wheel DODGE DURANGO 2005 2.G Workshop Manual

WARNING!
Fluid level should be checked on a level surface and
with the engine off to prevent injury from moving
parts and to insure accurate fluid level reading. Do
not overfill. Use only manufacturers recommended
power steering fluid.
If necessary, add fluid to restore to the proper indicated
level. With a clean cloth, wipe any spilled fluid from all
surfaces. Refer to Recommended Fluids, Lubricants, and
Genuine Parts for correct fluid type.
Front Suspension Ball Joints
The ball joints and seals should be inspected whenever
the vehicle is serviced for other reasons. Damaged seals
should be replaced to prevent leakage or contamination
of the grease.
Drive Shaft Constant Velocity Joints
All four wheel drive models are equipped with four
constant velocity joints. Periodic lubrication of these
joints is not required. However, the joint boot should be
inspected for external leakage or damage periodically. If
external leakage or damage is evident, the joint boot and
grease should be replaced immediately. Continued op-
eration could result in failure of the joint due to water
and dirt contamination of the grease. This would require
complete replacement of the joint assembly. Refer to the
Service Manual for the detailed replacement procedure.
Body Lubrication
Locks and all body pivot points, including such items as
seat tracks, doors,liftgate and hood hinges, should be
lubricated periodically to assure quiet, easy operation
and to protect against rust and wear. Prior to the appli-
cation of any lubricant, the parts concerned should be
wiped clean to remove dust and grit; after lubricating
excess oil and grease should be removed. Particular
MAINTAINING YOUR VEHICLE 321
7

Front Axle
Front Axle fluid level should be 3/4” (20 mm) below the
bottom of the fill hole.
Selection of Lubricating Grease
The National Lubricating Grease Institute (NLGI) has
developed a symbol (Certification Mark) to aid the
vehicle owner in the proper selection of grease for chassis
components. This symbol, an example shown below, is
located on the grease container and identifies the appli-
cation and quality of the grease.There are two groups
identified, those for wheel
bearings (Letter “G”) and
those for chassis (Letter
“L”) lubrication. Perfor-
mance categories within
these groups result in dual
letter designations for
each group. The letter des-
ignations shown in the ex-
ample are the highest
quality level available and when combined as shown can
be used for chassis lubrication. Use only those greases
that have the NLGI symbol on the container along with
the proper quality level for your application.
336 MAINTAINING YOUR VEHICLE

•Avoid using abrasive compounds and power buffing
that may diminish the gloss or thin out the paint
finish.
CAUTION!
Do not use abrasive or strong cleaning materials
such as steel wool or scouring powder, which will
scratch metal and painted surfaces.
Special Care
•
If you drive on salted or dusty roads or if you drive
near the ocean, hose off the undercarriage at least once
a month.
•It is important that the drain holes in the lower edges
of the doors, rocker panels and liftgate be kept clear
and open.
•If you detect any stone chips or scratches in the paint,
touch them up immediately. The cost of such repairs is
considered the responsibility of the owner.
•If your vehicle is damaged due to an accident or
similar cause which destroys the paint and protective
coating have your vehicle repaired as soon as possible.
The cost of such repairs is considered the responsibil-
ity of the owner.
•All wheels and wheel trim, especially aluminum and
chrome plated wheels should be cleaned regularly
with mild soap and water to prevent corrosion. To
remove heavy soil, select a nonabrasive, non-acidic
cleaner. Do not use scouring pads, steel wool, a bristle
brush or metal polishes. Only Moparcleaners are
recommended. Do not use oven cleaner. Avoid auto-
matic car washes that use acidic solutions or harsh
brushes that may damage the wheels’ protective fin-
ish.
338 MAINTAINING YOUR VEHICLE

•If you carry special cargo such as chemicals, fertilizers,
de-icer salt, etc., be sure that such materials are well
packaged and sealed.
•If a lot of driving is done on gravel roads, consider
mud or stone shields behind each wheel.
•Use Mopartouch up paint on scratches as soon as
possible. Your dealer has touch up paint to match the
color of your vehicle.
Interior Care
Use MoparFabric Cleaner to clean fabric upholstery
and carpeting.
Use MoparVinyl Cleaner to clean vinyl upholstery and
trim.
MoparTotal Clean is specifically recommended for
leather upholstery.Your leather upholstery can be best preserved by regular
cleaning with a damp soft cloth. Small particles of dirt
can act as an abrasive and damage the leather upholstery
and should be removed promptly with a damp cloth.
Stubborn soils can be removed easily with a soft cloth
and MoparTotal Clean. Care should be taken to avoid
soaking your leather upholstery with any liquid. Please
do not use polishes, oils, cleaning fluids, solvents, deter-
gents, or ammonia based cleaners to clean your leather
upholstery. Application of a leather conditioner is not
required to maintain the original condition.
WARNING!
Do not use volatile solvents for cleaning purposes.
Many are potentially flammable, and if used in
closed areas they may cause respiratory harm.
MAINTAINING YOUR VEHICLE 339
7

BULB REPLACEMENT
Headlights/Parking/Turn Signal
1. Remove the two bolts attaching the headlight to the
inner fender panel.2. Remove one nut that attaches the headlight to the
inner fender panel. Access to the nut is possible by
removing the fender panel access door which is located
in the wheel liner.
3. Grasp the headlight and pull firmly to disengage the
headlight from the fender panel.
4. While firmly holding the headlight in your hands
disconnect all connectors by following the procedure
described in step number 5 below.
5. Remove the bulb connector from the headlight making
sure to pull and release the red tab on all connectors.
Loosen the connector by pressing down on the black
and/or green release which is located below or above the
red tab. The green release is located above the red tab on
the 9008, the black release is located above the 3457AK
red tab, and the black release is located below the 194 red
tab.
MAINTAINING YOUR VEHICLE 349
7

Turn Signal.....................125,164,350
Flat Tire Stowage.....................289,295
Flooded Engine Starting................... 219
Floor Console.......................... 153
Fluid, Brake.........................331,360
Fluid Capacities......................... 357
Fluid Level Checks
Automatic Transmission................. 332
Brake............................... 331
Cooling System....................... 324
Engine Oil........................... 311
Power Steering........................ 320
Transfer Case......................... 335
Fog Lights..........................124,356
Folding Rear Seat.....................106,109
Four Wheel Drive....................... 226
Operation........................... 226
Four-Way Hazard Flasher.................. 286
Freeing A Stuck Vehicle................... 239Front Axle............................. 336
Fuel................................. 260
Adding............................. 262
Filter............................... 316
Gauge.............................. 164
Octane Rating......................260,359
Requirements......................260,357
Tank Capacity........................ 357
Fueling............................... 262
Fuses.............................152,341
Garage Door Opener..................... 142
GasCap ...........................263,307
Gas Gauge (Fuel Gauge)................... 164
Gasoline.............................. 260
Gasoline, Reformulated................... 261
Gauges
Coolant Temperature.................... 164
Fuel................................ 164
INDEX 399
10

Hazard Warning Flasher................. 286
Headlights........................... 123
High Beam........................... 126
High Beam/Low Beam Select............. 126
Instrument Cluster..................123,164
Interior..........................121,136
License............................. 354
Lights On Reminder.................... 124
Low Fuel.........................164,165
Malfunction Indicator................... 170
Park............................... 123
Passing............................. 125
Seat Belt Reminder..................... 165
Service.............................. 348
Turn Signal........................125,350
Warning (Instrument Cluster Description)..... 164
Washer Fluid......................... 170
Loading Vehicle......................... 268
Tires ............................... 244Locks................................. 13
Auto Unlock.......................... 16
Automatic Door........................ 15
Child Protection........................ 17
Door................................ 13
Ignition.............................. 12
Keys................................. 9
Power Door........................... 14
Steering Wheel......................... 12
Lower Anchors and Tether for CHildren (LATCH) . 57
Lubricating Oil......................... 336
Lubrication, Body....................... 321
Lug Nuts............................. 294
Luggage Carrier......................... 155
Lumbar Support........................ 103
Maintenance Free Battery.................. 318
Maintenance Procedures................... 310
Maintenance Schedule.................... 363
402 INDEX

Shoulder Belts........................... 29
Signals, Turn.....................125,164,350
Snow Chains (Tire Chains)................. 257
Snow Plow............................ 279
Snow Tires............................ 258
Spare Tire..........................252,253
Spark Plugs............................ 315
Speed Control.......................... 132
Speedometer........................... 166
Starting............................... 218
Automatic Transmission................. 218
Emergency (Jump Starting)............... 296
Engine Block Heater.................... 220
Engine Fails to Start.................... 219
Starting Procedures...................... 218
Steering
Column Controls...................... 124
Column Lock.......................... 12
Power...........................238,320Wheel, Tilt........................... 129
Steering Wheel Mounted Sound System
Controls............................. 194
Storage, Vehicle......................... 381
Stuck, Freeing.......................... 239
Sun Roof.............................. 149
Supplemental Tire Pressure Information........ 257
Synthetic Engine Oil...................... 314
Tachometer............................ 167
Taillights.............................. 350
Temperature Control, Automatic............. 202
Temperature Gauge, Engine Coolant.......... 164
Tether Anchor, Child Restraint............... 57
Theft System Arming...................... 25
Theft System Disarming.................... 25
Thermostat............................ 329
Tilt Steering Column..................... 129
Tire and Loading Information Placard....244,245,257
INDEX 407
10

Tire Identification Number (TIN)............. 243
Tire Markings.......................... 239
Tire Safety Information.................... 239
Tires ...............................66,248
Air Pressure.......................... 248
Alignment........................... 256
Chains.............................. 257
Changing............................ 288
Compact Spare........................ 252
General Information.................... 248
High Speed.......................... 251
Inflation Pressures..................... 249
Jacking............................. 291
Load Capacity.....................244,245
Radial.............................. 252
Replacement......................... 255
Rotation............................. 259
Safety...........................239,248
Sizes............................... 241Snow Tires........................... 258
Spare Tire........................... 289
Spinning............................ 254
Tread Wear Indicators................... 254
Wheel Mounting....................... 291
Wheel Nut Torque..................... 294
Tongue Weight/Trailer Weight.............. 274
Torque Converter Clutch.................. 225
Tow Hooks, Emergency................... 298
Towing............................... 271
Disabled Vehicle....................... 299
Guide.............................. 275
Recreational.......................... 280
Weight.............................. 275
Traction.............................. 284
Traction Control......................128,168
Traction Control Switch................... 128
Trailer Towing.......................... 271
Cooling System Tips.................... 278
408 INDEX

Warnings and Cautions..................... 5
Warranty Information..................... 387
Washers, Windshield..................... 127
Washing Vehicle......................... 337
Weight Load Carrying.................... 268
Wheel Alignment and Balance............... 256
Wheel and Wheel Trim.................... 338
Wheel Changing........................ 288
Wheel Mounting........................ 291
Wheel Nut Torque....................... 294
Wind Buffeting......................... 150
Window Fogging........................ 209
Windows.............................. 27
Power............................... 27
Windshield Defroster................66,200,205
Windshield Washers................126,127,322
Fluid............................126,322
Windshield Wiper Blades.................. 322
Windshield Wipers....................... 126Wiper Blade Replacement.................. 322
Wiper, Rear............................ 212
Wipers, Intermittent...................... 126
Wrecker Towing......................... 299
410 INDEX