clutch CHEVROLET SILVERADO 2017 3.G User Guide

Chevrolet Silverado Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-9956065) - 2017 - CRC - 4/29/16
Vehicle Care 383
Starter Switch Check
{Warning
When you are doing this
inspection, the vehicle could
move suddenly. If the vehicle
moves, you or others could be
injured.
1. Before starting this check, besure there is enough roomaround the vehicle.
2. Apply both the parking brakeand the regular brake.
Do not use the acceleratorpedal, and be ready to turn offthe engine immediately if itstarts.
3. For automatic transmissionvehicles, try to start the enginein each gear. The vehicleshould start only in P (Park) orN(Neutral). If the vehicle startsin any other position, contactyour dealer for service.
For manual transmissionvehicles, put the shift lever inNeutral, push the clutch pedaldown halfway, and try to startthe engine. The vehicle shouldstart only when the clutchpedal is pushed down all theway to the floor. If the vehiclestarts when the clutch pedal isnot pushed all the way down,contact your dealer for service.
Automatic Transmission
Shift Lock Control
Function Check
{Warning
When you are doing this
inspection, the vehicle could
move suddenly. If the vehicle
moves, you or others could be
injured.
1. Before starting this check, besure there is enough roomaround the vehicle. It should beparked on a level surface.
2. Apply the parking brake. Beready to apply the regularbrake immediately if the vehiclebegins to move.
3. With the engine off, turn theignition on, but do not start theengine. Without applying theregular brake, try to move theshift lever out of P (Park) withnormal effort. If the shift levermoves out of P (Park), contactyour dealer for service.
Ignition Transmission
Lock Check
While parked, and with the parkingbrake set, try to turn the ignition toLOCK/OFF in each shift leverposition.
.For automatic transmissionvehicles, the ignition should turnto LOCK/OFF only when theshift lever is in P (Park).
.For manual transmissionvehicles, the ignition should turnto LOCK/OFF only when youpress the key release button.

Chevrolet Silverado Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-9956065) - 2017 - CRC - 4/29/16
392 Vehicle Care
FusesUsage
19 Integrated chassiscontrol module
20 Electronicsuspension controlmodule
21 Fuel pump powermodule
22 Upfitter 1
23 Upfitter 2
24 Front wiper
25 ABS Valves
26 Upfitter 2
27 Upfitter 3
28 Right parkinglamps
29 Left parking lamps
30 Upfitter 3
31 Upfitter 4
32 Upfitter 4
33 Reverse lamps
34 Engine controlmodule/Ignition
FusesUsage
35 A/C clutch
36 Heated mirrors
37 Upfitter 1
38 Centerhigh-mountedstoplamp
39 Miscellaneous/Ignition
40 Transmission/Ignition
41 Fuel pump 2
42 Cooling fan clutch
43 Engine
44 Fuel injectors A–odd
45 Fuel injectors B–even
46 O2 Sensor B
47 Throttle control
48 Horn
49 Fog lamps
50 O2 Sensor A
FusesUsage
51 Engine controlmodule
52 Interior heater
53 Accessory powermodule/TPM pump
54 Front washer
55 A/C/Batteryregulated voltagecontrol
56 A/C module/Battery pack
57 Transmissioncontrol module/Engine controlmodule
58 Headlamps
74 Electric runningboards (ifequipped)
76 Fuel pump prime

Chevrolet Silverado Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-9956065) - 2017 - CRC - 4/29/16
Vehicle Care 393
RelaysUsage
59 Fuel pump
60 Upfitter 2
61 Upfitter 3
62 Upfitter 4
63 Trailer parkinglamps
64 Run/Crank
65 Upfitter 1
66 Fuel pump 2
67 A/C control
68 Starter
69 Rear windowdefogger
70 Engine controlmodule
71 Cooling fan clutch
72 CKT 95
73 CKT 92
75 Fuel pump prime
Instrument Panel Fuse
Block (Right)
The right instrument panel fuseblock access door is on thepassenger side edge of theinstrument panel.
Pull off the cover to access the fuseblock.

Chevrolet Silverado Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-9956065) - 2017 - CRC - 4/29/16
Service and Maintenance 455
Additional Required Services
Maintenance ScheduleAdditional RequiredServices - Normal
12 000 km/7,500 mi24 000 km/15,000 mi36 000 km/22,500 mi48 000 km/30,000 mi60 000 km/37,500 mi72 000 km/45,000 mi84 000 km/52,500 mi96 000 km/60,000 mi108 000 km/67,500 mi120 000 km/75,000 mi132 000 km/82,500 mi144 000 km/90,000 mi156 000 km/97,500 mi168 000 km/105,000 mi180 000 km/112,500 mi192 000 km/120,000 mi204 000 km/127,500 mi216 000 km/135,000 mi228 000 km/142,500 mi240 000 km/150,000 mi
Rotate tires and perform Required Services.Check engine oil level and oil life percentage.Change engine oil and filter, if needed.@@@@@@@@@@@@@@@@@@@@
Replace passenger compartment air filter. (1)@@@@@@
Replace engine air cleaner filter. (2)@@@
Inspect evaporative control system. (3)@@@
Replace spark plugs. Inspect spark plug wires.@
For GVW under 3 900 kg (8,600 lb), changetransfer case fluid, if equipped with 4WD. (4)@
For GVW over 3 900 kg (8,600 lb), changetransfer case fluid, if equipped with 4WD. (4)@@@
Drain and fill engine cooling system. (5)@
Visually inspect accessory drive belts. (6)@
Replace brake fluid. (7)
Replace clutch fluid. (8)

Chevrolet Silverado Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-9956065) - 2017 - CRC - 4/29/16
456 Service and Maintenance
Footnotes—MaintenanceSchedule Additional RequiredServices - Normal
(1)Or every two years, whichevercomes first. More frequentreplacement may be needed if thevehicle is driven in areas with heavytraffic, poor air quality, areas withhigh dust levels or are sensitive toenvironmental allergens. Filterreplacement may also be needed ifyou notice reduced airflow, windowsfogging up, or odors. Your local GMService location can help youdetermine when it is the right time toreplace your filter.
(2)Or every four years, whichevercomes first. If driving in dustyconditions, inspect the filter at eachoil change or more often as needed.
(3)Visually check all fuel and vaporlines and hoses for properattachment, connection, routing, andcondition.
(4)Do not directly power wash thetransfer case and/or front/rear axleoutput seals. High pressure watercan overcome the seals andcontaminate the fluid. Contaminatedfluid will decrease the life of thetransfer case and/or drive axles andshould be replaced.
(5)Or every five years, whichevercomes first. SeeCoolingSystem0368.
(6)Or every 10 years, whichevercomes first. Inspect for fraying,excessive cracking, or damage;replace, if needed.
(7)Replace brake fluid every fiveyears. SeeBrake Fluid0377.
(8)Replace clutch fluid every threeyears. SeeHydraulic Clutch0366.

Chevrolet Silverado Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-9956065) - 2017 - CRC - 4/29/16
Service and Maintenance 457
Maintenance ScheduleAdditional RequiredServices - Severe
12 000 km/7,500 mi24 000 km/15,000 mi36 000 km/22,500 mi48 000 km/30,000 mi60 000 km/37,500 mi72 000 km/45,000 mi84 000 km/52,500 mi96 000 km/60,000 mi108 000 km/67,500 mi120 000 km/75,000 mi132 000 km/82,500 mi144 000 km/90,000 mi156 000 km/97,500 mi168 000 km/105,000 mi180 000 km/112,500 mi192 000 km/120,000 mi204 000 km/127,500 mi216 000 km/135,000 mi228 000 km/142,500 mi240 000 km/150,000 mi
Rotate tires and perform Required Services.Check engine oil level and oil life percentage.Change engine oil and filter, if needed.@@@@@@@@@@@@@@@@@@@@
Replace passenger compartment air filter. (1)@@@@@@
Replace engine air cleaner filter. (2)@@@
Inspect evaporative control system. (3)@@@
Replace spark plugs. Inspect spark plug wires.@
Change automatic transmission fluid and filter.@@@
For GVW under 3 900 kg (8,600 lb), changetransfer case fluid, if equipped with 4WD. (4)@@@
For GVW over 3 900 kg (8,600 lb), changetransfer case fluid, if equipped with 4WD. (4)@@@@@@
Drain and fill engine cooling system. (5)@
Visually inspect accessory drive belts. (6)@
Replace brake fluid. (7)
Replace clutch fluid. (8)

Chevrolet Silverado Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-9956065) - 2017 - CRC - 4/29/16
458 Service and Maintenance
Footnotes—MaintenanceSchedule Additional RequiredServices - Severe
(1)Or every two years, whichevercomes first. More frequentreplacement may be needed if thevehicle is driven in areas with heavytraffic, poor air quality, areas withhigh dust levels or are sensitive toenvironmental allergens. Filterreplacement may also be needed ifyou notice reduced airflow, windowsfogging up, or odors. Your local GMService location can help youdetermine when it is the right time toreplace your filter.
(2)Or every four years, whichevercomes first. If driving in dustyconditions, inspect the filter at eachoil change or more often as needed.
(3)Visually check all fuel and vaporlines and hoses for properattachment, connection, routing, andcondition.
(4)Do not directly power wash thetransfer case and/or front/rear axleoutput seals. High pressure watercan overcome the seals andcontaminate the fluid. Contaminatedfluid will decrease the life of thetransfer case and/or drive axles andshould be replaced.
(5)Or every five years, whichevercomes first. SeeCoolingSystem0368.
(6)Or every 10 years, whichevercomes first. Inspect for fraying,excessive cracking, or damage;replace, if needed.
(7)Replace brake fluid every fiveyears. SeeBrake Fluid0377.
(8)Replace clutch fluid every threeyears. SeeHydraulic Clutch0366.
Special Application
Services
.Vehicles with Dual Wheels:Check dual wheel nut torque at160, 1 600, and 10 000 km (100,1,000, and 6,000 mi) of driving.Repeat this service whenever atire/wheel is serviced orremoved.
.Severe Commercial UseVehicles Only: Lubricate chassiscomponents every oil change.
.Have underbody flushing serviceperformed. See“UnderbodyMaintenance”inExteriorCare0441.

Chevrolet Silverado Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-9956065) - 2017 - CRC - 4/29/16
Service and Maintenance 463
UsageFluid/Lubricant
Front Axle Driveshaft Splines (All 4WD1500/2500/3500 Series) and Rear AxleDriveshaft Splines (All 2WD 1500Series with Automatic Transmission)
Spline Lubricant, Special Lubricant (GM Part No. 19257121, inCanada 19257122).
Front Axle (Four-Wheel Drive) SAE 75W-90 Synthetic Axle Lubricant (GM Part No. 88900401, inCanada 89021678).
Hydraulic Brake System DOT 3 Hydraulic Brake Fluid (GM Part No. 19299818, inCanada 19299819).
Hydraulic Clutch System DOT 4 Hydraulic Brake Fluid (GM Part No. 19299570).
Hydraulic Power Steering System(2500/3500 Series Only)GM Power Steering Fluid (GM Part No. 19329450, in Canada 19329451).
Key Lock Cylinders, Hood Hinges,Body Door Hinge Pins, Tailgate Hingeand Linkage, Fuel Door Hinge, TailgateHandle Pivot Points, Hinges, LatchBolt, and Linkage
Multi-Purpose Lubricant, Superlube (GM Part No. 12346241, inCanada 10953474).
Manual Transmission Manual Transmission Fluid (GM Part No. 93436060).
Rear Axle (1500 Series) SAE 75W-85 Synthetic Axle Lubricant (GM Part No. 19300457, inCanada 19300458).
Rear Axle (2500/3500 Series) SAE 75W-90 Synthetic Axle Lubricant (GM Part No. 88900401, inCanada 89021678).

Chevrolet Silverado Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-9956065) - 2017 - CRC - 4/29/16
498 Index
C
Calibration . . . . . . . . . . . . . . . . . . . . . . 122
California
Fuel Requirements . . . . . . . . . . . 312
Perchlorate Materials
Requirements . . . . . . . . . . . . . . . 352
California
Proposition
65 Warning . . . . . . . . . .351, 378, 432
Canadian Vehicle Owners . . . . . . . . 2
Capacities and
Specifications . . . . . . . . . . . . . . . . . 468
Carbon Monoxide
Engine Exhaust . . . . . . . . . . . . . . . 276
Ta i l g a t e . . . . . . . . . . . . . . . . . . . . . . . . . 4 2
Winter Driving . . . . . . . . . . . . . . . . 257
Cargo
Tie-Downs . . . . . . . . . . . . . . . . . . . . . 117
Cargo Lamp . . . . . . . . . . . . . . . . . . . . 177
Caution, Danger, and Warning . . . . 3
CD Player . . . . . . . . . . . . . . . . . . . . . . 196
Center Console Storage . . . . . . . . 116
Center High-Mounted
Stoplamp (CHMSL) and
Cargo Lamp . . . . . . . . . . . . . . . . . . . 389
Center Seat . . . . . . . . . . . . . . . . . . . . . 58
Chains, Tire . . . . . . . . . . . . . . . . . . . . 419
Charging
Wireless . . . . . . . . . . . . . . . . . . . . . . 126
Charging System Light . . . . . . . . . 138
Check
Ignition Transmission Lock . . . 383
Malfunction Indicator
Engine Light . . . . . . . . . . . . . . . . 138
Child Restraints
Infants and Young Children . . . . . 90
Lower Anchors and Tethers
for Children . . . . . . . . . . . . . . . . . . . 96
Older Children . . . . . . . . . . . . . . . . . . 88
Securing . . . . . . . . . . . . . . . . . 102, 106
Systems . . . . . . . . . . . . . . . . . . . . . . . . 92
Cleaning
Exterior Care . . . . . . . . . . . . . . . . . 441
Interior Care . . . . . . . . . . . . . . . . . . 446
Climate Control
Systems . . . . . . . . . . . . . . . . . 237, 238
Air Conditioning . . . . . . . . . 237, 238
Dual Automatic . . . . . . . . . . . . . . . 240
Heating . . . . . . . . . . . . . . . . . . 237, 238
Clock . . . . . . . . . . . . . . . . . . . . . . . . . . . 123
Cluster, Instrument . . . . . . . . . . . . . 128
Clutch, Hydraulic . . . . . . . . . . . . . . . 366
Collision Damage Repair . . . . . . . 479
Compartments
Storage . . . . . . . . . . . . . . . . . . . . . . . .115
Compass . . . . . . . . . . . . . . . . . . . . . . . 122
Messages . . . . . . . . . . . . . . . . . . . . 151
Connections
OnStar®...................... 488
Control . . . . . . . . . . . . . . . . . . . . . . . . . 297
Traction and Electronic
Stability . . . . . . . . . . . . . . . . . . . . . 295
Control Light
Hill Descent . . . . . . . . . . . . . . . . . . 141
Control of a Vehicle . . . . . . . . . . . . . 248
Convex Mirrors . . . . . . . . . . . . . . . . . . 46
Coolant
Engine . . . . . . . . . . . . . . . . . . . . . . . . 369
Engine Temperature Gauge . . 133
Cooling System . . . . . . . . . . . . . . . . . 368
Engine Messages . . . . . . . . . . . . 152
Courtesy Transportation
Program . . . . . . . . . . . . . . . . . . . . . . . 478
Cruise Control . . . . . . . . . . . . . . . . . . 298
Light . . . . . . . . . . . . . . . . . . . . . . . . . . 145
Cupholders . . . . . . . . . . . . . . . . . . . . . 116
Customer Assistance . . . . . . . . . . . 475
Offices . . . . . . . . . . . . . . . . . . . . . . . . 474
Te x t Te l e p h o n e ( T T Y )
Users . . . . . . . . . . . . . . . . . . . . . . . 475
Customer Information
Service Publications
Ordering Information . . . . . . . . 481

Chevrolet Silverado Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-9956065) - 2017 - CRC - 4/29/16
Index 501
General Information (cont'd)
Vehicle Care . . . . . . . . . . . . . . . . . . 351
Glass Replacement . . . . . . . . . . . . . 385
Glove Box . . . . . . . . . . . . . . . . . . . . . . 115
GM Mobility Reimbursement
Program . . . . . . . . . . . . . . . . . . . . . . . 476
H
Halogen Bulbs . . . . . . . . . . . . . . . . . . 385
Hazard Warning Flashers . . . . . . . 175
Head Restraints . . . . . . . . . . . . . . . . . 57
Headlamps
Aiming . . . . . . . . . . . . . . . . . . . . . . . . 385
Automatic . . . . . . . . . . . . . . . . . . . . . 174
Bulb Replacement . . . . . . . . . . . . 385
Daytime Running
Lamps (DRL) . . . . . . . . . . . . . . . . 174
Flash-to-Pass . . . . . . . . . . . . . . . . . 174
Headlamps, Front Turn
Signal, Sidemarker, and
Parking Lamps . . . . . . . . . . . . . . 386
High Intensity Discharge
(HID) Lighting . . . . . . . . . . . . . . . 386
High-Beam On Light . . . . . . . . . . 144
High/Low Beam Changer . . . . . 173
Lamps On Reminder . . . . . . . . . 145
Heated
Steering Wheel . . . . . . . . . . . . . . . 121
Heated and Ventilated Front
Seats . . . . . . . . . . . . . . . . . . . . . . . . . . 63
Heated Mirrors . . . . . . . . . . . . . . . . . . . 49
Heater
Engine Coolant . . . . . . . . . . . . . . . 272
Heating and Air
Conditioning . . . . . . . . . . . . . . 237, 238
High Voltage Devices and
Wiring . . . . . . . . . . . . . . . . . . . . . . . . . 389
High-Beam On Light . . . . . . . . . . . . 144
High-Speed Operation . . . . . . . . . . 407
Hill and Mountain Roads . . . . . . . . 256
Hill Descent Control (HDC) . . . . . 297
Hill Descent Control Light . . . . . . . 141
Hill Start Assist (HSA) . . . . . . . . . . 294
Home Page . . . . . . . . . . . . . . . . 186, 188
Hood . . . . . . . . . . . . . . . . . . . . . . . . . . . 353
Horn . . . . . . . . . . . . . . . . . . . . . . . . . . . . 122
How to Wear Safety Belts
Properly . . . . . . . . . . . . . . . . . . . . . . . . 67
Hydraulic Clutch . . . . . . . . . . . . . . . . 366
I
Idle System
Fast . . . . . . . . . . . . . . . . . . . . . . . . . . 271
Ignition Positions . . . . . . . . . . . . . . . 268
Ignition Transmission Lock
Check . . . . . . . . . . . . . . . . . . . . . . . . . 383
Immobilizer . . . . . . . . . . . . . . . . . . . . . . 45
Indicator
Vehicle Ahead . . . . . . . . . . . . . . . . 142
Infants and Young Children,
Restraints . . . . . . . . . . . . . . . . . . . . . . 90
Infotainment . . . . . . . . . . . . . . . . . . . . 181
Infotainment System . . . . . . . . . . . . 485
Instrument Cluster . . . . . . . . . . . . . . 128
Instrument Panel
Storage Area . . . . . . . . . . . . . . . . . .115
Interior Rearview Mirrors . . . . . . . . . 50
Introduction . . . . . . . . . . . . . . . . . . . . . . . 2
J
Jack
Auxiliary . . . . . . . . . . . . . . . . . . . . . . 207
Jump Starting - North
America . . . . . . . . . . . . . . . . . . . . . . . 432
K
Key and Lock Messages . . . . . . . . 153
Keyless Entry
Remote (RKE) System . . . . . . . . . 36
Keys . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 33
L
Labeling, Tire Sidewall . . . . . . . . . . 399
Lamps
Auxiliary Roof
Mounted Lamp . . . . . . . . . . . . . . 176
Cargo . . . . . . . . . . . . . . . . . . . . . . . . . 177