warning CHEVROLET SILVERADO 2003 1.G Service Manual

Changing a Flat Tire
If a tire goes ¯at, avoid further tire and wheel damage
by driving slowly to a level place. Turn on your
hazard warning ¯ashers.
{CAUTION:
Changing a tire can cause an injury. The
vehicle can slip off the jack and roll over you
or other people. You and they could be badly
injured. Find a level place to change your tire.
To help prevent the vehicle from moving:
1. Set the parking brake ®rmly.
2. Put the shift lever in PARK (P).
3. Turn off the engine.
4. Put the wheel blocks at the front and rear
of the tire farthest away from the one
being changed. That would be the tire on
the other side of the vehicle, at the
opposite end.The following steps will tell you how to use the jack and
change a tire.
5-80

Appearance Care
Remember, cleaning products can be hazardous. Some
are toxic. Others can burst into ¯ames if you strike a
match or get them on a hot part of the vehicle. Some are
dangerous if you breathe their fumes in a closed space.
When you use anything from a container to clean your
vehicle, be sure to follow the manufacturer's warnings
and instructions. And always open your doors or windows
when you are cleaning the inside.
Never use these to clean your vehicle:
·Gasoline
·Benzene
·Naphtha
·Carbon Tetrachloride
·Acetone
·Paint Thinner
·Turpentine
·Lacquer Thinner
·Nail Polish Remover
They can all be hazardous Ð some more than
others Ð and they can all damage your vehicle, too.Do not use any of these unless this manual says you
can. In many uses, these will damage your vehicle:
·Alcohol
·Laundry Soap
·Bleach
·Reducing Agents
Cleaning the Inside of Your Vehicle
Use a vacuum cleaner often to get rid of dust and
loose dirt. Wipe vinyl, leather, plastic and painted
surfaces with a clean, damp cloth.
Cleaning Fabric/Carpet
Your dealer has cleaners for the cleaning of fabric and
carpet. They will clean normal spots and stains very well.
You can get GM-approved cleaning products from your
dealer. See
Vehicle Care/Appearance Materials on
page 5-107.
Here are some cleaning tips:
·Always read the instructions on the cleaner label.
·Clean up stains as soon as you can Ð before
they set.
·Carefully scrape off any excess stain.
5-100

A
Accessory Power Outlets.................................3-19
Adding a Snow Plow or Similar Equipment.........4-61
Adding Washer Fluid.......................................5-43
Additional Program Information........................... 7-8
Additives, Fuel................................................. 5-5
Add-On Electrical Equipment...........................5-109
Add-On Equipment..........................................4-60
Adjusting the Speakers
(Balance/Fade)..................3-74, 3-78, 3-88, 3-101
After Off-Road Driving.....................................4-37
Air Bag Systems.............................................1-64
Adding Equipment to Your Air Bag-Equipped
Vehicle...................................................1-80
Air Bag Off Switch.......................................1-71
How Does an Air Bag Restrain?....................1-69
Passenger Sensing System...........................1-76
Servicing Your Air Bag-Equipped Vehicle.........1-80
What Makes an Air Bag In¯ate?....................1-69
What Will You See After an Air Bag In¯ates?......1-70
When Should an Air Bag In¯ate?...................1-68
Where Are the Air Bags?..............................1-66
Air Bag .........................................................3-37
Off Light.....................................................3-37
Passenger Status Indicator...........................3-40
Readiness Light..........................................3-36
Air Cleaner/Filter, Engine.................................5-21
Air Conditioning..............................................3-30
All-Wheel Drive (AWD) System.........................2-44All-Wheel Drive...............................................5-54
AM-FM Radio.................................................3-72
AM .............................................................3-123
Antenna, Fixed Mast......................................3-125
Antenna, XMŸ Satellite Radio Antenna
System.....................................................3-125
Anti-Lock Brake, System Warning Light..............3-45
Anti-lock Brake System..................................... 4-6
Appearance Care..........................................5-100
Care of Safety Belts...................................5-103
Chemical Paint Spotting..............................5-106
Cleaning the Inside of Your Vehicle..............5-100
Cleaning the Outside of Your Vehicle............5-103
Finish Damage..........................................5-106
Sheet Metal Damage..................................5-105
Underbody Maintenance.............................5-106
Vehicle Care/Appearance Materials...............5-107
Weatherstrips............................................5-103
Approaching a Hill..........................................4-28
Ashtrays........................................................3-20
Audio Output................................................3-117
Audio System(s).............................................3-71
AM-FM Radio.............................................3-72
Audio Steering Wheel Controls....................3-122
Care of Your Cassette Tape Player...............3-123
Care of Your CD and DVD Player................3-124
Care of Your CDs and DVDs.......................3-124
Chime Level Adjustment.............................3-125
Fixed Mast Antenna...................................3-125
Radio with Cassette and CD.........................3-85
1

Audio System(s) (cont.)
Radio with CD............................................3-75
Radio with Six-Disc CD................................3-98
Rear Seat Audio (RSA)...............................3-120
Setting the Time for Radios with Radio Data
Systems (RDS)........................................3-72
Setting the Time for Radios without Radio
Data Systems (RDS)................................3-72
Theft-Deterrent Feature...............................3-121
Understanding Radio Reception...................3-123
XMŸ Satellite Radio Antenna System...........3-125
Automatic Headlamp System............................3-15
Automatic Transfer Case..................................2-37
Automatic Transmission Check..........................6-13
Automatic Transmission Shift Lock Control
System Check.............................................6-15
Automatic Transmission...................................2-22
Fluid..................................................5-23, 5-26
Operation...................................................2-25
Auxiliary Battery..............................................4-94
Auxiliary Roof Mounted Lamp Switch.................3-17
B
Backing Up....................................................4-86
BATTERY NOT CHARGING.............................3-65
Battery Replacement......................................... 2-6
Battery Run-Down Protection............................3-19
Battery Warning Light......................................3-42Battery..........................................................5-47
Before Leaving on a Long Trip.........................4-44
Before You Drive...........................................3-111
Before You Go Off-Roading..............................4-24
Body Lubrication Service..................................6-14
Brake Adjustment............................................5-47
Brake Fluid....................................................5-44
Brake Pedal Travel.........................................5-47
Brake Wear...................................................5-46
Brake............................................................2-44
Parking......................................................2-44
System Inspection.......................................6-18
System Warning Light..................................3-44
Brakes..........................................................5-44
Braking in Emergencies..................................... 4-8
Braking........................................................... 4-6
Break-In, New Vehicle.....................................2-20
BUCKLE PASSENGER....................................3-65
BUCKLE SEATBELT.......................................3-65
Bulb Replacement...........................................5-59
Center High-Mounted Stoplamp (CHMSL) and
Cargo Lamp............................................5-63
Front Turn Signal, Sidemarker and Daytime
Running Lamps........................................5-61
Halogen Bulbs............................................5-59
Headlamps.................................................5-59
Pickup Box Identi®cation and Fender Marker
Lamps....................................................5-65
Replacement Bulbs......................................5-67
Roof Marker Lamps.....................................5-62
2

D
Daytime Running Lamps..................................3-15
Defensive Driving............................................. 4-2
Defogging and Defrosting.........................3-23, 3-31
Delayed Locking............................................... 2-9
Dinghy Towing................................................4-55
Doing Your Own Service Work........................... 5-3
Dolly Towing..................................................4-57
Dome Lamps.................................................3-18
Door............................................................... 2-9
Delayed Locking........................................... 2-9
Locks.......................................................... 2-7
Power Door Locks......................................... 2-8
Programmable Automatic Door Locks.............2-10
Rear Door Security Locks.............................2-12
Rear Doors.................................................2-13
DRIVER DOOR AJAR.....................................3-66
Driver Information Center (DIC).........................3-54
DIC Operation and Displays..........................3-55
DIC Warnings and Messages........................3-65
Driver............................................................1-16
Position, Safety Belt.....................................1-16
Driving Across an Incline..................................4-34
Driving Downhill..............................................4-32
Driving in Mud, Sand, Snow or Ice....................4-36
Driving in Water..............................................4-37
Driving On Grades..........................................4-87
Driving on Off-Road Hills.................................4-28
Driving on Snow or Ice....................................4-49Driving Through Deep Standing Water...............4-41
Driving Through Flowing Water.........................4-41
Driving Uphill..................................................4-29
Driving with a Trailer.......................................4-86
Driving..........................................................4-38
At Night.....................................................4-38
City...........................................................4-42
Defensive..................................................... 4-2
Drunken....................................................... 4-2
Freeway.....................................................4-43
Hill and Mountain Roads..............................4-46
In Rain and on Wet Roads...........................4-39
Winter........................................................4-48
Dual Automatic Climate Control System.............3-25
Dual Climate Control System............................3-22
Dual Stage Air Bags........................................1-68
Dual Tire Operation.........................................5-70
DVD ............................................................3-125
Cleaning the Video Screen..........................3-125
Distortion..................................................3-122
Rear Seat Entertainment System..................3-111
DVD Player..................................................3-111
E
Easy Exit Seat...............................................2-67
Electrical System...........................................5-109
Add-On Equipment.....................................5-109
Fuses and Circuit Breakers.........................5-110
5

Flash-To-Pass Feature....................................... 3-9
Flat Tire, Changing.........................................5-80
Flat Tire........................................................5-79
Fluid.............................................................5-23
Automatic Transmission........................5-23, 5-26
Manual Transmission....................................5-28
Power Steering...........................................5-42
Windshield Washer......................................5-43
FM Stereo....................................................3-123
Fog Lamps....................................................3-16
Folding the Rear Seat....................................... 1-8
Following Distance..........................................4-86
Footnotes........................................................ 6-5
Four-Wheel Drive....................................2-33, 5-56
Four-Wheel-Drive Light....................................3-52
Front Axle Locking Feature...............................2-33
Front Axle......................................................5-57
Front Reading Lamps (If Equipped)...................3-18
Front Storage Area.........................................2-65
Fuel Information Button....................................3-57
FUEL LEVEL LOW.........................................3-66
Fuel............................................................... 5-4
Additives...................................................... 5-5
California Fuel.............................................. 5-5
Filling a Portable Fuel Container..................... 5-8
Filling Your Tank........................................... 5-6
Fuels in Foreign Countries.............................. 5-6Fuel (cont.)
Gage.........................................................3-53
Gasoline Octane........................................... 5-4
Gasoline Speci®cations.................................. 5-5
Low Warning Light.......................................3-54
System Inspection.......................................6-17
Fuses..........................................................5-110
Fuses and Circuit Breakers.........................5-110
Windshield Wiper.......................................5-109
G
Gage............................................................3-47
Engine Coolant Temperature.........................3-47
Fuel..........................................................3-53
Oil Pressure...............................................3-51
Speedometer..............................................3-35
Tachometer.................................................3-35
Transmission Temperature.............................3-47
Voltmeter Gage...........................................3-42
Gasoline......................................................... 5-4
Octane........................................................ 5-4
Speci®cations............................................... 5-5
Getting Familiar with Off-Road Driving................4-26
Glove Box.....................................................2-64
GM Mobility Program for Persons with
Disabilities.................................................... 7-5
7

H
Hazard Warning Flashers................................... 3-6
Head Restraints............................................... 1-7
Headlamp High/Low Beam Changer.................... 3-9
Headlamps....................................................5-59
Bulb Replacement.......................................5-59
Front Turn Signal, Sidemarker and Daytime
Running Lamps........................................5-61
Halogen Bulbs............................................5-59
Pickup Box Identi®cation and Fender Marker
Lamps....................................................5-65
Roof Marker Lamps.....................................5-62
Headphones.................................................3-116
Heated Seats................................................... 1-5
Heating.........................................................3-30
Heavy-DutyTrailer Wiring Harness Package........4-90
Highway Hypnosis...........................................4-45
Hill and Mountain Roads..................................4-46
Hitches..........................................................4-85
Hood.............................................................. 5-8
Checking Things Under.................................. 5-8
Release....................................................... 5-9
Horn............................................................... 3-7
How to Add Coolant to the Coolant Surge Tank
Gasoline Engines........................................5-38
How to Add Fluid............................5-25, 5-28, 5-29
How to Check and Add Fluid............................5-30
How to Check Lubricant...................................5-55How to Check Power Steering Fluid..................5-43
How to Check........................5-23, 5-26, 5-28, 5-70
How to Inspect...............................................5-21
How to Use This Manual...................................... ii
How to Wear Safety Belts Properly...................1-15
Hydraulic Clutch System Check........................6-14
Hydraulic Clutch.............................................5-29
Hydroplaning..................................................4-41
I
If No Steam Is Coming From Your Engine..........5-35
If Steam Is Coming From Your Engine...............5-34
If the Light is Flashing.....................................3-50
If the Light Is On Steady.................................3-50
If You Are Stuck in Sand, Mud, Ice or Snow.......4-52
If You Do Decide To Pull A Trailer.....................4-68
If You're Caught in a Blizzard...........................4-50
Ignition Positions.............................................2-20
Ignition Transmission Lock Check......................6-15
Infants and Young Children, Restraints...............1-34
In¯ation -- Tire Pressure..................................5-69
Inspection......................................................6-18
Brake System.............................................6-18
Engine Cooling System................................6-17
Exhaust System..........................................6-17
Fuel System...............................................6-17
Part C - Periodic Maintenance.......................6-17
8

Inspection (cont.)
Steering and Suspension..............................6-17
Throttle System...........................................6-18
Transfer Case and Front Axle
(All-Wheel Drive)......................................6-18
Transfer Case and Front Axle (Four-Wheel
Drive).....................................................6-18
Instrument Panel Brightness Control..................3-18
Instrument Panel Fuse Block..........................5-110
Instrument Panel.............................................3-34
Cluster.......................................................3-34
Overview..................................................... 3-4
Interior Lamps................................................3-18
J
Jump Starting.................................................5-48
K
Key Lock Cylinders Service..............................6-14
Key Release Button (Manual Transmission)........2-21
KEYFOB X BATTERY LOW.............................3-67
Keyless Entry System....................................... 2-4
Keys............................................................... 2-3
L
Lamps On Reminder.......................................3-15
Lamps...........................................................3-14
Exterior......................................................3-14
Interior.......................................................3-18
Lap Belt........................................................1-25
Lap-Shoulder Belt...........................................1-16
LATCH System...............................................1-47
Child Restraints...........................................1-47
Securing a Child Restraint Designed for the
LATCH System........................................1-49
Latches, Seatback............................................ 1-7
Leaving Your Vehicle With
the Engine Running
(Automatic Transmission Only).......................2-48
LEFT REAR DOOR AJAR (Crew Cab)...............3-67
Light.............................................................3-37
Air Bag Off .................................................3-37
Air Bag Readiness.......................................3-36
Anti-Lock Brake System Warning...................3-45
Battery Warning..........................................3-42
Brake System Warning.................................3-44
Cruise Control.............................................3-52
Four-Wheel-Drive.........................................3-52
Low Fuel Warning.......................................3-54
9

Light (cont.)
Malfunction Indicator....................................3-49
Passenger Air Bag Status Indicator................3-40
Safety Belt Reminder...................................3-36
Tow/Haul Mode...........................................3-53
Traction Off................................................3-46
Up-Shift.....................................................3-43
Listening to a DVD................................3-97, 3-110
Loading Your Vehicle for Off-Road Driving..........4-24
Loading Your Vehicle.......................................4-58
Locking Rear Axle...........................................4-13
Lockout Protection..........................................2-12
Lock-Out Switch.............................................2-17
Locks............................................................. 2-9
Delayed Locking........................................... 2-9
Door........................................................... 2-7
Lockout Protection.......................................2-12
Power Door.................................................. 2-8
Programmable Automatic Door Locks.............2-10
Rear Door Security Locks.............................2-12
Loss of Control...............................................4-21
LOW COOLANT LEVEL..................................3-67
Low Fuel Warning Light...................................3-54
Lumbar........................................................... 1-4
Power Controls............................................. 1-4M
Maintenance, Normal Replacement Parts..........5-121
Maintenance Schedule.....................................6-12
At Each Fuel Fill.........................................6-12
At Least Once a Month................................6-12
At Least Once a Year..................................6-14
At Least Twice a Year..................................6-13
At the First 100, 1,000 and 6,000 Miles
(160, 1 600 and 10 000km).......................6-12
Brake System Inspection..............................6-18
Engine Cooling System Inspection.................6-17
Exhaust System Inspection...........................6-17
Fuel System Inspection................................6-17
How This Section is Organized....................... 6-3
Introduction.................................................. 6-2
Maintenance Requirements............................. 6-2
Part A - Scheduled Maintenance Services......... 6-4
Part B - Owner Checks and Services.............6-12
Part C - Periodic MaintenanceInspections......6-17
Part D - Recommended Fluids and Lubricants . . . 6-19
Part E - Maintenance Record........................6-22
Scheduled Maintenance................................. 6-5
Steering and Suspension Inspection...............6-17
Throttle System Inspection............................6-18
10

Maintenance Schedule (cont.)
Transfer Case and Front Axle (All-Wheel
Drive) Inspection......................................6-18
Transfer Case and Front Axle (Four-Wheel
Drive) Inspection......................................6-18
Using Your................................................... 6-4
Your Vehicle and the Environment................... 6-2
Maintenance When Trailer Towing.....................4-89
Making Turns.................................................4-86
Malfunction Indicator Light................................3-49
Manual Seats................................................... 1-3
Manual Selectable Ride...................................4-12
Manual Transfer Case.....................................2-34
Manual Transmission Check.............................6-13
Manual Transmission.......................................2-22
Fluid..........................................................5-28
Operation...................................................2-29
Manual Windows............................................2-15
Matching Transmitter(s) to Your Vehicle............... 2-5
Memory Seat.................................................2-66
Message.......................................................3-65
DIC Warnings and Messages........................3-65
Mexico, Central America and Caribbean Islands/
Countries (Except Puerto Rico and U.S. Virgin
Islands) ± Customer Assistance....................... 7-4
Mirrors..........................................................2-56
Automatic Dimming Rearview with Compass
and Temperature Display...........................2-56
Automatic Dimming Rearview with OnStar
ž,
Compass and Temperature Display.............2-53Mirrors (cont.)
Manual Rearview Mirror................................2-53
Outside Automatic Dimming Mirror.................2-61
Outside Camper-Type Mirrors........................2-59
Outside Convex Mirror.................................2-62
Outside Curb View Assist Mirrors...................2-61
Outside Heated Mirrors................................2-62
Outside Manual Mirrors................................2-59
Outside Power Camper-Type.........................2-60
Outside Power Foldaway Mirrors....................2-61
Outside Power Mirrors..................................2-60
Outside West Coast-Type Mirrors...................2-59
Model Reference................................................ vi
MyGMLink.com................................................ 7-3
N
New Vehicle Break-In......................................2-20
Noise Control System, Tampering......................5-58
Normal Maintenance Replacement Parts...........5-121
O
Odometer......................................................3-35
Off-Road Recovery..........................................4-19
OIL LIFE RESET............................................3-67
OIL PRESSURE LOW.....................................3-67
11