air filter CHEVROLET LOW CAB FORWARD 2020 Owner's Guide

Chevrolet Low Cab Forward 5.2L Diesel Engine 4500 HD/XD/5500 HD/XD
Owner Manual (GMNA-Localizing-U.S.-13337621) - 2020 - crc - 12/5/18
Service and Maintenance 329
33. Leaf Spring U-bolt Torque :
Tighten the U-Bolt nuts to the
specified torque after the first
1 040 km (650 miles), thereafter
every 16 000 km (10,000 miles).Model Leaf spring U-bolt nut tightening torque
Front Rear
4500HD 127 Y
(94 lb·ft) 177
Y
(131 lb·ft)
4500XD 196 Y
(145lb·ft) 177
Y
(131 lb·ft)
5500HD, 5500XD 196
Y
(145lb·ft) 284
Y
(209 lb·ft)
34. Wheel Nut Torque : Check tires
for excessive or abnormal wear,
or damage. Also check tire inflation
pressures and adjust.
Be sure wheels are not bent or
cracked and that wheel nuts have
been tightened to the specified
torque after the first 1,040 km
(650 miles) and then every
10 400 km (6,500 miles). Note that
there are left and right hand
threads. Wheel nut tightening torque
500Y(362 lb·ft)
35. King Pin : Lubricate the grease
fitting on the king pins every
12 months or 16 000 km
(10,000 miles) whichever occurs
first.
36. Wheel Hub Bearing Grease :
Clean and repack front wheel
bearings every 24 months or
48 000 km (30,000 miles) whichever
occurs first.
37. Air Conditioner Blower
Filter : The air conditioner blower
filter should be removed and
cleaned once a month.
38. Exhaust Injector : Clean the
exhaust injector every 176,000 km
(110,000 miles).
39. DEF Supply Pump Filter
Element : Replace the DEF supply
pump filter element every
192 000 km (120,000 miles) or
24 months whichever occurs first. 40. Starter :
The color displayed by
the starter indicator light will change
from green to amber when the
number of times remaining is 0 or
below and the screen is selected.
When the indicator light (amber)
comes on, have the vehicle
inspected/serviced at the nearest
dealer.
41. Wiper Blades : Inspect wiper
blades for wear, cracking,
or contamination. Clean the
windshield and wiper blades,
if contaminated, replace wiper
blades that are worn or damaged,
or at least once a year. See Wiper
Blade Replacement 0265.

Chevrolet Low Cab Forward 5.2L Diesel Engine 4500 HD/XD/5500 HD/XD
Owner Manual (GMNA-Localizing-U.S.-13337621) - 2020 - crc - 12/5/18
342 Service and Maintenance
5.2L Diesel
PartGM Part Number
Engine Air Cleaner 97780479
Engine Oil Filter 98298404
Fuel Filter: Engine Side 98147525
Fuel Filter: Chassis Side 98037481
Replacement Fasteners
During vehicle maintenance, any
fasteners used to replace older
ones must have the same
measurements and strength as
those removed, whether metric or
customary. Fasteners taken from
the vehicle should be saved for
reuse in the same location when
possible. Where a fastener cannot
be used again, take care to choose
a replacement that matches the old
one. For information and help, see
your dealer.{Warning
This vehicle is primarily
dimensioned in the metric system.
Most fasteners are metric and
many are very close in dimension
to well-known customary
fasteners in the inch system.
Mismatched or incorrect fasteners
can result in damage to the
vehicle or possibly personal
injury.

Chevrolet Low Cab Forward 5.2L Diesel Engine 4500 HD/XD/5500 HD/XD
Owner Manual (GMNA-Localizing-U.S.-13337621) - 2020 - crc - 12/5/18
Index 365
IndexA
Accessories andModifications . . . . . . . . . . . . . . . . . . 230
Add-On Electrical Equipment . . . 227
Additional Maintenance and Care . . . . . . . . . . . . . . . . . . . . . . 336
Adjustments Seat, Initial Drive . . . . . . . . . . . . . . . 26
Agreements Trademarks and License . . . . . .119
Air Cleaner/Filter, Engine . . . . . . . 243
Air Conditioning . . . . . . . . . . . . . . . . 121
Air Filter, Passenger Compartment . . . . . . . . . . . . . . . . . 125
Air Vents . . . . . . . . . . . . . . . . . . . . . . . 124
AM-FM Radio . . . . . . . . . . . . . . . . . . . . 85
Antenna Fixed Mast . . . . . . . . . . . . . . . . . . . . . 90
Antilock Brake System (ABS) . . . 207
Warning Light . . . . . . . . . . . . . . . . . . . 64
Appearance Care Exterior . . . . . . . . . . . . . . . . . . . . . . . 307
Interior . . . . . . . . . . . . . . . . . . . . . . . . 313
Assistance Program,
Roadside . . . . . . . . . . . . . . . . . . . . . . 358
Audio Bluetooth . . . . . . . . . . . . . . . . . . . . . 108 Audio Players
CD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 90
Automatic Transmission . . . . . . . . . . . . . . . . . 196
Transmission Fluid . . . . . . . . . . . 241
Automatic Transmission Selector Lever . . . . . . . . . . . . . . . . 205
Shift Lock Control Function
Check . . . . . . . . . . . . . . . . . . . . . . . 264
Automatic Transmission Fluid Temperature Warning Light . . . . . 66
Automatic Transmission Overdrive Off . . . . . . . . . . . . . . . . . . 206
Auxiliary Devices . . . . . . . . . . . . . . . . . . . . . . . 107
Axle, Rear . . . . . . . . . . . . . . . . . 261, 262
B
Battery - North America . . . . 259, 301
Battery Warning Light . . . . . . . . . . . . 61
Biodiesel . . . . . . . . . . . . . . . . . . . . . . . 219
Blade Replacement, Wiper . . . . . 265
Bluetooth
Overview . . . . . . . . . . . . . . . . . . . . . . 111
Bluetooth Audio . . . . . . . . . . . . . . . . 108
Brake Exhaust . . . . . . . . . . . . . . . . . . . . . . 213
System Warning Light . . . . . . . . . . 62

Chevrolet Low Cab Forward 5.2L Diesel Engine 4500 HD/XD/5500 HD/XD
Owner Manual (GMNA-Localizing-U.S.-13337621) - 2020 - crc - 12/5/18
Index 367
D
Damage Repair, Collision . . . . . . . 359
Danger, Warning, and Caution . . . . 3
Daytime Running Lamps (DRL)Indicator Light . . . . . . . . . . . . . . . . . . 69
Devices Auxiliary . . . . . . . . . . . . . . . . . . . . . . 107
Diesel Engine Engine Alarm andAutomatic Shutdown . . . . . . . . 164
Diesel Exhaust Fluid . . . . . . . . . . . . 180
Diesel Exhaust Fluid (DEF) Gauge . . . . . . . . . . . . . . . . . . . . . . . . . 60
Diesel Exhaust Fluid (DEF)
Warning Light . . . . . . . . . . . . . . . . . . 68
Diesel Particulate Filter . . . . . . . . . 171
Distracted Driving . . . . . . . . . . . . . . . 130
Dome Lamps . . . . . . . . . . . . . . . . . . . . 84
Door Locks . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
Power Locks . . . . . . . . . . . . . . . . . . . . 21
Drive Belt Routing, Engine . . . . . . 355
Driver Behavior . . . . . . . . . . . . . . . . . 129
Driver Information Center (DIC) . . . . . . . . . . . . . . . . . . . 70
Driving Better Fuel Economy . . . . . . . . . 129
Emergencies . . . . . . . . . . . . 145, 155 Driving (cont'd)
Hill and Mountain Roads . . . . . . 141
If the Vehicle is Stuck . . . . . . . . . 144
Wet Roads . . . . . . . . . . . . . . . . . . . 140
Winter . . . . . . . . . . . . . . . . . . . . . . . . 142
E
Electrical Equipment,
Add-On . . . . . . . . . . . . . . . . . . . . . . . 227
Electrical System
Overload . . . . . . . . . . . . . . . . . . . . . 277
Emergencies . . . . . . . . . . . . . . 145, 155
Engine Air Cleaner/Filter . . . . . . . . . . . . . 243
Alarm and Automatic
Shutdown . . . . . . . . . . . . . . . . . . . 164
Check Light (Malfunction Indicator) . . . . . . . . . . . . . . . . . . . . . . 61
Checks Before Operating . . . . . 166
Compartment Overview . . . . . . . 234
Coolant . . . . . . . . . . . . . . . . . . . . . . . 243
Coolant Temperature Gauge . . . . 60
Cover . . . . . . . . . . . . . . . . . . . . . . . . . 235
Drive Belt Routing . . . . . . . . . . . . 355
Exhaust . . . . . . . . . . . . . . . . . . . . . . 168
Heater . . . . . . . . . . . . . . . . . . . . . . . . 163
High Idle System . . . . . . . . . . . . . 165
Oil Pressure Light . . . . . . . . . . . . . . 67 Engine (cont'd)
Overheating . . . . . . . . . . . . . . . . . . 249
Reduced Power Light . . . . . . . . . . . 69
Running While Parked . . . . . . . . 170
Shutdown Warning Light . . . . . . . . 68
Engine Oil Level Indicator Light . . . . . . . . . . . . 67
Engines Diesel Fuel . . . . . . . . . . . . . . . . . . . 218
Exhaust Brake . . . . . . . . . . . . . . . . . . 213
Exhaust Brake Light . . . . . . . . . . . . . 65
Exhaust Fluid Diesel . . . . . . . . . . . . . . . . . . . . . . . . 180
Extender, Seat Belt . . . . . . . . . . . . . . 37
Exterior Lamp Controls . . . . . . . . . . 80
F
Filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . 171 Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . 260
Filter, Engine Air Cleaner . . . . . . . . . . . 243
Fixed Mast Antenna . . . . . . . . . . . . . 90
Flash-to-Pass . . . . . . . . . . . . . . . . . . . . 81
Flashers, Hazard Warning . . . . . . . 82
Flat Tire . . . . . . . . . . . . . . . . . . . . . . . . 300
Fluid Automatic Transmission . . . . . . 241
Brakes . . . . . . . . . . . . . . . . . . . . . . . . 258

Chevrolet Low Cab Forward 5.2L Diesel Engine 4500 HD/XD/5500 HD/XD
Owner Manual (GMNA-Localizing-U.S.-13337621) - 2020 - crc - 12/5/18
370 Index
P
ParkingBrake . . . . . . . . . . . . . . . . . . . . . . . . . .211
Over Things That Burn . . . . . . . 167
Passenger Compartment Air
Filter . . . . . . . . . . . . . . . . . . . . . . . . . . 125
Pedals . . . . . . . . . . . . . . . . . . . . . . . . . . 157
Perchlorate Materials Requirements, California . . . . . . 230
Phone
Bluetooth . . . . . . . . . . . . . . . . . . . . . . 111
Port USB . . . . . . . . . . . . . . . . . . . . . . . . . . . . 98
Power
Door Locks . . . . . . . . . . . . . . . . . . . . . 21
Outlets . . . . . . . . . . . . . . . . . . . . . . . . . 55
Reduced Engine Light . . . . . . . . . . 69
Steering Fluid . . . . . . . . . . . . . . . . . 252
Windows . . . . . . . . . . . . . . . . . . . . . . . 23
Power Take-Off (PTO) . . . . . . . . . . 227
Pregnancy, Using Seat Belts . . . . 35
Privacy Vehicle Data Recording . . . . . . . 363
Proposition
65 Warning,
California . . . . . . . . . . . .230, 259, 301, Back CoverPublication Ordering
Information . . . . . . . . . . . . . . . . . . . . 362
R
Radio Frequency Statement . . . . 362
Radio Reception . . . . . . . . . . . . . . . . . 89
Radios
AM-FM Radio . . . . . . . . . . . . . . . . . . . 85
Rear Axle . . . . . . . . . . . . . . . . . . 261, 262
Rear Seats . . . . . . . . . . . . . . . . . . . . . . 30
Rear Storage . . . . . . . . . . . . . . . . . . . . 45
Recommended Fluids and Lubricants . . . . . . . . . . . . . . . . . . . . . 339
Reduced Engine Power Light . . . . 69
Reimbursement Program, GM Mobility . . . . . . . . . . . . . . . . . . . 358
Remote Keyless Entry (RKE)
System . . . . . . . . . . . . . . . . . . . . . . . . . 14
Replacement Parts Maintenance . . . . . . . . . . . . . . . . . . 341
Reporting Safety Defects
General Motors . . . . . . . . . . . . . . . 363
U.S. Government . . . . . . . . . . . . . 363
Roads Driving, Wet . . . . . . . . . . . . . . . . . . 140
Roadside Assistance
Program . . . . . . . . . . . . . . . . . . . . . . . 358
Roofmarker Lamps . . . . . . . . . . . . . 274 Rotation, Tires . . . . . . . . . . . . . . . . . . 297
Routing, Engine Drive Belt . . . . . . 355
Running out of Fuel . . . . . . . . . . . . . 224
Running the Vehicle While
Parked . . . . . . . . . . . . . . . . . . . . . . . . 170
S
Safety Defects ReportingGeneral Motors . . . . . . . . . . . . . . . 363
U.S. Government . . . . . . . . . . . . . 363
Safety System Check . . . . . . . . . . . . 37
Scheduling Appointments . . . . . . . 359
Seat Belts . . . . . . . . . . . . . . . . . . . . . . . 31 Care . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37
Extender . . . . . . . . . . . . . . . . . . . . . . . . 37
Lap Belt . . . . . . . . . . . . . . . . . . . . . . . . 36
Reminders . . . . . . . . . . . . . . . . . . . . . . 60
Three-Point . . . . . . . . . . . . . . . . . . . . . 33
Use During Pregnancy . . . . . . . . . . 35
Seats Position, Front . . . . . . . . . . . . . . . . . . 26
Rear . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
Security Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . 21
Selector Lever . . . . . . . . . . . . . . . . . . 205
Service . . . . . . . . . . . . . . . . . . . . . . . . . 126 Accessories andModifications . . . . . . . . . . . . . . . . 230