transmission CHRYSLER ASPEN HYBRID 2009 2.G Owners Manual
[x] Cancel search | Manufacturer: CHRYSLER, Model Year: 2009, Model line: ASPEN HYBRID, Model: CHRYSLER ASPEN HYBRID 2009 2.GPages: 68, PDF Size: 0.17 MB
Page 2 of 68
JOBNAME: 146224AspenHEV 2009 PAGE: 1 SESS: 13 OUTPUT: Thu Jul 10 15:40:34 2008
/chrysler/chry-intl/warr-maint/146224-hghev-english/ibc
INTRODUCTION
The oil change indicator system will remind you
that it is time to take your vehicle in for scheduled
maintenance. Based on engine operation condi-
tion the oil change indicator message will illumi-
nate, this means that service is required for your
vehicle. Have your vehicle serviced as soon as
possible, within the next 800 km. The oil change
indicator message will not monitor the time since
the last oil change. Change your vehicles oil if it
has been 6 months since your last oil change even
if the oil change indicator message is NOT illu-
minated. Change your engine oil more often if
you drive your vehicle off-road for an extendedperiod of time.Under no circumstances should
oil change intervals exceed 10,000 km or
6 months, whichever comes first.Your dealer
will reset the oil change indicator message after
completing the scheduled oil change. If this
scheduled oil change is performed by someone
other than your dealer the message can be reset by
referring to the steps described in the Owner's
Manual.
The performance of all scheduled service work is
required to maintain your vehicle in good operat-
ing condition. Chrysler Canada Inc. reserves the
right to deny warranty coverage if the vehicle has
not been properly maintained. While we do not
insist that such work be performed by factory
authorized retailers, we strongly recommend that
an authorized Chrysler, Jeeptor Dodge Retailer
perform this work.AT EACH STOP FOR FUEL
²Check the engine oil level about 5 minutes
after a fully warmed engine is shut off. Check-
ing the oil level while the vehicle is on level
ground will improve the accuracy of the oil
level reading. Add oil only when the level is at
or below the ADD or MIN mark.
²Check the windshield washer solvent and add
if required.
ONCE A MONTH
²Check tire pressure and look for unusual wear
or damage.
²Inspect the battery and clean and tighten the
terminals as required.
²Check the fluid levels of coolant reservoir,
brake master cylinder, power steering and
transmission and add as needed.
²Check all lights and other electrical items for
correct operation.
²Check and clean wiper blades. Replace if
required.
AT EACH OIL CHANGE
²Change the engine oil filter.
²Inspect the brake hoses and lines.
VISUAL INSPECTIONS Ð
INSPECT FOR SIGNS OF COMPONENT
DETERIORATION AND PHYSICAL DAMAGE.
MAINTENANCEScheduled maintenance must be completed to provide the best vehicle
performance and reliability. The limited warranties in the warranty booklet DO NOT COVER
repairs required due to improper maintenance. We strongly suggest you keep track of scheduled
maintenance and keep receipts or other documents. Use only recommended MopartLubricants
and genuine MopartParts. In the event that a condition arises between maintenance intervals,
please contact your retailer. AVOID PROLONGED PERIODS OF IDLING.
NOTE: WHERE TIME (MONTHS) AND METRAGE ARE INDICATED, FOLLOW THE
INTERVAL THAT OCCURS FIRST.
Page 8 of 68
JOBNAME: 146224AspenHEV 2009 PAGE: 6 SESS: 29 OUTPUT: Thu Jul 10 15:40:34 2008
/chrysler/chry-intl/warr-maint/146224-hghev-english/warranty
5/100 POWERTRAIN WARRANTY
The following powertrain components are covered for5 years or 100,000
kilometres,whichever occurs first, measured from the vehicle's original
warranty start date.
Vehicles placed in taxi, limousine, postal or ambulance service and all SRT
vehicles are excluded from the5-year or 100,000-kilometrePowertrain
Warranty and are covered only under the3-year or 60,000-kilometreBasic
Warranty.
²Engine-
Cylinder block and all internal parts; cylinder head assemblies;
timing case, timing chain, timing belt, gears and sprockets; vibration damper;
oil pump; water pump and housing; intake and exhaust manifolds; flywheel
with starter ring gear; core plugs; valve covers; oil pan; turbocharger housing
and internal parts; turbocharger wastegate actuator; supercharger; serpentine
belt tensioner; seals and gaskets for listed components only.
²Front-Wheel Drive(If equipped) -Transaxle case and all internal parts;
axle shaft assemblies; constant velocity joints and boots; differential
cover; oil pan; transaxle speed sensors; transaxle solenoid assembly;
PRNDL position switch; transaxle electronic controller; torque con-
verter; seals and gaskets for listed components only.
Note: Manual transmission clutch parts are not covered at any time.²Rear-Wheel Drive(If equipped)- Transmission case and all internal
parts; torque converter, drive/flex plate; transmission range switch;
transmission control module; bell housing; oil pan; seals and gaskets for
listed components only. Rear axle housing and all internal parts; axle
shafts; axle shaft bearings; driveshaft assemblies; driveshaft centre
bearings; universal joints and yokes; seals and gaskets for listed
components only.
²4-Wheel Drive (4x4)(If equipped)- Transfer case and all internal parts;
transfer case control module and shift mode motor assembly; axle
housing and all internal parts; axle shafts; axle shaft bearings; driveshaft
assemblies (front and rear); driveshaft centre bearings; universal joints
and yokes; disconnect housing assembly; seals and gaskets for listed
components only.
²All-Wheel Drive (AWD)(If equipped)- Power transfer unit and all
internal parts; driveshaft and axle shaft assemblies; constant velocity
joints and boots; axle housing and all internal parts; differential carrier
assembly and all internal parts; output ball bearing; output flange; end
cover; viscous converter clutch; overrunning clutch; vacuum motor;
torque tube; pinion spacer and shim; seals and gaskets for these parts
only.
8
5/100 POWERTRAIN WARRANTY
Page 9 of 68
JOBNAME: 146224AspenHEV 2009 PAGE: 7 SESS: 36 OUTPUT: Thu Jul 10 15:40:34 2008
/chrysler/chry-intl/warr-maint/146224-hghev-english/warranty
5/100 DIESEL ENGINE WARRANTY(IF EQUIPPED)
The diesel engine parts are covered for5 years or 100,000 kilometres,
whichever occurs first.
²Diesel Engine-
Cylinder block and all internal parts; cylinder head
assemblies; core plugs; fuel injection pump and injectors; intake and exhaust
manifolds; oil pan; oil pump; timing gear drive belts and/or chains and cover;
turbocharger housing and internal parts; valve covers; water pump and
housing; seals and gaskets for listed components.
8/130 HYBRID SYSTEM WARRANTY(IF EQUIPPED)
These hybrid system parts are covered for8 years or 160,000 kilometres,
whichever occurs first.
²Transmission and all internal components
²TPIM Fan
²TPIM Pump
²TPIM Assembly
²APM Assembly
²HV AC Cables
²HV DC cables
²Hybrid Battery
CORROSION WARRANTY
For 3 years, regardless of distance driven,your Corrosion Warranty
covers any body sheet metal panel which develops a hole caused by
corrosion.
In addition, outer body panels are covered against holes caused by
corrosion up to5 years or 160,000 kilometres,whichever occurs first. An
outer body panel is a sheet metal panel which can be seen while walking
around the vehicle, and which is painted body colour.
This warranty applies only to holes caused by corrosion. Cosmetic or
surface corrosion (resulting from stone chips or scratches in the paint, for
example) will not be repaired under this warranty.
If corrosion damage is obviously neglected and allowed to worsen until a
hole develops, this warranty will not cover the repair.
9
5/100 DIESEL ENGINE / 8/130 HYBRID SYSTEM / CORROSION WARRANTIES
Page 16 of 68
JOBNAME: 146224AspenHEV 2009 PAGE: 14 SESS: 30 OUTPUT: Thu Jul 10 15:40:34 2008
/chrysler/chry-intl/warr-maint/146224-hghev-english/warranty
OTHER THINGS YOU SHOULD KNOW
OPTIONAL SERVICE CONTRACT
Chrysler Canada has a service contract specially designed for most new
vehicles, to cover repair costs beyond your vehicle's warranty. Protection
is available for almost every operating part of your vehicle, and at
reasonable cost.
Chrysler Canada stands fully behind its service contracts. Be sure that the
contract you buy is a genuineChryslerService Contract. We arenot
responsible for other companies' contracts. See page 24 for details on
available service contracts.
APPEARANCE ITEMS
Defects or damage to sheet metal, paint, trim and other appearance items
are normally found and corrected during new vehicle inspection. For your
protection, if you find any such defect or damage, you should tell your
selling retailer immediately, because if the problem worsens due to use and
exposure, repairs will not be covered by any warranty.
PRODUCTION CHANGES
Chrysler Canada and its retailers reserve the right to make changes in
vehicles built and/or sold at any time without incurring any obligations to
make the same or similar changes on vehicles which were built and/or sold
previously.
EXCHANGE PARTS
To reduce the amount of time your vehicle is out of service due to repairs,
Chrysler may offer exchange service on some parts. Mopar
tor AutoparŸ
brand exchange parts may be new, remanufactured, reconditioned or
repaired, but all meet Chrysler standards and are warranted the same as
new parts. Examples of parts that may be serviced by exchange include
engines, transmissions, instrument clusters, radios, tape and CD players,
speedometers and various electronic modules.
16
OTHER THINGS YOU SHOULD KNOW
Page 25 of 68
JOBNAME: 146224AspenHEV 2009 PAGE: 23 SESS: 30 OUTPUT: Thu Jul 10 15:40:34 2008
/chrysler/chry-intl/warr-maint/146224-hghev-english/warranty
1. POWERTRAIN PLANS*
Powertrain plans complement the factory powertrain warranty by provid-
ing enhanced roadside coverage and car rental allowance if your vehicle is
not drivable and must be kept overnight. Certain plans also provide
additional distance coverage.
Major components covered are:
²engine²transmission²front-wheel drive²rear-wheel drive
²4-wheel drive (4x4)²all-wheel drive vehicles
2.(GOLD(PLANS*
Each plan provides full mechanical repair protection to non-powertrain
(Gold) components. Certain plans also provide full mechanical protection
against powertrain component repairs beyond your vehicle's powertrain
warranty coverage. Contracts are available with or without a deductible.
Major components covered are:
²steering²air conditioning²engine cooling and fuel²front suspension
²rear suspension²electrical²hydraulic brake components²anti-lock
brakes
* Maximum terms available on new vehicles registered in Canada only.
3.(GOLDPLUS(PLANS*
The most complete protection available for your new vehicle is a9Gold
Plus9Service Contract which combines the benefits of Gold component
coverage (see9Gold9Plans), plus, the most important vehicle maintenance
functions:
²Engine oil and oil filter changes
²Tire rotation every other service
²9Peace-of-Mind9motoring with Tire Road Hazard Protection
which provides full, or pro-rata, replacement of the original four
tires, or their repair
²Rental car allowance for same-day warranty repairs - your vehicle
need not be kept overnight before eligibility for the rental allow-
ance is met
25
OPTIONAL CHRYSLER CANADA SERVICE CONTRACTS
Page 47 of 68
JOBNAME: 146224AspenHEV 2009 PAGE: 19 SESS: 13 OUTPUT: Thu Jul 10 15:40:34 2008
/chrysler/chry-intl/warr-maint/146224-hghev-english/intervals
Perform Maintenance At
100,000 km or 60 Months
oChange the engine oil and oil filter.Under no circumstances should the oil change
interval exceed 10 000 km or 6 months whichever occurs first.*
oRotate tires.
oReplace the engine air filter.
oInspect the transfer case fluid; change if using your vehicle for any of the following:
police, taxi, fleet or frequent trailer towing.
oInspect the brake linings; replace if necessary.
oFlush and replace the engine coolant at 60 months if not done at 170 000 km.
oChange the automatic transmission fluid and filter if using your vehicle for any of
the following: police, taxi, fleet or frequent trailer towing.
* Oil changes that are prompted by the oil change indicator system prior to this
schedule maintenance interval can be recorded in the oil change log section.
Perform Maintenance
At
60 Months or
100,000 km
Odometer Reading
DateRetailer Copy
Remove and attach to Repair Order
................................................................................................
Page 48 of 68
JOBNAME: 146224AspenHEV 2009 PAGE: 20 SESS: 13 OUTPUT: Thu Jul 10 15:40:34 2008
/chrysler/chry-intl/warr-maint/146224-hghev-english/intervals
oChange the engine oil and oil filter.Under no circum-
stances should the oil change interval exceed 10 000 km
or 6 months whichever occurs first.*
oRotate tires.
oReplace the engine air filter.
oInspect the transfer case fluid; change if using your vehicle
for any of the following: police, taxi, fleet or frequent
trailer towing.
oInspect the brake linings; replace if necessary.
oFlush and replace the engine coolant at 60 months if not
done at 170 000 km.
oChange the automatic transmission fluid and filter if using
your vehicle for any of the following: police, taxi, fleet or
frequent trailer towing.
* Oil changes that are prompted by the oil change indicator
system prior to this schedule maintenance interval can be
recorded in the oil change log section.
Perform Maintenance At
100,000 km or 60 Months
Odometer Reading
Date
Repair Order No.
CHRYSLER
RETAILERSTAMP
Signature of authorized Chrysler Canada Retailer
................................................................................................
Page 67 of 68
JOBNAME: 146224AspenHEV 2009 PAGE: 39 SESS: 13 OUTPUT: Thu Jul 10 15:40:34 2008
/chrysler/chry-intl/warr-maint/146224-hghev-english/intervals
Perform Maintenance At
200,000 km or 120 Months
oChange the engine oil and oil filter.Under no circumstances should the oil change
interval exceed 10 000 km or 6 months whichever occurs first.*
oRotate tires.
oReplace the engine air filter.
oInspect the front suspension components, tie rod ends and boot seals; replace if
necessary.
oInspect the transfer case fluid; change if using your vehicle for any of the following:
police, taxi, fleet or frequent trailer towing.
oInspect the brake linings; replace if necessary.
oInspect the CV joints.
oInspect the exhaust system.
oChange the automatic transmission fluid and filter.
oReplace the accessory drive belt(s).
* Oil changes that are prompted by the oil change indicator system prior to this
schedule maintenance interval can be recorded in the oil change log section.
Perform Maintenance
At
120 Months or
200,000 km
Odometer Reading
DateRetailer Copy
Remove and attach to Repair Order
................................................................................................
Page 68 of 68
JOBNAME: 146224AspenHEV 2009 PAGE: 40 SESS: 13 OUTPUT: Thu Jul 10 15:40:34 2008
/chrysler/chry-intl/warr-maint/146224-hghev-english/intervals
oChange the engine oil and oil filter.Under no circum-
stances should the oil change interval exceed 10 000 km
or 6 months whichever occurs first.*
oRotate tires.
oReplace the engine air filter.
oInspect the front suspension components, tie rod ends and
boot seals; replace if necessary.
oInspect the transfer case fluid; change if using your vehicle
for any of the following: police, taxi, fleet or frequent
trailer towing.
oInspect the brake linings; replace if necessary.
oInspect the CV joints.
oInspect the exhaust system.
oChange the automatic transmission fluid and filter.
oReplace the accessory drive belt(s).
* Oil changes that are prompted by the oil change indicator
system prior to this schedule maintenance interval can be
recorded in the oil change log section.
Perform Maintenance At
200,000 km or 120 Months
Odometer Reading
Date
Repair Order No.
CHRYSLER
RETAILERSTAMP
Signature of authorized Chrysler Canada Retailer
................................................................................................