brake DODGE CALIBER SRT 2008 1.G Owner's Guide

WARNING!
Use of a brake fluid that may have a lower initial
boiling point or unidentified as to specification, may
result in sudden brake failure during hard prolonged
braking. You could have an accident.
CAUTION!
Use of improper brake fluids will affect overall
clutch system performance. Improper brake fluids
may damage the clutch system resulting in loss of
clutch function and the ability to shift the transaxle.
WARNING!
Overfilling the brake fluid reservoir can result in
spilling brake fluid on hot engine parts and the
brake fluid catching fire.
Use only brake fluid that has been in a tightly closed
container to avoid contamination from foreign matter.
Do not allow petroleum based fluid to contaminate the
brake fluid as seal damage will result!
Manual Transaxle
Lubricant Selection
Use only the manufacturers recommended transmission
fluid. Refer to ªFluids, Lubricants, and Genuine Partsº
for correct fluid type.
MAINTAINING YOUR VEHICLE 317
7

Seat Belt Maintenance
Do not bleach, dye or clean the belts with chemical
solvents or abrasive cleaners. This will weaken the fabric.
Sun damage can also weaken the fabric.
If the belts need cleaning, use a mild soap solution or
lukewarm water. Do not remove the belts from the car to
wash them.
Replace the belts if they appear frayed or worn or if the
buckles do not work properly.
Dry with a soft tissue.
FUSES/INTEGRATED POWER MODULE (IPM)
An Integrated Power Module is located in the engine
compartment near the air cleaner assembly. This center
contains cartridge fuses and mini fuses. A label that
identifies each component may be printed on the inside
of the cover. Refer to ªEngine Compartmentº in this
section of the owner's manual for the underhood location
of the Integrated Power Module (IPM).
Cavity Cartridge
FuseMini
FuseDescription
1 Empty Empty
2 15 Amp
Lt. BlueAWD/4WD ECU
Feed
3 10 Amp
RedCHMSL Brake Switch
Feed
4 10 Amp
RedIgnition Switch Feed
5 20 Amp
YellowTrailer Tow
MAINTAINING YOUR VEHICLE 323
7

Chassis
Component Fluids, Lubricants and Genuine Parts.
Manual Transaxle Fluid MopartATF+4 MS9602
Brake Master Cylinder MopartDOT 3, SAE J1703 should be used. If DOT 3, SAE J1703 brake fluid
is not available, then DOT 4 is acceptable. Use only recommended brake flu-
ids or equivalent.
Power Steering Reservoir MopartPower Steering Fluid +4 or MopartATF+4 Automatic Transmission
Fluid.
MAINTAINING YOUR VEHICLE 335
7

²Check the fluid levels of coolant reservoir, brake
master cylinder, power steering and transmission and
add as needed.
²Check all lights and other electrical items for correct
operation.At Each Oil Change
²Change the engine oil filter.
²Inspect the brake hoses and lines.
²Check the Manual Transmission fluid level.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
340 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Required Maintenance Intervals
Perform Maintenance Every(Where time and mileage
are listed, follow the interval that occurs first.)
Maintenance Items Miles Kilometers or Months
Change the engine oil and engine oil filter. 6,000 10 000 6
Rotate Tires. 6,000 10 000 6
If using your vehicle for any of the following: Dusty
or off-road conditions. Inspect the engine air cleaner
filter, replace if necessary.12,000 20 000 12
Inspect the brake linings, replace if necessary. 12,000 20 000 12
Replace the air conditioning filter. 12,000 20 000 12
Inspect the CV Joints. Perform the first inspection at
12,000 miles (20 000 km) or 12 months.24,000 40 000 24
Inspect Exhaust System. Perform the first inspection at
12,000 miles (20 000 km) or 12 months.24,000 40 000 24
Inspect the front suspension, tie rod ends and boot
seals, replace if necessary.24,000 40 000 24
Replace the engine air cleaner filter. 30,000 50 000 30
MAINTENANCE SCHEDULES 341
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

ABS (Anti-Lock Brake System).............. 231
Adding Engine Coolant (Antifreeze).......... 311
Adding Fuel........................... 268
Adding Washer Fluid.................. 118,147
Additives, Fuel......................... 266
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . 302
Air Conditioner Maintenance............... 304
Air Conditioning Controls................. 213
Air Conditioning, Operating Tips............ 218
Air Conditioning Refrigerant.............304,305
Air Conditioning System................213,304
Air Pressure, Tires....................... 247
Airbag................................ 44
Airbag Deployment....................... 52
Airbag Light.......................54,66,158
Airbag Maintenance....................... 53
Airbag, Side............................ 50
Airbag, Window (Side Curtain)............... 45
Alarm System (Security Alarm)............28,158Alignment and Balance................... 253
Alterations/Modifications, Vehicle............. 7
Antenna, Satellite Radio................... 208
Antifreeze (Engine Coolant)...........310,333,334
Capacities........................... 333
Disposal............................ 312
Anti-Lock Brake System (ABS)............128,231
Anti-Theft Security Alarm (Theft Alarm)........ 28
Appearance Care........................ 318
Automatic Door Locks...................19,20
Ball Joints............................. 306
Battery............................... 302
Keyless Transmitter Replacement (RKE)....... 27
Belts, Drive............................ 299
Beverage Cooler........................ 148
Body Mechanism Lubrication............... 306
B-Pillar Location........................ 242
Brake Assist System...................... 130
356 INDEX

Brake Control System, Electronic............. 129
Brake Fluid............................ 335
Brake, Parking.......................... 228
Brake System........................230,315
Anti-Lock (ABS)....................128,231
Hoses.............................. 315
Master Cylinder....................... 316
Parking............................. 228
Warning Light........................ 161
Brakes.............................230,315
Break-In Recommendations, New Vehicle........ 65
Bulb Replacement....................... 327
Bulbs, Light............................ 327
Calibration, Compass..................... 178
Capacities, Antifreeze (Engine Coolant)........ 333
Capacities, Fluid........................ 333
Caps, Filler
Fuel................................ 268Oil (Engine).......................291,298
Car Washes............................ 319
Carbon Monoxide Warning................. 267
Cargo Area Cover....................... 143
Cargo Area Features...................... 141
Cargo Compartment
Light............................... 141
Luggage Carrier....................... 148
Cargo Light............................ 141
Cargo Load Floor........................ 144
Cargo Tie-Downs........................ 144
Carrier, Luggage........................ 148
Catalytic Converter...................... 300
Caution, Exhaust Gas...................... 65
CD (Compact Disc) Player...............181,188
CD (Compact Disc) Player Maintenance........ 211
Cellular Phone........................76,211
Center High Mounted Stop Light............ 332
Chains, Tire............................ 253
INDEX 357
10

Customer Assistance..................... 347
Data Recorder, Event...................... 54
Dealer Service.......................... 295
Defroster, Rear Window................... 147
Defroster, Windshield...................66,214
Delay (Intermittent) Wipers................. 117
Diagnostic System, Onboard................ 292
Dimmer Switch, Headlight................. 114
Disposal
Antifreeze (Engine Coolant)............... 312
Engine Oil........................... 299
Door Locks............................. 17
Door Locks, Automatic.................... 19
Door Opener, Garage..................... 122
Downshifting.......................... 227
Drive Belts............................ 299
Driver's Seat Back Tilt.................... 105Driving
On Slippery Surfaces.................... 234
Through Flowing, Rising, or Shallow Standing
Water................................ 235
Electric Remote Mirrors.................... 74
Electrical Power Outlets................... 138
Electronic Brake Control System............. 129
Brake Assist System.................... 130
Electronic Stability Program............... 131
Traction Control System................. 129
Electronic Speed Control (Cruise Control)....... 119
Electronic Stability Program (ESP)............ 131
Electronic Vehicle Information Center (EVIC).... 166
Emergency, In Case of
Jump Starting......................... 284
Towing............................. 287
Emission Control System Maintenance......293,338
Engine.............................65,291
INDEX 359
10

Break-In Recommendations................ 65
Checking Oil Level..................... 296
Cooling............................. 309
Exhaust Gas Caution.................... 267
Fuel Requirements..................... 264
Jump Starting......................... 284
Oil ...........................296,333,334
Oil Change Interval.................... 297
Oil Filler Cap......................291,298
Oil Filter............................ 334
Oil Selection.......................... 297
Operation............................ 65
Overheating.......................... 274
Temperature Gauge..................... 157
Enhanced Accident Response Feature.......... 53
Ethanol............................... 265
Event Data Recorder...................... 54
Exhaust Gas Caution..............31,65,267,308
Exhaust System......................... 308Filler Location Fuel...................... 157
Filters
Air Cleaner.......................... 302
Engine Fuel.......................... 302
Engine Oil........................299,334
Flashers.............................. 274
Hazard Warning....................... 274
Turn Signal.......................... 328
Flooded Engine Starting................... 225
Fluid, Brake........................... 335
Fluid Capacities......................... 333
Fluid Leaks............................. 67
Fluids................................ 334
Fluids, Lubricants and Genuine Parts.......... 334
Fog Lights....................... 113,162,328
Folding Rear Seat........................ 107
Folding Rear Seat (Sedan).................. 107
Freeing A Stuck Vehicle................... 286
Fuel..............................264,334
360 INDEX

Key-In Reminder......................... 12
Keyless Entry System (Sedan)................ 22
Keys................................. 12
Lane Change and Turn Signals...........162,328
Lap/Shoulder Belts....................... 33
Latches
Hood............................... 109
Lead Free Gasoline...................... 264
Life of Tires............................ 251
Liftgate (Sedan).......................... 29
Liftgate Window Wiper/Washer............. 146
Light Bulbs............................ 327
Lights..............................67,110
Airbag..........................54,66,158
Back-Up............................. 328
Brake Warning........................ 161
Bulb Replacement...................... 327
Cargo .............................. 141Center Mounted Stop................... 332
Daytime Running...................... 115
Dimmer Switch, Headlight................ 111
Electronic Stability Program (ESP)
Indicator...........................131,133
Engine Temperature Warning.............. 159
Fog .......................... 113,162,328
Headlight Switch...................... 111
Headlights........................... 111
High Beam Indicator.................... 165
Instrument Cluster..................... 111
License............................. 331
Lights On Reminder.................... 112
Low Fuel............................ 158
Malfunction Indicator (Check Engine)........ 164
Map Reading......................... 110
Oil Pressure.......................... 159
Seat Belt Reminder..................... 158
Security Alarm (Theft Alarm).............. 29
INDEX 363
10