horn DACIA SUPERNOVA 2004 Workshop Manual

82B
HORN - ENGINE IMMOBILISER
82B - 49TABLE 2
vnx.su

82B
HORN - ENGINE IMMOBILISER
82B - 50TABLE 2
vnx.su

82B
HORN - ENGINE IMMOBILISER
82B - 51
If after a complete checking of the anti intrusion system,
the replacement of the E.C.U. anti
intrusion is required, proceed as follows:
- remove from the central console the tape recorder’s frame and the tape recorder pulling
backward but without disconnecting the tape recorder from the vehicle’s wiring;
- dismount by detaching the aeration grill located on the right side of the central console ;
- dismount the t wo screws attaching t he E CU support i n t he ri ght side of the climate
control unit;
- take off the anti intrusion ECU together with its support through the central zone of the
central console; - disconnect the 24 ways connector from the anti intrusion ECU proceeding as follows:
remove towards exterior the two blocking clips of the connector and then carefully pull out the
connector; - dismount carefully the two way connector from the anti intrusion ECU;
- dismount the two screw attaching the anti intrusion ECU on its support;
- proceed the in reverse order of the dismounting;
- check the proper operation of the anti intrusion system. DISMOUNTING – REMOUNTING
OF THE ANTI INTRUSION ECU
vnx.su

82B
HORN - ENGINE IMMOBILISER
82B - 52
If siren dismounting is required, proceed as follows:
- dismount the two attachment nuts of the siren on its support;
- pull carefully the blocking clip of the wire connector to the siren and then disconnect the
siren;
- connect to the siren the connector of the wiri ng, by pushing, until you hear a “click”
confirming the correct c onnecting, then mount the two attachment screws of the siren on the
support;
- check the proper operation of the anti intrusion system. SIR
EN DISMOUNTING –REMOUNTING
vnx.su

82B
HORN - ENGINE IMMOBILISER
82B - 53
The engine hood connector is dismounted as follows:
- easy pull the blocking clip of the wirin g connector and then disconnect the engine hood contact;
- press the blocking clips of the lateral sides of the contact;
- push upward the contact i n order to remove it from its place.
Mount the new contact in its support by downward pushing, until a “click” is heard, confirming
the correct connecting. Connect the wires connector to t he contact of the hood.
Check the proper operation of the hood contact and of the anti intrusion system. DISMOUNTING – REMOUNTING OF THE HOOD CONTACT
vnx.su

82B
HORN - ENGINE IMMOBILISER
82B - 54
NOTE
If the dismounting / remounting of t he front doors or hatchback contacts,
check aft er that , the correct operation of the anti intrusion system.
LEFT SIDE VOLUME SENSOR REPLACEMENT
If sensor replacement is required, proceed as follows:
- take out carefully the sensor from its support by detaching from clips;
- dismount the attachment screw of the sensor support on the front left pillar upholstery.
- dismount the three attachment screws of the upper upholstery of the front left pillar and
carefully remove the upholstery;
- carefully disconnect the sensor connector from the vehicle’s wiring;
- mount the new volume sensor and its support performing the above mentioned operations
in reverse order, and then checking the proper operation of the anti intrusion system.
AT TENT ION
Be sure that the v olume sensor mounted on the l eft side has marked the
letter “T ” on the red colour collar.
Mo unt the volume sensor in such way, to be oriented towards the back of the vehicle,
parallel wi th the side windows.
RIGHT SIDE VOLUME SENSOR REPLACEMENT
If sensor replacement is required, proceed as follows:
- take out carefully the sensor from its support by detaching from clips;
- dismount the attachment screw of the sensor support on the front right pillar upholstery.
- dismount the three attachment screws of the upper upholstery of the front right pillar and
carefully remove the upholstery; - carefully disconnect the sensor connector from the vehicle’s wiring;
- mount the new volume sensor and its support performing the above mentioned operations
in reverse order, and then checking the proper operation of the anti intrusion system.
AT TENT ION
Be sure that the volume sensor mounted on the right side has marked t he l etter
“R” on the white colour collar. Mo unt the volume sensor in such way, to be oriented t owards the bac k of the v ehicle,
parallel wi th the side windows.
V OLUME SENSOR DISMOUNTING – REMOUNTING
vnx.su

89A
ELECTRICAL DIAGRAMS
89A - 13
191
192
193
194
195
196
199
205
209
210
212Cooling blower low speed control relay
Ignition coil
FLASH relay
Hatchback contact separation diode
Upstream oxygen sensor
C
hock sensor
Anti-intrusion indicator LED
Braking system ICP
AC pressure sensor (pressure controller)
Front ashtray lighting
Climate control blower control relay
700
778
857
871
887
927
993
109 1
120 2
133 5
142 8Right front door loud speaker
Left front door loud speaker
Injector 1
Injector 2
Injector 3
Injector 4
Fuel level transmitter and electric pump
Oil pressure contact
Lights, turning lights and horn switch
Electronic clock
Windscreen wiper motor
ELECTRIC COMPONENTS INDEX
vnx.su

89A
ELECTRICAL DIAGRAMS
89A - 25
196 INJECTOR 489-106
199 FU EL LEVEL TRANSMITTER AND ELECTRIC PUMP 89-146
200 REAR WINDOW DEFROSTING 89-149
205 OIL PRESSUR E CONTAC T 89-98
209 CLIGHTS, TURNING LIGHTS, HORN SWITCH 89-114
210 ELECTRONIC CLOC K 89-128
212 WINDSCREEN WIPER MOTOR 89-112
216 RIGHT FRONT BRAKE PAD 89-127
217 LEFT FRONT BRAKE PAD 89-127
221 WINDSCREEN WASHING PUMP 89-125
222 VALVE POTENTIOMETER 89-104
225 DIAGNOSTIC SOCKET 89-135
226 RIGHT HEADLAMP 89-125
227 LEFT HEADLAMP 89-125
244 WATER TEMPERATURE SENSOR 89-99
247 INSTRUMENT PANEL 89-135
250 SPEED TRANSDUC ER 89-117
255 RIGHT FRONT TURNING LAMP 89-126
256 LEFT FRONT TURNING LAMP 89-126
260 COCKPIT FUSE AND RELAYS BOX 89-119
261 R ADIO 89-128
262 COOLING MOTOR FAN (for vehicles with AC) 89-107
267 RIGHT SIDE SIGNALING LAMP 89-126
268 LEFT SIDE SIGNALING LAMP 89-127
272 INJECTION AIR TEMPERATURE SENSOR 89-103
298 CLIMATE CONTROL LIGHTING 89-131
319 AC STARTING BUTTON 89-131
321 MOTOR FAN RESISTANCE ( for vehicles with AC) 89-108
328 LEFT FRONT CEILING LAMP 89-149
329 RIGHT FRONT CEILING LAMP 89-149
371 CANISTER PURGING VALVE 89-101
427 UCE ANT I-INTRUSION 89-143
438 ENGINE HOOD CONTACT 89-118
442 SIREN 89-118
454 RIGHT VOLUMETRIC SENSOR(Rx) 89-142
454 LEFT VOLUMETRIC SENSOR (Tx) 89-142
474 AC R ELAY (on board) 89-129
503 UCE DECODER 89-115
560 HATCHBAC K C ONTACT 89-146
597 ENGINE RELAYS AND FUSE BOX ( for vehicles without AC) 89-94
597 ENGINE RELAYS AND FUSE BOX ( for vehicles with AC) 89-96
600 CLIMATE CONTROL B LOWER 89-130
639 STOP-S3 LAMP (on roof) 89-150
639 STOP[ -S3 LAMP (in aileron) 89-150
649 STEP-BY-STEP ENGINE 89-103
654 ANTI-STARTING BUSHING 89-116
778 IGNITION COIL 89-100
857 FLASH RELAY 89-116
887 SUPSTREAM OXYGEN SENSOR 89-100
927 CHOCK SENSOR 89-102
993 ANTI-INTRUSION INDICATOR LED 89-142
WIRE FUNCTIONS INDEX IN CONNECTORS AND COUPLINGS
vnx.su

89A
ELECTRICAL DIAGRAMS
89A - 52
HORN, TURNING AND LIGHTS SWITCH
BA
X
M
B
A
X X
2 1
R C
FRONT WIRINGB41
01
B L
Position Sectioning Destination
A1 1,0 64C LEFT TURNING
LIGHTS CONTROL
A2 1,0 64B CONTROL + TURNING RELAY
A3 1,0 64D RIGHT TURNI NG LIGHTS CONTROL
B1 1,0B + BATTERY
B2 0,59M SHUNT > FOG LIGHTS SWITCH
B3 1, 0 67A CONTROL + ACOUSTIC W ARNING
Position Sectioning Destination
A1 0,75 L + PARKING LIGHTS > FUSE
INLET F05
A2 3,0 B + BATTERY
B1 0,75 C+ LOW BEAM LIGHTS
B2 0 , 75 R + HIGH BEAM LIGHTS
BA
M-AS
X
X
B
A
X
X X
32 1
67A 9M B
64D 64B 64C 209
209
CONNECTORS AND CONNECTIONS WIRES FUNCTION
vnx.su

89B
ELECTRIC DIAGRAMS
89B - 3
(After 01.06.2001)
21
101
102
103
104
105
107
113
120
121
122
123
124
125
128
137
138
139
140
141
145
146
147
149
155
156
160
163
168
171
172
173
175
176
177
180
181
184
185
188
189
190
191
192
193
194
195
196
199
205
209
210
212Right signalling anti-return diode
Electric lighter
Ashtr a y
Alternator
Anti-theft system
Acoustic alarm
Battery
Windscreen wiper timer
Injection computer (UCE)
Fog lights switch
Fog headlights switch
Door closing switch
Climate blower switch
Hazard switch
Rear window defrosting switch
Turning signalling relay
Right rear door actuator
Left rear door actuator
Left front door actuator
Right front door actuator
Windscreen wiper-washer switch
Detona tion sensor
Atmospheric pressure sensor
RPM se nsor
Reverse driving contact
Handbrake contact
St op contact
Starte r
Documents compartment lighting lamp
AC compressor clutch
Right rear lamp
Left rear lamp
Left fog lamp
Right fog headlight
Left fog headlight
Left front door contact
Right front door contact
Right front parking lamp
Left front parking lamp
Cooling motor fan
Right rear loud speaker
Left rear loud speaker
Right front door loud speaker
Left front door loud speaker
Injector 1
Injector 2
Injector 3
Injector 4
Fuel level transmitter and electric pump
Oil pressure contact
Lights, turning lights and horn switch
Electronic clock
Windscreen wiper motorRight front brake pad
Left front brake pad
Windscreen washing pump
Va l ve potentiometer
Diagnostic socket
Right headlamp
Left headlamp
Fog lamps relay
Fog headlights control relay
Cooling motor fan control relay
Fuel pump control relay
Actuators relay
Injection water temperature sensor
Instrument panel
Ve hicle speed transducer
Right front turning lamp
Left front turning lamp
Cockpit fuse and relays box
Radio
Cooling motor fan and AC
Right side signalling lamp
Left side signalling lamp
Injection air temperature sensor
Rear window defrosting timer
Climate control lighting
AC starting button
Motor fan resistance ( f or AC)
Right front ceiling lamp
Canister purging valve
UCE anti-intrusion
Engine hood contact
Siren
Vo l u metric sensor
AC relay ( on board)
UCE decoder
AC compressor clutch control relay
Engine compartment fuse and relays box
Climate control blower
STOP-S3 l amp
St ep-by-step engine
Anti-starting bushing
Cooling blower low speed control relay
Ignition coil
FLASH relay
Upstream oxygen sensor
C hock sensor
Anti-intrusion indicator LED
Braking system ICP
AC pressure sensor (pressure controller)
Front ashtray lighting
Climate control blower control relay
216
217
221
222
225
226
227
230
231
234
236
238
244
247
250
255
256
260
261
262
267
268
272
294
298
319
321
329
371
427
438
442
454
474
503
584
597
600
639
649
654
700
778
857
887
927
993
109 1
120 2
133 5
142 8
CODE COMPONENT DENOMINATIONCODE COMPONENT DENOMINATION
ELECTRIC COMPONENTS INDEX
vnx.su