engine Citroen C4 PICASSO DAG 2010.5 1.G Manual PDF
[x] Cancel search | Manufacturer: CITROEN, Model Year: 2010.5, Model line: C4 PICASSO DAG, Model: Citroen C4 PICASSO DAG 2010.5 1.GPages: 355, PDF Size: 13.32 MB
Page 201 of 355
X
176
C H E C K S
CHECKING LEVELS
Check all of these levels regularly
and top them up if necessary, unless
otherwise indicated.
I f a l e v e l d r o p s s i g n i fi c a n t l y , h a v e t h e
corresponding system checked by a
CITROËN dealer.
Oil level
Engine oil change
Refer to the Maintenance and
Warranty Guide for details of the in-
terval for this operation. O i l s p e c i fi c a t i o n
The oil must correspond to your en-
gine and conform to the manufactur-
er's recommendations.
Brake fluid level
C h a n g i n g t h e fl u i d
Refer to the Maintenance and
Warranty Guide for details of the in-
terval for this operation.
F l u i d s p e c i fi c a t i o n
T h e b r a k e fl u i d m u s t c o n f o r m t o t h e
manufacturer's recommendations
a n d f u l fi l t h e D O T 4 s t a n d a r d s .
Coolant level
Changing the coolant
The coolant does not have to be
changed.
F l u i d s p e c i fi c a t i o n
The coolant must conform to the
manufacturer's recommendations.
The reading will only be
correct if the vehicle is on
level ground and the engine
has been off for more than
1 5 m i n u t e s .
The check is carried out either when
the ignition is switched on using the
oil level indicator on the instrument
panel, or using the dipstick. T h e b r a k e fl u i d l e v e l s h o u l d
be close to the "MAX" mark.
If it is not, check the brake
pad wear.
The coolant level should be
close to the "MAX" mark but
should never exceed it.
When the engine is warm,
the temperature of the coolant is
regulated by the fan. This can oper-
ate with the ignition off.
O n v e h i c l e s w h i c h a r e fi t t e d w i t h
a p a r t i c l e e m i s s i o n fi l t e r , t h e f a n
may operate after the vehicle has
b e e n s w i t c h e d o f f , e v e n i f t h e e n -
gine is cold.
In addition, as the cooling system is
pressurised, wait at least one hour
after switching off the engine before
carrying out any work.
To avoid any risk of scalding, un-
screw the cap by two turns to al-
low the pressure to drop. When the
pressure has dropped, remove the
cap and top up the level.
In order to maintain the re-
liability of the engine and
emission control system,
the use of additives in the engine
oil is prohibited. When working under the
bonnet, take care, as cer-
tain areas of the engine
may be extremely hot (risk
of burns).
Power steering fluid level T h e p o w e r s t e e r i n g fl u i d
level should be close to the
"MAX" mark. Unscrew the
cap, with the engine cold, to
check the level.
Page 202 of 355
X
177
C H E C K S
Screenwash and headlamp
wash fluid
F l u i d s p e c i fi c a t i o n
For optimum cleaning and to avoid
f r e e z i n g , t h i s fl u i d m u s t n o t b e
topped up with or replaced with plain
water. Diesel additive level (Diesel
engine with particle emission
filter)
A low additive level is indicated by
lighting of the service warning lamp,
accompanied by an audible warning
and a message on the multifunction
screen.
Topping up
This additive must be topped up by
a CITROËN dealer without delay.
Used products
Avoid prolonged contact of
u s e d o i l o r fl u i d s w i t h t h e
skin.
M o s t o f t h e s e fl u i d s a r e h a r m f u l t o
health or indeed very corrosive.
Do not discard used oil or
fl u i d s i n t o s e w e r s o r o n t o
the ground.
Take used oil to a CITROËN dealer
(France) or an authorised waste
disposal site.
I n t h e c a s e o f v e h i c l e s fi t t e d
with headlamp washers, the
m i n i m u m l e v e l o f t h i s fl u i d i s
indicated by an audible sig-
nal and a message on the multifunc-
tion screen.
Top up the level when you stop the
vehicle.
Page 203 of 355
X
178
C H E C K S
CHECKS
Unless otherwise indicated, check
these components in accordance
with the Maintenance and Warranty
Guide and according to your engine.
Otherwise, have them checked by a
CITROËN dealer.
Battery The battery does not re-
quire any maintenance.
However, check that the
terminals are clean and
correctly tightened, partic-
ularly in summer and winter.
When carrying out work on the bat-
tery, refer to the "Practical infor-
mation" section for details of the
precautions to be taken before dis-
connecting the battery and following
its reconnection. Air filter and passenger
compartment filter
Refer to the Maintenance
and Warranty Guide for
details of the replacement
intervals for these compo-
nents.
Depending on the environment (e.g.
dusty atmosphere) and the use of
the vehicle (e.g. city driving), replace
them twice as often if necessary
(refer to the "Engines" section).
A clogged passenger compartment
fi l t e r m a y h a v e a n a d v e r s e e f f e c t o n
the performance of the air condition-
ing system and generate undesir-
able odours.
Oil filter
R e p l a c e t h e o i l fi l t e r e a c h
time the engine oil is
changed. Particle filter system (Diesel)
Complementary to the catalytic con-
v e r t e r , t h i s fi l t e r m a k e s a n a c t i v e
contribution to the preservation of air
quality by the retaining of the unburnt
pollutant particles. Black exhaust
fumes are thus no longer emitted.
After prolonged idling or driving at very
low speeds, you may occasionally no-
tice water vapour being emitted from
the exhaust when accelerating. This is
of no consequence to the running of
the vehicle or to the environment.
If there is risk of clogging, a mes-
sage appears on the multifunction
screen, accompanied by an audi-
ble signal and lighting of the service
warning lamp.
This alert tells you that the particle
fi l t e r i s s t a r t i n g t o fi l l u p ( i n c o n d i t i o n s
of urban driving of exceptionally long
d u r a t i o n : l o w s p e e d s , t r a f fi c j a m s e t c . )
T o r e g e n e r a t e t h e fi l t e r , i t i s a d v i s e d
to drive as soon as possible, when
t r a f fi c c o n d i t i o n s p e r m i t , a t a s p e e d
of 40 mph (around 60 km/h) or
m o r e f o r a t l e a s t fi v e m i n u t e s ( u n t i l
the alert message disappears).
If this alert persists, consult a
CITROËN dealer.
Refer to the Maintenance and
Warranty Guide for details of the
replacement interval for this compo-
nent.
The presence of this label, in par-
ticular with the Stop & Start system,
i n d i c a t e s t h e u s e o f a s p e c i fi c 1 2 V
lead-acid battery with special tech-
n o l o g y a n d s p e c i fi c a t i o n , f o r w h i c h
the involvement of a CITROËN
dealer is required when replacing or
disconnecting the battery. Failure to observe this recommen-
dation may cause premature wear
of the battery.
Page 204 of 355
X
179
C H E C K S
Brake pads Brake wear depends on
the style of driving, par-
ticularly in the case of ve-
hicles used in town, over
short distances. It may be
necessary to have the condition of
the brakes checked, even between
vehicle services.
Unless there is a leak in the circuit, a
d r o p i n t h e b r a k e fl u i d l e v e l i n d i c a t e s
that the brake pads are worn.
Manual gearbox
The gearbox does not re-
quire any maintenance (no
oil change).
6 - s p e e d e l e c t r o n i c g e a r
control gearbox The gearbox does not re-
quire any maintenance (no
oil change).
Automatic gearbox The gearbox does not re-
quire any maintenance (no
oil change). Brake disc wear status
For information relating to
checking the brake disc
wear status, contact a
CITROËN dealer.
Electric parking brake
This system does not require any
routine servicing. However, in the
event of a problem, have the system
checked by a CITROËN dealer.
For more information, see "Driving -
Electric parking brake - § Operating
faults". Only use products recom-
mended by CITROËN or
products of equivalent qual-
i t y a n d s p e c i fi c a t i o n s .
In order to optimise the operation
of units as important as the braking
system, CITROËN selects and of-
f e r s v e r y s p e c i fi c p r o d u c t s .
To avoid damaging the electrical
units, the use of a high pressure
washer in the engine compartment
is strictly prohibited .
Refer to the Maintenance and
Warranty Guide for the details of the
level checking interval for this com-
ponent.
Refer to the Warranty and Maintenance
and Record for details of the checking
interval for this component.
Refer to the Maintenance and
Warranty Guide for details of the
level checking interval for this com-
ponent.
Page 225 of 355
XI
197
P R A C T I C A L I N F O R M A T I O N
Fuses in the engine
compartment
Access to the fuses
D e t a c h a n d r e m o v e t h e c o v e r .
A f t e r a n y o p e r a t i o n , c a r e f u l l y r e fi t
the cover. If the cover is not cor-
rectly positioned or not properly
closed, this could cause serious
problems on your vehicle. For the
same reason, take care not to spill
any liquid in the fusebox.
A l l w o r k o n t h e m a x i - f u s e s ,
which are located in these
f u s e b o x e s a n d w h i c h g i v e
e x t r a p r o t e c t i o n , m u s t b e c a r r i e d
o u t b y a C I T R O Ë N d e a l e r .
Page 237 of 355
XII
208
T E C H N I C A L D A T A
MODELS:
ENGINES AND GEARBOXES
Model codes:
UA... UE... UD...
5FS-0
5FS-0/CU1
5FV-8/P
5FV-8/PCU1
RFJ-F
PETROL ENGINES VTi 120 THP 155 VTi 143
Cubic capacity (cc) 1 598 1 598 1 997
Bore x stroke (mm) 77 x 85.8 77 x 85.8 85 x 88
EU standard maximum power (kW) 88 115 103
Maximum power engine speed (rpm) 6 000 6 000 6 000
EU standard maximum torque (Nm) 160 240 200
Maximum torque engine speed (rpm) 4 250 1 400 4 000
Fuel Unleaded Unleaded Unleaded
Catalytic converter Yes Yes Yes
GEARBOXES Manual
(5-speed)
Electronic gearbox system
(6-speed) Auto.
(4-speed)
OIL CAPACITIES (in litres)
E n g i n e ( w i t h fi l t e r r e p l a c e m e n t ) 4.25 - 5
UA...: CITROËN Grand C4 Picasso (7-seat).
UE...: CITROËN Grand C4 Picasso (5-seat).
UD...: CITROËN C4 Picasso (5-seat).
...CU1: commercial versions.
Page 238 of 355
XII
210
T E C H N I C A L D A T A
MODELS:
ENGINES AND GEARBOXES
Model codes:
UA... UE... UD...
9HZ-C
9HZ-C/
CU1
9HZ-H/P
9HZ-H/
PCU1
9HR-8
9HR-8/
CU1
9HR-8/P
9HR-8/
PCU1
9HR-8/PS
RHJ-H/P
RHJ-H/
PCU1
RHR-J
DIESEL ENGINES HDi 110 HDi 110 HDi 138
Cubic capacity (cc) 1 560 1 560 1 997
Bore x stroke (mm) 75 x 88.3 75 x 88.3 85 x 88
EU standard maximum power (kW) 80 82 100
Maximum power engine speed (rpm) 4 000 3 600 4 000
EU standard maximum torque (Nm) 240 270 270 320
Maximum torque engine speed (rpm) 1 750 1 750 2 000
Fuel Diesel Diesel Diesel
Catalytic converter Yes Yes Yes
P a r t i c l e e m i s s i o n fi l t e r ( P E F ) Yes Yes Yes
GEARBOXES Manual
(5-speed) Electronic
gearbox system
(6-speed) Manual
(6-speed) Electronic
gearbox system
(6-speed) Electronic
gearbox system
(6-speed) Electronic
gearbox system
(6-speed) Automatic
(6-speed)
OIL CAPACITIES (in litres)
E n g i n e ( w i t h fi l t e r r e p l a c e m e n t ) 3.75 3.75 -
- 5.25 5.25
...S: m o d e l fi t t e d w i t h S t o p & S t a r t .
UA...: CITROËN Grand C4 Picasso (7-seat).
UE...: CITROËN Grand C4 Picasso (5-seat).
UD...: CITROËN C4 Picasso (5-seat).
...CU1: commercial versions.
Page 239 of 355
XII
211
T E C H N I C A L D A T A
MODELS:
ENGINES AND GEARBOXES
Model codes:
UA... UE... UD...
RHE-8
RHE-8/CU1
RHE-8/P RHH-A
DIESEL ENGINES
HDi 150 HDi 163
Cubic capacity (cc) 1 997 1 997
Bore x stroke (mm) 85 x 88 85 x 88
EU standard maximum power (kW) 110 120
Maximum power engine speed (rpm) 3 750 3 750
EU standard maximum torque (Nm) 340 340
Maximum torque engine speed (rpm) 2 000 2 000
Fuel Diesel Diesel
Catalytic converter Yes Yes
P a r t i c l e e m i s s i o n fi l t e r ( P E F ) Yes Yes
GEARBOXES Manual
(6-speed)
Electronic gearbox system
(6-speed) Automatic
(6-speed)
OIL CAPACITIES (in litres)
E n g i n e ( w i t h fi l t e r r e p l a c e m e n t ) 5.25 - 5.25
UA...: CITROËN Grand C4 Picasso (7-seat).
UE...: CITROËN Grand C4 Picasso (5-seat).
UD...: CITROËN C4 Picasso (5-seat).
...CU1: commercial versions.
Page 240 of 355
XII
209
T E C H N I C A L D A T A
WEIGHTS AND TOWED LOADS (in kg)
Petrol engines VTi 120 THP 155 VTi 143
Gearboxes Automatic
Electronic gearbox system
Automatic
Model codes:
UA... UE... UD...
5FS-0 5FV-8/P RFJ-F
- Unladen weight 1 430 - 1 415 - 1 415 1 517 - 1 430 - 1 430 1 600 - 1 556 - 1 552
- Kerb weight 1 505 - 1 490 - 1 490 1 592 - 1 5 05 - 1 505 1 675 - 1 631 - 1 627
- Payload 770 - 700 - 525 703 - 630 - 610 660 - 514 - 538
- Gross vehicle weight (GVW) 2 200 - 2 115 - 2 015 2 220 - 2 060 - 2 040 2 2
60 - 2 070 - 2 090
- Gross train weight (GTW)
on a 12 % gradient 3 300 - 3 315 - 3 315 3 420 - 3 410 - 3 390 3 660 - 3 570 - 3 590
-
Braked trailer (within GTW limit)
on a 10 % or 12 % gradient 1 100 - 1 200 - 1 300 1 200 - 1 350 - 1 350 1 400 - 1 500 - 1 500
- Braked trailer * (with load transfer within GTW limit) 1 300 - 1 500 - 1 500 1 500 1 500
- Unbraked trailer 750 -745 - 745 750 750
- Recommended nose weight 60 60 60
The GTW and towed load values indicated apply up to a maximum altitude of 1,000 metres; the towed load mentioned
must be reduced by 10 % for each additional 1,000 metres of a ltitude.
The speed of a towing vehicle must not exceed 100 km/h (appro x. 60 mph) (comply with the legislation in force in your
country).
High ambient temperatures may result in a reduction in the pe rformance of the vehicle in order to protect the engine; when
the ambient temperature is higher than 37 °C, limit the we ight towed.
* The weight of the braked trailer can be increased, within the GTW limit, on condition that the GVW of the towing vehicle is reduced
by the same amount; warning, towing with a lightly loaded towing vehicle may have an adverse effect on its road holding.
Page 241 of 355
XII
216
T E C H N I C A L D A T A
* If the maximum rear axle weight is exceeded when the vehicle is towing, the maximum speed is limited to 50 mph
( 8 0 k m / h ) a s d e fi n e d b y p o i n t 2 . 7 o f t h e E U D i r e c t i v e .
** If the the gross vehicle weight is exceeded when th e vehicle is towing, the maximum speed is limited to 50 mph
( 8 0 k m / h ) a s d e fi n e d b y p o i n t 2 . 7 o f t h e E U D i r e c t i v e .
*** Maximum weight of the braked trailer within the GT W limit; warning, towing with a lightly loaded towing vehicle may
have an adverse effect on its road holding.
The GTW and towed load values indicated apply up to a maximum altitude of 1,000 metres; the towed load mentioned
must be reduced by 10 % for each additional 1,000 metres of a ltitude.
High ambient temperatures may result in a reduction in the pe rformance of the vehicle in order to protect the engine; when
the ambient temperature is higher than 37 °C, limit the we ight towed.
WEIGHTS AND TOWED LOADS (in kg)
- COMMERCIAL VERSIONS
Petrol engines VTi 120 THP 155
Gearboxes
Manual Electronic gearbox system
Model codes:
UA... UD...
UA5FS-
0/CU1
UD5FS-0/CU1
UA5FV-8/PCU1
UD5FV-8/PCU1
- Unladen weight 1 560 - 1 591 1 600 - 1 590
- Kerb weight 1 635 - 1 666 1 675 - 1 665
- Payload 630 - 624 620 - 620
- Gross vehicle weight (GVW) * 2 190 - 2 215 2 220 - 2 210
- Gross train weight (GTW)
on a 12 % gradient ** 3 290 - 3 415 3 420 - 3 410
-
Braked trailer (within GTW limit)
on a 10 % or 12 % gradient *** 1 100 - 1 200 1 200 - 1 200
- Braked trailer (with load transfer within GTW limit) -
-
- Unbraked trailer 750 - 750 750 - 750
- Recommended nose weight 70 - 60 70 - 60