fuel CHRYSLER ASPEN HYBRID 2009 2.G Owners Manual
[x] Cancel search | Manufacturer: CHRYSLER, Model Year: 2009, Model line: ASPEN HYBRID, Model: CHRYSLER ASPEN HYBRID 2009 2.GPages: 68, PDF Size: 0.17 MB
Page 2 of 68
JOBNAME: 146224AspenHEV 2009 PAGE: 1 SESS: 13 OUTPUT: Thu Jul 10 15:40:34 2008
/chrysler/chry-intl/warr-maint/146224-hghev-english/ibc
INTRODUCTION
The oil change indicator system will remind you
that it is time to take your vehicle in for scheduled
maintenance. Based on engine operation condi-
tion the oil change indicator message will illumi-
nate, this means that service is required for your
vehicle. Have your vehicle serviced as soon as
possible, within the next 800 km. The oil change
indicator message will not monitor the time since
the last oil change. Change your vehicles oil if it
has been 6 months since your last oil change even
if the oil change indicator message is NOT illu-
minated. Change your engine oil more often if
you drive your vehicle off-road for an extendedperiod of time.Under no circumstances should
oil change intervals exceed 10,000 km or
6 months, whichever comes first.Your dealer
will reset the oil change indicator message after
completing the scheduled oil change. If this
scheduled oil change is performed by someone
other than your dealer the message can be reset by
referring to the steps described in the Owner's
Manual.
The performance of all scheduled service work is
required to maintain your vehicle in good operat-
ing condition. Chrysler Canada Inc. reserves the
right to deny warranty coverage if the vehicle has
not been properly maintained. While we do not
insist that such work be performed by factory
authorized retailers, we strongly recommend that
an authorized Chrysler, Jeeptor Dodge Retailer
perform this work.AT EACH STOP FOR FUEL
²Check the engine oil level about 5 minutes
after a fully warmed engine is shut off. Check-
ing the oil level while the vehicle is on level
ground will improve the accuracy of the oil
level reading. Add oil only when the level is at
or below the ADD or MIN mark.
²Check the windshield washer solvent and add
if required.
ONCE A MONTH
²Check tire pressure and look for unusual wear
or damage.
²Inspect the battery and clean and tighten the
terminals as required.
²Check the fluid levels of coolant reservoir,
brake master cylinder, power steering and
transmission and add as needed.
²Check all lights and other electrical items for
correct operation.
²Check and clean wiper blades. Replace if
required.
AT EACH OIL CHANGE
²Change the engine oil filter.
²Inspect the brake hoses and lines.
VISUAL INSPECTIONS Ð
INSPECT FOR SIGNS OF COMPONENT
DETERIORATION AND PHYSICAL DAMAGE.
MAINTENANCEScheduled maintenance must be completed to provide the best vehicle
performance and reliability. The limited warranties in the warranty booklet DO NOT COVER
repairs required due to improper maintenance. We strongly suggest you keep track of scheduled
maintenance and keep receipts or other documents. Use only recommended MopartLubricants
and genuine MopartParts. In the event that a condition arises between maintenance intervals,
please contact your retailer. AVOID PROLONGED PERIODS OF IDLING.
NOTE: WHERE TIME (MONTHS) AND METRAGE ARE INDICATED, FOLLOW THE
INTERVAL THAT OCCURS FIRST.
Page 9 of 68
JOBNAME: 146224AspenHEV 2009 PAGE: 7 SESS: 36 OUTPUT: Thu Jul 10 15:40:34 2008
/chrysler/chry-intl/warr-maint/146224-hghev-english/warranty
5/100 DIESEL ENGINE WARRANTY(IF EQUIPPED)
The diesel engine parts are covered for5 years or 100,000 kilometres,
whichever occurs first.
²Diesel Engine-
Cylinder block and all internal parts; cylinder head
assemblies; core plugs; fuel injection pump and injectors; intake and exhaust
manifolds; oil pan; oil pump; timing gear drive belts and/or chains and cover;
turbocharger housing and internal parts; valve covers; water pump and
housing; seals and gaskets for listed components.
8/130 HYBRID SYSTEM WARRANTY(IF EQUIPPED)
These hybrid system parts are covered for8 years or 160,000 kilometres,
whichever occurs first.
²Transmission and all internal components
²TPIM Fan
²TPIM Pump
²TPIM Assembly
²APM Assembly
²HV AC Cables
²HV DC cables
²Hybrid Battery
CORROSION WARRANTY
For 3 years, regardless of distance driven,your Corrosion Warranty
covers any body sheet metal panel which develops a hole caused by
corrosion.
In addition, outer body panels are covered against holes caused by
corrosion up to5 years or 160,000 kilometres,whichever occurs first. An
outer body panel is a sheet metal panel which can be seen while walking
around the vehicle, and which is painted body colour.
This warranty applies only to holes caused by corrosion. Cosmetic or
surface corrosion (resulting from stone chips or scratches in the paint, for
example) will not be repaired under this warranty.
If corrosion damage is obviously neglected and allowed to worsen until a
hole develops, this warranty will not cover the repair.
9
5/100 DIESEL ENGINE / 8/130 HYBRID SYSTEM / CORROSION WARRANTIES
Page 13 of 68
JOBNAME: 146224AspenHEV 2009 PAGE: 11 SESS: 28 OUTPUT: Thu Jul 10 15:40:34 2008
/chrysler/chry-intl/warr-maint/146224-hghev-english/warranty
DAMAGE FROM IMPROPER MAINTENANCE
The warranties in this booklet do not cover repairs required due to
improper maintenance, lack of maintenance, use of contaminated or dirty
fuels or failure to use the proper fuels and lubricants recommended in the
Owner's Manual and herein.
EXTRA EXPENSES
The warranties in this booklet do not cover incidental or consequential
damages such as loss of use of your vehicle, loss of time, inconvenience,
expense for fuel, telephone, travel, rental car, overnight accommodation,
loss or damage to your personal property, commercial loss, loss of
income, etc.
NON-CHRYSLER MODIFICATIONS
The warranties in this booklet do not cover repairs required because of
non-Chrysler modifications, installation of special equipment or accesso-
ries, or use of special materials, fuels or additives. This includes special
bodies, body conversions, fuel system conversions, trailer hitches, window
tints, sunroofs, theft alarms, etc. Non-Chrysler modifications do not by
themselves void your warranty, but they are not covered by your warranty.
NON-CHRYSLER PARTS
The warranties in this booklet do not cover parts, equipment, materials or
additives not supplied by Chrysler or not certified for use on your vehicle.
Performance and racing parts are considered to be non-Chrysler parts.
13
WHAT IS NOT COVERED
Page 21 of 68
JOBNAME: 146224AspenHEV 2009 PAGE: 19 SESS: 29 OUTPUT: Thu Jul 10 15:40:34 2008
/chrysler/chry-intl/warr-maint/146224-hghev-english/warranty
²FLAT TIRE?If you have a flat tire, the service facility will remove it
and install your spare tire. The spare tire must be inflated and in sound
operating condition. Tire repairs are not covered.
²OUT OF FUEL?If your vehicle runs out of fuel, a small amount of
gasoline will be delivered to your location, where regulations permit. In all
other cases, including alternate fuels, your vehicle will be towed to the
nearest re-fuelling centre. In these instances, the cost of fuel purchased will
be your responsibility.
Please read(About Roadside Assistance((page 22) because there are
some limitations that may affect the service available to you.
TO REQUEST ASSISTANCE(SEE ALSO INSIDE FRONT COVER)
If your vehicle requires any of the services provided by the program, call
this toll-free number anytime, from any location in Canada or the United
States:1-800-363-4869(this number does not ring at Chrysler Canada).
Please identify yourself as a Chrysler vehicle owner and be ready to provide:
oYour Vehicle Identification Number
oYour licence plate number
oYour odometer reading (kilometres)
oThe location of your vehicle and the phone number where you can
be reached
oType of service needed (tow, flat tire, battery boost, etc.)Note:²In severe weather, some delays may be expected.
²You will have to personally authorize the service provided by the
tow company
²If your vehicle is towed to a retailer, you are responsible for
contacting the retailer to authorize the service
TOWING AFTER THE PROGRAM EXPIRES
Coverage under the Roadside Assistance Program expires at5 years or
100,000 kilometres(or at3 years or 60,000 kilometres,if applicable),
whichever occurs first. If you call the toll-free number for assistance after
the Program expires, you will have to pay for the service provided.
Some emissions coverage lasts longer than the Roadside Assistance
Program.* For warranted emission system repairs after the program
expires, towing (only) will be provided on a reimbursement basis. Call the
toll-free number and service will be dispatched, but you will have to pay
for the tow. For reimbursement consideration, see your authorized retailer
for further details.
* See page 10.
21
ROADSIDE ASSISTANCE
Page 22 of 68
JOBNAME: 146224AspenHEV 2009 PAGE: 20 SESS: 29 OUTPUT: Thu Jul 10 15:40:34 2008
/chrysler/chry-intl/warr-maint/146224-hghev-english/warranty
ABOUT ROADSIDE ASSISTANCE
The Chrysler Canada Roadside Assistance Program is not a warranty, but
the coverage is concurrent with the Basic and Powertrain Warranties.
Covered service must be provided in Canada or the Continental United
States and is limited to plated and insured vehicles that use public
roadways.
Service will not be provided free if you have driven into an area that is
inaccessible to the service vehicle or is not a regularly travelled and
maintained public road (such as beaches, recreational areas, construction
sites, open fields, private and seasonal roads). Cross-country, logging, auto
cross and any other form of off-road use is not covered.
The program does not cover winching or towing for vehicles that become
stuck while plowing snow.
The program does not cover repeat calls for the same problem (if avoidance
of the problem is within the control of the driver or owner), or towing from
one retailer to another, or service if the driver appears to be under the
influence of alcohol or drugs.The program does not pay for parts, tires, repairs, labour or vehicle storage.
Parts, repairs, or labour covered under a vehicle warranty will be provided
by your Chrysler Canada Retailer.
The program does not pay for towing required because of an accident.
For example, if a vehicle is winched from a ditch or snowbank and is then
determined to need a tow because of damage suffered when it left the road,
the tow will not be covered.
The program does not cover any9incidental or consequential damages9
connected with the failure of your vehicle or providing services to you.
Such damages include lost time, inconvenience, loss of use of your vehicle,
rental cars, fuel, telephone, travel or lodging, loss of personal or commer-
cial property, loss of revenue, etc.
All service providers are independent contractors and are not employees or
agents of Chrysler Canada. Any loss or damage to your vehicle or personal
property resulting from providing roadside service is the responsibility of
the roadside service provider (the towing company, for example).
Report any damage or loss to the manager of the service provider and to
your own insurance company within 24 hours and before any repairs are
performed.
22
ROADSIDE ASSISTANCE
Page 25 of 68
JOBNAME: 146224AspenHEV 2009 PAGE: 23 SESS: 30 OUTPUT: Thu Jul 10 15:40:34 2008
/chrysler/chry-intl/warr-maint/146224-hghev-english/warranty
1. POWERTRAIN PLANS*
Powertrain plans complement the factory powertrain warranty by provid-
ing enhanced roadside coverage and car rental allowance if your vehicle is
not drivable and must be kept overnight. Certain plans also provide
additional distance coverage.
Major components covered are:
²engine²transmission²front-wheel drive²rear-wheel drive
²4-wheel drive (4x4)²all-wheel drive vehicles
2.(GOLD(PLANS*
Each plan provides full mechanical repair protection to non-powertrain
(Gold) components. Certain plans also provide full mechanical protection
against powertrain component repairs beyond your vehicle's powertrain
warranty coverage. Contracts are available with or without a deductible.
Major components covered are:
²steering²air conditioning²engine cooling and fuel²front suspension
²rear suspension²electrical²hydraulic brake components²anti-lock
brakes
* Maximum terms available on new vehicles registered in Canada only.
3.(GOLDPLUS(PLANS*
The most complete protection available for your new vehicle is a9Gold
Plus9Service Contract which combines the benefits of Gold component
coverage (see9Gold9Plans), plus, the most important vehicle maintenance
functions:
²Engine oil and oil filter changes
²Tire rotation every other service
²9Peace-of-Mind9motoring with Tire Road Hazard Protection
which provides full, or pro-rata, replacement of the original four
tires, or their repair
²Rental car allowance for same-day warranty repairs - your vehicle
need not be kept overnight before eligibility for the rental allow-
ance is met
25
OPTIONAL CHRYSLER CANADA SERVICE CONTRACTS