check engine CHEVROLET TRACKER 1998 1.G Repair Manual

Downloaded from www.Manualslib.com manuals search engine Maintenance Schedule
I 1
I Short Trip/City Definition
Follow the Short Trip/City Maintenance Schedule if
any one of these conditions is true for your vehicle:
Most trips are less than 5 to 10 miles (8 to 16 km).
This is particularly important when outside
temperatures are below freezing.
driving in stop-and-go traffic).
of your vehicle. or other commercial application.
Most trips include extensive idling (such as frequent
You frequently tow a trailer or use a carrier on top
If the vehicle is used for delivery service, police, taxi
One of the reasons you should follow this schedule
if you operate your vehicle under any of these
conditions is that these conditions cause engine
oil to break down soonex
I Short Trip/City Intervals
Every 3,000 Miles (5 000 km): Engine Oil and
Filter Change (or
3 months, whichever occurs first).
Free-Wheeling
Hubs Inspection (if equipped)
(or
3 months, whichever occurs first).
Every 6,000 Miles (10 000 km): Tire Rotation.
Every 15,000 Miles (25 000 km): Air Cleaner Filter
Inspection,
if driving in dusty conditions. Front
Wheel Bearing Repack
(2WD only) (or at each
brake relining, whichever occurs first). Automatic
Transmission Service (severe conditions only).
Manual Transmission Fluid Change. Transfer Case
Fluid Change. Differential Fluid Change. Engine Idle
Speed Check. Valve Lash (Clearance) Adjustment.
Propeller Shafts and U-Joints Inspection (or every
15 months, whichever occurs fist).
Every 30,000 Miles (50 000 km): Air Cleaner Filter
Replacement. Spark Plug Replacement. Engine
Accessory Drive Belt Inspection (or every
24 months,
whichever occurs first). Cooling System Service
(or every
30 months, whichever occurs first). Fuel
Filter Replacement (or every
30 months, whichever
occurs first).
(Continued)

Downloaded from www.Manualslib.com manuals search engine Maintenance Schedule
I Short TripKity Intervals I
Every 45,000 Miles (75 000 km): Automatic
Transmission Fluid Hose Replacement (or every
45 months, whichever occurs first).
Every 50,000 Miles (83 000 km): Positive Crankcase
Ventilation (PCV) Valve Replacement.
Every 60,000 Miles (100 000 km): Engine Timing
and Distributor Check. Fuel Tank Cap Gasket
Replacement. Emission System Hoses Inspection.
Camshaft Timing Belt Replacement. Brake Fluid Service. Spark Plug Wire Replacement (or every
60 months, whichever occurs first). Wiring Harness
and Connectors Inspection (or every
60 months,
whichever occurs first).
At 90,000 Miles (150 000 km): Camshaft Timing
Belt Inspection.
Every 100,000 Miles (166 000 km): Automatic
Transmission Service (normal conditions). Fuel
Injector Inspection. Evaporative Emissions
Canister Replacement.
These intervals only summarize maintenance services.
Be sure to follow the complete maintenance schedule
on the following pages.
{Long Trip/Highway Definition
Follow this maintenance schedule only if none of
the conditions from the Short TripKity Maintenance
Schedule is true. Do not use this schedule if the vehicle
is used for trailer towing, driven in a dusty area or used
off paved roads. Use the Short TripKity schedule for
these conditions.
Driving a vehicle with a filly warmed engine
under highway conditions causes engine oil to
break down slowel:
7-6

Downloaded from www.Manualslib.com manuals search engine Maintenance Schedule
Long TriplHighway Intervals I
Every 7,500 Miles (12 500 km): Engine Oil and Filter
Change (or every
7.5 months, whichever occurs first).
Free-Wheeling Hubs Inspection (if equipped) (or every
3 months, whichever occurs first). Tire Rotation.
Transmission Service (severe conditions only).
Engine Idle Speed Check. Valve Lash (Clearance)
Adjustment. Propeller Shafts and U-Joints Inspection (or every
15 months, whichever occurs first).
Every 30,000 Miles (50 000 km): Engine Accessory
Drive Belt Inspection (or every
24 months, whichever
occurs first). Cooling System Service (or every
30 months, whichever occurs first). Spark Plug
Replacement. Air Cleaner Filter Replacement. Fuel
Tank, Cap and Lines Inspection. Front Wheel Bearing
Repack (2WD only) (or at each brake relining,
whichever occurs first). Manual Transmission Fluid
Change. Transfer Case Fluid Change. Differential
Fluid Change. Fuel Filter Replacement (or every
30 months, whichever occurs first).
Every 15,000 Miles (25 000 km): Automatic
Long Tripmighway Intervals
Every 45,000 Miles (75 000 km): Automatic
Transmission Fluid Hose Replacement (or every
45 months, whichever occurs first).
Every 50,000 Miles (83 000 km): Positive Crankcase
Ventilation (PCV) Valve Replacement.
Every 60,000 Miles (100 000 km): Engine Timing
and Distributor Check. Fuel Tank Cap Gasket
Replacement. Emission System Hoses Inspection.
Camshaft Timing Belt Replacement. Spark Plug
Wire Replacement (or every
60 months, whichever
occurs first). Wiring Harness and Connectors
Inspection (or every
60 months, whichever occurs
first). Brake Fluid Service.
At 90,000 Miles (150 000 km): Camshaft Timing
Belt Inspection.
Every 100,000 Miles (166 000 km): Automatic
Transmission Service (normal conditions). Fuel
Injector Inspection. Evaporative Emissions
Canister Replacement.
These intervals only summarize maintenance services.
Be sure to
follow the complete maintenance schedule on
the following pages.
7-7

Downloaded from www.Manualslib.com manuals search engine I Short TripKity Maintenance Schedule I
The services shown in this schedule up to 100,000 miles
(166 000 km) should be performed after 100,000 miles
(166 000 km) at the same intervals.
See “Owner Checks
and Services” and “Periodic
Maintenance Inspections” following.
Footnotes
The U.S. Environmental Protection Agency or the
California Air Resources Board has determined that the
failure to perform this maintenance item will not nullify
the emission warranty or limit recall liability prior to
the completion of the vehicle’s useful life. We, however,
urge that all recommended maintenance services be
performed at the indicated intervals and
the maintenance
be recorded.
+ A good time to check your brakes is during tire
rotation. See “Brake System Inspection” under “Periodic
Maintenance Inspections” in Part
C of this schedule.
7-8

Downloaded from www.Manualslib.com manuals search engine Short Trip/City Maintenance Schedule
- Uses such as found in taxi, police or delivery service.
If you do not use your vehicle under any of these conditions, change the fluid
andfilter every
100,000 miles (166 000 km).
Change manual transmission fluid.
0 Change transfer case fluid.
0 Change differential fluid.
0 Inspect the valve lash and adjust if necessary. An Emission Control Service.
0 Check engine idle speed and adjust it to underhood label specifications.
0 Inspect the locking front hubs (if equipped) for correct operation (or every
0 Inspect propeller shafts and u-joints for looseness and damage (or every
An Emission Control Service. (See footnote?.)
3 months, whichever occurs first). Repair or replace as necessary.
15 months, whichever occurs first). Inspect more frequently if used off-road
or for pulling a trailer. Tighten u-joint flange bolts if necessary.
18,000 Miles (30 000 km)
0 Change engine oil and filter (or every 3 months, whichever occurs first).
0 Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
An Emission Control Service.
rotation pattern and additional information. (See footnote +.)
(Continued)
I DATE
I MILEAGE ACTUAL I SERVICEDBY I
7-11

Downloaded from www.Manualslib.com manuals search engine Short Trip/City Maintenance Schedule
30,000 Miles (50 000 km) (Continued)
0
CI
0
0
Change automatic transmission fluid and filter if the vehicle is mainly driven
under one or more of these conditions:
- In heavy city traffic where the outside temperature regularly r\
eaches
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or delivery service.
If you do not use your vehicle under any of these conditions, change the fluid
and filter every 100,000 miles (166 000 km).
Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
rotation pattern and additional information. (See footnote
+.)
Change manual transmission fluid.
Change transfer case fluid.
Change differential fluid.
Inspect the valve lash and adjust if necessary.
An Emission Control Service.
Replace fuel filter (or every 30 months, whichever occurs first, or sooner if
filter is clogged).
An Emission Control Service. (See footnote “f )
Check engine idle speed and adjust it to underhood label specifications.
An Emission Control Service. (See footnote?.)
90°F (32°C) or higher.
7-14

Downloaded from www.Manualslib.com manuals search engine I Short Trip/City Maintenance Schedule 1
0 Change automatic transmission fluid and filter if the vehicle is mainly driven
under one or more of these conditions:
- In heavy city traffic where the outside temperature regularly reaches
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or delivery service.
If you do not use your vehicle under any of these conditions, change the fluid
and filter every
IO0,OOO miles (166 000 km).
filter if necessary.
An Emission Control Service. (See footnote?.)
90°F (32°C) or higher.
0 Inspect air cleaner filter if you are driving in dusty conditions. Replace
0 Change manual transmission fluid.
I7 Change transfer case fluid.
0 Change differential fluid.
0 Inspect the valve lash and adjust if necessary. An Emission Control Service.
~ 0 Check engine idle speed and adjust it to underhood label specifications.
I An Emission Control Service. (See footnote?.)
Inspect the locking front hubs (if equipped) for correct operation (or every
3 months, whichever occurs first). Repair or replace as necessary.
(Continued)
7-17

Downloaded from www.Manualslib.com manuals search engine I Short TripKity Maintenance Schedule I
60,000 Miles (100 000 km) (Continued)
0 Check engine idle speed and adjust it to underhood label specifications.
0 Inspect the locking front hubs (if equipped) for correct operation (or every
0 Adjust engine timing to underhood label specifications. Inspect \
the inside and
An Emission Control Service. (See footnote?.)
3 months, whichever occurs first). Repair or replace as necessary.
outside of the distributor cap and rotor for cracks, carbon tracking and
corrosion. Clean or replace as needed.
An Emission Control Service.
0 Inspect emission system hoses and replace as necessary.
0 Inspect propeller shafts and u-joints for looseness and damage (or every
An Emission Control Service. (See footnote?.)
15 months, whichever occurs first). Inspect more frequently if use\
d off-road
or for pulling a trailer. Tighten u-joint flange bolts if necessary.
63,000 Miles (105 000 km)
I7 Change engine oil and filter (or every 3 months, whichever occurs first).
An Emission Control Service.
0 Inspect the locking front hubs (if equipped) for correct operation (or every
3 months, whichever occurs first). Repair or replace if necessary.
DATE I
MILEAGE
7-22

Downloaded from www.Manualslib.com manuals search engine I Short TripKity Maintenance Schedule I
0 Check engine idle speed and adjust it to underhood label specifications.
0 Inspect the locking front hubs (if equipped) for correct operation (or every
0 Inspect propeller shafts and u-joints for looseness and damage (or every
An Emission Control Service. (See footnote?.)
3 months, whichever occurs first). Repair or replace as necessary.
15 months, whichever occurs first). Inspect more frequently if used off-road
or for pulling
a trailer. Tighten u-joint flange bolts if necessary.
78,000 Miles (130 000 km)
0 Change engine oil and filter (or every 3 months, whichever occurs first).
0 Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
0 Inspect the locking front hubs (if equipped) for correct operation (or every
An Emission Control Service.
rotation pattern and additional information. (See footnote +.)
3 months, whichever occurs first). Repair or replace if necessary\
.
81,000 Miles (135 000 km)
0 Change engine oil and filter (or every 3 months, whichever occurs first).
0 Inspect the locking front hubs (if equipped) for correct operation (or every
An Emission Control Sewice.
3 months, whichever occurs first). Repair or replace if nece,ssary.
DATE I
MILEAGE
DATE MILEAGE
7-25

Downloaded from www.Manualslib.com manuals search engine Short TripKity Maintenance Schedule
90,000 Miles (150 000 km) (Continued)
0
0
0
0
0
0
0
0
Replace air cleaner filter.
An Emission Control Service.
Inspect fuel tank, cap and lines for dam&ge Or leaks. Inspect fuel cap gasket
for
any damage. Replace parts as needed.
An Emission Control Service. (See footnote?.)
Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
rotation pattern and additional information. (See footnote
+.)
Change manual transmission fluid.
Change transfer case fluid.
Change differential fluid.
Inspect the valve lash and adjust if necessary.
An Emission Control Service.
Replace fuel filter (or every 30 months, whichever occurs first).
An Emission Control Service. (See footnote?.)
Check engine idle speed and adjust it to underhood label specifications.
An Emission Control Service. (See footnote?.)
Inspect the locking front hubs (if equipped) for correct operation (or every
3 months, whichever occurs first). Repair or replace as necessary.
Inspect propeller shafts and u-joints for looseness and damage (or every
15 months, whichever occurs first). Inspect more frequently if used off-road
or for pulling
a trailer. Tighten u-joint flange bolts if necessary.
7-28