service schedule DODGE POWER WAGON 2005 2.G User Guide

EMISSION CONTROL SYSTEM MAINTENANCE
The“Scheduled”maintenance services, listed inbold
typein this section (Section 8) must be done at the times
or mileages specified to assure the continued proper
functioning of the emission control system. These, and all
other maintenance services included in this manual,
should be done to provide best vehicle performance and
reliability. More frequent maintenance may be needed for
vehicles in severe operating conditions such as dusty
areas and very short trip driving.
Inspection and service also should be done any time a
malfunction is suspected.
NOTE:Maintenance, replacement, or repair of the emis-
sion control devices and systems on your vehicle may be
performed by any automotive repair establishment or
individual using any automotive part which has been
certified pursuant to U.S. EPA or, in the State of Califor-
nia, California Air Resources Board regulations.
MAINTENANCE SCHEDULES
There are two maintenance schedules that show the
requiredservice for your vehicle.
First is Schedule“B”. It is for vehicles that are operated
under the conditions that are listed below and at the
beginning of the schedule.
•Day or night temperatures are below 32°F(0°C).
•Stop and go driving.
•Extensive engine idling.
•Driving in dusty conditions.
•Short trips of less than 10 miles (16 km).
•More than 50% of your driving is at sustained high
speeds during hot weather, above 90°F C (32°).
•Trailer towing.
•Snowplowing.
410 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

•Heavy Loading.
•Taxi, police, or delivery service (commercial service).
•Off-road or desert operation.
•If equipped for and operating with E-85 (ethanol)
fuel.
NOTE:IfANYof these apply to you then change your
engine oil every 3,000 miles (5 000 km) or 3 months,
whichever comes first and follow schedule“B”of the
Maintenance Schedulessection of this manual.
NOTE:IfANYof these apply to you then flush and
replace your engine coolant every 102,000 miles (163 000
km) or 60 months, whichever comes first and follow
schedule“B”of theMaintenance Schedulessection of
this manual.
NOTE:Most vehicles are operated under the conditions
listed for ScheduleB.Second is Schedule“A”. It is for vehicles that are not
operated under any of the conditions listed under Sched-
uleB.
Use the schedule that best describes your driving condi-
tions. Where time and mileage are listed, follow the
interval that occurs first.
NOTE:Under no circumstances should oil change in-
tervals exceed 6000 miles (10 000 km) or 6 months
whichever comes first.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
MAINTENANCE SCHEDULES 411
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Schedule“B”
Follow schedule“B”if you usually operate your vehicle
under one or more of the following conditions.
•Day or night temperatures are below 32°F(0°C).
•Stop and go driving.
•Extensive engine idling.
•Driving in dusty conditions.
•Short trips of less than 10 miles (16 km).
•More than 50% of your driving is at sustained high
speeds during hot weather, above 90°F C (32°).
•Trailer towing.
•Snowplowing.
•Heavy Loading.
•Taxi, police, or delivery service (commercial service).
•Off-road or desert operation.
•If equipped for and operating with E-85 (ethanol)
fuel.
NOTE:IfANYof these apply to you then change your
engine oil every 3,000 miles (5 000 km) or 3 months,
whichever comes first and follow schedule“B”of the
Maintenance Schedulessection of this manual.
NOTE:IfANYof these apply to you then flush and
replace your engine coolant every 102,000 miles (163 000
km) or 60 months, whichever comes first and follow
schedule“B”of theMaintenance Schedulessection of
this manual.
If none of these apply to you, then change your engine oil
at every interval shown on scheduleAof theMainte-
nance Schedulessection of this manual.
SCHEDULE“B”413
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 105,000 108,000 111,000 114,000 117,000 120,000
(Kilometers) (168 000) (173 000) (178 000) (182 000) (187 000) (192 000)
Inspect PCV valve, replace as necessary.**X
Inspect auto tension drive belt and replace if
required.XX
Drain and refill automatic tranmission fluid
and change main sump and spin-on cooler
return filter (if equipped) [545RFE only].X
* This applies only if the vehicle is used for frequent
trailer towing, snowplowing, fleet vehicle or commercial
service.
**This maintenance is recommend, but not required.Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
SCHEDULE“B”423
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
**This maintenance is recommend, but not required.
WARNING!
You can be badly injured working on or around a
motor vehicle. Do only that service work for which
you have the knowledge and the right equipment. If
you have any doubt about your ability to perform a
service job, take your vehicle to a competent me-
chanic.
428 SCHEDULE“A”
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Hazard Warning Flasher................. 334
Headlights........................... 111
High Beam........................ 115,158
High Beam Indicator.................... 158
High Beam/Low Beam Select.............. 115
Instrument Cluster..................... 157
Intensity Control....................... 110
Interior........................... 110,122
Lights On Reminder.................... 113
Low Washer Fluid..................... 164
Passing............................. 114
Seat Belt Reminder..................... 159
Service.............................. 394
Transfer Case......................... 280
Transmission Warning................165,327
Turn Signal.................. 113,158,394,398
Warning (Instrument Cluster Description)..... 157
Limited-Slip Differential................281,379
Loading Vehicle......................... 315Tires ............................... 291
Locks................................. 18
Child Protection........................ 23
Door................................ 18
Ignition.............................. 15
Keys................................ 12
Power Door........................... 19
Steering Wheel......................... 15
Lower Anchors and Tether for CHildren (LATCH) . 63
Lubricants............................. 383
Lubrication, Body....................... 369
Lug Nuts............................. 341
Lumbar Support........................ 105
Maintenance........................... 356
Maintenance Free Battery.................. 364
Maintenance Procedures................... 356
Maintenance Schedule.................... 410
ScheduleA......................... 424
INDEX 447
10

ScheduleB.......................... 413
Malfunction Indicator Light................ 354
Manual, Service......................... 436
Manual Transmission..................275,379
Fluid Level Check...................... 379
Lubricant Selection..................379,408
Mirrors................................ 84
Automatic Dimming..................... 85
Electric Powered....................... 87
Outside.............................. 86
Rearview............................. 84
Trailer Towing......................88,326
Modifications/Alterations, Vehicle............. 7
Mopar Parts.........................356,435
Multi-Function Control Lever............... 113
Noise Control
Maintenance.......................... 384
Tampering Prohibited................384,385Noise Emission Warranty.................. 386
Occupant Restraints....................... 35
Octane Rating, Gasoline................... 307
Odometer..........................163,164
Trip .............................163,164
Off-Pavement Driving.................... 224
Off-Road Driving........................ 224
Oil, Engine.........................356,407
Capacity............................ 406
Change Interval....................... 357
Dipstick............................. 356
Disposal............................ 360
Filter............................360,407
Filter Disposal........................ 360
Identification Logo..................... 359
Materials Added to..................... 360
Pressure Gauge....................... 159
Recommendation...................358,406
448 INDEX