belt CHRYSLER ASPEN HYBRID 2009 2.G Owners Manual

JOBNAME: 146224AspenHEV 2009 PAGE: 6 SESS: 29 OUTPUT: Thu Jul 10 15:40:34 2008
/chrysler/chry-intl/warr-maint/146224-hghev-english/warranty
5/100 POWERTRAIN WARRANTY
The following powertrain components are covered for5 years or 100,000
kilometres,whichever occurs first, measured from the vehicle's original
warranty start date.
Vehicles placed in taxi, limousine, postal or ambulance service and all SRT
vehicles are excluded from the5-year or 100,000-kilometrePowertrain
Warranty and are covered only under the3-year or 60,000-kilometreBasic
Warranty.
²Engine-
Cylinder block and all internal parts; cylinder head assemblies;
timing case, timing chain, timing belt, gears and sprockets; vibration damper;
oil pump; water pump and housing; intake and exhaust manifolds; flywheel
with starter ring gear; core plugs; valve covers; oil pan; turbocharger housing
and internal parts; turbocharger wastegate actuator; supercharger; serpentine
belt tensioner; seals and gaskets for listed components only.
²Front-Wheel Drive(If equipped) -Transaxle case and all internal parts;
axle shaft assemblies; constant velocity joints and boots; differential
cover; oil pan; transaxle speed sensors; transaxle solenoid assembly;
PRNDL position switch; transaxle electronic controller; torque con-
verter; seals and gaskets for listed components only.
Note: Manual transmission clutch parts are not covered at any time.²Rear-Wheel Drive(If equipped)- Transmission case and all internal
parts; torque converter, drive/flex plate; transmission range switch;
transmission control module; bell housing; oil pan; seals and gaskets for
listed components only. Rear axle housing and all internal parts; axle
shafts; axle shaft bearings; driveshaft assemblies; driveshaft centre
bearings; universal joints and yokes; seals and gaskets for listed
components only.
²4-Wheel Drive (4x4)(If equipped)- Transfer case and all internal parts;
transfer case control module and shift mode motor assembly; axle
housing and all internal parts; axle shafts; axle shaft bearings; driveshaft
assemblies (front and rear); driveshaft centre bearings; universal joints
and yokes; disconnect housing assembly; seals and gaskets for listed
components only.
²All-Wheel Drive (AWD)(If equipped)- Power transfer unit and all
internal parts; driveshaft and axle shaft assemblies; constant velocity
joints and boots; axle housing and all internal parts; differential carrier
assembly and all internal parts; output ball bearing; output flange; end
cover; viscous converter clutch; overrunning clutch; vacuum motor;
torque tube; pinion spacer and shim; seals and gaskets for these parts
only.
8
5/100 POWERTRAIN WARRANTY

JOBNAME: 146224AspenHEV 2009 PAGE: 7 SESS: 36 OUTPUT: Thu Jul 10 15:40:34 2008
/chrysler/chry-intl/warr-maint/146224-hghev-english/warranty
5/100 DIESEL ENGINE WARRANTY(IF EQUIPPED)
The diesel engine parts are covered for5 years or 100,000 kilometres,
whichever occurs first.
²Diesel Engine-
Cylinder block and all internal parts; cylinder head
assemblies; core plugs; fuel injection pump and injectors; intake and exhaust
manifolds; oil pan; oil pump; timing gear drive belts and/or chains and cover;
turbocharger housing and internal parts; valve covers; water pump and
housing; seals and gaskets for listed components.
8/130 HYBRID SYSTEM WARRANTY(IF EQUIPPED)
These hybrid system parts are covered for8 years or 160,000 kilometres,
whichever occurs first.
²Transmission and all internal components
²TPIM Fan
²TPIM Pump
²TPIM Assembly
²APM Assembly
²HV AC Cables
²HV DC cables
²Hybrid Battery
CORROSION WARRANTY
For 3 years, regardless of distance driven,your Corrosion Warranty
covers any body sheet metal panel which develops a hole caused by
corrosion.
In addition, outer body panels are covered against holes caused by
corrosion up to5 years or 160,000 kilometres,whichever occurs first. An
outer body panel is a sheet metal panel which can be seen while walking
around the vehicle, and which is painted body colour.
This warranty applies only to holes caused by corrosion. Cosmetic or
surface corrosion (resulting from stone chips or scratches in the paint, for
example) will not be repaired under this warranty.
If corrosion damage is obviously neglected and allowed to worsen until a
hole develops, this warranty will not cover the repair.
9
5/100 DIESEL ENGINE / 8/130 HYBRID SYSTEM / CORROSION WARRANTIES

JOBNAME: 146224AspenHEV 2009 PAGE: 39 SESS: 13 OUTPUT: Thu Jul 10 15:40:34 2008
/chrysler/chry-intl/warr-maint/146224-hghev-english/intervals
Perform Maintenance At
200,000 km or 120 Months
oChange the engine oil and oil filter.Under no circumstances should the oil change
interval exceed 10 000 km or 6 months whichever occurs first.*
oRotate tires.
oReplace the engine air filter.
oInspect the front suspension components, tie rod ends and boot seals; replace if
necessary.
oInspect the transfer case fluid; change if using your vehicle for any of the following:
police, taxi, fleet or frequent trailer towing.
oInspect the brake linings; replace if necessary.
oInspect the CV joints.
oInspect the exhaust system.
oChange the automatic transmission fluid and filter.
oReplace the accessory drive belt(s).
* Oil changes that are prompted by the oil change indicator system prior to this
schedule maintenance interval can be recorded in the oil change log section.
Perform Maintenance
At
120 Months or
200,000 km
Odometer Reading
DateRetailer Copy
Remove and attach to Repair Order
................................................................................................

JOBNAME: 146224AspenHEV 2009 PAGE: 40 SESS: 13 OUTPUT: Thu Jul 10 15:40:34 2008
/chrysler/chry-intl/warr-maint/146224-hghev-english/intervals
oChange the engine oil and oil filter.Under no circum-
stances should the oil change interval exceed 10 000 km
or 6 months whichever occurs first.*
oRotate tires.
oReplace the engine air filter.
oInspect the front suspension components, tie rod ends and
boot seals; replace if necessary.
oInspect the transfer case fluid; change if using your vehicle
for any of the following: police, taxi, fleet or frequent
trailer towing.
oInspect the brake linings; replace if necessary.
oInspect the CV joints.
oInspect the exhaust system.
oChange the automatic transmission fluid and filter.
oReplace the accessory drive belt(s).
* Oil changes that are prompted by the oil change indicator
system prior to this schedule maintenance interval can be
recorded in the oil change log section.
Perform Maintenance At
200,000 km or 120 Months
Odometer Reading
Date
Repair Order No.
CHRYSLER
RETAILERSTAMP
Signature of authorized Chrysler Canada Retailer
................................................................................................