instrument panel CHEVROLET LOW CAB FORWARD 2019 Owner's Guide

Chevrolet Low Cab Forward 5.2L Diesel Engine 4500/5500 Series (GMNA-
Localizing-U.S.-12407814) - 2019 - crc - 12/13/17
268 Vehicle Care
free of any type of damage. Check
the right front brake hose and pipe
in the same way. The rear left and
right brake hoses and pipes should
also be checked in the same
manner.
Disc Brakes and Drum Brakes
If the brake pads and shoe linings
wear out beyond their usable limit,
not only will the brake performance
be impaired, but brake components
could also fail.
{Warning
Do not drive with brake pads and
shoe linings worn out beyond the
limit. Excessively worn brake
pads and shoe linings may cause
breakdown of brake components
and poor braking performance.
You and others could be seriously
injured.
Caution
The pad has an embedded wear
indicator. A squeaking noise from
the indicator means that the pad
is approaching the usable limit.
If the squeaking noise from the
indicator can be heard, contact
the nearest dealer for inspection
or replacement.
Brake Fluid
Checking the Brake Fluid
Level
Remove the inspection cover (1) on
the left- hand side of the instrument
panel by turning it with your fingers.
Check that the fluid level in the
reservoir is between the "MAX" and
"ADD" lines.
If the fluid surface cannot easily be
seen, rock the vehicle gently.
Adding Brake Fluid
If the level of brake fluid has
dropped below the "ADD" line,
remove the cap (2) and add fluid.
Take care to avoid filling beyond the
"MAX" line.
Tighten the cap securely after the
fluid has been added.
When adding brake fluid to the tank,
take care to prevent dirt and water
from entering it. Any dirt or water in
the system could cause the vehicle
to lose braking functions.
Inspect and change brake fluid
according to the Maintenance
Schedule.
Use the recommended brake fluid
when adding brake fluid.

Chevrolet Low Cab Forward 5.2L Diesel Engine 4500/5500 Series (GMNA-
Localizing-U.S.-12407814) - 2019 - crc - 12/13/17
288 Vehicle Care
The Location of Fuses and Relays
The fuses (3) and relays (2) are
located in the lower part of the
instrument panel in the center and
in the left rear of the cab.
The cover (1) must be opened in
order to carry out inspection and
replacement. In addition, the
cover (1) of the relay box at the left
rear of the cab must also be opened
at this time.
If you should spill water or a
beverage on the cover, wipe it off
before opening the cover.
The area around the cover may get
warm when the vehicle is being
driven, but this is not abnormal.Replacing Fuses
1. Before replacing fuses, firmly apply the parking brake, move
the selector lever to the
P (Park) position, and turn the
engine control switch to the
LOCK position.
2. The fuse puller is stored in the fuse box inside the cab. Place
the fuse puller on the fuse and
pull it out.
3. If the fuse appears asshown (2), the fuse is blown.
Replace with a spare fuse (1).
Spare fuses are stored in the
fuse box inside the cab.

Chevrolet Low Cab Forward 5.2L Diesel Engine 4500/5500 Series (GMNA-
Localizing-U.S.-12407814) - 2019 - crc - 12/13/17
Service and Maintenance 347
one side, unusual sounds when
braking, increased brake pedal
travel or harder pedal. The front and
rear brakes are attached to an auto
adjuster mechanism. If there are no
defects, as the pedal travel is
properly maintained, adjustments
are not necessary. Check regularly
that the brake fluid reservoir
(left-hand side of the instrument
panel) or HBB reservoir (5500HD,
5500XD models: left side behind the
cab) is properly filled and check for
fluid leaks. Any of these conditions
could indicate the need for brake
system inspection and/or service.
G: Exhaust System :Be alert for
any changes in the sound of the
exhaust system or any smell of
fumes. These are signs the system
may be leaking. Have it checked
and/or repaired at once. (Refer to
"Engine Exhaust Emissions Caution
(Carbon Monoxide)" under Engine
Exhaust 0177).
H: Windshield Wipers and
Washers : Check operation and
condition of the wiper blades. Check
the flow of the washer spray. I: Defroster :
Turn the outlet
selector knob to "Defroster" and the
fan speed control knob to the fully
clockwise position. Then check the
airflow from the ducts at the inside
base of the windshield.
J: Rearview Mirrors and Sun
Visors : Check that friction joints
hold mirrors and sun visors in place.
K: Horn : Sound the horn, now and
then, to be sure it works.
L: Lap-Shoulder Belts : Check the
seat belt system (including webbing,
buckles, latch plates and anchors)
for proper operation, and for
damage.
M: Seat Adjusters : When
adjusting the driver's manual seat,
be sure the seat adjusters latch by
pushing the seat forward and
backward. Do not attempt to adjust
the seat when the vehicle is in
motion.
N: Lamps : Check panel lighting,
warning lamps, indicator lamps and
interior lamps. On the outside,
check: license plate lamps, side
marker lamps, reflectors on outside mirrors, headlamps, parking lamps,
identification and clearance lamps,
taillights, brake lamps, turn signals,
cornering lamps, backup lamps and
hazard warning flashers. Have
headlamp aim checked immediately
if beams seem improperly aimed.
O: Glass, Mirrors, Lights and/or
Reflectors Condition :
Look for
broken, scratched, dirty or damaged
glass, mirrors, lamps or reflectors
that could reduce the view or
visibility, or cause injury. Replace,
clean or repair promptly.
P: Door Latches : Check that doors
close, latch and lock tightly. Check
for broken, damaged or missing
parts that might prevent tight
latching.
Q :Tilt Cab (Driving Position) : Be
sure the tilt lever is down and
locked.
R: Fluid Leaks : Check for fuel,
water, oil or other fluid leaks by
looking at the surface beneath the
vehicle after it has been parked for

Chevrolet Low Cab Forward 5.2L Diesel Engine 4500/5500 Series (GMNA-
Localizing-U.S.-12407814) - 2019 - crc - 12/13/17
376 Index
FuelBiodiesel . . . . . . . . . . . . . . . . . . . . . 228
Cold Weather Operation . . . . . . 230
Diesel Engines . . . . . . . . . . . . . . . 227
Economy Driving . . . . . . . . . . . . . . . 24
Filling the Tank . . . . . . . . . . . . . . . 235
Filter . . . . . . . . . . . . . . . . . . . . . . . . . . 270
Gauge . . . . . . . . . . . . . . . . . . . . . . . . . . 71
Running out of Fuel . . . . . . . . . . . 233
Water in Fuel . . . . . . . . . . . . . . . . . 231
Fuel for Diesel Engines . . . . . . . . . 227
G
Gauges
Diesel Exhaust Fluid (DEF) . . . . . 72
Engine Coolant Temperature . . . 72
Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . 71
Odometer . . . . . . . . . . . . . . . . . . . . . . . 70
Speedometer . . . . . . . . . . . . . . . . . . . 70
Tachometer . . . . . . . . . . . . . . . . . . . . . 71
Trip Odometer . . . . . . . . . . . . . . . . . . 70
Warning Lights andIndicators . . . . . . . . . . . . . . . . . . . . . 68
General Information Vehicle Care . . . . . . . . . . . . . . . . . . 240
Getting In and Out of the
Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . 29 Glove Box . . . . . . . . . . . . . . . . . . . . . . . 55
GM Mobility Reimbursement
Program . . . . . . . . . . . . . . . . . . . . . . . 366
H
Hazard Warning Flashers . . . . . . . . 94
HeadlampsAiming . . . . . . . . . . . . . . . . . . . . . . . . 277
Bulb Replacement . . . . . . . 277, 280
Daytime Running Lamps(DRL) Indicator Light . . . . . . . . . . 81
Flash-to-Pass . . . . . . . . . . . . . . . . . . . 93
High-Beam On Light . . . . . . . . . . . . 81
High/Low Beam Changer . . . . . . . 93
Heated Mirrors . . . . . . . . . . . . . . . . . . . 34
Heater Engine . . . . . . . . . . . . . . . . . . . . . . . . 172
Heating . . . . . . . . . . . . . . . . . . . . . . . . . 131
High Idle System . . . . . . . . . . . . . . . 174
High-Beam On Light . . . . . . . . . . . . . 81
Hill and Mountain Roads . . . . . . . . 150
Hooks Shopping Bag . . . . . . . . . . . . . . . . . . 57
Horn . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 65
HVAC . . . . . . . . . . . . . . . . . . . . . . . . . . . 131
I
Idle Shutdown . . . . . . . . . . . . . . . . . . 174
Idle Shutdown Light . . . . . . . . . . . . . 80
Ignition Positions . . . . . . . . . . . . . . . 166
Information Publication Ordering . . . . . . . . . . 370
Information on Loading the Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . 58
Instrument Cluster . . . . . . . . . . . . . . . 69
Instrument Panel Storage Area . . . . . . . . . . . . . . . . . . . 55
Introduction . . . . . . . . . . . . . . . . . . . . . . . 2
J
Jump Starting - North America . . . . . . . . . . . . . . . . . . . . . . . 311
K
Keyless EntryRemote (RKE) System . . . . . . . . . 26
Keys . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
L
Lamps
Cargo . . . . . . . . . . . . . . . . . . . . . . . . . . . 96
Cornering . . . . . . . . . . . . . . . . . . . . . . . 95
Dome . . . . . . . . . . . . . . . . . . . . . . . . . . . 96
Exterior Controls . . . . . . . . . . . . . . . . 92
Interior . . . . . . . . . . . . . . . . . . . . . . . . 287

Chevrolet Low Cab Forward 5.2L Diesel Engine 4500/5500 Series (GMNA-
Localizing-U.S.-12407814) - 2019 - crc - 12/13/17
Index 379
Shift Lock Control FunctionCheck, Automatic
Transmission . . . . . . . . . . . . . . . . . . 274
Shopping Bag Hooks . . . . . . . . . . . . 57
Sidemarker Lamps . . . . . . . . . . . . . 284
Signals, Turn and Lane-Change . . . . . . . . . . . . . . . . . . 94
Specifications and Capacities . . . . . . . . . . . . . . . . . . . . . 357
Speedometer . . . . . . . . . . . . . . . . . . . . 70
Starting and Stopping the Vehicle . . . . . . . . . . . . . . . . . . . . . . . . 168
Steering . . . . . . . . . . . . . . . . . . . . . . . . 149 Fluid, Power . . . . . . . . . . . . . . . . . . 262
Wheel Adjustment . . . . . . . . . . . . . . 65
Stoplamps and Back-up Lamps
Bulb Replacement . . . . . . . . . . . . 286
Storage Rear . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57
Storage Areas Glove Box . . . . . . . . . . . . . . . . . . . . . . 55
Information on Loading the
Vehicle . . . . . . . . . . . . . . . . . . . . . . . . 58
Instrument Panel . . . . . . . . . . . . . . . 55
Storage Compartments . . . . . . . . . . 54
Stuck Vehicle . . . . . . . . . . . . . . . . . . . 153 Sun Visors . . . . . . . . . . . . . . . . . . . . . . . 37
System
Noise Control . . . . . . . . . . . . . . . . . 272
T
Tachometer . . . . . . . . . . . . . . . . . . . . . . 71
TaillampsBulb Replacement . . . . . . . . . . . . 286
Temperature, Operating . . . . . . . . 171
Text Telephone (TTY) Users . . . . 365
Three-Point Seat Belt . . . . . . . . . . . . 45
Tires If a Tire Goes Flat . . . . . . . . . . . . 310
Pressure . . . . . . . . . . . . . . . . . . . . . . 307
Rotation . . . . . . . . . . . . . . . . . . . . . . 307
Tires and Wheels . . . . . . . . . . . . . . . 295
Towing Vehicle . . . . . . . . . . . . . . . . . . . . . . . 315
Trademarks and License Agreements . . . . . . . . . . . . . . . . . . . 129
Transmission
Automatic . . . . . . . . . . . . . . . . . . . . . 205
Fluid, Automatic . . . . . . . . . . . . . . 251
Overdrive Off, Automatic . . . . . . 215
Service Warning Light . . . . . . . . . . 77
Trip Odometer . . . . . . . . . . . . . . . . . . . 70 Turn and Lane-Change
Signals . . . . . . . . . . . . . . . . . . . . . . . . . 94
Turn Signal Bulb Replacement . . . . . . . . . . . . 286U
USB Port . . . . . . . . . . . . . . . . . . . . . . . 109
Using This Manual . . . . . . . . . . . . . . . . 3
V
VehicleControl . . . . . . . . . . . . . . . . . . . . . . . 139
Getting In and Out . . . . . . . . . . . . . . 29
Identification Number (VIN) . . . 353
Messages . . . . . . . . . . . . . . . . . . . . . . 86
Security . . . . . . . . . . . . . . . . . . . . . . . . 33
Service Soon Light . . . . . . . . . . . . . 74
Starting and Stopping . . . . . . . . . 168
Towing . . . . . . . . . . . . . . . . . . . . . . . . 315
Vehicle Care Tire Pressure . . . . . . . . . . . . . . . . . 307
Vehicle Data Recording and
Privacy . . . . . . . . . . . . . . . . . . . . . . . . 372
Ventilation, Air . . . . . . . . . . . . . . . . . . 134
Visors . . . . . . . . . . . . . . . . . . . . . . . . . . . 37