wheel CHEVROLET TRACKER 2004 2.G Owners Manual

Ignition Transmission Lock Check
While parked, and with the parking brake set, try to turn
the ignition key to LOCK in each shift lever position.
·With an automatic transmission, the key should turn
to LOCK only when the shift lever is in PARK (P).
·With a manual transmission, the key should turn to
LOCK only if you push the key in farther, while
turning it towards LOCK.
On all vehicles, the key should come out only in LOCK.
Parking Brake and Automatic
Transmission Park (P) Mechanism
Check
{CAUTION:
When you are doing this check, your vehicle
could begin to move. You or others could be
injured and property could be damaged. Make
sure there is room in front of your vehicle in
case it begins to roll. Be ready to apply the
regular brake at once should the vehicle begin
to move.Park on a fairly steep hill, with the vehicle facing
downhill. Keeping your foot on the regular brake, set the
parking brake.
·To check the parking brake's holding ability: With
the engine running and transmission in
NEUTRAL (N), slowly remove foot pressure from
the regular brake pedal. Do this until the vehicle is
held by the parking brake only.
·To check the PARK (P) mechanism's holding ability:
With the engine running, shift to PARK (P). Then
release the parking brake followed by the regular
brake.
If your vehicle is four-wheel drive, be sure the
transfer case is not in NEUTRAL.
Underbody Flushing Service
At least every spring, use plain water to ¯ush any
corrosive materials from the underbody. Take care to
clean thoroughly any areas where mud and other debris
can collect.
6-27

Throttle System Inspection
Inspect the throttle system for interference or binding,
and for damaged or missing parts. Replace parts
as needed. Replace any components that have high
effort or excessive wear. Do not lubricate accelerator
and cruise control cables.
Rear Axle and Front Axle
(Four-Wheel-Drive) Service
Check the gear lubricant level and add if needed. SeeRear Axle on page 5-48andFour-Wheel Drive on
page 5-49. A ¯uid loss may indicate a problem. Check
the system(s), and repair the system(s) if needed. Refer
to
Part A: Scheduled Maintenance Services on
page 6-4to determine when to change the lubricant.
Brake System Inspection
Inspect the complete system. Inspect brake lines and
hoses for proper hook-up, binding, leaks, cracks,
cha®ng, etc. Inspect disc brake pads for wear and rotors
for surface condition. Also inspect drum brake linings
for wear and cracks. Inspect other brake parts, including
drums, wheel cylinders, calipers, parking brake, etc.
Check parking brake adjustment. You may need to have
your brakes inspected more often if your driving
habits or conditions result in frequent braking.
6-29

Part D: Recommended Fluids and
Lubricants
Fluids and lubricants identi®ed below by name, part
number or speci®cation may be obtained from your
dealer.
Usage Fluid/Lubricant
Engine OilEngine oil which meets GM
Standard GM6094M and displays
the American Petroleum Institute
Certi®ed for Gasoline Engines
starburst symbol. To determine
the proper viscosity for your
vehicle's engine, see
Engine Oil
on page 5-13.
Engine Coolant50/50 mixture of clean, drinkable
water (preferably distilled)
and good quality Ethylene
Glycol Base Coolant
(GM Part No. U.S. 12378560, in
Canada 993089, or equivalent)
and conforming to GM
Speci®cation 1825M or approved
recycled coolant conforming to
GM Speci®cation 1825M. See
Engine Coolant on page 5-25.
Usage Fluid/Lubricant
Hydraulic Brake
SystemDelco Supreme 11
žBrake Fluid
or equivalent DOT-3 brake ¯uid.
Windshield
Washer SolventGM Optikleen
žWasher Solvent.
Hydraulic Clutch
SystemHydraulic Clutch Fluid
(GM Part No. U.S. 12345347, in
Canada 10953517) or equivalent
DOT-3 brake ¯uid.
Parking Brake
Cable GuidesChassis Lubricant
(GM Part No. U.S. 12377985, in
Canada 88901242) or lubricant
meeting requirements of
NLGI #2, Category LB or GC-LB.
Power Steering
SystemDEXRON
ž-III Automatic
Transmission Fluid.
Manual
Transmission (All)
and Transfer Case
(Four-Wheel-Drive)Synchromesh Transmission Fluid
(GM Part No. U.S. 12345349, in
Canada 10953465).
Automatic
TransmissionDEXRON
ž-III Automatic
Transmission Fluid.
6-30

Usage Fluid/Lubricant
Key Lock
CylindersMulti-Purpose
Lubricant, Superlube
(GM Part No. U.S. 12346241, in
Canada 10953474).
Manual
Transmission Shift
LinkageChassis Lubricant
(GM Part No. U.S. 12377985, in
Canada 88901242) or lubricant
meeting requirements of
NLGI #2, Category LB or GC-LB.
Clutch Linkage
Pivot PointsChassis Lubricant
(GM Part No. U.S. 12377985, in
Canada 88901242) or lubricant
meeting requirements of
NLGI #2, Category LB or GC-LB.
Floor Shift LinkageLubriplate Lubricant Aerosol
(GM Part No. U.S. 12346293, in
Canada 992723) or lubricant
meeting requirements of NLGI #2
Category LB or GC-LB.Usage Fluid/Lubricant
Chassis
LubricationChassis Lubricant
(GM Part No. U.S. 12377985, in
Canada 88901242) or lubricant
meeting requirements of
NLGI #2, Category LB or GC-LB.
Rear Axle (All)
and Front Axle
(Four-Wheel Drive)Axle Lubricant
(GM Part No. U.S. 12345977, in
Canada 10953482) or
SAE 80W-90 GL-5 gear lubricant.
Hood Latch
Assembly,
Secondary Latch,
Pivots, Spring
Anchor and
Release PawlLubriplate Lubricant Aerosol
(GM Part No. U.S. 12346293, in
Canada 992723) or lubricant
meeting requirements of
NLGI #2, Category LB or GC-LB.
Hood and Door
HingesMulti-Purpose
Lubricant, Superlube
(GM Part No. U.S. 12346241, in
Canada 10953474).
Weatherstrip
ConditioningDielectric Silicone Grease
(GM Part No. U.S. 12345579, in
Canada 992887).
6-31

GM Mobility Program for Persons
with Disabilities
This program, available to
quali®ed applicants, can
reimburse you up to
$1,000 toward eligible
aftermarket driver or
passenger adaptive
equipment you may
require for your vehicle
(hand controls,
wheelchair/scooter
lifts, etc.).
This program can also provide you with free resource
information, such as area driver assessment centers and
mobility equipment installers. The offer is available for
a limited period of time from the date of vehicle
purchase/lease. For more details, or to determine your
vehicle's eligibility, see your GM dealer or call the
GM Mobility Assistance Center at 1-800-323-9935. Text
telephone (TTY) users, call 1-800-833-9935.
GM of Canada also has a Mobility Program. Call
1-800-GM-DRIVE (463-7483) for details. All TTY users
call 1-800-263-3830.
Roadside Assistance Program
Security While You Travel
1-800-CHEV-USA (243-8872)
As the proud owner of a new Chevrolet vehicle, you are
automatically enrolled in the Chevrolet Roadside
Assistance program. This value-added service is
intended to provide you with peace of mind as you drive
in the city or travel the open road. Chevrolet's Roadside
Assistance toll-free number is staffed by courteous
and capable Roadside Assistance Representatives who
are available 24 hours a day, 365 days a year.
We will provide the following services during the
Bumper-to-Bumper warranty period, at no expense
to you:
·Fuel Delivery:Delivery of enough fuel
($5 maximum) for the customer to get to the
nearest service station.
·Lock-out Service (identi®cation required):
Replacement keys or locksmith service will
be covered at no charge if you are unable to gain
entry into your vehicle. Delivery of the replacement
key will be covered within 10 miles.
7-5

Child Restraints (cont.)
Securing a Child Restraint in a Rear Outside
Seat Position...........................................1-44
Securing a Child Restraint in the Right Front
Seat Position...........................................1-49
Top Strap...................................................1-39
Top Strap Anchor Location............................1-41
Where to Put the Restraint...........................1-38
Cigarette Lighter.............................................3-19
Cleaning
Inside of Your Vehicle..................................5-86
Outside of Your Vehicle................................5-89
Underbody Maintenance...............................5-91
Weatherstrips..............................................5-88
Cleaning Aluminum Wheels..............................5-90
Cleaning Exterior Lamps/Lenses.......................5-89
Cleaning Fabric/Carpet....................................5-86
Cleaning Glass Surfaces..................................5-88
Cleaning Interior Plastic Components.................5-88
Cleaning Leather............................................5-87
Cleaning the Top of the Instrument Panel...........5-88
Cleaning the Windshield, Backglass and
Wiper Blades..............................................5-90
Cleaning Tires................................................5-91
Cleaning Vinyl................................................5-87
Climate Control System...................................3-19
Air Filter, Passenger Compartment.................3-23
Outlet Adjustment........................................3-22Clutch, Hydraulic.............................................5-24
Coinholder(s)..................................................2-33
Control of a Vehicle.......................................... 4-7
Convenience Net............................................2-36
Coolant
Engine Temperature Gage............................3-32
Heater, Engine............................................2-15
Cooling System..............................................5-31
Cruise Control.................................................. 3-9
Cupholder(s)..................................................2-33
Current and Past Model Order Forms................7-12
Customer Assistance Information
Courtesy Transportation.................................. 7-7
Customer Assistance for Text
Telephone (TTY) Users............................... 7-4
Customer Assistance Offices........................... 7-4
Customer Satisfaction Procedure..................... 7-2
GM Mobility Program for Persons with
Disabilities................................................ 7-5
Reporting Safety Defects to General Motors....7-10
Reporting Safety Defects to the Canadian
Government............................................7-10
Reporting Safety Defects to the United States
Government............................................7-10
Roadside Assistance Program......................... 7-5
Service Publications Ordering Information........7-11
3

Engine Compartment Fuse Block......................5-96
Engine Coolant Level Check.............................6-24
Engine Oil Additives........................................5-16
Engine Oil Level Check...................................6-24
Entry Lighting.................................................3-17
Environmental Concerns..................................4-17
Event Data Records (EDR)................................ 7-9
Express-Down Window....................................2-11
Extender, Safety Belt.......................................1-28
Exterior Lamps...............................................3-13
F
Filter
Engine Air Cleaner......................................5-18
Finding a Station............................................3-40
Finish Care....................................................5-89
Finish Damage...............................................5-91
Five-Speed....................................................2-20
Fixed Mast Antenna........................................3-45
Flash to Pass.................................................. 3-7
Flat Tire........................................................5-72
Flat Tire, Changing.........................................5-72
Fluid
Automatic Transmission................................5-20
Manual Transmission....................................5-23
Power Steering...........................................5-37
Windshield Washer......................................5-37
Fluid Level Check...........................................6-25FM ...............................................................3-45
Folding the Seatback........................................ 1-6
Following Distance..........................................4-61
Footnotes................................................6-7, 6-17
Four-Door Models...................................1-24, 1-47
Four-Wheel Drive....................................2-22, 5-49
Four-Wheel-Drive Light....................................3-37
Front Axle......................................................5-50
Fuel............................................................... 5-4
Additives...................................................... 5-6
California Fuel.............................................. 5-5
Filling a Portable Fuel Container..................... 5-9
Filling Your Tank........................................... 5-7
Fuels in Foreign Countries.............................. 5-6
Gage.........................................................3-38
Gasoline Octane........................................... 5-4
Gasoline Speci®cations.................................. 5-4
System Inspection.......................................6-28
Fuses
Fuses and Circuit Breakers...........................5-94
G
Gage
Engine Coolant Temperature.........................3-32
Fuel..........................................................3-38
Speedometer..............................................3-28
Tachometer.................................................3-28
5

Inspection
Brake System.............................................6-29
Engine Cooling System................................6-28
Exhaust System..........................................6-28
Fuel System...............................................6-28
Part C - Periodic Maintenance.......................6-28
Steering, Suspension and Front Drive Axle
Boot and Seal.........................................6-28
Throttle System...........................................6-29
Instrument Panel
Cluster.......................................................3-27
Overview..................................................... 3-2
Instrument Panel Brightness.............................3-16
Instrument Panel Fuse Block............................5-94
Interior Lamps................................................3-16
J
Jump Starting.................................................5-43
K
Key Lock Cylinders Service..............................6-25
Keyless Entry System....................................... 2-3
Keys............................................................... 2-2
L
Lamps
Exterior......................................................3-13
Interior.......................................................3-16
Lap Belt........................................................1-25
Lap-Shoulder Belt...................................1-15, 1-26
LATCH System
Child Restraints...........................................1-42
Securing a Child Restraint Designed for the
LATCH System........................................1-44
Leaving Your Vehicle......................................... 2-9
Leaving Your Vehicle With the Engine
Running.....................................................2-26
Light
Air Bag Readiness.......................................3-29
Anti-Lock Brake System Warning...................3-31
Brake System Warning.................................3-30
Charging System.........................................3-30
Four-Wheel-Drive.........................................3-37
Malfunction Indicator....................................3-33
Oil Pressure...............................................3-36
Overdrive Off..............................................3-37
Power Indicator...........................................3-37
Safety Belt Reminder...................................3-28
Loading Your Vehicle.......................................4-51
Loading Your Vehicle for Off-Road Driving..........4-16
7

Locks
Door........................................................... 2-6
Leaving Your Vehicle..................................... 2-9
Power Door.................................................. 2-7
Rear Door Security Locks............................... 2-8
Long Trip/Highway De®nition.............................. 6-6
Long Trip/Highway Intervals............................... 6-6
Long Trip/Highway Scheduled Maintenance........6-17
Loss of Control...............................................4-15
Luggage Carrier..............................................2-34
Lumbar
Manual Controls............................................ 1-3
M
Maintenance, Normal Replacement Parts..........5-100
Maintenance Schedule
At Each Fuel Fill.........................................6-24
At Least Once a Month................................6-24
At Least Once a Year..................................6-25
At Least Twice a Year..................................6-25
Brake System Inspection..............................6-29
Engine Cooling System Inspection.................6-28
Exhaust System Inspection...........................6-28
Fuel System Inspection................................6-28
How This Section is Organized....................... 6-3
Introduction.................................................. 6-2
Long Trip/Highway Scheduled Maintenance.....6-17
Maintenance Requirements............................. 6-2Maintenance Schedule (cont.)
Part A - Scheduled Maintenance Services......... 6-4
Part B - Owner Checks and Services.............6-24
Part C - Periodic Maintenance Inspections......6-28
Part D - Recommended Fluids and
Lubricants...............................................6-30
Part E - Maintenance Record........................6-32
Rear Axle and Front Axle (Four-Wheel-Drive)
Service...................................................6-29
Selecting the Right Schedule.......................... 6-4
Short Trip/City Scheduled Maintenance............. 6-7
Steering, Suspension and Front Drive Axle
Boot and Seal Inspection..........................6-28
Throttle System Inspection............................6-29
Using Your................................................... 6-4
Your Vehicle and the Environment................... 6-2
Maintenance When Trailer Towing.....................4-64
Making Turns.................................................4-62
Malfunction Indicator Light................................3-33
Manual Lumbar Controls.................................... 1-3
Manual Seats................................................... 1-2
Manual Transmission.......................................2-14
Fluid..........................................................5-23
Operation...................................................2-20
Manual Windows............................................2-11
Matching Transmitter(s) to Your Vehicle............... 2-5
Mexico, Central America and Caribbean Islands/
Countries (Except Puerto Rico and U.S. Virgin
Islands) ± Customer Assistance....................... 7-4
8

Mirrors
Manual Rearview Mirror................................2-31
Outside Convex Mirror.................................2-33
Outside Manual Mirrors................................2-32
Outside Power Mirrors..................................2-32
MyGMLink.com................................................ 7-3
N
New Vehicle Break-In......................................2-12
Normal Maintenance Replacement Parts...........5-100
O
Odometer......................................................3-28
Off-Road Recovery..........................................4-13
Oil
Engine.......................................................5-13
Pressure Light.............................................3-36
Older Children, Restraints................................1-29
Online Owner Center........................................ 7-3
Opening a Rear Door When the Security Lock
Is On .......................................................... 2-8
Operating Your All-Wheel-Drive Vehicle Off
Paved Roads..............................................4-16
Operation......................................................3-20
Operation Tips................................................3-23
Other Warning Devices...................................... 3-5
Outlet Adjustment............................................3-22Outside
Convex Mirror.............................................2-33
Manual Mirrors............................................2-32
Power Mirrors.............................................2-32
Overdrive Off.................................................2-19
Overdrive Off Light..........................................3-37
Overseas ± Customer Assistance........................ 7-4
Owners, Canadian............................................... ii
Owner's Information........................................7-12
P
Park (P)
Shifting Into................................................2-25
Shifting Out of............................................2-27
Parking
Brake........................................................2-24
Over Things That Burn.................................2-28
Parking Brake and Automatic Transmission
Park (P) Mechanism Check...........................6-27
Parking on Hills..............................................4-63
Parking Your Vehicle.......................................2-28
Part A - Scheduled Maintenance Services............ 6-4
Part B - Owner Checks and Services................6-24
Part C - Periodic Maintenance Inspections..........6-28
Part D - Recommended Fluids and Lubricants....6-30
Part E - Maintenance Record...........................6-32
Passenger Compartment Air Filter.....................3-23
Passing.................................................4-13, 4-61
9