ESP DODGE SPRINTER 2008 2.G Service Manual

336 OperationBattery
4
Warning (Continued)
G
C
Keep out of the reach of chil-
dren.
Children cannot appreciate the
dangers involved in handling
batteries and acid.
E
Wear eye protection.
When mixing water and acid, the
liquid can splash in your eyes.
Rinse out your eyes immediately
after acid splashes with clean
water, and consult a doctor im-
mediately.
Continued
Warning (Continued)
G
F
When handling batteries, ob-
serve the safety precautions
and special protective measures
contained in these operating in-
structions.
Environmental note
H
Á
Batteries contain pollutants. Do
not dispose of old batteries with
the household garbage.
À
Dispose of batteries in an environ-
mentally responsible manner.
Take batteries to an authorized
Sprinter Dealer or a special collec-
tion point for old batteries.
Transport and store full batteries
in an upright position. When trans-
porting batteries, secure them so
that they do not tip over. Battery
acid can spill from the cell cap
vents and cause damage to the
environment.
nf_BA.book Page 336 Friday, January 25, 2008 3:53 PM

342 OperationTires and wheels
4
For more information on tire size desig-
nation, load and speed rating, see "Tire
labeling" (
\2
page 382).
See an authorized Sprinter Dealer for in-
formation on tested and recommended
rims and tires for summer and winter op-
eration. They can also offer advice con-
cerning tire service and purchase.
!
CAUTION
Only use tires which have been test-
ed and approved for your Sprinter ve-
hicle by the vehicle manufacturer.
Tires approved by the vehicle manu-
facturer are developed to provide the
best possible performance in con-
junction with the driving safety sys-
tems on your Sprinter vehicle such as
ABS, BAS, ASR or ESP
®.
Using tires other than those ap-
proved by the vehicle manufacturer
may result in damage that is not cov-
ered by the Sprinter vehicle warran-
ty.
!
CAUTION
Using tires other than those ap-
proved by the vehicle manufacturer
can have detrimental effects, such as
\4
poor handling characteristics
\4
increased noise
\4
increased fuel consumption
Tires and rims not approved by the
vehicle manufacturer may, under
load, exhibit dimensional variations
and different tire deformation char-
acteristics that could cause them to
come into contact with the vehicle
body or axle parts. Damage to the
tires or the vehicle may be the result.
nf_BA.book Page 342 Friday, January 25, 2008 3:53 PM

370 OperationTires and wheels
4
Warning (Continued)
G
As an added safety feature, your vehicle
has been equipped with a Tire Pressure
Monitoring System (TPMS) that illumi-
nates a low tire pressure telltale when one
or more of your tires is significantly under-
inflated. Accordingly, when the low tire
pressure telltale illuminates, you should
stop and check your tires as soon as pos-
sible, and inflate them to the proper pres-
sure. Driving on a significantly
underinflated tire causes the tire to over-
heat and can lead to tire failure.
Continued
Warning (Continued)
G
Underinflation also reduces fuel efficiency
and tire tread life, and may affect the ve-
hicle’s handling and stopping ability.
Please note that the TPMS is not a substi-
tute for proper tire maintenance, and it is
the driver’s responsibility to maintain cor-
rect tire pressure, even if underinflation
has not reached the level to trigger illumi-
nation of the TPMS low tire pressure tell-
tale.
Continued
Warning (Continued)
G
USA only:Your vehicle has also been equipped with a
TPMS malfunction indicator to indicate when
the system is not operating properly. The
TPMS malfunction indicator is combined
with the low tire pressure telltale. When the
system detects a malfunction, the telltale will
flash for approximately 1 minute and then re-
main continuously illuminated. This se-
quence will continue upon subsequent
vehicle start-ups as long as the malfunction
exists. When the malfunction indicator is illu-
minated, the system may not be able to de-
tect or signal low tire pressure as intended.
Continued
nf_BA.book Page 370 Friday, January 25, 2008 3:53 PM

372 OperationTires and wheels
4
\1
Make sure the tire inflation pressure
of all four tires is correct, using the
tire and loading information placard
1 or the tire inflation pressure placard
located on the driver’s door B-pillar
(
\2
page 362).
In addition to the placard also con-
sult the tire inflation pressure table
(
\2
page 628).
Warning
G
It is the driver’s responsibility to calibrate
the TPMS on the recommended cold infla-
tion pressure. Underinflated tires affect
the ability to steer or brake the vehicle.
You might lose control over the vehicle.1. For vehicles with a gross weight capacity less
than 10 000 lbs (4 536 kg) (USA only).
iReactivate the TPMS after adjusting
the tire inflation pressure to the infla-
tion pressure recommended for the
vehicle operating condition. Tire
pressure should only be adjusted on
cold tires. Observe the recommend-
ed tire inflation pressure on the tire
and loading information placard on
the driver’s door B-pillar
(\2
page 354).
nf_BA.book Page 372 Friday, January 25, 2008 3:53 PM

375 Operation
Tires and wheels
4 i
When the message
Tire pres. dis-
played after driving for several
minutes
appears in the multifunction
display, the individual inflation pres-
sure values are matched with the
tires. The individual values are dis-
played after a few minutes' driving.54.32-2278-31
Warning
G
It is the driver’s responsibility to calibrate
the TPMS on the recommended cold infla-
tion pressure. Underinflated tires affect
the ability to steer or brake the vehicle.
You might lose control over the vehicle.
iIf a spare wheel without wheel sen-
sors is mounted, the system may still
indicate the tire inflation pressure of
the removed wheel for some min-
utes. If this happens, keep in mind
that the indicated value where the
spare wheel is mounted does not re-
flect the actual spare tire inflation
pressure.
nf_BA.book Page 375 Friday, January 25, 2008 3:53 PM

377 Operation
Tires and wheels
4
Warning
G
Each tire, including the spare (if provided),
should be checked monthly when cold
and inflated to the inflation pressure rec-
ommended by the vehicle manufacturer
on the vehicle placard or the tire inflation
pressure label. (If your vehicle has tires of
a different size than the size indicated on
the vehicle placard or the tire inflation
pressure label, you should determine the
proper tire inflation pressure for those
tires).
Continued
Warning (Continued)
G
As an added safety feature, your vehicle
has been equipped with a Tire Pressure
Monitoring System (TPMS) that illumi-
nates a low tire pressure telltale when one
or more of your tires is significantly under-
inflated. Accordingly, when the low tire
pressure telltale illuminates, you should
stop and check your tires as soon as pos-
sible, and inflate them to the proper pres-
sure. Driving on a significantly
underinflated tire causes the tire to over-
heat and can lead to tire failure.
Continued
Warning (Continued)
G
Underinflation also reduces fuel efficiency
and tire tread life, and may affect the ve-
hicle’s handling and stopping ability.
Please note that the TPMS is not a substi-
tute for proper tire maintenance, and it is
the driver’s responsibility to maintain cor-
rect tire pressure, even if underinflation
has not reached the level to trigger illumi-
nation of the TPMS low tire pressure tell-
tale.
Continued
nf_BA.book Page 377 Friday, January 25, 2008 3:53 PM

379 Operation
Tires and wheels
4
Reactivating the Advanced TPMSThe TPMS must be reactivated when you
have adjusted the tire inflation pressure
to a new level (e.g. because of different
load or driving conditions). The TPMS is
then recalibrated to the current tire in-
flation pressures.
\1
Make sure the tire inflation pressure
of all four tires is correct, using the
tire and loading information placard
1
or the tire inflation pressure placard
located on the driver’s door B-pillar
(
\2
page 362).
Warning!
G
It is the driver’s responsibility to calibrate
the TPMS on the recommended cold infla-
tion pressure. Underinflated tires affect
the ability to steer or brake the vehicle.
You might lose control over the vehicle.
1. For vehicles with a gross weight capacity less
than 10 000 lbs (4 536 kg) (USA only).
iReactivate the TPMS after adjusting
the tire inflation pressure to the infla-
tion pressure recommended for the
vehicle operating condition. Tire in-
flation pressure should only be adju-
sted on cold tires. Observe the
recommended tire inflation pressure
on the tire and loading information
placard
1 or on the tire inflation pres-
sure placard on the driver’s door B-
pillar (\2
page 362).
nf_BA.book Page 379 Friday, January 25, 2008 3:53 PM

380 OperationTires and wheels
4
\1
Press button
è
or
ÿ
on the
multifunction steering wheel repeat-
edly until the standard display menu
appears in the multifunction display
(
\2
page 157).
\1
Press the
j
or
k
button re-
peatedly until you see the current in-
flation pressures for each tire appear
in the display or the following mes-
sage appears in the display
Tire pres. displayed
after driving
for several minutes
\1
Press reset button0 on the instru-
ment cluster (
\2
page 20).The following message will appear in
the multifunction display:
Tire pres.
Adjust pres.
\1
Press
æ
button.
The following message will appear in
the multifunction display:
Tire pres. monitor
reactivatedAfter a few minutes' driving, the cur-
rent tire inflation pressure values are
accepted as reference values and
then monitored.If you wish to cancel the activation pro-
cess :
\1
Press
ç
button.
Potential problems associated with
underinflated and overinflated tiresProper tire inflation pressure is essential
to the safe and satisfactory operation of
your vehicle. The following three primary
areas are affected by improper tire infla-
tion pressure:
nf_BA.book Page 380 Friday, January 25, 2008 3:53 PM

400 OperationTires and wheels
4
Tires on the front and rear axles of vehi-
cles operate at different loads and per-
form different steering, driving and
braking functions. For these reasons,
they wear at unequal rates, and develop
irregular wear patterns. These effects
can be reduced by timely rotation of
tires.
The benefits of rotation are especially
worthwhile with aggressive tread de-
signs such as those on On/Off Road
type tires. Rotation will increase tread
life, help to maintain mud, snow, and wet
traction levels, and contribute to a
smooth ride. If applicable to your vehicle’s tire config-
uration, tires can be rotated according
to the tire manufacturer’s recommend-
ed intervals in the tire manufacturer’s
warranty pamphlet located in your vehi-
cle literature portfolio. If none is avail-
able, tires should be rotated every
10 000 miles (16 000 km), or sooner if
necessary, according to the degree of
tire wear.
The same rotation (spinning) direction
must be maintained when mounted, see
"Direction of rotation" (
\2
page 351).
Warning (Continued)
G
could result in changes to steering, han-
dling, and braking of your Sprinter vehicle.
This can cause unpredictable handling
and stress to steering and suspension
components. You could lose control and
have an accident resulting in serious inju-
ry or death.could result in tire overloading and failure,
if the tires' load index are not identical.
You could lose control and have an acci-
dent.
nf_BA.book Page 400 Friday, January 25, 2008 3:53 PM

404 OperationWinter driving
4
\3 Winter drivingHave your vehicle winterproofed at the
onset of winter at an authorized Sprinter
Dealer. This service includes the follow-
ing:\4
Oil change, if the current engine oil
used has not been approved for win-
ter use
\4
The antifreeze / anti-corrosion con-
centration in the coolant is checked
\4
The addition of a concentrated
cleaning agent to the water in the
windshield washer system
\4
Battery check
\4
A tire changeYou will find information about diesel
fuel for use at low outside temperatures
in the “Technical data” section
(
\2
page 614).
Please also observe the information
about winter driving (
\2
page 406).
Winter tires should also be operated as
printed on the tire and loading informa-
tion placard
1 or on the tire inflation pres-
sure placard located on the driver’s door
B-pillar, refer to “Tires and wheels” (
\2
page 362). Not all M+S rated radial-
ply tires provide special winter perfor-
mance. Make sure the tires you use
show M+S and the mountain/snowflake
marking
.
on the tire side wall.
These tires meet specific snow traction
performance requirements of the Rub-
ber Manufacturers Association (RMA)
and the Rubber Association of Canada
(RAC) and have been designed specifi-
cally for use in snow conditions. Use of
winter tires is the only way to achieve
the maximum effectiveness of the ABS,
BAS, ASR and ESP
® in winter operation.
Winter tires1. For vehicles with a gross weight capacity less
than 10 000 lbs (4 536 kg) (USA only).
nf_BA.book Page 404 Friday, January 25, 2008 3:53 PM