also inspect for open seams, holes,
loose connections, or other
conditions which could cause heat
build-up at the rear body floor pan,
or could let exhaust fumes seep into
the passenger compartment. Dust
or water in the cabin may indicate a
leak in that area. Required repairs
should be made at once.

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
Index 409
Diesel Engine (cont'd)High Idle System . . . . . . . . . . . . . 174
Diesel Exhaust Fluid . . . . . . . . 30, 189
Diesel Exhaust Fluid (DEF) Gauge . . . . . . . . . . . . . . . . . . . . . . . . . 83
Diesel Exhaust Fluid (DEF) Warning Light . . . . . . . . . . . . . . . . . . 90
Diesel Particulate Filter . . . . . . . . . 180
Distracted Driving . . . . . . . . . . . . . . . 133
Dome Lamps . . . . . . . . . . . . . . . . . . . 107
Door Locks . . . . . . . . . . . . . . . . . . . . . . . . . . . 36
Power Locks . . . . . . . . . . . . . . . . . . . . 39
Drive Belt Routing, Engine . . . . . . 396
Driver Behavior . . . . . . . . . . . . . . . . . 133
Driver Information
Center (DIC) . . . . . . . . . . . . . . . . . . . 93
Driving
Emergencies . . . . . . . . . . . . 148, 161
For Better Fuel Economy . . . . . . . 29
Hill and Mountain Roads . . . . . . 144
If the Vehicle is Stuck . . . . . . . . . 148
Wet Roads . . . . . . . . . . . . . . . . . . . 143
Winter . . . . . . . . . . . . . . . . . . . . . . . . 145
Driving the Vehicle . . . . . . . . . . . . . . . . 3
E
Electrical Equipment, Add-On . . . . . . . . . . . . . . . . . . . . . . . 241 Electrical System
Overload . . . . . . . . . . . . . . . . . . . . . 298
Emergencies . . . . . . . . . . . . . . 148, 161
Engine Air Cleaner/Filter . . . . . . . . . . . . . 263
Alarm and AutomaticShutdown . . . . . . . . . . . . . . . . . . . 174
Check Light (Malfunction Indicator) . . . . . . . . . . . . . . . . . . . . . . 84
Checks Before Operating . . . . . 175
Compartment Overview . . . . . . . 249
Coolant . . . . . . . . . . . . . . . . . . . . . . . 263
Coolant Temperature Gauge . . . . 82
Cover . . . . . . . . . . . . . . . . . . . . . . . . . 250
Drive Belt Routing . . . . . . . . . . . . 396
Exhaust . . . . . . . . . . . . . . . . . . . . . . 178
Heater . . . . . . . . . . . . . . . . . . . . . . . . 173
High Idle System . . . . . . . . . . . . . 174
Oil Pressure Light . . . . . . . . . . . . . . 89
Overheating . . . . . . . . . . . . . . . . . . 269
Reduced Power Light . . . . . . . . . . . 91
Running While Parked . . . . . . . . 179
Shutdown Warning Light . . . . . . . . 91
Engine Oil Level Indicator Light . . . . . . . . . . . . 90
Engines Diesel Fuel . . . . . . . . . . . . . . . . . . . 232
Exhaust Brake . . . . . . . . . . . . . . . . . . 222 Exhaust Brake Light . . . . . . . . . . . . . 88
Exhaust Fluid
Diesel . . . . . . . . . . . . . . . . . . . . . . . . 189
Extender, Seat Belt . . . . . . . . . . . . . . 55
Exterior Lamp Controls . . . . . . . . . 103
F
Filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . 180 Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . 282
Filter, Engine Air Cleaner . . . . . . . . . . . 263
Fixed Mast Antenna . . . . . . . . . . . . 113
Flash-to-Pass . . . . . . . . . . . . . . . . . . . 104
Flashers, Hazard Warning . . . . . . 105
Flat Tire . . . . . . . . . . . . . . . . . . . . . . . . 326
Fluid Automatic Transmission . . . . . . 260
Brakes . . . . . . . . . . . . . . . . . . . . . . . . 280
Diesel Exhaust . . . . . . . . . . . . . . . . . 30
Power Steering . . . . . . . . . . . . . . . 273
Washer . . . . . . . . . . . . . . . . . . . . . . . 274
Frequency Statement Radio . . . . . . . . . . . . . . . . . . . . . . . . . 404
Front Seat Position Seats Adjustment . . . . . . . . . . . . . . . . . . . . . 44
Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . 231
Biodiesel . . . . . . . . . . . . . . . . . . . . . 233
Cold Weather Operation . . . . . . 235
Diesel Engines . . . . . . . . . . . . . . . 232

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
410 Index
Fuel (cont'd)Economy Driving . . . . . . . . . . . . . . . 29
Filling the Tank . . . . . . . . . . . . . . . 240
Filter . . . . . . . . . . . . . . . . . . . . . . . . . . 282
Foreign Countries . . . . . . . . . . . . 232
Gauge . . . . . . . . . . . . . . . . . . . . . . . . . . 81
Running out of Fuel . . . . . . . . . . . 238
Water in Fuel . . . . . . . . . . . . . . . . . 236
Fuel for Diesel Engines . . . . . . . . . 232
G
Gauges
Diesel Exhaust Fluid (DEF) . . . . . 83
Engine Coolant Temperature . . . 82
Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . 81
Odometer . . . . . . . . . . . . . . . . . . . . . . . 80
Speedometer . . . . . . . . . . . . . . . . . . . 80
Tachometer . . . . . . . . . . . . . . . . . . . . . 81
Trip Odometer . . . . . . . . . . . . . . . . . . 80
Warning Lights andIndicators . . . . . . . . . . . . . . . . . . . . . 76
General Information Vehicle Care . . . . . . . . . . . . . . . . . . 245
Getting In and Out of the
Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . 35
Glove Box . . . . . . . . . . . . . . . . . . . . . . . 61
GM Mobility Reimbursement Program . . . . . . . . . . . . . . . . . . . . . . . 400
H
Hazard Warning Flashers . . . . . . . 105
Headlamps
Aiming . . . . . . . . . . . . . . . . . . . . . . . . 288
Bulb Replacement . . . . . . . 288, 291
Daytime Running Lamps(DRL) Indicator Light . . . . . . . . . . 92
Flash-to-Pass . . . . . . . . . . . . . . . . . 104
High-Beam On Light . . . . . . . . . . . . 92
High/Low Beam Changer . . . . . 104
Heated Mirrors . . . . . . . . . . . . . . . . . . . 40
Heater Engine . . . . . . . . . . . . . . . . . . . . . . . . 173
Heating . . . . . . . . . . . . . . . . . . . . . . . . . 126
High Idle System . . . . . . . . . . . . . . . 174
High-Beam On Light . . . . . . . . . . . . . 92
Hill and Mountain Roads . . . . . . . . 144
Hooks Shopping Bag . . . . . . . . . . . . . . . . . . 64
Horn . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 72
HVAC . . . . . . . . . . . . . . . . . . . . . . . . . . . 126
I
Idle Shutdown . . . . . . . . . . . . . . . . . . 174
Ignition Positions . . . . . . . . . . . . . . . 163
Infants and Young Children, Restraints . . . . . . . . . . . . . . . . . . . . . . 57
Information on Loading the Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . 64 Instrument Cluster . . . . . . . . . . . . . . . 77
Instrument Panel
Storage Area . . . . . . . . . . . . . . . . . . . 61
Introduction . . . . . . . . . . . . . . . . . . . . . . . 2
J
Jump Starting - North America . . . . . . . . . . . . . . . . . . . . . . . 326
K
Keyless EntryRemote (RKE) System . . . . . . . . . 32
Keys . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31
L
Lamps
Cargo . . . . . . . . . . . . . . . . . . . . . . . . . 107
Cornering . . . . . . . . . . . . . . . . . . . . . 106
Dome . . . . . . . . . . . . . . . . . . . . . . . . . 107
Exterior Controls . . . . . . . . . . . . . . 103
Interior . . . . . . . . . . . . . . . . . . . . . . . . 298
License Plate . . . . . . . . . . . . . . . . . 297
Malfunction Indicator (CheckEngine) . . . . . . . . . . . . . . . . . . . . . . . 84
Roofmarker . . . . . . . . . . . . . . . . . . . 295
Sidemarker . . . . . . . . . . . . . . . . . . . 295
Lap Belt . . . . . . . . . . . . . . . . . . . . . . . . . 53
Lighter, Cigarette . . . . . . . . . . . . . . . . 74
Lighting Illumination Control . . . . . . . . . . . 106