CHEVROLET MONTE CARLO 1999 5.G Owners Manual

yellowblue
6-63
Fuse Rating
Description
19 Power Accessory #1
-- Door Lock
Switches, Trunk Courtesy Lamp,
O/S Mirror Switch, (S.E.O.)
Emergency Vehicle
-Rear
Compartment Lid Lamp or
Window Panel Lamps
20 Steering Wheel Control #2
--
Steering Wheel Radio Controls
21 Air Bag
-- Air Bag System
22 Cruise Control
-- Cruise Control
Cut
-Out Switch, Cruise Control
Module, Turn Signal Cruise
Control Switches
23 Stoplamps
-- Stoplamp Switch
(Brake)
24 Not Used
25 English/Metric (S.E.O.)Fuse Rating
Description
26 Not Used
27 Not Used
28 CTSY Lamps
-- Vanity Mirrors,
I/P Compartment Lamp, I/S
Lighted Rearview Mirror, Dome
Lamp
29 Wiper
-- Wiper Switch
30 Turn Signal
-- Turn Signal Flasher
31 Not Used
32 Power Locks
-- Door Lock Relay,
Remote Keyless Entry Receiver
33 DRL MDL
-- Daytime Running
Lamp Module, (S.E.O.) Accessory
Switch
34 Not Used
35 Not Used

yellowblue
6-64
Fuse Rating
Description
36 Not Used
37 Rear Defog
-- Rear Window
Defogger Switch Relay
38 Radio
-- Radio, Power Drop
39 I/P Electronics Ignition Feed
--
Headlamp Switch, Instrument
Cluster, Chime Module, Keyless
Entry Receiver, Stoplamp switch
(TCC and BTSI) (S.E.O.)
Accessory SwitchFuse Rating
Description
40 Not Used
41 Power Drop
42 Evap. Sol.
-- Evaporation
Emissions (EVAP) Canister Vent
Solenoid Valve
43 Not Used
44 Not Used
45 Not Used

yellowblue
6-65
Underhood Electrical Center -- Passenger's Side
Some fuses are in a fuse block on the passenger's side of
the engine compartment.
Fuse Description
R/CMPT REL Remote Trunk Release, Back
-Up
Lamps, Remote Control Door
Lock Receiver
PCM BAT Powertrain Control Module
(PCM), Fuel Pump Relay, Fan
Cont #1 and #2 Relay
A/C CONT A/C CMPR Relay
TRANS Automatic Transaxle

yellowblue
6-66
Fuse Description
F/INJN Fuel Injectors
PCM IGN Mass Air Flow (MAF) Sensor
Heated Oxygen Sensor #1 and #2
Evaporative Emissions (EVAP)
Canister Purge Solenoid Valve
ELEK IGN Ignition Control (IC) Module
10 I/P Fuse Block
12 Passenger's Side Underhood
Electrical Center, IGN SYST
Relay, R/CMPT REL fuse, PCM
BAT fuse
13 FAN CONT #1 Relay
Relay Description
14 FUEL PUMP
15 A/C CMPR
16 FAN CONT #2
-- Secondary
Cooling Fan (Passenger's Side)
17 FAN CONT #1
-- Primary
Cooling Fan (Driver's Side)
18 IGN SYSTUnderhood Electrical Center
-- Driver's Side
Additional fuses are in a fuse block on the driver's side
of the engine compartment.

yellowblue
6-67
Fuse Description
FAN #3 FAN #3 Relay
PARK LPS Headlamp Switch
HORN Horn RelayFuse Description
ABS Anti
-Lock Brake System
11 Circuit Breaker C, Starter Relay,
STR WHL Control # 2, Power
Accessory #2, and Theft
-Deterrent
Relay
12 HD LPS
-- Circuit Breaker to
Headlamp Switch
13 ABS
-- ABS Relay
Relay Description
14 ABS
-- Anti-Lock Brake System
15 FAN #3
-- Secondary Cooling Fan
(Passenger's Side)
16 HORN

yellowblue
6-68
Replacement Bulbs
Exterior Lamps Bulb Number
Back
-Up 3156 or 3057. . . . . . . . . . . . . . . . . . . . . . . . .
Center High
-Mounted Stoplamp 891T2. . . . . . . . . . .
Front Parking/Turn Signal 3357NA. . . . . . . . . . . . . . .
Headlamp, High
-Beam 9005. . . . . . . . . . . . . . . . . . .
Headlamp, Low
-Beam 9006. . . . . . . . . . . . . . . . . . . .
Stop/Tail/Turn Signal 3057. . . . . . . . . . . . . . . . . . . . .
Interior Lamps Bulb Number
Dome 10230955. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
*For service information on these bulbs, contact your
Chevrolet dealer service department.
Capacities and Specifications
Please refer to ªRecommended Fluids and Lubricantsº
in the Index for more information.
4T60E:
Automatic Transaxle
Pan Removal and Replacement 7.0 quarts (6.7 L). . .
After Complete Overhaul 9.6 quarts (9.2 L). . . . . . . .
4T65E:Automatic Transaxle
Pan Removal and Replacement 7.4 quarts (7.0 L). . .
After Complete Overhaul 10.0 quarts (9.5 L). . . . . . .
When draining/replacing converter, more fluid will be
needed.
Cooling System Including Reservoir
3100 (Code M) V6 11.6 quarts (10.9 L). . . . . . . . . . . .
3800 (Code K) V6 11.7 quarts (11.0 L). . . . . . . . . . . .
Refrigerant (R
-134a),
Air Conditioning*1.88 lbs. (0.85 kg) . . . . . . . . . . .
Engine Crankcase
- Oil and Filter Change
3100 (Code M) V6 4.5 quarts (4.3 L). . . . . . . . . . . . .
3800 (Code K) V6 4.5 quarts (4.3 L). . . . . . . . . . . . .
Fuel Tank
3100 (Code M) V6 16.6 gallons (62.8 L). . . . . . . . . . .
3800 (Code K) V6 16.6 gallons (62.8 L). . . . . . . . . . .
*See ªAir Conditioning Refrigerantsº later in this
section.
Note: All capacities are approximate. When adding, be
sure to fill to the approximate level, as recommended in
this manual. See ªRecommended Fluids and Lubricantsº
in the Index.

yellowblue
6-69
Engine Specifications 3100 (Code M) 3800 (Code K)
Type V6 V6. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Displacement 191 CID 231 CID. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Compression Ratio 9.6:1 9.25:1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Firing Order 1
-2-3-4-5-61-6-5-4-3-2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Thermostat Temperature 195
F (91
C) 195
F (91
C) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Horsepower 160 @ 5200 200 @ 5200. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

yellowblue
6-70
Air Conditioning Refrigerants
Not all air conditioning refrigerants are the same.
If the air conditioning system in your vehicle needs
refrigerant, be sure the proper refrigerant is used.
If you're not sure, ask your dealer.
Normal Maintenance
Replacement Parts
Engine Air Cleaner/Filter
All Engines A1208C. . . . . . . . . . . . . . . . . . . . . . . . . . .
Battery
3100 (Code M) V6 600 CCA. . . . . . . . . . . . . . . . . . . .
3800 (Code K) V6 690 CCA. . . . . . . . . . . . . . . . . . . .
Engine Oil Filter
3100 (Code M) V6 PF47. . . . . . . . . . . . . . . . . . . . . . .
3800 (Code K) V6 PF47. . . . . . . . . . . . . . . . . . . . . . .
PCV Valve
3100 (Code M) V6 CV892C. . . . . . . . . . . . . . . . . . . .
Radiator Cap
All Engines RC27. . . . . . . . . . . . . . . . . . . . . . . . . . . . . Spark Plugs
3100 (Code M) V6 AC Type 41
-940 . . . . . . . . . . . . . .
Gap: 0.060 inches (.152 cm)
3800 (Code K) V6 AC Type 41
-921 . . . . . . . . . . . . . .
Gap: 0.060 inches (1.52 cm)
Windshield Wiper
Length 22 inches (56 cm). . . . . . . . . . . . . . . . . . . . . .
Type hook. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Vehicle Dimensions
Wheelbase 107.5 inches (273.0 cm). . . . . . . . . . . . . .
Tread Width (Front) 59.5 inches (151.2 cm). . . . . . . .
Tread Width (Rear) 59.1 inches (150.0 cm). . . . . . . .
Length 200.7 inches (509.9 cm). . . . . . . . . . . . . . . . .
Width 71.9 inches (182.5 cm). . . . . . . . . . . . . . . . . . .
Height 53.9 inches (136.8 cm). . . . . . . . . . . . . . . . . . .

7-
yellowblue
7-1
Section 7 Maintenance Schedule
This section covers the maintenance required for your vehicle. Your vehicle needs these services to retain its safety,
dependability and emission control performance.
7
-2 Introduction
7
-4 Part A: Scheduled Maintenance Services
7
-5 Scheduled Maintenance
7
-14 Part B: Owner Checks and Services7
-18 Part C: Periodic Maintenance Inspections
7
-20 Part D: Recommended Fluids and Lubricants
7
-21 Part E: Maintenance Record

yellowblue
7-2
Have you purchased the GM Protection Plan? The Plan
supplements your new vehicle warranties. See your
Warranty and Owner Assistance booklet, or your dealer
for details.
Introduction
Your Vehicle and the Environment
Proper vehicle maintenance not only helps to keep your
vehicle in good working condition, but also helps the
environment. All recommended maintenance procedures
are important. Improper vehicle maintenance can even
affect the quality of the air we breathe. Improper fluid
levels or the wrong tire inflation can increase the level
of emissions from your vehicle. To help protect our
environment, and to keep your vehicle in good
condition, please maintain your vehicle properly.