trailer CHEVROLET TRACKER 1996 Owner's Manual

I Short Trip/City Maintenance Schedule I
30,000 Miles (50 000 km) (Continued)
17 Replace spark plugs.
An Emission Control Service.
17 Replace air cleaner filter.
An Emission Control Service.
El Inspect fuel tank, cap and lines for damage or
leaks. Inspect fuel cap gasket for
any damage.
Replace parts as needed.
An Emission Control Service.
Rotate tires. See “Tire Inspection and Rotation”
in the Index for proper rotation pattern and
additional information. During tire rotation,
check brake calipers for fieedom
of movement.
Refer to the appropriate GM service manual for
proper caliper service procedures.
Change manual transmission fluid (or every
15 months, whichever occurs first).
0 Inspect the valve lash and adjust if necessary.
An Emission Control Service.
0 Replace fuel filter (or every 30 months,
whichever occurs first, or sooner
if filter is
clogged). An Emission Control Service.
0 Check engine idle speed and adjust it
to underhood label specifications.
An Emission Control Service.?
17 Inspect the locking front hubs (if equipped)
for correct operation (or every 3 months,
whichever occurs first). Repair
or replace
as necessary.
0 Inspect propeller shafts and u-joints for
looseness and damage
(or every 15 months,
whichever occurs first). Inspect more
frequently
if used off-road or for pulling
a trailer, Tighten u-joint flange bolts
if necessary.
I DATE I ACTUAL MILEAGE ISERVICED BY1
7-14
ProCarManuals.com

Short TriplCity Maintenance Schedule
45,000 Miles (75 000 km)
El Change engine oil and filter (or every
3 months, whxhever occurs first).
An Emission Control Service.
17 Clean and repack the front wheel bearings
(or at each brake relining, whichever
occurs first).
in dusty conditions. Replace filter if
necessary.
An Emission Control Service. ?
0 Change manual transmission fluid (or every
15 months, whichever occurs first).
17 Inspect the valve lash and adjust if
necessary. An Emission Control Service.
0 Check engine idle speed and adjust it to
underhood< label specifications.
An Emission Control Service.?
0 Inspect air cleaner filter if you are driving
0 Inspect the loclung front hubs (if equipped)
for correct operation (or every
3 months,
whichever occurs first). Repair or replace
as necessary.
0 Inspect propeller shafts and u-joints for
looseness and damage (or every
15 months,
whichever occurs first). Inspect more
frequently
if used off-road or for pulling
a trailer. Tighten u-joint
flange bolts
if necessary.
I DATE I ACTUAL MILEAGE ISERVICED BY: I
7-17
ProCarManuals.com

~~ Short Trip/City Maintenance Schedule
60,000 Miles (100 000 km) (Continued)
0 Adjust engine timing to underhood label
specifications. Inspect the
inside and outside
of the distributor cap and rotor for cracks,
carbon tracking
and corrosion. Clean or
replace as needed.
An Emission Control Service.
0 Inspect emission system hoses and replace
as necessary. An Emission Control Service. f
0 Inspect propeller shafts and u-joints for
looseness and damage
(or every 15 months,
whichever
occurs first). Inspect more
frequently if used off-road Or for pulling
a trailer. Tighten u-joint flange bolts
if necessary.
DATE ACTUAL MILEAGE SERVICED BY:
63,000 Miles (105 000 km)
Change engine oil and filter (or every
3 months, whichever occurs first).
An Emission Control Service.
Inspect the locking front hubs (if equipped)
for correct operation (or every 3 months,
whichever occurs
first). Repair or replace
if necessary.
RATE
SERVICED BY: ACTUAL MILEAGE
ProCarManuals.com

Short TriplCity Maintenance Schedule
Inspect the locking front hubs (if equipped)
for correct operation (or every
3 months,
whichever occurs first). Repair or replace
as necessary.
0 Inspect propeller shafts and u-joints for
looseness and damage (or every
15 months,
whichever occurs first). Inspect more
frequently if used off-road or for pulling
a trailer. Tighten u-joint flange bolts
if necessary.
78,000 Miles (130 000 km)
0 Change engine oil and filter (or every
3 months, whichever occurs first).
0 Rotate tires. See “Tire Inspection and
An Emission Control Service.
Rotation’’ in the Index for proper rotation
pattern and additional information. During
tire rotation, check brake calipers
for
freedom of movement. Refer to the
appropriate
GM service manual for proper
caliper service procedures.
0 Inspect the locking front hubs (if equipped)
for correct operation (or
every 3 months,
whichever occurs first). Repair or replace
if necessary.
DATE ACTUAL MILEAGE
SERVICED BY
7-25
ProCarManuals.com

I Short TriplCity Maintenance Schedule I
Inspect propeller shafts and u-joints for
looseness and damage (or every
15 months,
whichever occurs first). Inspect more
frequently if used off-road or for pulling
a trailer. Tighten u-joint flange bolts
if necessary.
I DATE I ACTUAL MILEAGE ISERVICED BY: I
93,000 Miles (155 000 km)
CI Change engine oil and filter (or every
3 months, whichever occurs first).
An Emission Control Sewice.
0 Inspect the locking front hubs (if equipped)
for correct operation
(or every 3 months,
whichever occurs first). Repair or replace
if necessary.
DATE
SERVICED BY: ACTUAL MILEAGE
'
ProCarManuals.com

I Short Trip/City Maintenance Schedule I
100,000 Miles (166 000 km)
Change automatic transmission fluid and
filter
if the vehicle is mainly driven under
one
or more of these conditions:
- In heavy city traffic where the outside
temperature regularly reaches
90 OF
(32" C) or higher.
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or
If you do not use your vehicle under any of these
conditions, the fluid andfilter do not require changing.
delivery service.
0 Replace Po sitive Cranl ltcase Ventilation
(PCV) valve.
Replace any worn, plugged or
collapsed hoses.
An Emission Control Service.
0 Inspect Exhaust Gas Recirculation (EGR)
system.
An Emission Control Service.
0 Inspect fuel injector.
An Emission Control Service.
0 Replace evaporative emissions canister.
An Emission Control Service.
I DATE ACTUAL MILEAGE SERVICED BY:
7-31
ProCarManuals.com

Long TriplHighway Maintenance Schedule I
15,000 Miles (25 000 km)
Change engine oil and filter (or every
7.5 months, whichever occurs first).
An Emission Control Service.
0 Rotate tires. See “Tire Inspection and
Rotation”
in the Index for proper rotation
pattern and additional information. During
tire rotation, check brake calipers for
freedom
of movement. Refer to the
appropriate
GM service manual for proper
caliper service procedures.
Inspect the locking front hubs (if equipped)
for correct operation (or every
3 months,
whichever occurs first). Repair or replace
if necessary.
Inspect the valve lash and adjust if
necessary.
An Emission Control Service.
0 Check engine idle speed and adjust it to
underhood label specifications.
An Emission Control Service.?
0 Inspect propeller shafts and u-joints for
looseness and damage (or every
15 months,
whichever occurs first). Inspect more
frequently
if used off-road or for pulling
a trailer. Tighten u-joint flange bolts
if necessary.
DATE SERVICED BY ACTUAL MILEAGE
7-33
ProCarManuals.com

1 Long Trip/Highway Maintenance Schedule
30,000 Miles (50 000 km) (Continued)
c] Check engine idle speed and adjust it to
underhood label specifications.
An Emission Control Service.?
0 Inspect propeller shafts and u-joints for
looseness and damage (or every
15 months,
whichever occurs first). Inspect more
frequently if used off-road or for pulling
a trailer. Tighten u-joint flange bolts
if necessary.
37,500 Miles (62 500 km)
0 Change engine oil and filter (or every
7.5 months, whichever occurs first).
An Emission Control Service.
17 Rotate tires. See “Tire Inspection and
Rotation” in the Index for proper rotation
pattern and additional information. During
tire rotation, check brake calipers
for
freedom of movement. Refer to the
appropriate
GM service manual for proper
caliper service procedures.
0 Inspect the locking front hubs (if equipped)
for correct operation
(or every 3 months,
whichever occurs first). Repair
or replace
if necessarv.
I DATE I ACTUAL MILEAGE (SERVICED BY:(
7-36
ProCarManuals.com

1 Long Trip/Highway Maintenance Schedule I
45,000 Miles (75 000 km)
ll Change engine oil and filter (or every
7.5 months, whichever occurs first).
An Emission Control Service.
0 Rotate tires. See “Tire Inspection and
Rotation” in the Index for proper rotation
pattern and additional ,information. During
tire rotation, check brake calipers for
freedom of movement.
Refer to the
appropriate
GM service manual for proper
caliper service procedures.
0 Inspect the locking front hubs (if equipped)
for correct operation (or every
3 months,
whichever occurs first). Repair or replace
if necessary.
0 Inspect the valve lash and adjust if
necessary. An Emission Control Service.
0 Check engine idle speed and adjust it to
underhood label specifications.
An Emission Control Sewice.?
0 Inspect propeller shafts and u-joints for
looseness and damage (or every
15 months,
whichever occurs first). Inspect more
frequently
if used offlroad or for pulling
a trailer. Tighten u-joint flange bolts
if necessary.
DATE ACTUAL MILEAGE SERVICED BY:
7-37
ProCarManuals.com

i Long TriplHighway Maintenance Schedule
50,000 Miles (83 000 km)
0 Change automatic transmission fluid and
filter
if the vehicle is mainly driven under
one or more
of these conditions:
- In heavy city traffic where the outside
temperature regularly reaches
90 OF
(32°C) or higher.
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or
delivery service.
If you do not use your vehicle under any of these
conditions, thefluid
andfilter do not require changing.
0 Replace Positive Crankcase Ventilation
(PCV) valve. Replace any worn, plugged or
collapsed hoses. An Emission Control Service.
7-38
ProCarManuals.com