oil Citroen C5 2008.5 (RD/TD) / 2.G User Guide
[x] Cancel search | Manufacturer: CITROEN, Model Year: 2008.5, Model line: C5, Model: Citroen C5 2008.5 (RD/TD) / 2.GPages: 306, PDF Size: 18.9 MB
Page 157 of 306
157
10
C H E C K S
CHECKING LEVELS
Check all of these levels regularly
and top them up if necessary, unless
otherwise indicated.
I f a l e v e l d r o p s s i g n i fi c a n t l y , h a v e t h e
corresponding system checked by a
CITROËN dealer.
Oil level Oil change
Refer to the Maintenance and
Warranty Guide for details of the in-
terval for this operation.
O i l s p e c i fi c a t i o n
The oil must correspond to your en-
gine and conform to the manufactur-
er’s recommendations. Brake fluid level
Fluid change
Refer to the Maintenance and
Warranty Guide for details of the in-
terval for this operation.
T h i s fl u i d m u s t b e c h a n g e d r e g u l a r l y .
F l u i d w h i c h h a s b e e n u s e d e x c e s -
sively may cause a loss of braking
e f fi c i e n c y .
F l u i d s p e c i fi c a t i o n
T h e b r a k e fl u i d m u s t c o n f o r m t o t h e
manufacturer’s recommendations
a n d f u l fi l t h e D O T 4 s t a n d a r d s .
The reading will only be
correct if the vehicle is on
level ground and the engine
has been off for more than
15 minutes.
The check is carried out either when
the ignition is switched on using the
oil level indicator on the instrument
panel, or using the dipstick.
Between two oil changes, the con-
s u m p t i o n s h o u l d n o t e x c e e d 0 . 5 l i t r e
per 600 miles (1,000 km).
Check this level also between each
scheduled service and before long
journeys. T h e b r a k e fl u i d l e v e l s h o u l d
be close to the "MAX" mark.
If it is not, check the brake
pad wear.
In order to maintain the re-
liability of the engine and
emission control system,
the use of additives in the engine
oil is prohibited. Power steering fluid or power
steering and suspension
fluid level
T h i s fl u i d m u s t b e t o p p e d u p
by a CITROËN dealer.
Dipstick
There are 2 marks on the
dipstick:
-
A = m a x ; n e v e r e x -
ceed this level,
- B = min; top up the
l e v e l v i a t h e o i l fi l l e r
cap, using the type of
oil suited to your en-
gine.
Page 158 of 306
158
10
C H E C K S
Screenwash and headlamp
wash fluid
F l u i d s p e c i fi c a t i o n
For optimum cleaning and to avoid free-
z i n g , t h i s fl u i d m u s t n o t b e t o p p e d u p o r
replaced with water.
Reservoir capacities:
- s c r e e n w a s h : a p p r o x i m a t e l y 3 . 5 l i t r e s ,
- screenwash and headlamp wash: a p p r o x i m a t e l y 6 . 1 5 l i t r e s .
Diesel additive level (Diesel
engine with particle emission
filter)
A low additive level is indicated by
lighting of the service warning lamp,
accompanied by an audible warning
and a message on the multifunction
screen.
Topping up
This additive must be topped up by
a CITROËN dealer without delay.
Used products
Avoid prolonged contact of
u s e d o i l o r fl u i d s w i t h t h e
skin.
M o s t o f t h e s e fl u i d s a r e h a r m f u l t o
health or indeed very corrosive.
Do not discard used oil or
fl u i d s i n t o s e w e r s o r o n t o
the ground.
Take used oil to a an authorised
waste disposal site CITROËN.
I n t h e c a s e o f v e h i c l e s fi t t e d
with headlamp washers, the
m i n i m u m l e v e l o f t h i s fl u i d i s
indicated by an audible signal
and a message on the multifunction
screen.
Top up the level when you stop the
vehicle.
Coolant level
Coolant change
The coolant does not have to be
changed.
F l u i d s p e c i fi c a t i o n
The coolant must conform to the
manufacturer’s recommendations. The coolant level should be
close to the "MAX" mark but
s h o u l d n e v e r e x c e e d i t .
When the engine is warm, the tem-
perature of the coolant is regulated
by the fan. This can operate with the
ignition off.
O n v e h i c l e s w h i c h a r e fi t t e d w i t h
a p a r t i c l e e m i s s i o n fi l t e r , t h e f a n
may operate after the vehicle has
been switched off, even if the en-
gine is cold.
In addition, as the cooling system is
pressurised, wait at least one hour
after switching off the engine before
carrying out any work.
To avoid any risk of scalding, unscrew
the cap by two turns to allow the pres-
sure to drop. When the pressure has
dropped, remove the cap and top up
the level.
Page 159 of 306
159
10
C H E C K S
CHECKS
Unless otherwise indicated, check
these components in accordance
with the Maintenance and Warranty
Guide and according to your engine.
Otherwise, have them checked by a
CITROËN dealer.
Battery The battery does not re-
quire any maintenance.
However, check that the
terminals are clean and
correctly tightened, par-
ticularly in summer and
winter.
When carrying out work on the bat-
tery, refer to the "Practical information" section for details of the precautions
to be taken before disconnecting the
battery and following its reconnection.
Air filter and passenger compartment filter
Refer to the Maintenance
and Warranty Guide for
details of the replacement
intervals for these compo-
nents.
Depending on the environment (e.g.
dusty atmosphere) and the use of
the vehicle (e.g. city driving), replace
them twice as often if necessary
(refer to the "Engines" paragraph).
A c l o g g e d c a b i n fi l t e r m a y h a v e a n
adverse effect on the performance
of the air conditioning system and
generate undesirable odours.
Oil filter
R e p l a c e t h e o i l fi l t e r e a c h
time the engine oil is
changed. Particle filter system (Diesel)
Complementary to the catalytic
c o n v e r t e r , t h i s fi l t e r m a k e s a n a c -
tive contribution to the preservation
of air quality by the retaining of the
unburnt pollutant particles. Black
e x h a u s t f u m e s a r e t h u s n o l o n g e r
emitted.
After prolonged idling or driving at very
low speeds, you may occasionally
notice water vapour being emitted from
t h e e x h a u s t w h e n a c c e l e r a t i n g . T h i s i s
of no consequence to the running of
the vehicle or to the environment.
If there is risk of clogging, a mes-
sage appears on the instrument
panel display, accompanied by an
audible signal and lighting of the
service warning lamp.
This alert tells you that the particle
fi l t e r i s s t a r t i n g t o fi l l u p ( i n c o n d i t i o n s
o f u r b a n d r i v i n g o f e x c e p t i o n a l l y l o n g
d u r a t i o n : l o w s p e e d s , t r a f fi c j a m s
etc.)
T o r e g e n e r a t e t h e fi l t e r , i t i s a d v i s e d
to drive as soon as possible, when
t r a f fi c c o n d i t i o n s p e r m i t , a t a s p e e d
of 40 mph (around 60 km/h) or
m o r e f o r a t l e a s t fi v e m i n u t e s ( u n t i l
the alert message disappears).
If this alert persists, consult a
CITROËN dealer.
Refer to the Maintenance and
Warranty Guide for details of the
replacement interval for this compo-
nent.
Page 160 of 306
160
10
C H E C K S
Brake pads Brake wear depends on
the style of driving, par-
ticularly in the case of ve-
hicles used in town, over
short distances. It may be
necessary to have the condition of
the brakes checked, even between
vehicle services.
Unless there is a leak in the circuit, a
d r o p i n t h e b r a k e fl u i d l e v e l i n d i c a t e s
that the brake pads are worn.
Manual gearbox
T h e g e a r b o x d o e s n o t r e -
quire any maintenance (no
oil change).
Automatic gearbox T h e g e a r b o x d o e s n o t r e -
quire any maintenance (no
oil change). Brake disc wear
For information relating to
checking the brake disc
wear, contact a CITROËN
dealer.
Parking brake If the parking brake travel is
too long or if a loss of effec-
tiveness of this system is
noticed, the parking brake
must be adjusted, even be-
tween two services.
This system must be checked by a
CITROËN dealer. Only use products recom-
mended by CITROËN or
products of equivalent
q u a l i t y a n d s p e c i fi c a t i o n s .
In order to optimise the operation
of units as important as the braking
system, CITROËN selects and of-
f e r s v e r y s p e c i fi c p r o d u c t s .
To avoid damaging the electrical
units, the use of a high pressure
washer in the engine compartment
is strictly prohibited .
Refer to the Maintenance and
Warranty Guide for the details of the
level checking interval for this com-
ponent.
Refer to the Maintenance and
Warranty Guide for details of the
level checking interval for this com-
ponent.
Page 195 of 306
192
12
T E C H N I C A L D A T A
MODELS:
ENGINES AND GEARBOXES
Model codes:
RD... RW...
6FYC RFJC RFJF RFJC/FF XFVJ
PETROL ENGINES
1.8 l. 16V
127
hp
2 l. 16V 143
hp
B i o fl e x 2 l .
16V 143
hp 3 l. V6 24V
215 hp
Cubic capacity (cm 3
) 1 749 1 997 1 997 2 946
B o r e x s t r o k e ( m m ) 8 2 . 7 x 8 1 . 4 8 5 x 8 8 8 5 x 8 8 8 7 x 8 2 . 6
E U s t a n d a r d m a x i m u m p o w e r ( k W ) 92 103 103 155
M a x i m u m p o w e r e n g i n e s p e e d ( r p m ) 6 000 6 000 6 000 6 000
E U s t a n d a r d m a x i m u m t o r q u e ( N m ) 170 200 200 290
M a x i m u m t o r q u e e n g i n e s p e e d ( r p m ) 3 750 4 000 4 000 3 750
Fuel Unleaded Unleaded Unleaded/E85 Unleaded
Catalytic converter Yes Yes Yes Yes
GEARBOXES Manual
(5-speed) Manual
(5-speed) Auto.
(4-speed) Manual
(5-speed) Auto.
(6-speed)
OIL CAPACITIES (in litres)
Engine (with cartridge replacement)
5 5 5 - 4.75
G e a r b o x - F i n a l d r i v e - - - - -
Page 196 of 306
197
12
T E C H N I C A L D A T A
MODELS:
ENGINES AND GEARBOXES
Model codes:
RD... RW....
9HZC
9HZC/1
RHF8 RHRJ 4HTH UHZJ
DIESEL ENGINES
1.6 l. HDi 110
hp
2 l. HDi
140
hp
2 l. HDi
138
hp
2 l. HDi 173
hp V6 HDi 208
hp
Cubic capacity (cm 3
) 1 560 1 997 2 179 2 720
B o r e x s t r o k e ( m m ) 7 5 x 8 8 . 3 8 5 x 8 8 8 5 x 9 6 8 1 x 8 8
E U s t a n d a r d m a x i m u m p o w e r ( k W ) 80 103 100 125 150
M a x i m u m p o w e r e n g i n e s p e e d ( r p m ) 4 000 4 000 4 000 4 000
E U s t a n d a r d m a x i m u m t o r q u e ( N m ) 240 320 370 440
M a x i m u m t o r q u e e n g i n e s p e e d ( r p m ) 1 750 2 000 1 500 1 900
Fuel Diesel Diesel Diesel Diesel
Catalytic converter Yes Yes Yes Yes
P a r t i c l e e m i s s i o n fi l t e r ( P E F ) Yes Yes Yes Yes
GEARBOXES Manual
(5-speed) Manual
(6-speed) Auto.
(6-speed) Manual
(6-speed) Auto.
(6-speed)
OIL CAPACITIES (in litres)
E n g i n e ( w i t h fi l t e r r e p l a c e m e n t )
3.75 5.25 5.25 5.5
G e a r b o x - F i n a l d r i v e 1.9 - - - -
Page 199 of 306
198
12
T E C H N I C A L D A T A
FUEL
CONSUMPTION (SALOON) In accordance with directive 80/1268/CEE
Diesel
engines
Gearboxes
Model codes:
RD...
Urban
Litres
/100 km
(
mpg
)
Extra
-urban
Litres
/100 km
(
mpg
)
Mixed
Litres
/100 km
(
mpg
)
Emission of
CO 2 by weight
(g/km)
1.6 l. HDi
110
hp
Airdream
Manual 9HZC/1 6.6 (42.8) 4.6 (61.4) 5.3 (53.3) 140
1.6 l. HDi
110
hp
Manual 9HZC 7.3 (38.7) 4.7 (60.1) 5.6 (50.4) 149
2 l. HDi 140
hp Manual RHF8 7.5 (37.7) 4.8 (58.9) 5.8 (48.7) 153
2 l. HDi 138
hp Auto. RHRJ 9.9 (28.5) 5.5 (51.4) 7.1 (39.8) 189
2 l. HDi 173
hp Manual 4HTH 8.8 (32.1) 5.2 (54.3) 6.5 (43.5) 172
V6 HDi 208
hp Auto. UHZJ 11.8 (23.9) 6.4 (44.1) 8.4 (33.6) 223
T h e f u e l c o n s u m p t i o n fi g u r e s s h o w n h e r e c o r r e s p o n d t o t h e v a l u e s c o m m u n i c a t e d a t t h e t i m e o f p r i n t i n g .
These fuel consumption values were established in accordance wi th Directive 80/1268/CEE. They may vary depending
o n t h e s t y l e o f d r i v i n g , t r a f fi c c o n d i t i o n s , w e a t h e r c o n d i t i o n s , t h e l o a d i n t h e v e h i c l e , t h e m a i n t e n a n c e o f t h e v e h i c l e a n d
the use of accessories.
Quality of the fuel used for Diesel engines
The Diesel engines are perfectly compatible with biofuels w hich conform to current and future European standards (diesel
f u e l w h i c h c o m p l i e s w i t h s t a n d a r d E N 5 9 0 m i x e d w i t h a b i o f u e l w h i c h c o m p l i e s w i t h s t a n d a r d E N 1 4 2 1 4 ) w h i c h c a n b e
d i s t r i b u t e d a t t h e p u m p s ( p o s s i b l e i n c o r p o r a t i o n o f 0 t o 7 % F a t t y A c i d M e t h y l E s t e r ) .
The use of any other type of (bio) fuel (vegetable or animal oils, domestic fuel...) is strictly prohibited (risk of damage to
the engine and fuel circuit).
Page 295 of 306
156
10
C H E C K S HDi 173 -
V6 HDi 240 engines
(with particle filter)
1. Screen wash and headlamp
wash reservoir.
2. Power steering and suspension
fl u i d r e s e r v o i r .
3. Engine coolant reservoir.
4. Engine oil dipstick.
5. E n g i n e o i l fi l l e r c a p .
6. A i r fi l t e r .
7. B r a k e fl u i d r e s e r v o i r .
8. Battery.
9. "+" and "-" terminals for starting
with a slave battery.
The diesel fuel system
being under high pres-
sure:
- Any intervention on the system
is prohibited.
- HDi engines are the result of advanced technology.
Any intervention requires spe-
c i a l q u a l i fi c a t i o n s w h i c h o n l y a
CITROËN dealer can guarantee.
HDi 173
V6 HDi 240
Page 302 of 306
197
12
T E C H N I C A L D A T A
MODELS:
ENGINES AND GEARBOXES
Model codes:
RD... RW....
9HZC
9HZC/1
RHF8 RHRJ
4HTH
4HPH
X8ZA
DIESEL ENGINES
1.6 litre HDi 110 hp
2 litre HDi
140 hp
2 litre HDi
138 hp
2.2 litre HDi 173 hp
3 litre V6 HDi 240 hp
Cubic capacity (cc) 1 560 1 997 2 179 2 992
Bore x stroke (mm) 75 x 88.3 85 x 88 85 x 96 84 x 90
EU standard maximum power (kW) 80 103 100 125 177
Maximum power engine speed (rpm) 4 000 4 000 4 000 3 800
EU standard maximum torque (Nm) 240 320 370 450
Maximum torque engine speed (rpm) 1 750 2 000 1 500 1 600
Fuel Diesel Diesel Diesel Diesel
Catalytic converter Yes Yes Yes Yes
P a r t i c l e e m i s s i o n fi l t e r ( P E F ) Yes Yes Yes Yes
GEARBOXES Manual (5-speed) Manual
(6-speed) Auto.
(6-speed) Manual
(6-speed) Auto.
(6-speed)
OIL CAPACITIES (in litres)
E n g i n e ( w i t h fi l t e r r e p l a c e m e n t ) 3.75 5.25 5.25
-
Gearbox - Final drive 1.9 - - - -
During the year.