ABS DODGE SPRINTER 2007 2.G User Guide

268 Practical hintsWhat to do if ...
5
Indicator and warning lamps in the
instrument clusterWarning
G
Always have maintenance work carried out
at an authorized Sprinter Dealer which has
the necessary specialist knowledge and
tools to carry out the work required.
The manufacturer recommends that you use
an authorized Sprinter Dealer for this pur-
pose.
In particular, work relevant to safety or on
safety-related systems must be carried out
at an authorized Sprinter Dealer. There is a
risk of an accident and injury if this work is
carried out incorrectly.
Problem
Possible cause / result
Suggested solutions
v
The yellow ASR/ESP
® warning
lamp flashes while the vehicle is
in motion.
WARNING
G
ESP
® or ASR is intervening because at least
one of the wheels has reached its tire grip
limit.
\1Adapt your driving style to suit the
road and traffic conditions. Do not
use too much throttle.
\1Drive slowly.
The yellow ASR / ESP
® warning
lamp is lit while the engine is run-
ning.
WARNING
G
ASR is deactivated.
\1Reactivate ASR.
Exceptions (\2page 45).
#
-
k
6
The yellow ESP
®, ABS-, ASR/
BAS indicator lamps and the red
brake system indicator lamp are
lit while the engine is running.
WARNING
G
EBV has malfunctioned.
The rear wheels could lock up sooner than
expected when you apply the brakes.
\1Also observe the messages in the dis-
play on vehicles with steering wheel
buttons (\2page 284).
\1Continue driving, but with even great-
er care.
\1Have the system checked at an autho-
rized Sprinter Dealer as soon as pos-
sible.

269 Practical hints
What to do if ...
5
#
-
k
6
The yellow ESP
®, ABS, ASR/BAS
indicator lamps and the red
brake system indicator lamp are
lit while the engine is running.
WARNING
G
EBV has been deactivated due to undervolt-
age.
The battery may not be being charged.
The rear wheels could lock up sooner than
expected when you apply the brakes.
\1Also observe the messages in the dis-
play on vehicles with steering wheel
buttons (\2page 284).
\1Stop your vehicle as soon as it is safe
to do so.
\1Do not drive any further.
\1Consult an authorized Sprinter Dealer.
6
The red brake system indicator
lamp is lit while the engine is run-
ning.
A signal also sounds.
WARNING
G
There is insufficient brake fluid in the fluid
reservoir.
\1Also observe the messages in the dis-
play on vehicles with steering wheel
buttons (\2page 284).
\1Do not add brake fluid under any cir-
cumstances. This will not solve the
problem.
\1Do not drive any further.
\1Consult an authorized Sprinter Dealer.
6
When towing a trailer:
The red brake system indicator
lamp is lit while the engine is run-
ning.
A signal also sounds.
WARNING
G
The trailer's brake booster is malfunctioning.
The vehicle's driving and braking characteris-
tics may change. There is a risk of the trailer
overbraking.
\1Also observe the messages in the dis-
play on vehicles with steering wheel
buttons (\2page 284).
\1Stop your vehicle as soon as it is safe
to do so.
\1Do not drive any further.
\1Consult an authorized Sprinter Dealer.
Problem
Possible cause / result
Suggested solutions

271 Practical hints
What to do if ...
5
-
The yellow ABS indicator lamp is
lit while the engine is running.
WARNING
G
ABS has been deactivated due to a malfunc-
tion. ESP
®, ASR and BAS as well as cruise
control have also been deactivated as a re-
sult.
The brake system continues to function
with the normal braking effect but with no
electronic support. The wheels could there-
fore lock up, for example if the brakes are
applied with maximum force.
\1Also observe the messages in the dis-
play on vehicles with steering wheel
buttons (\2page 284).
\1Continue driving, but with even great-
er care.
\1Have the system checked at an autho-
rized Sprinter Dealer as soon as pos-
sible.
WARNING
G
ABS is temporarily unavailable.
Self diagnosis may not have been complet-
ed yet.
The brake system is still available with the
normal braking effect.
\1Drive on for a distance of more than
13 mph (20 km / h).
ABS is available again if the message
goes out.
ABS has been deactivated due to undervolt-
age.
The battery may not be being charged.
The brake system continues to function
with the normal braking effect but with no
electronic support. The wheels could there-
fore lock up, for example if the brakes are
applied with maximum force.
\1Continue driving, but with even great-
er care.
\1Have the system checked at an autho-
rized Sprinter Dealer as soon as pos-
sible.
Problem
Possible cause / result
Suggested solutions

285 Practical hints
Display messages
5
Text messagesDisplay messages
Possible cause / result
Possible solution
ABS
Visit workshop
WARNING
G
ABS has been deactivated due to a malfunc-
tion. ESP
®, ASR and BAS as well as cruise
control have also been deactivated as a re-
sult.
The brake system is still available with the
full brake boosting effect but without ABS.
\1Continue driving, but with even greater
care.
\1Have the system checked at an autho-
rized Sprinter Dealer as soon as possi-
ble.
unavailable
WARNING
G
ABS is temporarily unavailable.
Self diagnosis may not have been complet-
ed yet.
The brake system is still available with the
normal braking effect.
\1Drive on for a distance of more than
13 mph (20 km / h).
ABS is available again if the message
goes out.
ABS has been deactivated due to undervolt-
age.
The battery may not be being charged.
The brake system is still available with the
normal braking effect.
\1Continue driving, but with even greater
care.
\1Visit an authorized Sprinter Dealer im-
mediately.

299 Practical hints
Where will I find...?
5
The warning triangles are behind the driv-
er's seat.
1Warning triangles
\1Remove warning triangles1 from the
brackets upward.The fire extinguisher is secured to the front
of the co-driver’s seat base.
1Fire extinguisher
2Tabs
\1Pull tabs2 upward.
\1Take fire extinguisher1 out of the
bracket.The first-aid kit is located in the storage
compartment in the co-driver’s door.
1Locked
2Unlocked
Turn the two quick-release locks clockwise
to unlock2 and fold out the cover.
Warning triangle and warning lamp
N72.10-2148-31
Fire extinguisheriRead the instructions on the fire extin-
guisher carefully and familiarize your-
self with its operation.
First-aid kit

347 Practical hintsFuses
5
Fuse block F55/1Fuse block F55/2
No.
Consumer
Amp.
1
Horn
15 A
2
Electric steering lock ESTL
(electronic ignition switch
EIS)
25 A
3
Te rm ina l 30 Z , ve hi cle s wit h
gasoline engine/electronic
ignition switch EIS/instru-
ment cluster
10 A
4
Light switch/center
console switch unit
5A
5
Windshield wipers
30 A
6
Fuel pump
15 A
7
MRM (jacket tube module)
5A
8
Terminal 87 (2)
20 A
9
Terminal 87 (3)
20 A
10
Terminal 87 (4)
10 A
11
Terminal 15 R vehicle
15 A
12
Airbag control unit
10 A
13
Cigarette lighter/glove box
lighting/radio*
15 A
14
Diagnostic socket/light
switch/instrument cluster
5A
No.
Consumer
Amp.
15
Front heating system
5A
16
Terminal 87 (1)
10 A
17
Airbag control unit
10 A
18
Terminal 15 vehicle, brake
lamp switch
7.5 A
19
Interior lights
7.5 A
20
Power window co-driver’s
side/terminal 30/2 signal
acquisition and actuation
module SAM
25 A
21
Engine control unit
5A
22
Antilock Brake System
(ABS)
5A
23
Starter motor
25 A
24
Diesel engine components
10 A
25
12V socket on the bottom
of the center console
25 A
No.
Consumer
Amp.
1
Control panel, left door
25 A
2
Diagnostic socket
10 A
No.
Consumer
Amp.
3
Brake system (valves)
25 A
4
Brake system (delivery
pump)
40 A
5
Terminal 87 (5), vehicles
with gasoline engine
7.5 A
6
Terminal 87 (6), vehicles
with gasoline engine
7.5 A
7
Headlamp cleaning system*
30 A
8
Anti-theft alarm system
(ATA)
15 A
9
Unassigned
–
No.
Consumer
Amp.
10
Radio*
15 A
11
Telephone*
7.5 A
12
Front blowers
30 A
13
Unassigned
–
14
Seat heating*/center
console switch unit
30 A

362 *Technical dataService products and capacities
6
Coolants, lubricants, etc.
Service
interval
Product name/product number
MB
sheet
MS-
No.
1
Air conditioning
The air conditioning system of your vehicle contains R-134a, a refrigerant that does not deplete the ozone layer in the upper atmo-
sphere.Refrigerant R-134a
—
Refrigerant R-134a
361.0
Automatic transmissionAutomatic transmission fluid
10 years
60,000 mi
(96,000 km)
MOPAR
® 05127382AB
Shell ATF 3403
Shell ATF 3353
236.10
236.12
BrakesUse brake fluid approved for DaimlerChrysler standard MB 331.0 and/or DaimlerChrysler material standard MS-9971, brake fluid certified
to DOT 4 Plus standards, that also maintains a minimum dry boiling point (ERBP) of 500 °F (260°C), a minimum wet boiling point (WERBP)
of 356 °F (180 °C) and a maximum viscosity of 1500 mm
2/s, conforming to FMVSS 116 and ISO 4925.
Brake fluid
2 years
2
Intac B026E Dry boiling point: 500°F (260°C)
Wet boiling point: 356°F (180°C)
MOPAR
® MS-9971 Part No. 04549625AC or equivalent
331.0
9971
1 DaimlerChrysler Material Standard-No.
2 Over the course of a brake fluid’s service life, its boiling point falls due to the continuous absorption of moisture from the atmosphere. If the boiling point of the
brake fluid is too low, vapor pockets may form in the brake system when the brakes are applied hard (e.g. when driving on long downhill stretches). This has a det-
rimental effect on braking efficiency, which could increase the stopping distance. This increases the risk of an accident. Have the brake fluid renewed every 2 years.

367 *Technical data
Rims and tires
6
\3 Rims and tires
!
CAUTION
Only use tires which have been tested
and approved for your Sprinter vehicle
by the vehicle manufacturer. Tires ap-
proved by the vehicle manufacturer are
developed to provide the best possible
performance in conjunction with the
driving safety systems on your Sprinter
vehicle such as ABS, BAS, ASR or ESP
®.
Using tires other than those approved
by the vehicle manufacturer may result
in damage that is not covered by the
Sprinter warranty.
Using tires other than those approved
by the vehicle manufacturer can have
detrimental effects, such as
\4poor handling characteristics
\4increased noise
\4increased fuel consumption
Moreover, tires and rims not approved
by the vehicle manufacturer may, un-
der load, exhibit dimensional variations
and different tire deformation charac-
teristics that could cause them to come
into contact with the vehicle body or
axle parts. Damage to the tires or the
vehicle may be the result.
Warning
G
Loose wheel nuts or bolts could cause the
vehicle to lose a wheel while it is in motion.
This would jeopardize the operating and
road safety of the vehicle. You could lose
control of the vehicle as a result, cause an
accident an injure yourself or others.
If a wheel was replaced or new wheel nuts
are used, the wheel bolts or wheel nuts must
be retightened to the specified tightening
torque after 30 miles (50 km).
If new or repainted wheels are mounted, the
wheel bolts or wheel nuts must be retight-
ened again to the specified tightening
torque after approximately 600 to 3000
miles (about 1000 to 5000 km).
iFurther information on tires and rims is
available at any authorized Sprinter
Dealer. A placard with the recommend-
ed tire inflation pressures is located on
\4the driver’s door B-pillar for vehi-
cles with a gross weight capacity
less than 10,000 lbs (4500 kg)
(\2page 375)
\4on a label below the driver’s seat on
an outward facing position of the
mounting pillar for vehicles with a
gross weight capacity above
10,000 lbs (4500 kg) (\2page 375)
The tire inflation pressure should be
checked regularly and should only be
adjusted on cold tires.

371 *Technical data
Lashing points and carrier systems
6
\3 Lashing points and carrier systemsYou will find further information on the
lashing eyes in the "Operation" section
(\2page 158).Lashing eyes
The maximum tensile load of the lashing
eyes is:
Load rails*
The maximum tensile load of the lashing
points in the load compartment is:The specified values only apply to loads on
the load compartment floor if:
\4the load is secured to 2 lashing points
on the rail and
\4the distance to the next lashing point
used on the same rail is about 3 ft
(1 m).Lashing points!
CAUTION
Observe the data on the maximum
load-bearing capacity of the individual
lashing points.
During full-braking applications, for ex-
ample, forces can be involved that are
much greater than the weight force of
the load.
Always use several lashing points in or-
der to distribute force absorption, and
make sure that the lashing points have
an equal load.
Lashing eyes
Permissible nom-
inal tensile force
Crewbus
3500 N
Panel van
5000 N
Lashing point
Permissible nom-
inal tensile force
Load rails in the
load compartment
floor
5000 N
Lower load rail on
the side wall
2500 N
Upper load rail on
the side wall
1500 N

377
Numerics
12 V socket
. . . . . . . . . . . . . . . . . . . 170
A
ABS
see Antilock Brake System
Acceleration skid control (ASR)
. . . 44
activating/deactivating
. . . . . . . . . . 45
display message
. . . . . . . . . . . . . . 291
indicator lamp
. . . . . . . . . . . . 268
–270
malfunction
. . . . . . . . . . . . . . . . . . 270
warning lamp . . . . . . . . . . . . . . 44
, 268
Accessory weight
. . . . . . . . . . . . . . 228
Accident
. . . . . . . . . . . . . . . . . . . . . . 251
Additional turn signal lamp
. . . . . . 307
ADR
see Operating speed governor
Air conditioning in the rear . . . . . . 136
Air conditioning, regulated
refrigerant
. . . . . . . . . . . . . . . . . . . 362
Air pressure
see Tire inflation pressure
Air vents
air distribution
. . . . . . . . . . . . . . . . 133
in the rear
. . . . . . . . . . . . . . . . . . . 137
Airbag
co-driver's . . . . . . . . . . . . . . . . . . . . 33driver's
. . . . . . . . . . . . . . . . . . . . . . . 33
safety notes
. . . . . . . . . . . . . . . . . . . 31
thorax sidebag . . . . . . . . . . . . . . . . . 34
windowbag
. . . . . . . . . . . . . . . . . . . . 35
Air-conditioning system
see Tempmatic
Air-conditioning system in the rear
compartment
air cleaner . . . . . . . . . . . . . . . . . . . 240
Air-recirculation mode
air conditioning in the rear
. . . . . . . 136
rear heating
. . . . . . . . . . . . . . . . . . 136
Tempmatic . . . . . . . . . . . . . . . . . . . 133
Alarm
audible
. . . . . . . . . . . . . . . . . . . . . . 250
Anticorrosion/antifreeze fluid
. . . 363
Antilock Brake System (ABS)
. . . . . 42
display message
. . . . . . . . . . . . . . 285
indicator lamp
. . . . . . . 268
, 269
, 271
malfunction
. . . . . . . . . . . . . . . . . . 271
Anti-theft alarm system (ATA)
. . . . . 47
malfunction
. . . . . . . . . . . . . . . . . . 250
switching off the alarm
. . . . . . . . . . 47
Anti-theft system
immobilizer
. . . . . . . . . . . . . . . . . . . 47
see Anti-theft alarm
system (ATA)
Aquaplaning
see HydroplaningArmrest
. . . . . . . . . . . . . . . . . . . . . . . 72
Ashtray . . . . . . . . . . . . . . . . . . . . . . . 168
Aspect ratio
. . . . . . . . . . . . . . . . . . . 228
ASR
see Acceleration skid control
ASSYST
. . . . . . . . . . . . . . . . . . . . . . . 238
calling up the due date
vehicles with steering wheel
buttons
. . . . . . . . . . . . . . . . . . . . 239
vehicles without steering wheel but-
tons
. . . . . . . . . . . . . . . . . . . . . . 240
Attaching lashing straps
. . . . . . . . 158
Attaching locking rods
. . . . . . . . . . 158
Audible alarm
. . . . . . . . . . . . . . . . . 250
Automatic car wash
. . . . . . . . . . . . 242
headlamps
. . . . . . . . . . . . . . . . . . . 193
windshield . . . . . . . . . . . . . . . . . . . 193
Automatic headlamp control
. . . . . . 78
Automatic locking
. . . . . . . . . . . . . . . 64
entire vehicle
. . . . . . . . . . . . . . . . . . 65
rear doors
. . . . . . . . . . . . . . . . . . . . 65
Automatic transmission
. . . . . . . . . 121
accelerator pedal position . . . . . . . 123
changing gear yourself
. . . . . . . . . . 122
driving tips
. . . . . . . . . . . . . . . . . . . 123
fluid
. . . . . . . . . . . . . . . . . . . . . . . . 362
gearshift pattern
. . . . . . . . . . . . . . 121
kickdown
. . . . . . . . . . . . . . . . . . . . 123
malfunctions
. . . . . . . . . . . . . . . . . 256
Index
A