engine coolant CHRYSLER VOYAGER 2002 Owners Manual

CHRYSLER VOYAGER 2002 Owners Manual VOYAGER 2002 CHRYSLER CHRYSLER https://www.carmanualsonline.info/img/25/56871/w960_56871-0.png CHRYSLER VOYAGER 2002 Owners Manual

Page 1285 of 2399

CHRYSLER VOYAGER 2002 Owners Manual Calibrate the tester according to the manufactur-
ers instructions. The shop air source for testing
should maintain 483 kPa (70 psi) minimum, 1,379
kPa (200 psi) maximum, with 552 kPa (80 psi) rec-
o

Page 1286 of 2399

CHRYSLER VOYAGER 2002 Owners Manual MOPARtGASKET MAKERis an anaerobic type
gasket material. The material cures in the absence of
air when squeezed between two metallic surfaces. It
will not cure if left in the uncovered tube. The
anaero

Page 1288 of 2399

CHRYSLER VOYAGER 2002 Owners Manual REMOVAL - ENGINE ASSEMBLY
(1) Perform fuel pressure release procedure (Refer
to 14 - FUEL SYSTEM/FUEL DELIVERY - STAN-
DARD PROCEDURE).
(2) Disconnect negative battery cable.
(3) Remove air cleaner an

Page 1292 of 2399

CHRYSLER VOYAGER 2002 Owners Manual (20) Install the powertrain struts (Fig. 8).
(21) Install the engine rear mount bracket.
(22) Install the engine front mount and bracket
assembly.
(23)AWD equipped;Install the power transfer
unit (PTU

Page 1301 of 2399

CHRYSLER VOYAGER 2002 Owners Manual INSTALLATION
(1) Install air box into vehicle and onto the locat-
ing pin.
(2) Install bolt to hold air box to the upper radia-
tor cross member.
(3) Install the inlet hose to the throttle body.
(4) C

Page 1340 of 2399

CHRYSLER VOYAGER 2002 Owners Manual (9) Lower vehicle and fill crankcase with specified
type and amount of engine oil. (Refer to LUBRICA-
TION & MAINTENANCE/FLUID TYPES -
DESCRIPTION)
(10) Install oil fill cap.
(11) Start engine and ins

Page 1341 of 2399

CHRYSLER VOYAGER 2002 Owners Manual OIL COOLER & LINES
DESCRIPTION
An engine oil cooler is used on 3.3/3.8L engines
(Heavy Duty Cooling Only) (Fig. 104). The cooler is a
coolant-to-oil type and mounted between the oil filter
and engine

Page 1347 of 2399

CHRYSLER VOYAGER 2002 Owners Manual (11) If oil pressure is low and pump is within spec-
ifications, inspect for worn engine bearings or other
reasons for oil pressure loss.
ASSEMBLY
(1) Assemble pump, using new parts as required.
Insta

Page 1352 of 2399

CHRYSLER VOYAGER 2002 Owners Manual (6) Connect the engine coolant temperature sensor
(Fig. 126).
(7) Connect the heater supply (Fig. 126) and radi-
ator upper hoses to manifold.
(8) Connect the fuel line. (Refer to 14 - FUEL SYS-
TEM/F

Page 1364 of 2399

CHRYSLER VOYAGER 2002 Owners Manual DESCRIPTION - ENGINE COVER
The engine cover is a black plastic cover used to
cover the top of the engine (Fig. 10). It is used to iso-
late engine noises.
REMOVAL
REMOVAL - 2.5L DIESEL ENGINE
(1) Disc