battery Citroen C ZERO 2011 1.G Owner's Guide
[x] Cancel search | Manufacturer: CITROEN, Model Year: 2011, Model line: C ZERO, Model: Citroen C ZERO 2011 1.GPages: 164, PDF Size: 8.98 MB
Page 91 of 164
8
!
i
Practical information
89
Never charge the battery without
first disconnecting the terminals and
removing it from the vehicle.
Do not disconnect the terminals when
the "Ready" lamp is on, nor when the
vehicle is being charged.
Before disconnecting
You must wait 2 minutes after switching
off the ignition before disconnecting the
battery.
Batteries contain harmful substances
such as sulphuric acid and lead. They
must be disposed of in line with legal
requirements and never put out with
household waste.
Take used batteries to an authorised
collection point.
)
Disconnect the negative (-) terminal.
)
Lift the protective cover on the (+) terminal 2
.
)
Slacken nut 3
.
)
Disconnect the positive (+) terminal.
)
Remove the battery.
)
Charge the battery following the
instructions given by the manufacturer of
the battery charger.
)
Reconnect the battery starting with the (+)
cable.
After reconnecting
After reconnecting the battery, switch
on the ignition and wait 1 minute
before star ting, to allow initialisation
of the electronic systems. However,
if minor problems persist after doing
this, contact a CITROËN dealer or a
qualified workshop.
Remember to enter the radio code
yourself, referring to the relevant
section.
Ensure that the battery posts and cable
terminals are clean. If they are covered
with sulphates (whitish or greenish
deposit), disconnect and clean them.
Page 110 of 164
i
Practical information
108
Fuse N°
Rating
Functions
1
-
Not used.
2
30 A
Internal fuse.
3
40 A
Electric motor.
4
40 A
Radiator fan.
5
40 A
Electric windows.
6
30 A
Vacuum pump.
7
15 A
Main batter y ECU.
8
15 A
Third brake lamp.
9
15 A
Front foglamps.
10
15 A
Water pump.
Front compartment fuses
The fusebox is placed in the front compar tment
under the heating system reser voir. Only these
fuses can be replaced.
The replacement of fuses for other units
(vacuum pump and battery accessories)
requires the involvement of a CITROËN
dealer or a qualified workshop.
Page 111 of 164
8
Practical information
109
Access to the fuses
)
Open the bonnet (refer to the "Checks"
section),
)
Unclip the cover and remove it completely
by pulling towards you.
)
Change the fuse (refer to the
corresponding paragraph).
)
When you have finished, close the cover
carefully to ensure sealing of the fusebox.
Fuse N°
Rating
Functions
11
10 A
On-board charger.
12
10 A
Direction indicator.
13
10 A
Horn.
14
10 A
Daytime running lamps.
15
15 A
Battery fan.
16
10 A
Air conditioning compressor.
17
20 A
Right hand dipped beam.
18
20 A
Left hand dipped beam, headlamp adjusters.
19
10 A
Right hand main beam.
20
10 A
Left hand main beam.
Page 113 of 164
8
i !
!
!
Practical information
111
Accessories
A wide range of accessories and genuine par ts is available from the CITROËN dealer network.
These accessories and par ts have been tested and approved for reliability and safety.
They are all adapted to your vehicle and benefit from CITROËN's recommendation and warranty.
Conversion kits
You can obtain an "Enterprise" kit to conver t a
trade vehicle to a private car and vice-versa.
"Comfort":
black armrest, reading lamp, insulated
modules, rear parking sensors, cigarette lighter,
ashtray with base...
"Transport solutions":
boot carpet, rear parcel shelf, boot dividers...
"Security and safety":
alarm, wheel security bolts, child seats,
breathalyzer, warning triangle, high visibility
vest, first aid kit, snow chains, non-slip covers...
Precautions for
washing
To avoid damaging the electrical
components, the use of a high pressure
jet wash is strictly prohibited:
- in the front compar tment (under
the bonnet),
- under the body.
For washing the body, do not use a
pressure greater than 80 bars. Check - before washing the vehicle -
that the charging flaps and the charging
socket covers (normal and fast charge)
are properly closed.
Do not wash the vehicle while the
battery is being recharged.
Page 116 of 164
!
i
Checks
114
Bonnet
Protects the components in the front compar tment and provides access for checking levels, recharging the 12 V ancillaries battery, changing fuses, ...
)
Push the exterior safety catch B
to the left
and raise the bonnet.
)
Open the bonnet fully and on the right,
unclip the stay C
from its holder.
)
Fit the stay C
in one of the two notches
to hold the bonnet open.
)
Open the front right door.
)
Pull the interior release lever A
, located at
the bottom of the door aperture.
Opening
Closing
)
Take the stay out of the suppor t notch.
)
Clip the stay in its housing.
)
Lower the bonnet and release it at the end
of its travel.
)
Pull on the bonnet to check that it is fully
latched.
Do not press down on the middle of
the bonnet if it does not fully close, as
there is a risk of deforming it. Open
the bonnet fully and close it again.
The location of the interior release lever
prevents opening of the bonnet while
the front right door is closed.
Page 117 of 164
9
!
Checks
115
1.
Screenwash fluid reservoir.
2.
Heater fluid reser voir.
3.
Brake fluid reser voir.
4.
Ancillaries battery.
5.
Fusebox.
Front compartment
To avoid damaging electrical
components, the use of a high pressure
jet washer in the front compar tment is
strictly prohibited.
Page 120 of 164
!
i
Checks
118
The coolant level should be between
the MIN "L" and MA X "F" marks.
Coolant level
Avoid prolonged contact of used fluids
with the skin.
Most of these fluids are harmful to
health and some are very corrosive.
Do not discard used fluids into sewers
or onto the ground.
Take used fluids to a CITROËN dealer
or a qualified workshop (France) or to
an authorised waste disposal site.
Used products
Rear compartment
Changing the coolant
The coolant does not have to be changed.
Coolant specifi cation
The coolant must conform to the
manufacturer's recommendations.
As the cooling system is pressurised, wait at
least one hour after switching off the motor and/
or the end of the charge cycle before carrying
out any work.
To avoid any risk of scalding, unscrew the cap
by two turns to allow the pressure to drop.
When the pressure has dropped, remove
the cap and top up the level.
Ancillaries battery
electrolyte level
Remove the battery protective cover to check
this level (see § "ancillaries battery").
The electrolyte level should be between
the MIN "LOWER LEVEL" and MA X "UPPER
LEVEL".
If necessary, top up using distilled water by
removing the individual battery caps.
Check the electrolyte level at least once
per month.
Page 122 of 164
Technical data
120
MODEL:
MOTOR AND MAIN BATTERY
Model type code:
1 N ZK Z Z
Electric motor
Y4 F1
Te c h n o l o g y
Synchronous with neodymium permanent magnets
Max. power: EU standard (kW)
49
Max. power speed (rpm)
2 500 to 8 000
Max. torque: EU standard (Nm)
18 0
Max. torque speed (rpm)
0 to 2 500
Main battery
Lithium-Ion
Energy capacity (kWh)
16
Normal charge
Voltage (V)
220
Charging time
(
* )
(
** )
:
- 16 A
- 13 A
- 10 A
6 hours
7 hours
9 hours
Fast charge
Voltage (V)
330
Charging time (80% charge) **
30 minutes
*
Depending on the power supply in the country.
**
Time measured for ambient temperatures between 20 and 25 °C. Range varies according to the exterior climatic conditions, the driver's style of driving, the use of electrical equipment, the frequency of normal or fast
charges and ageing of the main battery.
Page 123 of 164
10
!
Technical data
121
WEIGHTS (
in
kg)
Electric motor
Y4 F1
Main battery
Lithium-Ion
Model type code:
1 N ZK Z Z
Unladen weight
1 120
Kerb weight
1 195
Gross vehicle weight (GV W)
1 450
Gross train weight (GTW)
1 450
Maximum load on the roof (including the roof bars)
43
Your vehicle cannot be fitted with a towbar. It cannot tow a trailer.
Page 128 of 164
126
EMERGENCY OR ASSISTANCE CALL
CITROËN LOCALISED EMERGENCY CALL
In an emergency, press this button for more than
2 seconds. Flashing of the green LED and a voice
message confi rm that the call has been made to the
CITROËN Emergency team * .
Pressing this button again immediately cancels the request. The green
LED goes off.
A press (at any time) of more than 8 seconds on this button, cancels the
request.
CITROËN LOCALISED ASSISTANCE CALL
When the ignition is switched on, the
green LED comes on for 3 seconds
indicating that the system is operating
correctly.
If the orange LED fl ashes: there is a
system fault.
If the orange LED is on continuously: the
backup battery must be replaced.
In either case, contact a CITROËN.
Pressing this button again immediately cancels the request.
The cancellation is confi rmed by a voice message.
Press this button for more than 2 seconds to request
assistance if the vehicle breaks down.
A voice message confi rms that the call has been made * .
OPERATION OF THE SYSTEM
The green LED remains on (without fl ashing) when communication is
established. It goes off at the end of communication.
This call is dealt with by the CITROËN Emergency team which receives
locating information from the vehicle and can send a detailed alert to the
appropriate emergency services. In countries in which the team is not
operational, or when the locating service has been expressly declined,
the call is dealt with directly by the emergency services (112) without the
vehicle location.
If an impact is detected by the airbag ECU, and independently
of the deployment of any airbags, an emergency call is made
automatically.
* These services are subject to conditions and availability.
Consult a CITROËN dealer.
If you purchased your vehicle outside the CITROËN dealer network,
we invite you to have a dealer check the confi guration of these services
and, if desired, modifi ed to suit your wishes. In a multi-lingual country,
confi guration is possible in the offi cial national language of your choice.
For technical reasons, particularly to improve the quality of Telematic
services to customers, the manufacturer reserves the right to carry out
updates to the vehicle's on-board telematic system.
If you benefi t from the CITROËN eTouch offer, you also have available
additional services in your MyCITROEN personal space, via the CITROËN
Internet website www.citroen.co.uk.