light DODGE CARAVAN 2004 4.G Owners Manual

Rear Tail, Stop, Turn Signal, Side Marker and
Back-up Lights
1. Raise the liftgate.
2. Remove the two light assembly push-in type fasteners.
3. Squeeze the socket assembly tabs to remove it from the
housing.4. Pull the bulb to remove it from the socket.
5. Replace the bulb, reinstall the socket, and reattach the
light assembly.
342 MAINTAINING YOUR VEHICLE

Center High Mounted Stop Light (CHMSL)
1. Remove the two screws securing the CHMSL.
2. Twist the bulb socket to remove from the CHMSL
housing.
3. Pull the bulb out of the socket.
4. Replace the bulb, reinstall the socket and reattach the
CHMSL.
License Light
1. Remove the two lens assembly mounting screws.
2. Pull the bulb out of the socket. Replace the bulb and
reattach the lens assembly.
FLUID CAPACITIES
U.S. Metric
Fuel (Approximate)20 Gallons 76 Liters
Engine Oil-with filter
2.4 Liter Engine 5.0 qts 4.7 Liters
3.3 & 3.8 Liter Engines 5.0 qts 4.7 Liters
Cooling System *
2.4 Liter Engines 11.4 qts 10.7 Liters
² 3.3 & 3.8 Liter Engines 13.4 qts 12.6 Liters
* Includes heater and coolant recovery bottle filled to
MAX level.
² * Add 2.9 quarts (2.8 liters) if equipped with a rear
heater.
MAINTAINING YOUR VEHICLE 343
7

²Taxi, police, or delivery service (commercial ser-
vice).L
²Off-road or desert operation.
NOTE:Most vehicles are operated under the conditions
listed for Schedule9B9.
Second is ScheduleªAº. It is for vehicles that are not
operated under any of the conditions listed under Sched-
ule9B9.
Use the schedule that best describes your driving condi-
tions. Where time and mileage are listed, follow the
interval that occurs first.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
At Each Stop for Fuel
²Check the engine oil level about 5 minutes after a fully
warmed engine is shut off. Checking the oil level while
the vehicle is on level ground will improve the accu-
racy of the oil level reading. Add oil only when the
level is at or below the ADD or MIN mark.
²Check the windshield washer solvent and add if
required.
Once a Month
²Check tire pressure and look for unusual wear or
damage.
²Inspect the battery and clean and tighten the terminals
as required.
²Check the fluid levels of coolant reservoir, brake
master cylinder and transmission; add as needed.
²Check all lights and all other electrical items for correct
operation.
MAINTENANCE SCHEDULES 349
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Contract, and you require service after your manufactur-
er's new vehicle limited warranty expires, please refer to
your contract documents, and contact the person listed in
those documents.
We appreciate that you have made a major investment
when you purchased your new vehicle. Your dealer has
also made a major investment in facilities, tools, and
training to assure that you are absolutely delighted with
your ownership experience. You'll be pleased with their
sincere efforts to resolve any warranty issues or related
concerns.
WARRANTY INFORMATION
See your manufacturer's Warranty Information Booklet
for information on warranty coverage and transfer of
warranty.
MOPARTPARTS
Mopartfluids, lubricants, parts, and accessories are
available from your dealer. They will help you keep your
vehicle operating at its best.
IF YOU NEED CONSUMER ASSISTANCE 375
9

Adding Fuel........................... 270
Adding Washer Fluid..................221,316
Additives, Fuel......................... 268
Adjustable Pedals....................... 106
Air Conditioner Maintenance............... 312
Air Conditioning.....................199,203
Air Conditioning Controls................. 199
Air Conditioning Filter.................219,313
Air Conditioning, Operating Tips............ 218
Air Conditioning, Rear Zone.............206,214
Air Conditioning Refrigerant............... 312
Air Conditioning System..........199,203,208,312
Air Conditioning System, Zone Control........ 200
Air Pressure, Tires....................... 252
Airbag................................ 48
Airbag Deployment....................... 55
Airbag Light.....................52,57,72,152
Airbag Maintenance....................... 57
Airbag, Side............................ 54Alarm Light........................... 154
Alarm System........................... 26
Alignment and Balance................... 258
All Wheel Drive...................235,259,329
Alterations/Modifications, Vehicle............. 7
Antifreeze Disposal...................... 321
Antifreeze (Engine Coolant)..............319,320
Anti-Lock Brake System................... 237
Anti-Lock Warning Light.................. 153
Anti-Theft Security Alarm.................. 26
Appearance Care........................ 330
Ashtray............................... 130
Auto Down Power Windows................ 37
Automatic Dimming Mirror................. 77
Automatic Door Locks..................... 19
Automatic Headlights.................... 100
Automatic Temperature Control............. 208
Automatic Transaxle...................231,326
Adding Fluid......................... 345
382 INDEX

Filter............................... 328
Fluid and Filter Changes................. 328
Fluid Level Check...................... 327
Interlock System....................... 232
Reset Mode.......................... 233
Selection Of Lubricant................326,345
Shifting............................. 233
Special Additives...................... 329
Ball Joints............................. 314
Battery............................... 311
Gas Caution.......................... 311
Jump Starting......................... 288
Keyless Transmitter Replacement............ 25
Saving Feature........................ 101
Bearings.............................. 330
Belts, Drive............................ 307
Body Mechanism Lubrication............... 315
B-Pillar Location........................ 247Brake, Parking.......................... 235
Brake System........................237,323
Anti-Lock........................... 237
Fluid Check.......................324,345
Hoses.............................. 323
Warning Light........................ 151
Brake/Transmission Interlock............... 232
Break-In Recommendations, New Vehicle........ 70
Bulb Replacement....................... 339
Bulbs, Light............................ 338
Calibration, Compass..................... 112
Capacities, Fluid........................ 343
Caps, Filler
Fuel................................ 270
Radiator............................ 320
Car Washes............................ 331
Carbon Monoxide Warning................. 269
Cargo ................................ 135
INDEX 383
10

Cargo Compartment
Luggage Carrier....................... 139
Cassette Tape and Player Maintenance......... 197
Cassette Tape Player..................... 161
Catalytic Converter...................... 309
CD Changer......................170,182,187
CD Player...............167,171,174,178,180,187
Center High Mounted Stop Light............ 343
Center Lap Belts......................... 47
Chains, Tire............................ 263
Changing A Flat Tire..................... 282
Child Restraint.......................... 58
Child Restraint Tether Anchors............... 62
Child Safety Locks........................ 32
Child Seat............................58,64
Clean Air Gasoline....................... 266
Climate Control......................... 199
Clock................................ 159
Compact Disc Maintenance................. 198Compact Disc Player..................161,167
Compact Spare Tire...................... 255
Compass.............................. 111
Compass Calibration..................... 112
Compass Variance....................... 112
Computer, Trip/Travel.................... 114
Console, Overhead....................... 110
Console, Removable...................... 132
Contract, Service........................ 374
Coolant Pressure Cap..................... 320
Cooling System......................... 318
Adding Coolant (Antifreeze).............. 320
Coolant Capacity...................... 343
Coolant Level......................... 321
Disposal of Used Coolant................ 321
Drain, Flush, and Refill.................. 319
Inspection........................... 318
Points to Remember.................... 321
Pressure Cap......................... 320
384 INDEX

Radiator Cap......................... 320
Selection of Coolant..................319,344
Cruise Control.......................... 107
Cruise Light........................... 157
Cup Holder.........................129,334
Customer Assistance..................... 372
Daytime Running Lights................... 101
Dealer Service.......................... 302
Defroster, Rear Window................... 222
Defroster, Windshield................72,203,213
Digital Video Disc Player.................. 187
Dimmer Control......................... 99
Dipsticks
Automatic Transaxle.................... 327
Disposal
Antifreeze........................... 321
Domelight............................. 99
Door Ajar Light......................... 151Door Locks............................. 17
Door Locks, Automatic.................... 19
Door Opener, Garage..................... 119
Drive Belts............................ 307
Drive Shaft Universal Joints................ 315
Driving
On Slippery Surfaces.................... 290
DVD Player............................ 187
Electric Remote Mirrors.................... 79
Electrical Power Outlets................... 127
Electronic Speed Control................... 107
Electronic Vehicle Information Center.......... 115
Emergency, In Case of
Jacking............................. 282
Overheating.......................... 281
Emission Control System Maintenance......301,348
Engine............................298,299
Air Cleaner.......................... 309
INDEX 385
10

Air Cleaner Filter...................... 308
Block Heater......................... 230
Break-In Recommendations................ 70
Checking Oil Level..................... 303
Compartment......................298,299
Coolant............................. 344
Cooling............................. 318
Exhaust Gas Caution..................36,269
Fails to Start.......................227,229
Fuel Requirements..................... 266
Oil ..............................303,344
Oil Change Interval.................... 305
Oil Selection.......................... 305
Oil Synthetic......................... 307
Overheating.......................... 281
Temperature Gauge..................... 154
Exhaust Gas Caution..............36,71,269,317
Exhaust System......................... 317
Exterior Folding Mirrors................... 78Filters
Air Cleaner.......................... 308
Air Conditioning....................219,313
Automatic Transaxle.................... 328
Engine Fuel.......................... 309
Engine Oil........................307,344
Engine Oil Disposal.................... 307
Flashers
Hazard Warning....................... 280
Turn Signal..................158,159,340,342
Fluid Capacities......................... 343
Fluid Leaks............................. 72
Fluid Level Checks
Automatic Transaxle.................... 327
Brake............................... 345
Power Steering.....................314,345
Fog Light Service........................ 341
Fog Lights..........................102,341
Freeing A Stuck Vehicle................... 291
386 INDEX

Fuel................................. 266
Adding............................. 270
Additives............................ 268
Clean Air............................ 266
Filler Cap............................ 270
Filter............................... 309
Gasoline............................ 266
Gauge.............................. 151
Hoses.............................. 326
Light............................... 151
Octane Rating......................266,344
Requirements......................... 266
Tank Capacity........................ 343
Fueling............................... 270
Fuses................................ 336
Garage Door Opener..................... 119
GasCap .............................. 270
Gasoline.............................. 266Gasoline, Clean Air...................... 266
Gasoline, Reformulated................... 267
Gauges
Coolant Temperature.................... 154
Fuel................................ 151
Speedometer......................... 151
Tachometer.......................... 153
Gearshift.............................. 233
General Information..................16,25,263
Glass Cleaning.......................... 333
Grocery Bag Retainer...................... 91
Gross Axle Weight Rating.................. 273
Gross Vehicle Weight Rating................ 273
Hazard Warning Flasher................... 280
Head Phones........................... 192
Head Restraints.......................... 82
Headlights............................. 99
Bulb Replacement...................... 339
INDEX 387
10