tow DODGE SPRINTER 2008 2.G Owner's Guide

360 OperationTires and wheels
4
To assure that your vehicle does not ex-
ceed the maximum permissible weight
limits (GVWR and GAWR for front and
rear axle and GCWR), have the loaded
vehicle (including driver, passengers and
all cargo and, if applicable, trailer fully
loaded) weighed on a suitable commer-
cial scale.
Trailer tongue loadThe tongue load (tongue weight at the
hitch ball) of any trailer is an important
weight to measure because it affects the
load you can carry in your vehicle. If a
trailer is towed, the tongue load must be
added to the weight of all occupants
riding and any cargo you are carrying in
the vehicle to prevent exceeding your
Sprinter tow vehicle’s rear GAWR. The
tongue load is 10% of the trailer weight
and everything loaded in it.For example, if the trailer tongue load
equals 140 lbs (63.5 kg) and the deter-
mined available cargo/luggage and trail-
er tongue weight equals 500 lbs (227
kg), the amount of available cargo and
luggage load capacity is 360 lbs (500 –
140 = 360 lbs) (163.5 kg (227 – 63.5 =
163.5 kg)).
For further information on vehicle and
trailer weights and ratings, loading a
trailer and trailer towing, see “Trailer
towing” (
\2
page303).
nf_BA.book Page 360 Friday, January 25, 2008 3:53 PM

429 Practical hints
5 Practical hints
What to do if .............. 430
Display messages........... 484
Where will I find...?........... 513
Changing bulbs........... 525
Changing the batteries........... 539
Fuel system........... 542
Replacing the wiper blades........... 545
Flat tire........... 547
Battery........... 573
Jump-starting........... 581
Towing........... 585
Fuses........... 589
nf_BA.book Page 429 Friday, January 25, 2008 3:53 PM

447 Practical hints
What to do if ...
5
It is no longer possible to lock or unlock the
vehicle using the remote control.
The remote control batteries are weak or dis-
charged.
\1Point the remote control towards the
driver’s door handle at close range and
try again.
If this does not work:
\1Lock or unlock the vehicle using the key
(\2page 88).
\1Check the batteries of the remote
control (\2page 86). Change the
batteries if necessary (\2page 540).
The remote control is malfunctioning.
\1Lock or unlock the vehicle using the key
(\2page 88).
\1Have the remote control checked at an
authorized Sprinter Dealer.
Problem
Possible cause / result
Suggested solutions
nf_BA.book Page 447 Friday, January 25, 2008 3:53 PM

464 Practical hintsWhat to do if ...
5
6
When towing a trailer:
The red brake system indicator
lamp is lit while the engine is run-
ning.
A signal also sounds.
WAR NING
G
The trailer's brake booster is malfunctioning.
The vehicle's driving and braking characteris-
tics may change. There is a risk of the trailer
overbraking.
\1Also observe the messages in the dis-
play on vehicles with steering wheel
buttons (\2page 489).
\1S t o p y o u r v e h i c l e a s s o o n a s i t i s s a f e t o
do so.
\1Do not drive any further.
\1Consult an authorized Sprinter Dealer.
Problem
Possible cause / result
Suggested solutions
nf_BA.book Page 464 Friday, January 25, 2008 3:53 PM

472 Practical hintsWhat to do if ...
5
:

The yellow engine oil level
warning lamp lights up, the
-
2.0 l
engine oil level mes-
sage appears in the display
and the warning buzzer
sounds after the engine is
started or while the vehicle
is in motion.
There is insufficient or no oil in the engine.
There is a risk of engine damage.
\1Stop your vehicle as soon as it is safe to
do so.
\1Switch off the engine.
\1Check the engine oil level using the dip-
stick (\2page 328).
\1If the oil level is correct, have the mal-
function rectified immediately at an au-
thorized Sprinter Dealer.
\1If there is insufficient or no oil in the en-
gine, have the vehicle towed to an au-
thorized Sprinter Dealer.
Problem
Possible cause / result
Suggested solutions
nf_BA.book Page 472 Friday, January 25, 2008 3:53 PM

475 Practical hints
What to do if ...
5
•
The red coolant warning
lamp lights up while the en-
gine is running.
The coolant temperature is too high.
\1Do not drive any further.
\1Consult an authorized Sprinter Dealer.
If the vehicle is switched off after being sub-
jected to extreme loads (for example driving
in mountainous terrain, trailer towing, etc.),
the coolant warning lamp may light up when
the ignition is switched on or the engine is
restarted. Run the engine for approximately
1 minute at idling speed.
Consult an authorized Sprinter Dealer if the
coolant warning lamp remains lit.
A
The yellow reserve fuel
warning lamp lights up while
the vehicle is in motion.
The fuel level has fallen into the reserve range.
\1Refuel at the nearest refueling station
(\2page 316).
Problem
Possible cause / result
Suggested solutions
nf_BA.book Page 475 Friday, January 25, 2008 3:53 PM

486 Practical hintsDisplay messages
5
Display messages
Possible cause / result
Possible solution
N
There is insufficient or no oil in the engine.
There is a risk of engine damage.
\1Stop your vehicle as soon as it is safe
to do so.
\1Switch off the engine.
\1Check the engine oil level using the
dipstick (\2page 326).
\1If the oil level is correct, have the mal-
function rectified immediately at an au-
thorized Sprinter Dealer.
\1If there is insufficient or no oil in the
engine, have the vehicle towed to an
authorized Sprinter Dealer.
nf_BA.book Page 486 Friday, January 25, 2008 3:53 PM

502 Practical hintsDisplay messages
5
Z
Coolant
Stop, turn engine
off
The coolant temperature is too high.
\1Do not drive any further.
\1Consult an authorized Sprinter Dealer.
If the vehicle is switched off after being
subjected to extreme loads (for example driving
in mountainous terrain, trailer towing, etc.), this
message may be displayed when the ignition is
switched on or the engine is restarted. Run the
engine for approximately 1 minute at idling
speed.
Consult an authorized Sprinter Dealer if the
message remains displayed.
H
Coolant
Check level
The coolant level is too low.
Never run the engine if the coolant level is
too low. The engine could overheat and be
damaged.
\1Add coolant (\2page 329).
\1If you are having to add coolant frequently,
have the cooling system checked at an au-
thorized Sprinter Dealer.
Display symbol
Display message
Possible cause / result
Possible solution
nf_BA.book Page 502 Friday, January 25, 2008 3:53 PM

508 Practical hintsDisplay messages
5
N
Engine oil level
Stop, turn engine
off
There is insufficient or no oil in the engine.
There is a risk of engine damage.
\1Stop your vehicle as soon as it is safe to do
so.
\1Switch off the engine.
\1Check the engine oil level using the dipstick
(\2page 326).
\1If the oil level is correct, have the malfunc-
tion rectified immediately at an authorized
Sprinter Dealer.
\1If there is insufficient or no oil in the engine,
have the vehicle towed to an authorized
Sprinter Dealer.
Display symbol
Display message
Possible cause / result
Possible solution
nf_BA.book Page 508 Friday, January 25, 2008 3:53 PM

524 Practical hintsWhere will I find...?
5
In the event of a malfunction, it is possi-
ble to manually release the selector le-
ver from the lock in parking position
P,
for example to have the vehicle towed
away.
1Cover cap
\1
Remove cover cap
1
.
2Pencil\1
Insert a pencil
2
or similar imple-
ment into the opening.
\1
Press pencil
2
in and at the same
time move the selector lever out of
position
P.
\1
Pull out pencil
2
.
\1
Clip cover cap
1
back on.
Releasing the parking lock manu-
ally
N27.60-2088-31
N27.60-2089-31
nf_BA.book Page 524 Friday, January 25, 2008 3:53 PM