belt DODGE SPRINTER 2008 2.G Service Manual

482 Practical hintsWhat to do if ...
5
Problem
Possible cause / result
Suggested solutions
/
The yellow water separator indi-
cator lamp
1 lights up while the ig-
nition is on.
The water that has collected in the water sepa-
rator has reached the maximum level.
\1Drain the water separator
(\2page 542).
\1Have the water separator drained at an
authorized Sprinter Dealer.
W
The yellow washer fluid level indi-
cator lamp for the windshield
washer / headlamp cleaning sys-
tem lights up after the engine is
started or while the vehicle is in
motion.
The windshield washer fluid level is too low.
\1Check the fluid level in the reservoir
and add windshield washer fluid if nec-
essary (\2page 333).
<

The red seat belt telltale lights up
for approximately 6 seconds
when the ignition is switched on.
A signal also sounds.
The telltale reminds you to fasten your seat
belt.
\1Fasten your seat belt.
nf_BA.book Page 482 Friday, January 25, 2008 3:53 PM

497 Practical hints
Display messages
5
Symbol messagesDisplay symbol
Display message
Possible cause / result
Possible solution
#

Battery/
Alternator
Visit workshop
The battery is not being charged. Possible
causes:
\4malfunctioning alternator
\4torn poly-V-belt
\1Stop immediately and check the poly-V-
belt.
If it is torn:
\1Do not drive any further.
\1Consult an authorized Sprinter Dealer.
If it is not damaged:
\1Drive to the nearest authorized Sprinter
Dealer immediately.
2

Brake wear
Visit workshop
WARNING
G
The brake pads / linings have reached their
wear limit.
\1Have the brake pads / linings replaced as
soon as possible at an authorized Sprinter
Dealer.
nf_BA.book Page 497 Friday, January 25, 2008 3:53 PM

501 Practical hints
Display messages
5
k
unavailable
ASR as well as BAS have been switched off
due to undervoltage.
The battery may not be being charged.
The brake system is still available with the
normal braking effect.
\1Continue driving, but with even greater
care.
\1Have the system checked at an authorized
Sprinter Dealer as soon as possible.
ì
Please enter PIN:
You have not yet entered your details in the
telephone.
\1Enter the PIN for your SIM card.
<
Seatbelt sys.
Visit
workshop
WARNING
G
The belt system has malfunctioned.
\1Have the system checked at an authorized
Sprinter Dealer as soon as possible.
Display symbol
Display message
Possible cause / result
Possible solution
nf_BA.book Page 501 Friday, January 25, 2008 3:53 PM

639 Index
stopping . . . . . . . . . . . . . . . . . . . 206
towing . . . . . . . . . . . . . . . . . . . . 587
trailer towing . . . . . . . . . . . . . . . 207
working on the vehicle . . . . . . . . 207Auxiliary heating
. . . . . . . . . . . . . 236
heater booster function . . . . . . . 234
malfunctions . . . . . . . . . . . . . . . 453
with water heater
changing the remote control
batteries . . . . . . . . . . . . . . . . . 541
remote control . . . . . . . . . . . . 239
selecting a switch-on time . . . 240
setting the switch-on time . . . 242
B
Bar
. . . . . . . . . . . . . . . . . . . . . . . . 394
BASsee Brake AssistBatteryauxiliary . . . . . . . . . . . . . . . . . . . 577
charge indicator lamp . . . . . . . . 469
check lamp (auxiliary heating
remote control) . . . . . . . . . . . . . 240
display message . . . . . . . . . . . . 497
in the auxiliary heating remote
control . . . . . . . . . . . . . . . . . . . . 541
in the engine compartment . . . . 577
in the key . . . . . . . . . . . . . . . . . . 540
indicator lamp (key) . . . . . . . . . . . 86
isolating switch . . . . . . . . . 338
,339
recharging . . . . . . . . . . . . . . . . . 579
reconnecting . . . . . . . . . . . . . . . 580
removing . . . . . . . . . . . . . . . . . . 578safety notes . . . . . . . . . . . . . . . . 335
starter battery
disconnecting . . . . . . . . . . . . 575
Bead
. . . . . . . . . . . . . . . . . . . . . . . 394
Belt force limiters
. . . . . . . . . . . . .44
Bi-xenon headlamps
. . . . . . . . . . 527
driving abroad . . . . . . . . . . . . . . 311
Body builder guideline
. . . . . . . . . .11
Bottle holdersee Cup holdersBrake Assist (BAS)
. . . . . . . . . . . . .71
display message . . . . . . . . 500
–501
indicator lamp . . . . . . . . . . 462,465
malfunction . . . . . . . . . . . . . . . . 465
Brake fluid
. . . . . . . . . . . . . . . . . . 617
checking the brake fluid level . . 331
display message . . . . . . . . . . . . 498
B
nf_BA.book Page 639 Friday, January 25, 2008 3:53 PM

645 Index
Environmental protection
. . . . . . . 5
ESP
®/ASR warning lamp
. . 22
,73,461
Exterior lighting
. . . . . . . . . . . . . 129
additional bulbs . . . . . . . . . . . . . 533
Constant headlamp mode
(vehicles with steering wheel
buttons) . . . . . . . . . . . . . . . . . . . 171
delayed switch-off
(vehicles with steering wheel
buttons) . . . . . . . . . . . . . . . . . . . 173
front bulbs . . . . . . . . . . . . . . . . . 526
lamp failure monitor . . . . . . . . . 129
locator lighting
(vehicles with steering wheel
buttons) . . . . . . . . . . . . . . . . . . . 172
rear bulbs . . . . . . . . . . . . . . . . . 530
Exterior mirrors
. . . . . . . . . 208
,209
Eyeglasses compartment
. . . . . 290
F
Fastening seat beltssee Wearing seat beltsFault memorysee Malfunction memoryFax machine
. . . . . . . . . . . . . . . . 315
Fire extinguisher
. . . . . . . . . . . . 514
First-aid kit
. . . . . . . . . . . . . . . . . 514
Flat tirechanging a wheel . . . . . . . . . . . . 548
Premium tire sealant . . . . . . . . . 557Flow improvers
. . . . . . . . . . . . . . 615
Folding table in the backrest
. . 291
Front foglamps
. . . . . . 130
,134
,526
changing bulbs . . . . . . . . . . . . . 527
Fuelgauge . . . . . . . . . . . . . . . . . . . . 145
line . . . . . . . . . . . . . . . . . . 433
,435
loss . . . . . . . . . . . . . . . . . . 433,435
malfunctions . . . . . . . . . . . . . . . 434
see Gasoline or Diesel
Fuel filter with
water separatordraining . . . . . . . . . . . . . . . . . . . 542Fuel requirementsdiesel engine . . . . . . . . . . . . . . . 612
gasoline engine . . . . . . . . . . . . . 611Fuse boxin the driver's seat . . . . . . . . . . 594
main . . . . . . . . . . . . . . . . . . . . . 589Fuse chart
. . . . . . . . . . . . . . . . . . 589
Fuses
. . . . . . . . . . . . . . . . . . . . . . 589
F
nf_BA.book Page 645 Friday, January 25, 2008 3:53 PM

647 Index
Heater
. . . . . . . . . . . . . . . . . 228
–233
air distribution . . . . . . . . . . . . . . 230
airflow . . . . . . . . . . . . . . . . . . . . 230
air-recirculation mode . . . . . . . . 231
control panel . . . . . . . . . . . . . . . 228
defrosting . . . . . . . . . . . . . . . . . 232
fogged-up windows . . . . . . . . . . 231
heating . . . . . . . . . . . . . . . . . . . . 229
see Rear heater . . . . . . . . . . . . . 233
special settings . . . . . . . . . . . . . 231
temperature . . . . . . . . . . . . . . . . 230
ventilation . . . . . . . . . . . . . . . . . 229
Heater booster function
. . . . . . 234
Heater booster system
. . . . . . . 235
Heatingrear window . . . . . . . . . . . . . . . . 214
seat . . . . . . . . . . . . . . . . . . . . . . 122windshield . . . . . . . . . . . . . 213
,223
High-beam headlamps
. . . . 131
,526
changing bulbs . . . . . . . . . . . . . 527
High-pressure cleaners
. . . . . . . 418
Hood
. . . . . . . . . . . . . . . . . . . . . . . 318
Horn
. . . . . . . . . . . . . . . . . . . . . . . . 19
Hydroplaning
. . . . . . . . . . . . . . . 197
I
Identification lamps
. . . . . . . . . . 533
changing bulbs . . . . . . . . . 533
,536
Ignition lock
. . . . . . . . . . . . . . . . 111
Immobilizer
. . . . . . . . . . . . . . . . . . 77
Indicatorvehicles with steering wheel buttons
Service due date . . . . . . . . . . 412vehicles without steering wheel
buttons
service due date . . . . . . . . . . 412
Indicator and warning lampsair cleaner . . . . . . . . . . . . . . . . . 477
brake system . . . . . . . . . . . . . . . 464
braking . . . . . . . . . . . . . . . . . . . 462
engine oil level . . . . . . . . . . . . . 471
seat belt . . . . . . . . . . . . . . . . . . 482
seat belt reminder . . . . . . . . . . . 482
SRS . . . . . . . . . . . . . . . . . . . . . . 469
water separator . . . . . . . . . . . . . 482Indicator lampABS . . . . . . . . . . . . . . . . . . . . . . 466
ASR . . . . . . . . . . . . . . . . . . 462
,465
BAS . . . . . . . . . . . . . . . . . . 462,465
battery charge . . . . . . . . . . . . . . 469
I
nf_BA.book Page 647 Friday, January 25, 2008 3:53 PM

648 Indexbrake pad/lining wear . . . . . . . . 470
coolant . . . . . . . . . . . . . . . . . . . . 474
engine diagnostic . . . . . . . . . . . . 477
ESP
®
. . . . . . . . . . . . . . . . . 462
,468
handbrake . . . . . . . . . . . . . . . . . 189
operating speed governor (ADR) . . 274poly-V-belt . . . . . . . . . . . . . . . . . 469
preglow . . . . . . . . . . . . . . . 186
,476
reserve warning
indicator (fuel) . . . . . . . . . . 475,476
windshield washer/headlamp
cleaning system washer fluid
level . . . . . . . . . . . . . . . . . . . . . . 482
Inflation pressuresee Tires, Inflation pressuresInformation regarding electronic
recording devices
. . . . . . . . . . . . . 16
Instrument cluster
. . . . . . . . 20
,142
lighting . . . . . . . . . . . . . . . . . . . . 144
speedometer . . . . . . . . . . . . . . . 145
tachometer . . . . . . . . . . . . . . . . 145
vehicles with steering wheel buttons
selecting the language . . . . . . 166
setting the status line . . . . . . . 167
Instrument lighting
. . . . . . . . . . . 144
Interior lightingchanging bulbs . . . . . . . . . . . . . . 537
front . . . . . . . . . . . . . . . . . . . . . . 137
rear . . . . . . . . . . . . . . . . . . . . . . 138Interior lighting, rear
. . . . . . . . . 138
Interior motion sensor
. . . . . . . . . 80
Intermittent wipe
. . . . . . . . . . . . 210
ISOFIX child seat securing
system
. . . . . . . . . . . . . . . . . . . . . . 61
TopTether . . . . . . . . . . . . . . . . . . 64
J
Jackjacking points . . . . . . . . . . . . . . 551
preparing . . . . . . . . . . . . . . . . . . 550
storage location . . . . . . . . . . . . . 515Jump-starting
. . . . . . . . . . . . . . . 581
connection point . . . . . . . . . . . . 582
Jump-starting connection
point
. . . . . . . . . . . . . . . . . . . . . . . 582
J
nf_BA.book Page 648 Friday, January 25, 2008 3:53 PM

652 Indexvehicles without steering wheel
buttons . . . . . . . . . . . . . . . . . . . . 148Overhead control panel
. . . . . . . . 27
hands-free microphone . . . . . . . . 27
interior lighting . . . . . . . . . . . . . . 137
Overrun cut-off
. . . . . . . . . . . . . . 194
Overviewindicator and warning lamps . . . . 22
menus
(vehicles with steering wheel
buttons) . . . . . . . . . . . . . . . . . . . 154
switch . . . . . . . . . . . . . . . . . . . . . 29Oxidation catalyst
. . . . . . . . . . . . 313
P
Paper holder
. . . . . . . . . . . . . . . . 296
Parking
. . . . . . . . . . . . . . . . . . . . . 193
on uphill or downhill gradients . . 189
Parking aidsee ParktronicParking brakesee HandbrakeParking lamps
. . . . . . . . . . . . . . . 131
changing bulbs . . . . . . . . . . . . . . 529
Parking locksee Automatic transmissionParktronic
. . . . . . . . . . . . . . 253
,422
cleaning the sensors . . . . . . . . . 422
indicator lamp . . . . . . . . . . . . . . 451
malfunction . . . . . . . . . . . . 451–452range of the sensors . . . . . . . . . 254
roll-back warning . . . . . . . . . . . . 257
switching on/off . . . . . . . . . . . . 258
trailer towing . . . . . . . . . . . . . . . 258
warning display . . . . . . . . . 256
,451
Partition sliding door
. . . . . . . . . 109
Parts
. . . . . . . . . . . . . . . . . . . . . . . 600
Pen holder
. . . . . . . . . . . . . . . . . . 289
Perimeter lamp
. . . . . . . . . . . . . . 531
Plastic trims
. . . . . . . . . . . . . . . . 423
Poly-V-beltmalfunction . . . . . . . . . . . . . . . . 469Pounds per square inchsee PSIPower steering fluid
. . . . . . . . . . 620
Premium tire sealantstorage location . . . . . . . . . . . . . 521
P
nf_BA.book Page 652 Friday, January 25, 2008 3:53 PM

654 IndexRear window heating
. . . . . . . . . 214
malfunction . . . . . . . . . . . . . . . . 458
Rear window wiper
. . . . . . . . . . . 212
Rear-view mirror
. . . . . . . . . . . . . 208
Recommended tire inflation
pressure
. . . . . . . . . . . . . . . . . . . . 397
Refueling
. . . . . . . . . . . . . . . . . . . 316
Remote controlauxiliary heating . . . . . . . . . . . . . 239
battery check lamp . . . . . . . . . 240
changing the batteries . . . . . . 541
central locking . . . . . . . . . . . . . . . 86
changing the batteries . . . . . . . . 539
key . . . . . . . . . . . . . . . . . . . . . . . . 86
lost . . . . . . . . . . . . . . . . . . . . . . . 448
opening the vehicle . . . . . . . . . . . 83
problems . . . . . . . . . . . . . . . . . . 445
Removing the battery cover in the
driver’s footwell
. . . . . . . . . . . . . 576
Removing/installing the floor cover-
ing in the driver’s footwell
. . . . . 575
Reserve warning indicator
(fuel)
. . . . . . . . . . . . . . . . . . . 475
,476
Residual heat mode
. . . . . . . . . . 222
problems . . . . . . . . . . . . . . . . . . 459
Restraint system
. . . . . . . . . . . . . 34
airbags . . . . . . . . . . . . . . . . . . . . . 36
belt force limiters . . . . . . . . . . . . 44
child restraint systems . . . . . . . . 56
display message . . . . . . . . . . . . 496
emergency tensioning retractor . 44
front airbags . . . . . . . . . . . . . . . . 50
malfunction . . . . . . . . . . . . . . . . 469
seat belt . . . . . . . . . . . . . . . . . . . . 36thorax sidebag . . . . . . . . . . . . . . . 51
windowbags . . . . . . . . . . . . . . . . . 53
Reverse lamp
. . . . . . . . . . . 530
,531
changing bulbs . . . . . . . . . . . . . 531
Reverse warning feature
. . . . . . 271
Rims
. . . . . . . . . . . . . . . . . . . . . . . 397
Road hazard lamp
. . . . . . . . . . . . 513
Roll-back warningsee ParktronicRoof load
. . . . . . . . . . . . . . . . . . . 630
Roof rack
. . . . . . . . . . . . . . . . . . . 285
Roof ventilator
. . . . . . . . . . . . . . 247
S
Seat
. . . . . . . . . . . . . . . . . . . 114
,116
adjusting . . . . . . . . . . . . . . 112,114
folding rear bench seat . . . . . . . 124
S
nf_BA.book Page 654 Friday, January 25, 2008 3:53 PM

655 Index
fore-and-aft adjustment . . . . . . . 114
heating . . . . . . . . . . . . . . . . . . . . 122
malfunction . . . . . . . . . . . . . . 458
height . . . . . . . . . . . . . . . . . . . . . 115
suspension . . . . . . . . . . . . . . . . 116
suspension lock . . . . . . . . . . . . . 116
swivelling . . . . . . . . . . . . . . . . . . 116
vertical lock . . . . . . . . . . . . . . . . 116Seat belt
. . . . . . . . . . . . . . . . . . . . 36
adjusting height . . . . . . . . . . . . . . 40
cleaning . . . . . . . . . . . . . . . . . . . 425
telltale . . . . . . . . . . . . . . . . . . . . 482
wearing . . . . . . . . . . . . . . . . . . . . 39
Seat heatingswitching on . . . . . . . . . . . . . . . 123Seating capacity
. . . . . . . . . . . . . 354
Securing a load
. . . . . . . . . . . . . . 280
Securing tensioning straps
. . . . 280
Selector leverlock . . . . . . . . . . . . . . . . . . 185
,201
Servicecalling up the due date
vehicles with steering wheel
buttons . . . . . . . . . . . . . . . . . . 413
vehicles without steering
wheel buttons . . . . . . . . . . . . 414
indicator . . . . . . . . . . . . . . . . . . 411Service information
. . . . . . . . . . . . 9
Service lifetires . . . . . . . . . . . . . . . . . . . . . . 349Service products
. . . . . . . . 322
,410
capacities . . . . . . . . . . . . . . . . . 621
coolants, lubricants, etc. . . . . . . 616
diesel . . . . . . . . . . . . . . . . . . . . . 612engine oils . . . . . . . . . . . . . . . . . 606
fuels . . . . . . . . . . . . . . . . . . . . . 610
gasoline . . . . . . . . . . . . . . . . . . . 610
notes . . . . . . . . . . . . . . . . . . . . . 604
windshield washer fluid . . . . . . . 333
Setting the blower speed
. . . . . 220
Setting the date
. . . . . . . . . . . . . 169
vehicles with steering wheel
buttons . . . . . . . . . . . . . . . . . . . 169
vehicles without steering wheel
buttons . . . . . . . . . . . . . . . . . . . 150
Settingsresetting all (vehicles with steering
wheel buttons) . . . . . . . . . . . . . 162Shift rangeautomatic transmission . . . . . . . 204
display . . . . . . . . . . . . . . . . . . . . 202
nf_BA.book Page 655 Friday, January 25, 2008 3:53 PM