radiator DODGE NEON 1999 Service Owner's Manual

LAMP SERVICE
INDEX
page page
REMOVAL AND INSTALLATION
CENTER HIGH MOUNTED STOP LAMP
(CHMSL)............................. 10
DOME LAMP........................... 11
FOG LAMP.............................. 9
FRONT SIDE MARKER LAMP.............. 10
HEADLAMP MODULE..................... 9LICENSE PLATE LAMP................... 11
PARK AND TURN SIGNAL LAMP............. 9
REAR CARGO LAMP..................... 11
TAIL, STOP AND TURN SIGNAL LAMP........ 10
UNDERHOOD LAMP..................... 11
VISOR VANITY LAMP..................... 11
REMOVAL AND INSTALLATION
HEADLAMP MODULE
REMOVAL
(1) Release hood latch and open hood.
(2) From behind bumper fascia, remove bolt hold-
ing outboard end of module to fender and closure
panel.
(3) Loosen bolts holding inboard end of module to
radiator closure panel and remove bolt to grille.
(4) Remove bolts attaching top of module to upper
crossmember (Fig. 1).
(5) Disconnect wire connector from headlamp and
parking lamp sockets.
(6) Remove headlamp module from vehicle.
INSTALLATION
For installation, reverse the above procedures.
FOG LAMP
REMOVAL
(1) Remove bolt holding fog lamp to radiator clo-
sure panel (Fig. 2).
(2) Separate fog lamp from radiator closure panel.
(3) Pull fog lamp through opening in fascia.
(4) Disengage wire connector from fog lamp bulb
base.
(5) Separate fog lamp from vehicle.
INSTALLATION
Reverse the preceding operation.
PARK AND TURN SIGNAL LAMP
REMOVAL
(1) Release hood latch and open hood.
(2) Remove screws holding lamp to headlamp mod-
ule (Fig. 3).
(3) Separate park and turn signal lamp from vehi-
cle.
(4) Disengage wire connector from back of lamp
socket.
Fig. 1 Headlamp Module
Fig. 2 Fog Lamp
PLLAMPS 8L - 9

LAMPS
CONTENTS
page page
BULB APPLICATION....................... 8
LAMP BULB SERVICE..................... 2LAMP DIAGNOSIS........................ 1
LAMP SERVICE........................... 5
LAMP DIAGNOSIS
INDEX
page
GENERAL INFORMATION
HEADLAMP LEVELING MOTOR.............. 1
GENERAL INFORMATION
HEADLAMP LEVELING MOTOR
This vehicle is equipped with a remote headlamp
leveling system. This system allows the driver to
adjust the vertical headlamp aim from the interior ofthe vehicle to compensate for passenger or cargo
load. A headlamp leveling switch is located in the
instrument panel and controls the headlamp leveling
motor and leveling cable found mounted to the upper
radiator crossmember behind the headlamp assem-
bly.
PLLAMPS 8L - 1

LAMP SERVICE
INDEX
page page
GENERAL INFORMATION
HEADLAMP DIMMER SWITCH............... 5
HEADLAMP SWITCH...................... 5
REMOVAL AND INSTALLATION
FOG LAMP.............................. 6HEADLAMP ASSEMBLY.................... 5
HEADLAMP LEVELING MOTOR.............. 6
SIDE REPEATER LAMP.................... 6
GENERAL INFORMATION
HEADLAMP SWITCH
Service procedures for the headlamp switch can be
found in Group 8E, Instrument Panel and Gauges.
More information can be found in Group 8W, Wiring
Diagrams.
HEADLAMP DIMMER SWITCH
The headlamp dimmer switch is incorporated into
the multi-function (turn signal) switch. Proper proce-
dures can be found in Group 8J, Turn Signal and
Flashers. More information can be found in Group
8W, Wiring Diagrams.
REMOVAL AND INSTALLATION
HEADLAMP ASSEMBLY
REMOVAL
(1) Release hood latch and open hood.
(2) Remove headlamp horizontal aim cable from
retainer clip on radiator upper crossmember.
(3) Disengage wire connector from leveling motor.
(4) Remove bolts holding headlamp leveling motor
to the upper radiator crossmember.
(5) Remove plastic locking cap holding vertical lev-
eling cable into leveling motor arm.
(6) Separate leveling cable from motor arm.
(7) Rotate leveling cable case one quarter turn
counter-clockwise and separate cable from motor
bracket.
(8) Separate leveling motor and bracket from vehi-
cle.
(9) From between front fascia and headlamp
assembly, remove bolt holding outboard end of
assembly to fender.
(10) Remove bolts holding inboard end of assembly
to radiator closure panel.
(11) Remove bolts holding top of assembly to upper
crossmember (Fig. 1).(12) Disengage wire connector from headlamp and
parking lamp sockets.
(13) Separate headlamp assembly from vehicle.
INSTALLATION
(1) Position headlamp assembly to vehicle.
(2) Route headlamp leveling cables through open-
ing in radiator closure panel.
(3) Engage wire connector to headlamp and park-
ing lamp sockets.
(4) Install bolts to hold top of assembly to upper
crossmember.
(5) Install bolts to hold inboard end of assembly to
radiator closure panel.
(6) Install bolt to hold outboard end of assembly to
fender.
(7) Position leveling motor and bracket to vehicle.
(8) Insert leveling cable through opening in level-
ing motor bracket.
(9) Rotate leveling cable case one quarter turn
clockwise.
(10) Engage leveling cable to leveling motor arm.
(11) Install plastic locking cap to hold leveling
cable into motor arm.
(12) Install bolts to hold leveling motor to upper
radiator crossmember.
(13) Engage wire connector to leveling motor.
(14) Engage horizontal aim cable to retainer clip
on upper radiator crossmember.
Fig. 1 Headlamp Assembly
PLLAMPS 8L - 5

(15) Verify lamp operation.
HEADLAMP LEVELING MOTOR
REMOVAL
(1) Disengage wire connector from headlamp level-
ing motor.
(2) Remove bolts holding headlamp leveling motor
to upper radiator crossmember (Fig. 2).
(3) Remove plastic locking cap holding leveling
cable into motor arm (Fig. 3).
(4) Remove leveling cable from leveling motor arm.
(5) Rotate leveling cable case one quarter turn
counter-clockwise and separate cable from motor
bracket.
(6) Separate leveling motor from vehicle.
INSTALLATION
(1) Position headlamp leveling motor to vehicle.
(2) Insert leveling motor through hole in leveling
motor bracket.(3) Rotate leveling cable base one quarter turn
clockwise.
(4) Engage leveling cable to leveling motor arm.
(5) Engage plastic locking cap to hold leveling
cable into motor arm.
(6) Install bolts to hold headlamp leveling motor to
upper radiator crossmember.
(7) Engage wire connector to headlamp leveling
motor.
FOG LAMP
REMOVAL
(1) Remove nut holding fog lamp to radiator cross-
member (Fig. 4).
(2) Separate fog lamp from radiator crossmember.
(3) Pull fog lamp through opening in fascia.
(4) Disengage fog lamp wire connector from body
wiring harness.
(5) Separate fog lamp from vehicle.
INSTALLATION
(1) Position fog lamp to vehicle.
(2) Engage fog lamp wire connector to body wiring
harness.
(3) Insert fog lamp through opening in fascia.
(4) Position fog lamp to radiator crossmember.
(5) Install nut to hold fog lamp to radiator cross-
member.
SIDE REPEATER LAMP
REMOVAL
(1) Push Repeater Lamp Assembly Rearward
(2) While pushing Repeater Lamp Assembly rear-
ward, pry edge of lamp away from car.
(3) Pull Repeater Lamp Assembly from hole.
INSTALLATION
(1) Position Repeater Lamp Assembly in mounting
hole.
Fig. 2 Headlamp Leveling Motor
Fig. 3 Headlamp Leveling Cable From Leveling
Motor
Fig. 4 Fog Lamp
8L - 6 LAMPSPL
REMOVAL AND INSTALLATION (Continued)

8W-02 COMPONENT INDEX
Component Page
A/C Compressor Clutch..................8W-42
A/C Compressor Clutch Relay.............8W-42
A/C Cycling Switch.....................8W-42
A/C Heater Blower Motor................8W-42
A/C Heater Control.....................8W-42
A/C Pressure Switches...................8W-42
ABS Warning Lamp Relay................8W-35
Airbag Control Module...................8W-43
Airbags..............................8W-43
Antenna..............................8W-47
Ash Receiver Lamp.....................8W-44
Automatic Shut Down Relay..............8W-30
Back-Up Lamp Switch...................8W-51
Back-Up Lamps........................8W-51
Battery..............................8W-20
Battery Temperature Sensor..............8W-30
Blower Motor Resistor Block..............8W-42
Brake Warning Lamp Switch...........8W-40, 50
Camshaft Position Sensor................8W-30
Center High Mounted Stop Lamp..........8W-51
Cigar Lighter Relay.....................8W-41
Cigar Lighter/Power Outlet...............8W-41
Circuit Breakers.......................8W-11
Clockspring.....................8W-30, 41, 61
Clutch Pedal Position Switch...........8W-10, 21
Combination Flasher....................8W-52
Controller Anti-Lock Brake...............8W-35
Crankshaft Position Sensor...............8W-30
Data Link Connector....................8W-30
Daytime Running Lamp Module...........8W-50
Diode No. 1........................8W-15, 42
Diode No. 2......................8W-10, 11, 44
Diode No. 3......................8W-11,44,70
Dome Lamp...........................8W-44
Door Ajar Switches.....................8W-44
Door Jamb Switches....................8W-44
Door Lock Motors......................8W-61
Door Lock Motors......................8W-61
Door Lock Switches.....................8W-61
Duty Cycle Evap/Purge Solenoid...........8W-30
EGR Transducer Solenoid................8W-30
Engine Coolant Temperature Sensor........8W-30
Engine Oil Pressure Switch...............8W-40
Engine Starter Motor....................8W-21
Engine Starter Motor Relay...............8W-21
Fog Lamp Relays....................8W-50, 51
Fog Lamp Switches..................8W-50, 51
Fog Lamps.........................8W-50, 51
Fuel Injectors..........................8W-30
Fuel Pump Module.....................8W-30
Fuel Pump Relay.......................8W-30
Fuse Block............................8W-11Component Page
Fuses (FB)............................8W-11
Fuses (PDC)...........................8W-10
Fusible Link........................8W-20, 21
Generator.............................8W-20
Glove Box Lamp And Switch..............8W-44
Grounds..............................8W-15
Halo Lamp............................8W-44
Headlamp Dimmer And Optical Horn Switch .8W-50
Headlamp Leveling Motors...............8W-50
Headlamp Leveling Switch...............8W-50
Headlamp Switch.......................8W-50
Headlamps............................8W-50
High Speed Warning Module..............8W-40
Horn Relay...........................8W-41
Horn Switches.........................8W-41
Horns................................8W-41
IAT/Map Sensor........................8W-30
Idle Air Control Motor...................8W-30
Ignition Coil Pack......................8W-30
Ignition Switch........................8W-10
Illumination Lamps.....................8W-40
Immobilizer...........................8W-61
Immobilizer Engine Sensor............8W-30, 61
Indicator Lamps........................8W-40
Instrument Cluster.....................8W-40
Intermittent Wipe/Wash Switch............8W-53
Key-In Switch.........................8W-40
Knock Sensor..........................8W-30
License Lamps.........................8W-51
Map/Reading Lamps....................8W-44
Noise Supressor.....................8W-10, 30
Oxygen Sensors........................8W-30
Park Brake Switch...................8W-40, 50
Park/Neutral Position Switch...........8W-30, 51
Park/Turn Signal Lamps..............8W-50, 52
Power Distribution Center................8W-10
Power Folding Mirror Relay...............8W-62
Power Mirror Fuse Holder................8W-62
Power Mirrors.........................8W-62
Power Steering Pressure Switch...........8W-30
Power Sunroof Motor....................8W-64
Power Window Motors...................8W-60
Power Window Switches.................8W-60
Powertrain Control Module...............8W-30
PRNDL Lamp.........................8W-44
Radiator Fan Motor.....................8W-42
Radio................................8W-47
Rear Window Defogger..................8W-48
Rear Window Defogger Switch.............8W-48
Remote Keyless Entry Module.............8W-61
Remote Keyless Entry Program
Module Connector....................8W-61
PL8W - 02 COMPONENT INDEX 8W - 02 - 1

8W-10 POWER DISTRIBUTION
Component Page
A/C Compressor Clutch.............8W-10-14, 15
A/C Compressor Clutch Relay........8W-10-14, 15
Automatic Shut Down Relay............8W-10-16
Battery...........................8W-10-5, 6
Capacitor..........................8W-10-16
Circuit Breaker.......................8W-10-8
Clutch Pedal Position Switch.......8W-10-9, 10, 11
Controller Anti-Lock Brake.......8W-10-12, 14, 15
Data Link Connector..................8W-10-16
Diode No. 1......................8W-10-14, 15
Diode No. 2.........................8W-10-13
Dome Lamp........................8W-10-13
Downstream Heated Oxygen Sensor......8W-10-16
Engine Starter Motor..................8W-10-7
Engine Starter Motor Relay......8W-10-7, 9, 10, 11
Fog Lamp Relay.....................8W-10-17
Fuel Injector No. 1...................8W-10-16
Fuel Injector No. 2...................8W-10-16
Fuel Injector No. 3...................8W-10-16
Fuel Injector No. 4...................8W-10-16
Fuel Pump Module...................8W-10-16
Fuel Pump Relay....................8W-10-16
Fuse 1 (FB)..........................8W-10-8
Fuse 2 (FB)..........................8W-10-8
Fuse 2 (PDC).....................8W-10-5, 6, 7
Fuse 3 (FB)..........................8W-10-8
Fuse 3 (PDC).....................8W-10-5, 6, 8
Fuse 4 (FB)..........................8W-10-8
Fuse 5 (FB)..........................8W-10-8
Fuse 5 (PDC)....................8W-10-5, 6, 12
Fuse 6 (FB)..........................8W-10-8
Fuse 7 (FB)..........................8W-10-8
Fuse 8 (FB)..........................8W-10-8
Fuse 8 (PDC)....................8W-10-5, 6, 12
Fuse 9 (FB).......................8W-10-9, 10
Fuse 10 (FB)...................8W-10-9, 10, 11
Fuse 10 (PDC)...................8W-10-5, 6, 12
Fuse 11 (FB)...................8W-10-9, 10, 11
Fuse 11 (PDC)....................8W-10-5, 6, 7
Fuse 12 (FB)........................8W-10-11
Fuse 13 (PDC)...................8W-10-5, 6, 13
Fuse 14 (FB)...................8W-10-9, 10, 11
Fuse 15 (FB)...................8W-10-9, 10, 11
Fuse 16 (FB)...................8W-10-9, 10, 11Component Page
Fuse 16 (PDC).....................8W-10-6, 17
Fuse 18 (PDC)................8W-10-5, 6, 14, 15
Fuse 20 (PDC)................8W-10-5, 6, 14, 15
Fuse 21 (PDC)...................8W-10-5, 6, 16
Fuse 23 (PDC)................8W-10-5, 6, 14, 15
Fuse 25 (PDC)................8W-10-5, 6, 14, 15
Fuse Block...................8W-10-8, 9, 10, 11
G101...............................8W-10-9
G204...............................8W-10-7
Generator..........................8W-10-16
Glove Box Lamp And Switch............8W-10-13
Headlamp Switch.....................8W-10-8
High Speed Warning Module...........8W-10-13
Horn..............................8W-10-14
Horn No. 1.........................8W-10-15
Horn No. 2.........................8W-10-15
Horn Relay......................8W-10-14, 15
Ignition Coil Pack....................8W-10-16
Ignition Switch.............8W-10-7, 8, 9, 10, 11
Immobilizer......................8W-10-10, 11
Instrument Cluster.................8W-10-7, 13
Left Fog Lamp......................8W-10-17
Left Visor/Vanity Lamps...............8W-10-13
Map/Reading Lamps..................8W-10-13
Noise Supressor.....................8W-10-16
Power Distribution
Center.....8W-10-5, 6, 7, 8, 12, 13, 14, 15, 16, 17
Power Mirror Switch..................8W-10-13
Powertrain Control Module...........8W-10-9, 16
Radiator Fan Motor..................8W-10-12
Radio..............................8W-10-13
Rear Fog Lamp Switch................8W-10-17
Rear Window Defogger Switch..........8W-10-12
Right Fog Lamp.....................8W-10-17
Right Visor/Vanity Lamps..............8W-10-13
Solid State Fan Relay.................8W-10-12
Stop Lamp Switch.................8W-10-14, 15
Time Delay Relay....................8W-10-13
Time Out Relay......................8W-10-13
Trunk Lamp........................8W-10-13
Turn Signal/Hazard Switch..........8W-10-14, 15
Underhood Lamp....................8W-10-13
Upstream Heated Oxygen Sensor........8W-10-16
PL8W - 10 POWER DISTRIBUTION 8W - 10 - 1

5FUSE30A
5
A16
14
GY
4
3
BATT A0
1
RADIATOR
FAN
MOTOR
C25
14
LG
810 8FUSE
30A10FUSE40A
A4
14
BK/RD
4C102
A4
14
BK/RD
4
SWITCH DEFOGGER
WINDOW
REAR
25
CONTROLLER
ANTI-LOCK
BRAKE
A20
12
RD/DG
679
RELAY FAN
STATE
SOLIDCENTER DISTRIBUTION
POWER
(8W-42-5)
(8W-48-2)
(8W-48-3)(8W-35-2) (8W-42-5)(8W-10-5)
(8W-10-5)
(8W-10-6)
8W - 10 - 12 8W-10 POWER DISTRIBUTIONPL
J988W-18201

8W-15 GROUND DISTRIBUTION
Component Page
A/C Compressor Clutch...............8W-15-5, 6
A/C Compressor Clutch Relay..........8W-15-5, 6
A/C Heater Control....................8W-15-9
ABS Warning Lamp Relay............8W-15-7, 8
Airbag Control Module...............8W-15-7, 8
Ash Receiver Lamp................8W-15-10, 11
Battery...........................8W-15-7, 8
Brake Warning Lamp Switch..........8W-15-2, 3
Center High Mounted Stop Lamp.....8W-15-12, 14
Cigar Lighter Relay...................8W-15-11
Cigar Lighter/Power Outlet..........8W-15-10, 11
Clockspring..........................8W-15-7
Combination Flasher.................8W-15-7, 8
Controller Anti-Lock Brake............8W-15-2, 3
Data Link Connector..................8W-15-4
Daytime Running Lamp Module..........8W-15-7
Diode No. 1........................8W-15-5, 6
Downstream Heated Oxygen Sensor.....8W-15-2, 3
Driver Door Lock Switch................8W-15-9
Driver Power Window Switch............8W-15-9
Engine Starter Motor Relay...........8W-15-2, 3
Fog Lamp Relay......................8W-15-3
Fog Lamp Switch....................8W-15-10
Front Fog Lamp Switch...............8W-15-11
Fuel Pump Module................8W-15-12, 13
G101.............................8W-15-2, 3
G102...............................8W-15-4
G103.............................8W-15-5, 6
G104.............................8W-15-7, 8
G105.............................8W-15-7, 8
G110.............................8W-15-7, 8
G111...............................8W-15-8
G201.............................8W-15-7, 8
G202.............................8W-15-7, 8
G203...............................8W-15-9
G204...........................8W-15-10, 11
G301...........................8W-15-12, 13
G302...........................8W-15-12, 14
G303...........................8W-15-12, 13
Glove Box Lamp And Switch.........8W-15-10, 11
Halo Lamp......................8W-15-10, 11
Headlamp Leveling Switch.............8W-15-11
Headlamp Switch.................8W-15-10, 11
High Speed Warning Module............8W-15-8
Horn...............................8W-15-2
Horn No. 1..........................8W-15-6
Horn No. 2..........................8W-15-3
Horn Switches.......................8W-15-7
Ignition Switch...................8W-15-10, 11Component Page
Immobilizer..........................8W-15-8
Instrument Cluster................8W-15-10, 11
Intermittent Wipe/Wash Switch........8W-15-7, 8
Left Back-Up Lamp................8W-15-12, 14
Left Fog Lamp.....................8W-15-5, 6
Left Headlamp.....................8W-15-2, 3
Left Headlamp Leveling Motor...........8W-15-3
Left License Lamp...................8W-15-14
Left Park/Turn Signal Lamp...........8W-15-2, 3
Left Rear Fog Lamp..................8W-15-14
Left Repeater Lamp...................8W-15-3
Left Tail/Stop Lamp..................8W-15-14
Left Tail/Stop/Turn Signal Lamp.........8W-15-12
Left Turn Signal Lamp................8W-15-14
License Lamp.......................8W-15-12
Map/Reading Lamps...............8W-15-10, 11
Power Folding Mirror Relay.............8W-15-9
Power Mirror Switch...................8W-15-9
Power Steering Pressure Switch..........8W-15-4
Power Sunroof Motor..................8W-15-9
Powertrain Control Module..............8W-15-4
PRNDL Lamp....................8W-15-10, 11
Radiator Fan Motor.................8W-15-2, 3
Radio.............................8W-15-7, 8
Rear Fog Lamp Switch................8W-15-11
Rear Window Defogger.............8W-15-12, 13
Rear Window Defogger Switch.........8W-15-7, 8
Remote Keyless Entry Module...........8W-15-7
Right Back-Up Lamp...............8W-15-12, 13
Right Fog Lamp....................8W-15-5, 6
Right Headlamp....................8W-15-5, 6
Right Headlamp Leveling Motor..........8W-15-6
Right License Lamp..................8W-15-14
Right Park/Turn Signal Lamp..........8W-15-5, 6
Right Rear Fog Lamp.................8W-15-13
Right Repeater Lamp..................8W-15-6
Right Tail/Stop Lamp.................8W-15-13
Right Tail/Stop/Turn Signal Lamp.......8W-15-12
Right Turn Signal Lamp...............8W-15-13
Seat Belt Switch..................8W-15-12, 14
Solid State Fan Relay................8W-15-2, 3
Stop Lamp Switch.....................8W-15-4
Sunroof Vent Switch...................8W-15-9
Underhood Lamp...................8W-15-2, 3
Upstream Heated Oxygen Sensor.......8W-15-2, 3
Vehicle Speed Control Servo.............8W-15-2
Vehicle Speed Control Switch............8W-15-7
Windshield Washer Pump Motor........8W-15-2, 3
PL8W - 15 GROUND DISTRIBUTION 8W - 15 - 1

2
RADIATOR
FAN
MOTOR
1
SOLID
STATE
FAN
Z1
18
BKZ1
14
BK
1
Z1
20
BK
HORN
Z1
14
BK
S111
2
2
SENSOR OXYGEN
HEATED
DOWNSTREAM
UPSTREAM
HEATED
SENSOR OXYGEN
Z1
18
BKZ1
18
BK
Z1
18
BK
1C161
Z1
20
BK
31
Z1
18
BK
4
SERVO CONTROL
SPEED
VEHICLE
Z1
20
BK
3LAMP SIGNAL
TURN
PARK/
LEFT
Z1
18
BK
B2
Z1
18
BK
Z1
18
BK
HEADLAMP LEFT
SWITCH LAMP
WARNING
BRAKE
S107 S119
824
CONTROLLER
ANTI-LOCK
BRAKE
B
Z1
12
BKZ1
12
BKZ1
18
BK
MOTOR PUMP
WASHER
WINDSHIELD
Z1
14
BK
Z1
18
BK
G101 S108(MTX) RELAY
MOTOR
STARTER
ENGINE RELAY
1
Z1
18
BK
LAMP UNDERHOOD
C104
2
BK18Z1(8W-21-2)
(8W-53-2)
(8W-53-3) (8W-35-2) (8W-40-7)(8W-50-5)
(8W-52-4) (8W-30-14) (8W-30-3)(8W-30-3) (8W-41-2)
(8W-42-5) (8W-42-5)
(8W-44-7)
8W - 15 - 2 8W-15 GROUND DISTRIBUTION
EXCEPT BUILT-UP-EXPORTPL
J988W-18230

2
RADIATOR
FAN
MOTOR
1
SOLID
STATE
FAN
Z1
18
BKZ1
14
BK
1
Z1
20
BK
Z1
14
BK
S111
22
SENSOR OXYGEN
HEATED
DOWNSTREAM UPSTREAM
HEATED
SENSOR OXYGEN
Z1
18
BKZ1
18
BK
Z1
18
BK
1C161
Z1
20
BK
31
Z1
18
BK
3LAMP SIGNAL
TURN
PARK/
LEFT
Z1
18
BK
2
3
Z1
18
BK
Z1
20
BK
HEADLAMP LEFT
SWITCH LAMP
WARNING
BRAKE
S107 S119
824
CONTROLLER
ANTI-LOCK
BRAKE
B
Z1
12
BKZ1
12
BKZ1
18
BK
MOTOR PUMP
WASHER
WINDSHIELD
3
Z1
22
BK
Z1
14
BKZ1
18
BK
G101 S108 RELAYNO. 2 HORN
MOTOR
LEVELING
HEADLAMP
LEFT
S127
BK18Z1
BK18Z1
LEFT
REPEATER
LAMP
2
FOG
LAMP
RELAY
(IN PDC)
46
BK18Z1
UNDERHOOD
LAMP
(LHD)
2
BK18Z1
(MTX) (IN PDC)
RELAY
MOTOR
STARTER
ENGINE
(8W-42-5)
(8W-42-5)(8W-30-3) (8W-30-3)
(8W-52-5) (8W-50-6)
(8W-40-9)
(8W-35-2)
(8W-53-2)
(8W-53-3) (8W-41-3)
(8W-50-7)
(8W-50-8) (8W-52-5)(8W-50-13)
(8W-44-7)
(8W-21-3)
(8W-21-4)
PL8W-15 GROUND DISTRIBUTION
BUILT-UP-EXPORT8W - 15 - 3
8231J988W-1