engine coolant CHRYSLER VOYAGER 1996 Workshop Manual

SEAT BELT CHIME
The seat belt chime will sound for 4 to 8 seconds,
when the ignition is turned on and the driver's seat
belt is not buckled (seat belt switch is closed to
ground). This is a reminder to the driver to buckle
the seat belt. The seat belt lamp is controlled by the
mechanical instrument cluster. The cluster will also
illuminate the seat belt warning lamp for 6 seconds.
Buckling the driver's seat belt before the time out
has expired will cause the chime to stop immediately.
Chime rate: 38 to 62 chimes per minute.
To test the seat belt warning system, the ignition
switch must be in the OFF position for 1 minute
before starting the test. Turn the ignition switch to
the on position with the driver's seat belt not buck-
led. The seat belt warning lamp should light and the
chime should sound 4 to 8 seconds.
SEAT BELT LAMP
The seat belt lamp in the instrument cluster sig-
nals the vehicle passengers to fasten their seat belts.
The seat belt lamp is illuminated directly by the
instrument cluster for 6 seconds after the instrument
cluster receives the message from the Body Control
Module. The seat belt lamp is therefore illuminated
for 6 seconds whenever the ignition switch is moved
to run/start position.
(1) While ignition is off, the seat belt lamp will not
be illuminated.
(2) The ignition power feed status will be updated
every 250 milliseconds or on change.
(3) This lamp will be checked by the instrument
cluster for 6 seconds with every run/start cycle of the
ignition switch.
TURN SIGNAL ON CHIME
The turn signal on chime will warn the driver that
the turn signals have been left on. When the Body
Control Module receives a turn signal input for 1.6
km (1.0 miles), vehicle speed is greater than 24 km/h
(15 mph), the chime will sound continuously until the
turn signal is turned OFF. If vehicle speed drops
below 24 km/h (15 mph) prior to the warning being
activated, the accumulated distance traveled will be
reset. The turn signal chime is not activated whenthe emergency flashers are turned on. This feature
can also be disabled in EEPROM. Chime rate: 38 to
62 chimes per minute.
For the turn signal warning system to operate:
²Must have input from either the right or left
turn signal lamps. Creates a voltage change between
0 and battery voltage.
²The vehicle speed sensor sends a message to the
Powertrain Control Module that vehicle has exceeded
24 km/h (15 mph) for 1.6 km (1.0 miles).
²When the above two conditions are met, the
chime will sound. The chime will stop when no fur-
ther voltage change is detected.
²If hazard warning signals are pulsing, no chime
will sound.
²If speed drops below 24 km/h (15 mph) before
the warning is issued, the warning will not be issued
and the distance counter will be reset.
²If turn signal lamps are not working properly,
the chime will not sound.
²When using the scan tool, refer to the proper
Body Diagnostic Manual for the procedure.
WARNING LAMP ANNOUNCEMENT CHIME
The warning lamp announcement chime will warn
the driver to scan the instrument cluster to observe
which warning lamp is illuminated. Whenever the
volts, low fuel, low washer fluid, coolant level (gas/
diesel), low coolant level, engine temperature high
(diesel only), door ajar or gate ajar lamps are first
illuminated, the chime will sound one tone. The door/
liftgate ajar warning lamp announcement chime
sounds only if the vehicle speed is above 2 m.p.h.
Two seconds after ignition switch is turned ON or
until the seat belt warning chime ends, all warning
announcement chimes will be consolidated into one
warning announcement. This will occur 2 seconds
after the seat belt warning chime ends. If a warning
announcement should occur while another warning
chime in progress (turn signal, low oil pressure or
high speed warnings), no additional chimes will
sound after the chime in progress ends. All associ-
ated lamps will be illuminated, and the active chime
will be the warning announcement.
NS/GSCHIME WARNING/REMINDER SYSTEM 8U - 3
DIAGNOSIS AND TESTING (Continued)

8W-02 COMPONENT INDEX
Component Page
2-4 Pressure Switch.....................8W-31
2-4 Solenoid...........................8W-31
A/C Compressor Clutch..................8W-42
A/C Compressor Clutch Relay...........8W-10, 42
A/C Heater Control.....................8W-42
A/C On Indicator.......................8W-42
A/C Pressure Transducer..............8W-30, 42
A/C Switch............................8W-42
A/C Zone Door Actuator..................8W-42
ABS Warning Lamp..................8W-35, 46
Accelerator Pedal Position Sensor..........8W-30
Airbag Control Module...................8W-43
Airbag Indicator Lamp...................8W-43
Airbag Warning Lamp...................8W-46
All Wheel Drive Solenoid.................8W-31
Ambient Air Temperature Sensor...........8W-49
Ash Receiver Lamp.....................8W-44
Automatic Day/Night Mirror..............8W-44
Automatic Shut Down Relay............8W-10, 30
Splice Information......................8W-70
Back-Up Lamp.........................8W-51
Back-Up Switch.....................8W-44, 51
Battery...............................8W-20
Blend Door Actuator.....................8W-42
Body Control Module....................8W-45
Brake Pressure Switch...................8W-46
Brake Warning Lamp....................8W-46
Camshaft Position Sensor................8W-30
Center Dome Lamp.....................8W-44
Center High Mounted Stop Lamp..........8W-51
Cigar/Accessory Relay...................8W-41
Clockspring.......8W-10, 15, 30, 33, 39, 40, 41, 43
Cluster Illumination Lamps...............8W-40
Clutch Interlock Switch...............8W-12, 21
Clutch Interlock Switch Jumper......8W-12, 21, 31
Clutch Switch.......................8W-30, 33
Combination Flasher/DRL Module. . . .8W-50, 51, 52
Combination Relays.....................8W-54
Compass/Mini-Trip Computer..............8W-49
Control Sleeve Sensor....................8W-30
Controller Anti-Lock Brake...............8W-35
Courtesy Lamp Relay...........8W-10, 12, 44, 50
Crank Case Heater......................8W-30
Crankshaft Position Sensor...............8W-30
Cruise Indicator Lamp...................8W-40
Data Link Connector....................8W-30
Diesel Power Relay...................8W-10, 30
Dome Lamp Switch.....................8W-50
Door Ajar Indicator Lamp................8W-40
Door Ajar Switches................8W-39, 40, 44
Door Lock Relay........................8W-61
Speakers..............................8W-47Component Page
Door Unlock Relay......................8W-61
Oxygen Sensors........................8W-30
Door Ajar Switches.............8W-39, 40, 44, 45
Door Arm/Disarm Switches.............8W-39, 61
Door Courtesy Lamps....................8W-44
Door Lock Motors.......................8W-61
Door Lock Switches.....................8W-61
Door Unlock Relays.....................8W-61
Heated Seat Backs......................8W-63
Heated Seat Cushions...................8W-63
Heated Seat Modules....................8W-63
Heated Seat Switches....................8W-63
Power Mirrors.........................8W-62
Power Seat Switches....................8W-63
Power Window Switches..................8W-60
Seat Motors...........................8W-63
Window Motors........................8W-60
Radiator Fans.........................8W-42
Dump Solenoid.........................8W-33
EGR Solenoid..........................8W-30
Electric Wiper De-Icer...................8W-48
Electronic PRNDL Indicator...............8W-40
Engine Coolant Temperature Gauge.........8W-40
Engine Coolant Temperature Lamp.........8W-46
Engine Coolant Temperature Sensor........8W-30
Engine Oil Pressure Switch...............8W-46
Engine Speed Sensor....................8W-30
Engine Starter Motor....................8W-21
Engine Starter Motor Relay............8W-10, 21
Evap Leak Detection Pump...............8W-30
Evap/Purge Solenoid....................8W-30
Evaporator Temperature Sensor............8W-42
Express Down Module...................8W-60
Flexible Fuel Sensor.....................8W-30
Fog Lamps............................8W-50
Fog Lamp Relay........................8W-50
Front Blower Motor.....................8W-42
Front Blower Motor Relay.............8W-10, 42
Front Blower Motor Resistor Block.........8W-42
Front Cigar Lighter/Power Outlet..........8W-41
Front Reading Lamp Defeat Switch.........8W-44
Front Reading Lamps/Switch..............8W-44
Front Washer Motor.....................8W-53
Front Wiper Switch.....................8W-53
Fuel Gauge............................8W-40
Fuel Heater...........................8W-30
Fuel Heater Relay...................8W-10, 30
Fuel Injectors..........................8W-30
Fuel Pump Module......................8W-30
Fuel Pump Relay....................8W-10, 30
Fuel Quantity Actuator..................8W-30
Fuel Shutdown Solenoid..................8W-30
NS/GS8W - 02 COMPONENT INDEX 8W - 02 - 1

8W-15 GROUND DISTRIBUTION
Component PageA/C Compressor Clutch....................8W-15-2, 3
A/C Heater Control........................8W-15-4
Airbag Control Module......................8W-15-4
All Wheel Drive Solenoid....................8W-15-13
Ash Receiver Lamp........................8W-15-6
Automatic Day/Night Mirror...................8W-15-5
AW4B13..............................8W-15-13
AWS1................................8W-15-13
Battery..............................8W-15-2, 3
Body Control Module.......................8W-15-6
Brake Pressure Switch......................8W-15-8
BS08.................................8W-15-5
BS31.................................8W-15-3
BS40.................................8W-15-3
BS41.................................8W-15-3
Center High Mounted Stop Lamp...............8W-15-14
Cigar/Accessory Relay.......................8W-15-7
Clockspring.............................8W-15-4
Clutch Switch............................8W-15-8
Combination Flasher/DRL Module...............8W-15-6
Controller Anti-Lock Brake....................8W-15-4
Crank Case Heater........................8W-15-3
CS06..............................8W-15-11, 12
Data Link Connector....................8W-15-2, 4, 12
Door Lock Relay..........................8W-15-6
Door Unlock Relay.........................8W-15-6
Downstream Heated Oxygen Sensor..............8W-15-5
Driver Door Arm/Disarm Switch.............8W-15-11, 12
Driver Door Courtesy Lamp...................8W-15-7
Driver Door Lock Switch..................8W-15-11, 12
Driver Door Unlock Relay....................8W-15-6
Driver Heated Seat Back.....................8W-15-9
Driver Heated Seat Cushion...................8W-15-9
Driver Heated Seat Module...................8W-15-9
Driver Heated Seat Switch....................8W-15-9
Driver Power Mirror........................8W-15-4
Driver Power Seat Switch....................8W-15-5
Driver Power Window Switch..................8W-15-7
DS01.................................8W-15-7
EC1C19...............................8W-15-5
Engine Speed Sensor.......................8W-15-3
ES01.................................8W-15-3
ES02.................................8W-15-3
ES11 .................................8W-15-2
ES12.................................8W-15-3
ES18.................................8W-15-2
ES23.................................8W-15-2
ES30.................................8W-15-3
ES31.................................8W-15-3
Front Blower Motor Relay....................8W-15-7
Front Cigar Lighter/Power Outlet...............8W-15-4
Fuel Heater.............................8W-15-3
Fuel Heater Relay.........................8W-15-3
Fuel Tank Module........................8W-15-13
G100................................8W-15-2, 3
G101.................................8W-15-2
G102................................8W-15-2, 3
G103................................8W-15-2, 3
G104.................................8W-15-4
G200.................................8W-15-4
G201.................................8W-15-4
G202.................................8W-15-5
G204.................................8W-15-4
G300...........................8W-15-5, 6, 7, 8, 9
G301............................8W-15-10, 11, 12
G302.................................8W-15-13
G400.................................8W-15-14
Headlamp Dimmer Switch....................8W-15-4
Headlamp Switch........................8W-15-4, 6
Headlamp Washer........................8W-15-10
High Note Horn.......................8W-15-11, 12
Hood Ajar Switch.........................8W-15-10
HS1..................................8W-15-9
HS3..................................8W-15-9
HS5D B09..............................8W-15-9
HS5P B56..............................8W-15-9
Ignition Switch.........................8W-15-4, 6
Instrument Cluster.......................8W-15-4, 6
Junction Block...........................8W-15-6
Key-In Halo Lamp.........................8W-15-6
Left Combination Relay.....................8W-15-13Component PageLeft Door Speaker.........................8W-15-5
Left Front Park/Turn Signal Lamp...............8W-15-7
Left Headlamp...........................8W-15-8
Left Headlamp Leveling Motor.................8W-15-8
Left High Headlamp........................8W-15-8
Left Liftgate Flood Lamp....................8W-15-14
Left Low Headlamp........................8W-15-8
Left Rear Door Ajar Switch...................8W-15-13
Left Rear Lamp Assembly....................8W-15-13
Left Rear Speaker.........................8W-15-5
Left Repeater Lamp........................8W-15-5
Left Speed Control Switch....................8W-15-4
Left Stop/Turn Signal Relay..................8W-15-13
License Lamp...........................8W-15-14
Liftgate Ajar Switch.......................8W-15-14
Liftgate Arm/Disarm Switch..................8W-15-14
Low Coolant Level Switch....................8W-15-3
Low Note Horn..........................8W-15-10
Low Washer Fluid Switch.................8W-15-11, 12
Memory Power Seat Switch..................8W-15-5, 9
Memory Seat/Mirror Module.................8W-15-5, 9
Memory Set Switch........................8W-15-7
Message Center...........................8W-15-6
Name Brand Speaker Relay...................8W-15-6
Needle Movement Sensor.....................8W-15-3
Overhead Console......................8W-15-11, 12
Passenger Door Arm/Disarm Switch.............8W-15-10
Passenger Door Courtesy Lamp.................8W-15-7
Passenger Door Lock Switch..................8W-15-10
Passenger Heated Seat Back...................8W-15-9
Passenger Heated Seat Cushion.................8W-15-9
Passenger Heated Seat Module.................8W-15-9
Passenger Heated Seat Switch.................8W-15-9
Passenger Power Mirror.....................8W-15-4
Passenger Power Seat Switch................8W-15-5, 12
Passenger Power Window Switch................8W-15-7
Power Distribution Center.................8W-15-2, 3, 7
Power Folding Mirror Switch..................8W-15-6
Power Mirror Switch.......................8W-15-6
Powertrain Control Module..................8W-15-2, 3
Radiator Fan Disconnect.....................8W-15-3
Radiator Fan No. 1........................8W-15-2
Radiator Fan No. 2........................8W-15-2
Radiator Fan Relay........................8W-15-2
Radiator Fan Relay No. 1.....................8W-15-3
Radio.................................8W-15-5
Rear Blower Front Control Switch...............8W-15-4
Rear Blower Rear Control Switch...............8W-15-13
Rear Cigar Lighter/Power Outlet...............8W-15-13
Rear Window Defogger.....................8W-15-14
Rear Wiper Motor.........................8W-15-14
Remote Keyless Entry Module..................8W-15-4
RF3E40...............................8W-15-2
RFS2.................................8W-15-2
Right Combination Relay....................8W-15-13
Right Door Speaker........................8W-15-5
Right Front Park/Turn Signal Lamp.............8W-15-10
Right Headlamp..........................8W-15-10
Right Headlamp Leveling Motor................8W-15-10
Right High Headlamp......................8W-15-10
Right Liftgate Flood Lamp...................8W-15-14
Right Low Headlamp......................8W-15-10
Right Rear Door Ajar Switch..................8W-15-13
Right Rear Lamp Assembly...................8W-15-13
Right Rear Speaker........................8W-15-5
Right Repeater Lamp......................8W-15-10
Right Speed Control Switch...................8W-15-4
Right Stop/Turn Signal Relay.................8W-15-13
Seat Belt Switch..........................8W-15-8
Sentry Key Immobilizer Module.................8W-15-4
Stop Lamp Switch.......................8W-15-6, 7
Traction Control Switch......................8W-15-6
Trailer Tow Connector......................8W-15-13
Transmission Control Module..................8W-15-2
Transmission Control Relay...................8W-15-2
Universal Garage Door Opener..............8W-15-11, 12
Upstream Heated Oxygen Sensor................8W-15-2
Vehicle Speed Control Servo...................8W-15-2
Wiper Module............................8W-15-5
Wiper On Relay...........................8W-15-7
NS/GS8W - 15 GROUND DISTRIBUTION 8W - 15 - 1

BATTERY
Z0
2
BK
G103 G100
Z0
6
BK
Z0
10
BK
ES01
Z12
16
BK/TN
24 1
POWERTRAIN
CONTROL
MODULE
BK/TN16 Z12
Z12
14
BK/TN
Z1
16
BK
3B107
E95
Z12
16
BK/TN 46
BS31
BK16Z1
ES02
2
FUEL
HEATER
Z1
18
BK
2
BK18Z1
SWITCH
2
LOW
COOLANT
LEVEL
Z1
20
BK
CENTER DISTRIBUTION
POWER
3C6
Z1
20
BK
RELAY HEATER
FUEL
85
SENSOR
MOVEMENT
NEEDLE
BK18 Z122
ES31
2E97
B106
Z122
18
BK
Z1
18
BK
BS41
Z1
18
BK
ENGINE
SPEED
SENSOR
Z122
18
BK
ES30
BK18Z1
BK18 Z122
7
Z12
18
BK
BS40
BK18Z1
Z12
14
BK/TN
A
(8W-15-5)
TO
G300
B
(8W-15-12)TO
G301
RELAY RADIATOR
2
NO. 1
FAN FAN
1
RADIATOR
DISCONNECT
Z1
12
BK
BK12Z1
ES12
Z1
12
BK
G102
SHIELDSHIELD
Z1
18
BK
2
A/C
COMPRESSOR
CLUTCH
CRANK
CASE
HEATER
86
(8W-20-3)(8W-30-28)
(8W-30-29)
(8W-45-9) (8W-10-9)
(8W-30-29)(8W-30-35) (8W-30-35)
(8W-42-10) (8W-42-10)
(8W-42-9)
(8W-30-29)
NS/GS8W-15 GROUND DISTRIBUTION
DIESEL8W - 15 - 3
GS001503J988W-3

8W-30 FUEL/IGNITION SYSTEM
Component Page
A/C Compressor Clutch Relay................8W-30-5, 37
A/C Heater Control....................8W-30-5, 32, 37
A/C Pressure Transducer.............8W-30-10, 16, 24, 38
Accelerator Pedal Position Sensor...............8W-30-38
Airbag Control Module....................8W-30-4, 31
All Wheel Drive Solenoid....................8W-30-20
Automatic Shut Down Relay . . .8W-30-2, 7, 8, 9, 14, 15, 21, 22, 23
AW4B13...............................8W-30-6
AW4B13..............................8W-30-20
AWS1................................8W-30-20
AWS2................................8W-30-20
Back-Up Switch........................8W-30-6, 20
Battery..........................8W-30-2, 3, 29, 32
Body Control Module.............8W-30-4, 6, 20, 31, 36, 39
BS01................................8W-30-39
BS02...............................8W-30-6, 20
BS05...............................8W-30-4, 31
BS06...............................8W-30-4, 31
BS30................................8W-30-36
BS31..............................8W-30-28, 35
BS32................................8W-30-33
BS33................................8W-30-28
BS34..........................8W-30-33, 34, 36, 38
BS40................................8W-30-35
BS41................................8W-30-35
Camshaft Position Sensor..............8W-30-8, 14, 22, 24
Clockspring...........................8W-30-5, 39
Clutch Switch...........................8W-30-39
Compass/Mini-Trip Computer.................8W-30-31
Control Sleeve Sensor......................8W-30-34
Controller Anti-Lock Brake.................8W-30-4, 31
Crank Case Heater........................8W-30-29
Crankshaft Position Sensor...............8W-30-8, 14, 22
Data Link Connector.................8W-30-3, 4, 30, 31
Diesel Power Relay.................8W-30-28, 29, 32, 33
Downstream Heated Oxygen Sensor............8W-30-7, 21
EGR Solenoid.......................8W-30-18, 20, 29
Engine Coolant Temperature Sensor......8W-30-10, 16, 24, 36
Engine Speed Sensor.......................8W-30-35
Engine Starter Motor Relay...............8W-30-6, 20, 28
ES01................................8W-30-29
ES02.............8W-30-8, 10, 11, 14, 16, 17, 22, 24, 25, 29
ES03.....................8W-30-10, 11, 16, 17, 24, 25
ES05...................8W-30-14, 19, 22, 25, 33, 34, 36
ES06..........................8W-30-28, 29, 32, 33
ES07..........................8W-30-2, 18, 20, 26
ES08............................8W-30-17, 19, 25
ES09................................8W-30-37
ES11................................8W-30-2, 3
ES12.................8W-30-2, 7, 8, 9, 14, 15, 21, 22, 23
ES13.................................8W-30-4
ES14.................................8W-30-4
ES17........................8W-30-8, 11, 14, 17, 22
ES18...............................8W-30-7, 21
ES21..................8W-30-7, 8, 10, 11, 14, 16, 17, 24
ES24.................................8W-30-3
ES26................................8W-30-32
ES28................................8W-30-32
ES29................................8W-30-32
ES30................................8W-30-35
ES31................................8W-30-35
ES37................................8W-30-32
ES40................................8W-30-29
ES99.................................8W-30-9
Evap Leak Detection Pump................8W-30-18, 26
Evap/Purge Solenoid..................8W-30-12, 18, 26
Flexible Fuel Sensor.......................8W-30-22
FS01..............................8W-30-16, 23
FS02............................8W-30-16, 22, 24
FS03.................................8W-30-15
Fuel Heater............................8W-30-29
Fuel Heater Relay........................8W-30-29
Fuel Injector No. 1....................8W-30-9, 15, 23
Fuel Injector No. 2....................8W-30-9, 15, 23
Fuel Injector No. 3....................8W-30-9, 15, 23
Fuel Injector No. 4....................8W-30-9, 15, 23
Fuel Injector No. 5........................8W-30-23Component Page
Fuel Injector No. 6........................8W-30-23
Fuel Pump Module......................8W-30-33, 34
Fuel Pump Relay.......................8W-30-6, 20
Fuel Quantity Actuator.....................8W-30-33
Fuel Shutdown Solenoid.....................8W-30-33
Fuel Tank Module.......................8W-30-6, 20
Fuel Temperature Sensor....................8W-30-33
Fuel Timing Solenoid......................8W-30-33
Fuse 6 (JB).............................8W-30-32
Fuse 13 (PDC)...........................8W-30-39
Fuse 16 (PDC).....................8W-30-2, 6, 20, 29
Fuse 17 (PDC) . .8W-30-2, 7, 8, 9, 14, 15, 21, 22, 23, 28, 29, 32, 33
Fuse 28 (PDC).........................8W-30-3, 30
Fusible Link A0..........................8W-30-32
G100.............................8W-30-2, 3, 29
G101...............................8W-30-7, 21
G103.............................8W-30-2, 3, 29
G200.............................8W-30-3, 5, 30
G300.................8W-30-7, 13, 19, 21, 27, 28, 35, 39
G301..............................8W-30-30, 35
G302...............................8W-30-6, 20
Generator.......................8W-30-2, 13, 19, 27
Glow Plug Lamp.........................8W-30-32
Glow Plug No. 1..........................8W-30-32
Glow Plug No. 2..........................8W-30-32
Glow Plug No. 3..........................8W-30-32
Glow Plug No. 4..........................8W-30-32
Glow Plug Relay.........................8W-30-32
Idle Air Control Motor.................8W-30-12, 18, 26
Ignition Coil Pack.....................8W-30-8, 14, 22
Instrument Cluster......................8W-30-4, 31
Intake Air Temperature Sensor................8W-30-17
Intake Air Temperature/Manifold Absolute
Pressure Sensor.......................8W-30-10
Junction Block............8W-30-2, 3, 6, 13, 18, 19, 20, 26,
27, 28, 29, 30, 32, 36
Knock Sensor.......................8W-30-10, 16, 24
Left Front Park/Turn Signal Lamp..............8W-30-39
Left Headlamp Leveling Motor.................8W-30-39
Left Speed Control Switch..................8W-30-5, 39
Manifold Absolute Pressure Sensor............8W-30-16, 24
Memory Seat/Mirror Module................8W-30-3, 30
Message Center...................8W-30-13, 19, 27, 32
Needle Movement Sensor....................8W-30-35
Overhead Console.......................8W-30-4, 31
Power Distribution Center .8W-30-2, 3, 5, 6, 7, 8, 9, 14, 15, 18, 20,
21, 22, 23, 26, 28, 29, 30, 32, 33, 36, 37, 39
Powertrain Control Module...................8W-30-10
Powertrain Control Module...................8W-30-11
Powertrain Control Module...................8W-30-12
Powertrain Control Module...................8W-30-13
Powertrain Control Module...................8W-30-8
Powertrain Control Module...................8W-30-9
Powertrain Control Module .8W-30-2, 3, 4, 5, 6, 7, 8, 9, 14, 15, 16,
17, 18, 19, 20, 21, 22, 23, 24, 25, 26,
27, 28, 29, 30, 32, 33, 34, 35, 36, 37, 38, 39
PS01...............................8W-30-4, 31
PS02...............................8W-30-4, 31
PTC 1 (JB)..............8W-30-2, 6, 18, 20, 26, 28, 29, 36
Radiator Fan Relay........................8W-30-5
Radiator Fan Relay No. 1....................8W-30-37
Radiator Fan Relay No. 2....................8W-30-37
Radiator Fan Relay No. 3....................8W-30-37
Radio.............................8W-30-3, 4, 30
Right Speed Control Switch.................8W-30-5, 39
Sentry Key Immobilizer Module.................8W-30-4
Service Engine Soon Lamp..............8W-30-13, 19, 27
Stop Lamp Switch.................8W-30-13, 19, 27, 39
Throttle Position Sensor................8W-30-11, 17, 25
Transmission Control Module.......8W-30-3, 4, 17, 19, 25, 27
Transmission Range Sensor..........8W-30-6, 19, 20, 27, 34
Turbo Boost Pressure Sensor..................8W-30-34
Upstream Heated Oxygen Sensor.............8W-30-7, 21
Vacuum Solenoid.........................8W-30-27
Vehicle Speed Control Servo..............8W-30-13, 19, 27
Vehicle Speed Sensor..................8W-30-11, 17, 36
Vent Solenoid...........................8W-30-27
NS/GS8W - 30 FUEL/IGNITION SYSTEM 8W - 30 - 1

POWERTRAIN
CONTROL
MODULE
K4
18
BK/LB
C243
SENSOR
GROUND
ES21
2
1
KNOCK
SENSOR
SIGNAL
C125
DB/LG18 K42
KNOCK
SENSOR
K6
18
VT/WT
61C2
SUPPLY5V
D C
A
C136DG/RD18K1
BK/LB18 K4
A/C
PRESSURE
TRANSDUCER
K4
18
BK/LB
12
3 SENSOR
GROUNDA/C
PRESSURE
SIGNAL SUPPLY5V
C18
18
DB
C242
SIGNAL PRESSUREA/C
ES02
18 K4
BK/LBBK/LBK4
18
K2
18
TN/BK
26C1
21
SENSOR TEMPERATURE
COOLANT
ENGINE
ES03
BK/LBK4
18 K6
18
VT/WTK6
18
VT/WT
SIGNAL SENSOR PRESSUREABSOLUTEMANIFOLD
SIGNAL SENSOR TEMPERATURECOOLANTENGINE
INTAKE
AIR
TEMPERATURE
SENSOR
SIGNAL
K21
18
BK/RD
37
C1
BGROUNDSENSOR 5V
SUPPLY
TEMPERATURE
SENSOR
SIGNAL SIGNALSENSORMAPPRESSURE
SENSOR INTAKE
AIR
TEMPERATURE/
MANIFOLD
ABSOLUTE
AIR INTAKE
(8W-70-4)(8W-70-4)(8W-70-7)
8W - 30 - 10 8W-30 FUEL/IGNITION SYSTEM
2.0LNS/GS
J988W-3GS003010

POWERTRAIN
CONTROL
MODULE
K4
18
BK/LB
C243
SENSOR
GROUND
ES02
ES21
BK/LBK4
18
2
1
KNOCK
SENSOR
SIGNAL
C125
DB/LG18 K42
KNOCK
SENSOR
K6
18
VT/WT
61C2
SUPPLY5V
ES03
8
CB
A
11
F09
E69
C1
36DG/RD18K1
K1
18
DG/RD BK/LB18 K4
SENSOR PRESSURE
ABSOLUTE
MANIFOLD
A/C
PRESSURE
TRANSDUCER
K4
18
BK/LB DB18 C18
12
3 SENSOR
GROUNDA/C
PRESSURE
SWITCH
SIGNAL SUPPLY5V
E69
F09
9
C18
18
DB
C242
SIGNAL SWITCH PRESSUREA/C
FS01
18 K4
BK/LB
BK/LBK4
18
K2
18
TN/BK
26C1
21
SENSOR TEMPERATURE
COOLANT
ENGINE
12
TN/BK18 K2
FS02
VT/WT18 K6
BK/LBK4
18
5
K6
18
VT/WTK6
18
VT/WT
K6
18
VT/WT
SIGNAL SENSOR PRESSUREABSOLUTEMANIFOLD
SIGNAL SENSOR TEMPERATURECOOLANTENGINE (8W-70-5)
(8W-70-5) (8W-70-7)(8W-70-5)(8W-70-7)
8W - 30 - 16 8W-30 FUEL/IGNITION SYSTEM
2.4LNS/GS
J988W-3GS003016

POWERTRAIN
CONTROL
MODULE
K4
18
BK/LB
C243
SENSOR
GROUND
ES02
BK/LBK4
18
2
1
KNOCK
SENSOR
SIGNAL
C125
DB/LG18 K42
K6
18
VT/WT
61C2
SUPPLY5VCB
A
10
F02
E78
C1
36DG/RD18K1
K1
18
DG/RD BK/LB18 K4
SENSOR PRESSURE
ABSOLUTE
MANIFOLD
A/C
PRESSURE
TRANSDUCER
K4
18
BK/LB
12
3 SENSOR
GROUNDA/C
PRESSURE
SIGNAL SUPPLY5V
C18
18
DB
C242
PRESSUREA/C
18 K4
BK/LB
BK/LBK4
18
K2
18
TN/BK
26C1
21
SENSOR TEMPERATURE
COOLANT
ENGINEES03
14
K6
18
VT/WTK6
18
VT/WT
FS02
E78
F0211
TN/BK18 K2
SENSOR TEMPERATURECOOLANTENGINE
SIGNAL SENSOR PRESSUREABSOLUTEMANIFOLD
E78 F02
2E78
F02
ES21
18 K4
BK/LB
(3.8L) SENSOR
KNOCK
2
CAMSHAFT
POSITION
SENSOR
K4
18
BK/LB
SENSOR
GROUND
SIGNALSIGNAL (8W-70-6)(8W-70-7)
(8W-70-6)
(8W-30-22)
8W - 30 - 24 8W-30 FUEL/IGNITION SYSTEM
3.3L/3.8LNS/GS
J988W-3GS003024

POWERTRAIN
CONTROL
MODULE
9A
PTC
1
38
(ST-RUN) IGNITIONFUSED
ST-RUN A21
JUNCTION
BLOCK
30C1
F87
18
WT/BK
6
6C6 C2
CENTER DISTRIBUTION
POWER
F87
18
WT/BK
31
SENSOR SPEED
VEHICLE
2
WT/OR18 G7
VEHICLE
SPEED
SENSOR 43
4E96
B108
C142
2K159
20
VT/RD
OR/BK20 G55
59
1
COOLANT
TEMPERATURE
SENSOR
3
60C1
14
2
33
ES05
GROUNDSENSOR6
E97
B106
K4
20
BK/LB
BS34
BK/LB20 K4
8
TN/BK20 K2
K2
20
TN/BK
BK/YL20 G58
3E120
B33
G58
20
BK/YL
BODY
CONTROL
MODULE
72C175C1 BS30
G7
18
WT/OR
WT/OR18 G7
SENSORSPEED VEHICLESENSOR
GROUND
GROUNDSENSOR
K4
20
BK/LB
COOLANT
TEMPERATURE
SENSOR
TEMPERATURECOOLANTENGINE COOLANT
TEMPERATURE
SENSOR
SIGNAL SENSOR TEMPERATURE (ST-RUN) IGNITIONFUSED
SENSORSPEED VEHICLE
SIGNAL SENSORSPEED ENGINE ENGINE
DISABLE
SIGNAL DISABLE
SIGNAL SENSOR SIGNALENGINE SPEED F87 18 WT/BK
ENGINE
K4
18
BK/LB
SIGNAL
SIGNALCOOLANT
SIGNAL SIGNAL
ENGINE
SIGNALENGINE
SENSOR
SIGNAL (8W-12-13)(8W-10-16)
(8W-12-2)
(8W-10-29)
(8W-70-11)
(8W-70-11) (8W-45-9)
8W - 30 - 36 8W-30 FUEL/IGNITION SYSTEM
DIESELNS/GS
J988W-3GS003036
K4
20
BK/LB

8W-40 INSTRUMENT CLUSTER
Component Page
A/C Heater Control....................8W-40-4
AW4B13............................8W-40-2
Body Control
Module........8W-40-2, 3, 4, 5, 6, 7, 8, 9, 10, 11
BS05........................8W-40-5, 6, 8, 10
BS06........................8W-40-5, 6, 8, 10
BS30...............................8W-40-7
BS40...............................8W-40-7
Clockspring......................8W-40-10, 11
Cluster Illumination Lamps.............8W-40-4
Cruise Indicator Lamp..............8W-40-10, 11
Data Link Connector...................8W-40-9
Door Ajar Indicator Lamp...............8W-40-3
Driver Door Ajar Switch................8W-40-3
Electronic PRNDL Indicator.............8W-40-5
Engine Coolant Temperature Gauge.....8W-40-8, 9
Engine Coolant Temperature Sensor.....8W-40-8, 9
Engine Speed Sensor...................8W-40-7
ES13........................8W-40-5, 6, 8, 10
ES14........................8W-40-5, 6, 8, 10
ES30...............................8W-40-7
Fuel Gauge..........................8W-40-2
Fuel Tank Module.....................8W-40-2
Fuse 2 (JB)..............8W-40-2, 3, 4, 5, 6, 8, 10
Fuse 28 (PDC)........................8W-40-2
G200...............................8W-40-2
G300...............................8W-40-4
G301...............................8W-40-7
G302...............................8W-40-3
G400...............................8W-40-3Component Page
Ignition Switch.....................8W-40-2, 4
Instrument Cluster............8W-40-2, 3, 4, 5, 6,
7, 8, 9, 10, 11
Junction Block...........8W-40-2, 3, 4, 5, 6, 8, 10
Left Rear Door Ajar Switch..............8W-40-3
Left Speed Control Switch...........8W-40-10, 11
Liftgate Ajar Indicator Lamp.............8W-40-3
Liftgate Ajar Switch...................8W-40-3
Low Fuel Warning Indicator Lamp........8W-40-2
Low Washer Fluid Level
Indicator Lamp.................8W-40-10, 11
Low Washer Fluid Switch...........8W-40-10, 11
Memory Seat/Mirror Module.............8W-40-2
Odometer............................8W-40-5
Passenger Door Ajar Switch.............8W-40-3
Power Distribution Center..............8W-40-2
Powertrain Control
Module..............8W-40-5, 6, 7, 8, 9, 10, 11
PS01............8W-40-2, 3, 4, 5, 6, 7, 8, 9, 10, 11
PS02............8W-40-2, 3, 4, 5, 6, 7, 8, 9, 10, 11
Right Rear Door Ajar Switch.............8W-40-3
Right Speed Control Switch..........8W-40-10, 11
Seat Belt Indicator Lamp...............8W-40-4
Seat Belt Switch......................8W-40-4
Speedometer.......................8W-40-6, 7
Tachometer........................8W-40-6, 7
Transmission Control Module..........8W-40-5, 6
Trip Odometer........................8W-40-5
Vehicle Speed Sensor.................8W-40-6, 7
Voltage Indicator Lamp...............8W-40-8, 9
NS/GS8W - 40 INSTRUMENT CLUSTER 8W - 40 - 1