suspension CHEVROLET LUMINA 1993 1.G Owners Manual
[x] Cancel search | Manufacturer: CHEVROLET, Model Year: 1993, Model line: LUMINA, Model: CHEVROLET LUMINA 1993 1.GPages: 324, PDF Size: 17.44 MB
Page 270 of 324
Downloaded from www.Manualslib.com manuals search engine Maintenance Schedule
Section A: Scheduled Maintenance Services (cont.)
Explanation of Scheduled Maintenance Services
Below are explanations of the services listed in Schedule I
and Schedule 11. The proper fluids and
lubricants to use are listed in Section
D. Make sure whoever services your vehicle uses these. All
parts should be replaced and all necessary repairs done
before you or anyone else drives the vehicle.
ITEM
NO.
1
2
SERVICE
Engine Oil and Filter Change*-Always use SG
Energy Conserving I1 oils of proper viscosity. The
“SG” designation may be shown alone or in
combination with others, such as “SG/CC,”
“SG/CD” or “SF, SG, CC,” etc. To determine the
preferred viscosity for your vehicle’s engine
(e.g.,
SAE 5W-30 or SAE 1OW-30) see the Index under
Engine Oil.
Chassis Lubrication-Lubricate the transaxle shift
linkage, parking brake cable guides, underbody contact points and linkage. Lubricate the front and
rear suspension.
ITEM
NO. SERVICE
3 Throttle Body Mounting Bolt Torque (3.1L
Code T or W engine only)*-Check the torque of
the mounting bolts and/or nuts.
4 Tire and Wheel Rotation and Inspection-For
proper wear and maximum tire life, rotate your
tires following the instructions in this manual. See
the
Index under Tires, Inspection G Rotation.
Check the tires for uneven wear or damage. If you
see irregular or premature wear, check the wheel
alignment. Check for damaged wheels also.
NOTE: To determine your engine’s displacement and code, see the Index under Engine Identification.
* An Emission Control Service.
* The US. Environmental Protection Agency has determined that the failure \
to perform this maintenance item will not nullify the emission
warranty
or limit recall liability prior to the completion of vehicle useful life. General Motors, however, urges that all recommended
maintenance services be performed at the indicated intervals and\
the maintenance be recorded in Section
E: Maintenance Record.
5 Engine Accessory Drive Belt Inspection
(California 3.1L Code T
or W engine*)-Inspect 1
the belt for cracks, fraying, wear and proper
tension. Replace as needed.
Page 276 of 324
Downloaded from www.Manualslib.com manuals search engine Maintenance Schedule
Section C: Periodic Maintenance Inspections
Listed below are inspections and services which should be performed at least twice a year (for instance, each spring an\
d M).
You should let your GM dealer’s service department or other qualified service center do these jobs. Make sure any necessary
repairs are completed at once.
INSPECTION
OR SERVICE
Steering, Suspension
and Front-Wheel-Drive
Axle Boot and Seal
Inspection
Exhaust System
Inspection
Throttle Linkage
Inspection
Brake System
Inspection
I
WHAT SHOULD BE DONE
Inspect the front and rear suspension and steering system for damaged, loose or missing parts,
signs of wear, or lack of lubrication. Inspect the power steering lines and hoses for pro\
per
hookup, binding,
leaks, cracks, chafing, etc. Clean and then inspect the drive axle boot seals for
damage, tears or leakage. Replace
seals if necessary.
Inspect the complete exhaust system. Inspect the body near the exhaust system.
Look for broken,
damaged, missing or out-of-position parts as well as open seams, holes, loose connections, or
other conditions which could cause
a heat build-up in the floor an or could let exhaust fumes
into
the vehicle. See the Index under Engine Exhaust.
Inspect the throttle linkage for interference or binding, and for damaged or missing parts.
Replace parts as needed.
-~~
Inspect the complete system. Inspect brake lines and hoses for proper hookup, binding, leaks,
cracks, chafing, etc. Inspect disc brake pads for wear and rot\
ors for surface condition. Inspect
other brake parts, including calipers, parking brake, etc. Check parking brake adjustment. You
may need to have your brakes inspected more often
if your driving habits or conditions result in
frequent braking.
NOTE: A low brake fluid level can indicate worn disc brake pads which \
may need to be
serviced.
Also, if the brake system warning light stays on or comes on, something may be wrong
with the brake system.
See the Ida under Brake System Warning Light. If your vehicle is
equipped with anti-lock brakes and the anti-lock brake system w\
arning light
stays on, comes on
or flashes, something may be wrong with the anti-lock brake system. See the
Index under Anti-
Lock Brake System Warning Light.
I
Page 293 of 324
Downloaded from www.Manualslib.com manuals search engine 1993 CHEVROLET SERVICE PUBLICATIONS ORDERING INFORMATION
The following publications cowring the operation and servicing of your vehicle can be purchased by filling out the Service Publications Order Form
in this book and mailina it with mur check, money order or credit card information to Helm. Incormrated (address listed below).
CURRENT PUBLICATIONS FOR 1993 CHEVROLET LUMINA
PRODUCT SERVICE PUBLICATIONS
Product Service Publications (PSP’s), are bulletins, letters \
and articles
published for trained dealer service personnel. See Service Publica-
tions listed previously in this section.
A cumulative index is published quarterly during the current model
year. The indexes list all PSP’s published
by Chevrolet in the model year.
PSP index
Year Form Number Price
1993 PSPI-93 ............................... Free
1992 PSPI-92
............................... Free
1991 PSPI-91
............................... Free
1990 PSPI-90
............................... Free
NOTE: Form Numbers for individual Product Service Publications may
be found in the PSP Index. Prices are
$4.00 for the first PSP and $2.00
for each additional PSP on the same order.
PSP Bound Bulletin Book (Complete Year Bulletins)
Year Description Form Number Price
1991 All PSPk .................... PSP-91-4 40.00
1990 All PSPk .................... PSP-90-4 40.00
For subscription information call Helm, Incorporated. SERVICE MANUALS
Service Manuals have the diagnosis, repair and overhaul informat\
ion
on engines, transmission, axle, suspension, brakes, electrical, s\
teer-
ing, body, etc.
Model Form Number Price 1993 Chevrolet Lumina.
............. ST-379-93 $43.00
*Please specify special body
or engine types on order form. Write
information in the Form Number column.
For example: Turbo,
Convertible.
OWNER’S INFORMATION
Owner publications are written directly for Owners and intended to pro-
vide basic operational information about the vehicle. The Owner’s
Manual includes the Maintenance Schedule
for all models.
1993 Chevrolet Lumina Owner’s Manual
in Portfolio:
Includes &dfolio, Owner‘s Manualand Wrranty Booklet.
1993 Chevrolet Lumina In-Porlfolio
....... .lo202984 $15.00
Without Portfolio: Includes Owner‘s Manual.
1993
Chevrolet Lumina Without Portfolio ......... .lo193599 $11.00
~~~~ ~~ ~
CURRENT & PAST MODEL ORDER FORMS Address all inquiries to: HELM, INCORPORATED
Service Publications are available
for current and past model Chevrolet EO, Box 07130
vehicles. To request an order form, please specify year and model Detroit, MI 482CV
name of vehicle.
Credit Card Orders ONLY: 1-800-782-4356
For information and inquiries call: (313) 883-1430