wheel DODGE NEON 2000 Service Repair Manual

TERMINOLOGY
This a list of terms with there definitions used in
the wiring diagrams.
Built-Up-Export....... Vehicles Built For Sale In
Markets Other Than North America
Except-Built-Up-Export . Vehicles Built For Sale In
North America
LHD ................Left Hand Drive Vehicles
RHD ...............Right Hand Drive Vehicles
ATX . . Automatic Transmission-Front Wheel Drive
MTX ....Manual Transmission-Front Wheel Drive
AT ....Automatic Transmission-Rear Wheel Drive
MT......Manual Transmission-Rear Wheel Drive
SOHC...........Single Over Head Cam Engine
DOHC............Dual Over Head Cam Engine
CONNECTOR INFORMATION
CAUTION: Not all connectors are serviced. Some
connectors are serviced only with a harness. A typ-
ical example might be the Supplemental Restraint
System connectors. Always check parts availability
before attempting a repair.
IDENTIFICATION
In-line connectors are identified by a number, as
follows:
²In-line connectors located on theengine com-
partment harnessareC100series numbers.
²Connectors located on theinstrument panel
harnessareC200series numbers.
²Connectors located on thebody harnessare
C300series numbers.
²Jumper harness connectorsareC400series
numbers.
²Grounds and ground connectorsare identi-
fied with aªGºand follow the same series number-
ing as the in-line connector.
Component connectors are identified by the compo-
nent name instead of a number. Multiple connectors
on a component use a C1, C2, etc. identifier.
LOCATIONS
Section 8W-90 contains connector/ground location
illustrations. The illustrations contain the connector
name (or number)/ground number and component
identification. Connector/ground location charts in
Section 8W-90 reference the illustration number for
components and connectors.
Section 8W-80 shows each connector and the cir-
cuits involved with that connector. The connectors
are identified using the name/number on the Dia-
gram pages.
SPLICE LOCATIONS
Splice Location charts in Section 8W-70 show the
entire splice, and provide references to other sections
the splice serves.
Section 8W-95 contains illustrations that show the
general location of the splices in each harness. The
illustrations show the splice by number, and provide
a written location.
NOTES, CAUTIONS, and WARNINGS
Throughout this group additional important infor-
mation is presented in three ways; Notes, Cautions,
and Warnings.
NOTESare used to help describe how switches or
components operate to complete a particular circuit.
They are also used to indicate different conditions
that may appear on the vehicle. For example, an
up-to and after condition.
CAUTIONSare used to indicate information that
could prevent making an error that may damage the
vehicle.
WARNINGSprovide information to prevent per-
sonal injury and vehicle damage. Below is a list of
general warnings that should be followed any time a
vehicle is being serviced.
WARNING: ALWAYS WEAR SAFETY GLASSES FOR
EYE PROTECTION.
WARNING: USE SAFETY STANDS ANYTIME A PRO-
CEDURE REQUIRES BEING UNDER A VEHICLE.
WARNING: BE SURE THAT THE IGNITION SWITCH
ALWAYS IS IN THE OFF POSITION, UNLESS THE
PROCEDURE REQUIRES IT TO BE ON.
WARNING: SET THE PARKING BRAKE WHEN
WORKING ON ANY VEHICLE. AN AUTOMATIC
TRANSMISSION SHOULD BE IN PARK. A MANUAL
TRANSMISSION SHOULD BE IN NEUTRAL.
WARNING: OPERATE THE ENGINE ONLY IN A
WELL-VENTILATED AREA.
WARNING: KEEP AWAY FROM MOVING PARTS
WHEN THE ENGINE IS RUNNING, ESPECIALLY THE
FAN AND BELTS.
WARNING: TO PREVENT SERIOUS BURNS, AVOID
CONTACT WITH HOT PARTS SUCH AS THE RADIA-
TOR, EXHAUST MANIFOLD(S), TAIL PIPE, CATA-
LYTIC CONVERTER, AND MUFFLER.
PL8W - 01 GENERAL INFORMATION 8W - 01 - 7
DESCRIPTION AND OPERATION (Continued)

Component Page
Sunroof Switch.......................8W-64
Sunroof Vent Switch...................8W-64
Tail/Stop Lamps......................8W-51
Tail/Stop/Turn Signal Lamps..........8W-51, 52
Throttle Position Sensor................8W-30
Torque Converter Clutch Solenoid.........8W-30
Traction Control Switch.................8W-35
Trunk Key Cylinder Switch..............8W-61
Turn Signal Lamps....................8W-52
Underhood Lamp......................8W-44Component Page
Vehicle Speed Control Servo.............8W-33
Vehicle Speed Control Switch............8W-33
Vehicle Speed Sensor...................8W-30
Visor/Vanity Lamps....................8W-44
Wheel Speed Sensors...................8W-35
Windshield Washer Pump...............8W-53
Wipe/Wash Switch.....................8W-53
Wiper Motor.........................8W-53
8W - 02 - 2 8W - 02 COMPONENT INDEXPL

8W-35 ANTI-LOCK BRAKES
Component Page
Brake Lamp Switch..................8W-35-2
Controller Anti-Lock Brake.........8W-35-2, 3, 4
Data Link Connector.................8W-35-2
Fuse 5 (PDC).......................8W-35-2
Fuse 8 (PDC).......................8W-35-2
Fuse 10 (FB)........................8W-35-3
Fuse 11 (FB)........................8W-35-3
Fuse 23 (PDC)......................8W-35-2
Fuse Block.........................8W-35-3Component Page
G103..............................8W-35-2
G204..............................8W-35-3
Instrument Cluster...................8W-35-3
Left Front Wheel Speed Sensor.........8W-35-4
Left Rear Wheel Speed Sensor..........8W-35-4
Power Distribution Center.............8W-35-2
Right Front Wheel Speed Sensor........8W-35-4
Right Rear Wheel Speed Sensor.........8W-35-4
Traction Control Switch...............8W-35-3
PL8W - 35 ANTI-LOCK BRAKES 8W - 35 - 1

SENSOR SPEED
WHEEL
FRONT
LEFT
LEFT
REAR
WHEEL
SPEED
SENSORRIGHT
FRONT
WHEEL
SPEED
SENSOR
RIGHT
REAR
WHEEL
SPEED
SENSOR
LEFT
FRONT
WHEEL
SPEED
SENSOR
(-)12-VOLT
SUPPLY
(-) SENSORSPEED WHEELREARLEFT RIGHT
FRONT
WHEEL
SPEED
SENSOR
(-) (-)SENSORSPEED WHEELREAR RIGHT
125619202322 B8
18
RD/DB
B9
18
RDB6
18
WT/DBB7
18
WT
B2
20
YL B1
20
YL/DB B3
20
LG/DBB4
20
LG
12
12
12
12
CONTROLLER
ANTI-LOCK
BRAKE
PAIR TWISTED
TWISTED
PAIR
TWISTED
PAIR
PAIR TWISTED
2C10613C1064
B3
18
LG/DBB4
18
LGB1
18
YL/DBB2
18
YL
TWISTED
PAIR
PAIR TWISTED
12-VOLT
SUPPLY12-VOLT
SUPPLY SUPPLY12-VOLT
8W - 35 - 4 8W-35 ANTI-LOCK BRAKESPL
008W-10PLI03504

Component Page
Fuel Pump Module..................8W-80-25
Generator.........................8W-80-25
Glove Box Lamp/Switch..............8W-80-25
Headlamp Leveling Switch............8W-80-25
High Note Horn....................8W-80-25
Hood Ajar Switch...................8W-80-26
Idle Air Control Motor................8W-80-26
Ignition Coil.......................8W-80-26
Ignition Switch.....................8W-80-26
Inlet Air Temperature Sensor..........8W-80-27
Instrument Cluster..................8W-80-27
Knock Sensor......................8W-80-27
Leak Detection Pump................8W-80-28
Left Back-Up Lamp..................8W-80-28
Left City Lamp.....................8W-80-28
Left Front Door Speaker..............8W-80-28
Left Front Fog Lamp..............8W-80-28, 29
Left Front Side Marker Lamp..........8W-80-29
Left Front Turn Signal Lamp..........8W-80-29
Left Front Wheel Speed Sensor.........8W-80-29
Left Headlamp...................8W-80-29, 30
Left Headlamp Leveling Motor.........8W-80-30
Left Instrument Panel Speaker.........8W-80-30
Left License Lamp..................8W-80-30
Left Park/Turn Signal Lamp...........8W-80-30
Left Rear Door Lock Motor............8W-80-31Component Page
Left Rear Fog Lamp.................8W-80-31
Left Rear Speaker...................8W-80-31
Left Rear Turn Signal Lamp...........8W-80-31
Left Rear Wheel Speed Sensor.........8W-80-31
Left Repeater Lamp.................8W-80-32
Left Tail/Stop Lamp.................8W-80-32
Left Tail/Stop/Turn Signal Lamp........8W-80-32
License Lamp......................8W-80-32
Low Note Horn.....................8W-80-32
Manifold Absolute Pressure Sensor......8W-80-33
Map/Reading Lamps.................8W-80-33
Multi-Function Switch...............8W-80-33
Oxygen Sensor 1/1 Upstream..........8W-80-34
Oxygen Sensor 1/2 Downstream........8W-80-34
Park/Neutral Position Switch..........8W-80-34
Passenger Airbag...................8W-80-34
Passenger Cylinder Lock Switch........8W-80-34
Passenger Door Lock Motor...........8W-80-34
Passenger Door Lock Switch...........8W-80-35
Passenger Power Mirror..............8W-80-35
Passenger Power Window Motor........8W-80-35
Passenger Power Window Switch.......8W-80-35
Power Mirror Switch.................8W-80-36
Power Steering Pressure Switch........8W-80-36
Powertrain Control Module - C1........8W-80-37
Powertrain Control Module - C2........8W-80-38
8W - 80 - 2 8W - 80 CONNECTOR PIN-OUTSPL

Component Page
PRNDL Lamp......................8W-80-39
Proportional Evap/Purge Solenoid.......8W-80-39
Radiator Fan Motor.................8W-80-39
Radio.............................8W-80-39
Rear Window Defogger Switch.........8W-80-40
Remote Keyless Entry Module.........8W-80-40
Right Back-Up Lamp................8W-80-41
Right City Lamp....................8W-80-41
Right Front Door Speaker.............8W-80-41
Right Front Fog Lamp...............8W-80-41
Right Front Side Marker Lamp........8W-80-42
Right Front Turn Signal Lamp.........8W-80-42
Right Front Wheel Speed Sensor.......8W-80-42
Right Headlamp....................8W-80-42
Right Headlamp Leveling Motor........8W-80-43
Right Instrument Panel Speaker.......8W-80-43
Right License Lamp.................8W-80-43
Right Park/Turn Signal Lamp..........8W-80-43
Right Rear Door Lock Motor...........8W-80-43
Right Rear Fog Lamp................8W-80-44
Right Rear Speaker..................8W-80-44
Right Rear Turn Signal Lamp..........8W-80-44Component Page
Right Rear Wheel Speed Sensor........8W-80-44
Right Repeater Lamp................8W-80-44
Right Tail/Stop Lamp................8W-80-45
Right Tail/Stop/Turn Signal Lamp......8W-80-45
Seat Belt Switch....................8W-80-45
Sentry Key Immobilizer Module........8W-80-45
Siren.............................8W-80-45
Sunroof Control Module..............8W-80-46
Sunroof Motor......................8W-80-46
Sunroof Switch.....................8W-80-46
Sunroof Vent Switch.................8W-80-46
Throttle Position Sensor..............8W-80-46
Torque Converter Clutch Solenoid.......8W-80-47
Traction Control Switch..............8W-80-47
Trunk Key Cylinder Switch............8W-80-47
Underhood Lamp...................8W-80-47
Vehicle Speed Control Servo...........8W-80-47
Vehicle Speed Sensor................8W-80-48
Windshield Washer Pump.............8W-80-48
Wipe/Wash Switch...................8W-80-48
Wiper Motor.......................8W-80-48
PL8W - 80 CONNECTOR PIN-OUTS 8W - 80 - 3

CAV CIRCUIT FUNCTION
1 B8 18RD/DB LEFT FRONT WHEEL SPEED SENSOR (-)
2
3B9 18RD
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
CONTROLLER
ANTI-LOCK
BRAKE
BLACK
23 17 1
7
8
924
25 1610
D25 18VT/YLF12 18DB/WT
Z1 12BK GROUND
FUSED B(+) A20 12RD/DB12-VOLT SUPPLY
FUSED IGNITION SWITCH OUTPUT (ST-RUN)
PCI BUS
L50 18WT/TN
B6 18WT/DB
B7 18WT
B1 18YL/DB RIGHT REAR WHEEL SPEED SENSOR (-)
Z1 12BK GROUNDBRAKE LAMP SWITCH OUTPUT
FUSED B(+) A10 12RD/DG--
--
--
---
B3 18LG/DB
18LG B4 LEFT REAR WHEEL SPEED SENSOR (-)
12-VOLT SUPPLY
- -
B27 18RD/YL TRACTION CONTROL SWITCH SENSE
-
B2 18YL
12-VOLT SUPPLY 12-VOLT SUPPLY RIGHT FRONT WHEEL SPEED SENSOR (-)-
(MTX) SWITCH
CLUTCH INTERLOCK SWITCH SENSE T141 20YL/RD 3
1
3
INTERLOCKCLUTCH
GROUND Z1 18BK 2CLUTCH SWITCH K119 20LG/BK 1
FUNCTION CIRCUIT CAV
BLACK
-
- -
-
-
SPEED CONTROL
CLOCKSPRING5
6
7 3
4 2 1CIRCUIT CAV
1
7
X3 22BK/RD-
-
FUNCTION
DRIVER AIRBAG LINE 2
DRIVER AIRBAG LINE 1 R43 18BK/LB
R45 18DG/LB
V37 20RD/LG
Z10 20BK/TNSPEED CONTROL SWITCH SIGNAL HORN RELAY CONTROL
GROUND-
- GREEN
PL8W-80 CONNECTOR PIN-OUTS 8W - 80 - 19
PLI08019008W-10

CAV CIRCUIT FUNCTION
1
B8 18RD/DB LEFT FRONT WHEEL SPEED SENSOR (-)
2B9 18RD 12-VOLT SUPPLY2
BLACK
1
LEFT FRONT
WHEEL SPEED SENSORSIDE MARKER LAMPLEFT FRONT
1 2
NATURAL
HEADLAMP SWITCH OUTPUT 20BK/YL L7 2GROUND Z1 20BK 1
FUNCTION CIRCUIT CAV
(EXCEPT BUILT-UP-EXPORT)
L250 18WT
1 3
Z1 18BK GROUND
3 2
LEFT TURN SIGNAL L161 18LG/OR 1
FUNCTION CIRCUIT CAV
(BUILT-UP-EXPORT)LEFT FRONT
TURN SIGNAL LAMPFOG LAMP
CAV CIRCUIT FUNCTION
BL39 18LB FUSED FOG LAMP SWITCH OUTPUT A
Z1 18BK GROUND BLACK
A
B
LEFT FRONT
(EXCEPT CHRYSLER)
NATURAL
DUMMY CIRCUIT PLUG
(BUILT-UP-EXPORT)
2
LEFT HEADLAMP
CAV CIRCUIT FUNCTION
1 L3 16RD/OR DIMMER SWITCH HIGH BEAM OUTPUT
L43 14VT FUSED LEFT LOW BEAM OUTPUT
3
Z1 14BK GROUND 2
13
PL8W-80 CONNECTOR PIN-OUTS 8W - 80 - 29
PLI08029J008W-10

MOTOR DOOR LOCKLEFT REAR
DOOR LOCK DRIVER 18OR/BK P33 DOOR UNLOCK DRIVER 18PK/VT P36
CAV CIRCUIT FUNCTION
1
B3 20LG/DB LEFT REAR WHEEL SPEED SENSOR (-) 2B4 20LG1
BLUE
2
LEFT REAR
WHEEL SPEED
SENSOR SPEAKER LEFT REAR
2 1
BLACK
LEFT REAR SPEAKER (-) 18BR/LB X57
2
LEFT REAR SPEAKER (+) 18BR/YL X51 1
FUNCTION CIRCUIT CAV
12-VOLT SUPPLY BLACK
34
2 1CAV
3
4 2
- - 1
FUNCTION CIRCUIT
--
REAR FOG LAMP FEED
L38 16BR/WT L250 18YL
31
FOG LAMP LEFT REAR
GROUND
Z1 16BKFUNCTION
CAV CIRCUIT
1
2
3
1 3
L63 18DG/RD LEFT TURN SIGNAL
3 2
GROUND 18BK Z1 1
FUNCTION CIRCUIT CAV
(BUILT-UP-EXPORT)LEFT REAR TURN
SIGNAL LAMP
--
(BUILT-UP-EXPORT)
DUMMY CIRCUIT PLUG
GRAY
GRAY
PL8W-80 CONNECTOR PIN-OUTS 8W - 80 - 31
PLI08031008W-10

(BUILT-UP-EXPORT)
(EXCEPT BUILT-UP-EXPORT)
2
RIGHT HEADLAMP WHEEL SPEED SENSORRIGHT FRONT SIDE MARKER LAMPRIGHT FRONT
RIGHT HEADLAMP
CAV CIRCUIT FUNCTION
1 L3 16RD/OR DIMMER SWITCH HIGH BEAM OUTPUT
L44 14VT/RD FUSED RIGHT LOW BEAM OUTPUT
3
Z1 14BK GROUND
1
BLACK
2
DIMMER SWITCH HIGH BEAM OUTPUT 16RD/OR L3 3GROUND 14BK Z1 2
FUSED RIGHT LOW BEAM OUTPUT 14VT/RD L44 1
FUNCTION CIRCUIT CAV
12-VOLT SUPPLY 18WT B7
2RIGHT FRONT WHEEL SPEED SENSOR (-) 18WT/DB B6 1
FUNCTION CIRCUIT CAV
1 2
NATURAL
HEADLAMP SWITCH OUTPUT 20BK/YL L7 2GROUND Z1 18BK 1
FUNCTION CIRCUIT CAV
31
BLACK
2
(EXCEPT BUILT-UP-EXPORT)
DUMMY CIRCUIT PLUG L250 18WT
1 3
(BUILT-UP-EXPORT)
CAV CIRCUIT FUNCTION
1
Z1 18BK GROUND
2
3L160 18TN/RD RIGHT TURN SIGNAL
RIGHT FRONT TURN
SIGNAL LAMP
NATURAL
2
13
8W - 80 - 42 8W-80 CONNECTOR PIN-OUTSPL
J008W-10PLI08042