tow DODGE DURANGO 2004 2.G Workshop Manual

MAINTENANCE SCHEDULES
There are two maintenance schedules that show the
requiredservice for your vehicle.
First is ScheduleªBº. It is for vehicles that are operated
under the conditions that are listed below and at the
beginning of the schedule.
²Day or night temperatures are below 32É F (0É C).
²Stop and go driving.
²Extensive engine idling.
²Driving in dusty conditions.
²Short trips of less than 10 miles (16 km).
²More than 50% of your driving is at sustained high
speeds during hot weather, above 90É F (32É C).
²Trailer towing.
²Taxi, police, or delivery service (commercial service).
²Off-road or desert operation.
²If equipped for and operating with E-85 (ethanol)
fuel.
NOTE:IfANYof these apply to you then change your
engine oil every 3,000 miles (5 000 km) or 3 months,
whichever comes first and follow schedule ªBº of the
9Maintenance Schedules9section of this manual.
NOTE:Most vehicles are operated under the conditions
listed for Schedule9B9.
Second is ScheduleªAº. It is for vehicles that are not
operated under any of the conditions listed under Sched-
ule9B9.
Use the schedule that best describes your driving condi-
tions. Where time and mileage are listed, follow the
interval that occurs first.
NOTE:Under no circumstances should oil change in-
tervals exceed 6000 miles (10 000 km) or 6 months
whichever comes first.
MAINTENANCE SCHEDULES 341
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Schedule ªBº
Follow schedule ªBº if you usually operate your vehicle
under one or more of the following conditions.
²Day or night temperatures are below 32É F (0É C).
²Stop and go driving.
²Extensive engine idling.
²Driving in dusty conditions.
²Short trips of less than 10 miles (16 km).
²More than 50% of your driving is at sustained high
speeds during hot weather, above 90É F (32É C).
²Trailer towing.
²Taxi, police, or delivery service (commercial service).
²Off-road or desert operation.
²If equipped for and operating with E-85 (ethanol)
fuel.
NOTE:IfANYof these apply to you then change your
engine oil every 3,000 miles (5 000 km) or 3 months,
whichever comes first and follow schedule ªBº of the
9Maintenance Schedules9section of this manual.
SCHEDULE ªBº 343
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 48,000 51,000 54,000 57,000 60,000
(Kilometers) (77 000) (82 000) (86 000) (91 000) (96 000)
Change engine oil and engine oil filter. X X X X X
Rotate tires. X X X
Change rear axle fluid.X
Change front axle fluid (4X4).X
Inspect brake linings. X
Inspect engine air cleaner filter, replace if necessary.X
Replace spark plugs.X
Inspect PCV valve, replace as necessary.*X
Inspect and replace ignition cables if necessary (5.7L only).X
Inspect auto tension drive belt and replace if required. X
Drain and refill automatic transmission fluid, change filter
(3.7L). This applies only if your vehicle is used for police,
taxi, fleet, or trailer towing.X
Drain and refill automatic transmission fluid and change
main sump filter (4.7L/5.7L only).X
Inspect transfer case fluid (4X4).X
SCHEDULE ªBº 347
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 105,000 108,000 111,000 114,000 117,000 120,000
(Kilometers) (168 000) (173 000) (178 000) (182 000) (187 000) (192 000)
Drain and refill automatic transmission fluid,
change filter (3.7L). This applies only if your
vehicle is used for police, taxi, fleet, or trailer
towing.X
Drain and refill automatic transmission fluid
and change main sump filter (4.7L/5.7L only).X
* This maintenance is recommended by the manufacture
to the owner but is not required to maintain the emis-
sions warranty.
³ This maintenance is not required if previously replaced.Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
352 SCHEDULE ªBº
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Daytime Running Lights................... 107
Dealer Service.......................... 291
Defroster, Rear Window................... 195
Defroster, Windshield................63,182,187
Delay Wipers........................... 110
Diagnostic System, Onboard................ 289
Dimmer Switch, Headlight................. 147
Dipsticks
Automatic Transmission................. 316
Oil (Engine).......................... 292
Power Steering........................ 303
Disarming, Theft System................... 25
Disc Brakes............................ 313
Disposal
Used Coolant......................... 308
Door Ajar Light......................... 151
Door Locks............................. 13
Door Opener, Garage..................... 126
Drive Belts............................ 297Drive Shaft Universal Joints................ 304
Electric Remote Mirrors.................... 72
Electrical Power Outlets................... 135
Electronic Speed Control................... 116
Emergency, In Case of
Freeing Vehicle When Stuck............... 221
Jacking............................. 275
Overheating.......................... 310
Towing............................. 282
Emission Control System Maintenance......... 340
Emission Related Components.............. 311
Engine
Air Cleaner.......................... 298
Block Heater......................... 202
Break-In Recommendations................ 62
Compartment......................287,288
Coolant..........................308,337
Cooling............................. 306
INDEX 373
10

Exhaust Gas Caution..................62,248
Fails to Start.......................... 201
Flooded, Starting...................... 201
Fuel Requirements..................... 335
Jump Starting......................... 280
Oil ...........................292,335,337
Oil Selection.......................... 335
Oil Synthetic......................... 296
Overheating.......................... 310
Starting............................. 200
Temperature Gauge..................... 146
Engine Oil Viscosity Chart................. 295
Entry System, Illuminated.................. 13
Equipment Identification Plate.............. 267
Ethylene Glycol Antifreeze................. 308
Exhaust Gas Caution................62,248,306
Exhaust System.......................62,306
Extender, Seat Belt........................ 37
Exterior Lighting........................ 106Filters
Air Cleaner.......................... 298
Engine Fuel.......................... 299
Engine Oil........................297,337
Engine Oil Disposal.................... 296
Flashers
Hazard Warning....................... 270
Turn Signal.....................108,146,329
Flat Tire Stowage.....................273,279
Flooded Engine Starting................... 201
Floor Console.......................... 137
Fluid, Brake........................... 338
Fluid Capacities......................... 335
Fluid Level Checks
Automatic Transmission................. 316
Brake............................... 313
Cooling System....................... 306
Engine Oil........................... 292
Power Steering........................ 303
374 INDEX

Headlights............................ 327
Delay.............................. 106
High Beam........................... 109
High Beam/Low Beam Select Switch........ 109
Lights On Reminder.................... 107
Passing............................. 109
Replacing............................ 327
Heated Mirrors.......................... 73
Heated Seats............................ 90
Heater.............................179,184
Heater, Engine Block..................... 202
High Beam Indicator..................... 147
High Beam/Low Beam Select Switch.......... 109
Hitches
Trailer Towing........................ 257
Homelink Transmitter.................... 126
Hood Release.......................... 102
Hoses................................ 311Ignition............................... 12
Key ................................. 9
Lock................................ 12
Illuminated Entry........................ 13
Infant Restraint........................50,51
Inflation Pressure Tires.................... 239
Inside Rearview Mirror.................... 70
Instrument Cluster....................... 146
Instrument Panel and Controls.............. 144
Instrument Panel Lens Cleaning............. 324
Interior Appearance Care.................. 323
Interior Lighting........................ 104
Interior Lights.......................... 104
Intermittent Wipers...................... 110
Introduction............................. 4
Jack Operation.......................272,275
Jacking Instructions...................... 276
376 INDEX

Reclining Front Seats...................... 87
Recommended Fluids, Lubricants and Genuine
Parts............................... 337
Recreational Towing...................... 262
Shifting into Transfer Case Neutral (N)....... 263
Shifting out of Transfer Case Neutral (N)..... 265
Reformulated Gasoline.................... 243
Refrigerant............................ 303
Release, Hood.......................... 102
Reminder, Seat Belt....................... 35
Remote Keyless Entry..................... 19
Remote Sound System Controls.............. 177
Replacement Keys........................ 10
Replacement Parts....................... 291
Replacement Tires....................... 237
Reporting Safety Defects................... 365
Restraints, Child.......................50,55
Restraints, Occupant...................... 28
Rocking Vehicle When Stuck................ 221Roof Type Carrier....................... 139
Rotation, Tires.......................... 241
Safety Checks Inside Vehicle................. 63
Safety Checks Outside Vehicle............... 64
Safety Defects, Reporting.................. 365
Safety Information, Tire................... 221
Safety Tips............................. 62
Satellite Radio.......................... 173
Satellite Radio Antenna................... 176
Schedule, Maintenance.................... 341
Seat Belt Maintenance.................... 324
Seat Belt Reminder....................... 35
Seat Belts............................28,29
And Pregnant Women................... 37
Child Restraint.......................50,61
Extender............................. 37
Front Seat............................ 29
Inspection............................ 63
INDEX 381
10

Jacking............................. 275
Load Capacity.....................226,227
Radial.............................. 234
Replacement......................... 237
Rotation............................. 241
Safety...........................221,230
Sizes............................... 223
Snow Tires........................... 240
Spare Tire........................... 273
Spinning............................ 236
Tread Wear Indicators................... 236
Wheel Mounting....................... 275
Wheel Nut Torque..................... 278
Tongue Weight/Trailer Weight.............. 256
Torque Converter Clutch.................. 207
Towing............................... 254
Disabled Vehicle....................... 282
Guide.............................. 258
Recreational.......................... 262Weight.............................. 258
Traction.............................. 267
Traction Control...................... 112,150
Traction Control Switch................... 112
Trailer Towing.......................... 254
Cooling System Tips.................... 260
Hitches............................. 257
Minimum Requirements................. 258
Trailer and Tongue Weight................ 256
Wiring.............................. 259
Trailer Towing Guide..................... 258
Trailer Weight.......................... 258
Transaxle............................. 203
Automatic........................... 203
Operation........................... 203
Transfer Case........................... 319
Fluid............................... 338
Transmission........................203,315
Automatic........................203,315
384 INDEX

Windshield Defroster................63,182,187
Windshield Washers................ 110,111,305
Fluid............................ 110,305
Windshield Wiper Blades.................. 305
Windshield Wipers....................... 110Wiper Blade Replacement.................. 305
Wiper, Rear............................ 194
Wipers, Intermittent...................... 110
Wrecker Towing......................... 282
386 INDEX