brake DODGE VIPER 2017 VX / 3.G Service Manual

Chassis
ComponentFluid, Lubricant, or Genuine Part
Transmission We recommend you use MOPAR ATF+4 Automatic Trans-
mission Fluid.
Rear Axle We recommend you use Castrol SAF-XJ/SAE 75W-140
Synthetic Gear and Axle Lubricant.
Brake/Clutch Master Cylinder We recommend you use MOPAR Brake and Clutch Fluid
DOT 4 Motor Vehicle.
Power Steering Reservoir We recommend you use MOPAR Power Steering Fluid + 4,
MOPAR or ATF+4 Automatic Transmission Fluid.
300 MAINTAINING YOUR VEHICLE

MAINTENANCE SCHEDULES
The Scheduled Maintenance services listed in this manual
must be done at the times or mileages specified to protect
your vehicle warranty and ensure the best vehicle perfor-
mance and reliability. More frequent maintenance may be
needed for vehicles in severe operating conditions, such as
dusty areas and very short trip driving. Inspection and
service should also be done anytime a malfunction is
suspected.
NOTE: Under no circumstances should oil change inter-
vals exceed 6,000 miles (10 000 km) or six months,
whichever comes first.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.At Each Stop For Fuel
•
Check the engine oil level about five minutes after a
fully warmed engine is shut off. Checking the oil level
while the vehicle is on level ground will improve the
accuracy of the oil level reading. Add oil only when the
level is at or below the ADD or MIN mark.
• Check the windshield washer solvent, and add if re-
quired.
Once A Month
• Check tire pressure and look for unusual wear or
damage. Rotate tires at the first sign of irregular wear,
even if it occurs before your next scheduled service.
• Inspect the battery, and clean and tighten the terminals
as required.
• Check the fluid levels of the coolant reservoir, brake
master cylinder, power steering, and transmission, and
add as needed.
• Check all lights and all other electrical items for correct
operation.
302 MAINTENANCE SCHEDULES

At Each Oil Change
•Change the engine oil filter.
• Inspect the exhaust system.
NOTE: Also, inspect the exhaust system if you notice a
change in the sound of the exhaust system, or if the exhaust
fumes can be detected inside the vehicle. •
Inspect the brake hoses.
• Inspect the suspension components.
• Lubricate door hinges and check springs.
• Check the engine coolant level, hoses, and clamps.
• Check power steering fluid level.
MAINTENANCE CHART
Miles:6,000
12,000
18,000
24,000
30,000
36,000
42,000
48,000
54,000
60,000
66,000
72,000
78,000
84,000
90,000
96,000
102,000
108,000 114,000
120,000
126,000
132,000
138,000
144,000
150,000
Or Months: 6 12 18 24 30 36 42 48 54 60 66 72 78 84 90 96 102 108 114 120 126 132 138 144 150
Or Kilometers:
10,000
20,000
30,000
40,000
50,000
60,000
70,000
80,000
90,000
100,000 110,000
120,000
130,000
140,000
150,000
160,000
170,000
180,000
190,000
200,000
210,000
220,000
230,000
240,000
250,000
Change the engine oil and en-
gine oil filter. XXXXXXXXXXXXXXXXXXXXXXXXX
Inspect the brake linings; replace
if necessary. XXXXXXXXXXXX
Rotate the tires, rotate at the first
sign of irregular wear, even if it
occurs before scheduled mainte-
nance. XXXXXXXXXXXXXXXXXXXXXXXXX
Inspect the exhaust system. XXXXXXXXXXXX
Change Brake Fluid. * XXXXXX
8
MAINTENANCE SCHEDULES 303

Miles:6,000
12,000
18,000
24,000
30,000
36,000
42,000
48,000
54,000
60,000
66,000
72,000
78,000
84,000
90,000
96,000
102,000
108,000 114,000
120,000
126,000
132,000
138,000
144,000
150,000
Or Months: 6 12 18 24 30 36 42 48 54 60 66 72 78 84 90 96 102 108 114 120 126 132 138 144 150
Or Kilometers:
10,000
20,000
30,000
40,000
50,000
60,000
70,000
80,000
90,000
100,000 110,000
120,000
130,000
140,000
150,000
160,000
170,000
180,000
190,000
200,000
210,000
220,000
230,000
240,000
250,000
Adjust the parking brake on ve-
hicles equipped with four wheel
disc brakes. XXXXX
Change the manual transmission
fluid. XXXX
Inspect the manual transmission
fluid, add as necessary. XX XX XX XX
Change the rear axle fluid. XXXXXXXX
Inspect front suspension, tie rod
ends, and boot seals, for cracks
or leaks and all parts for damage,
wear, improper looseness or end
play; replace if necessary. XXXXXXXXXXXX
Replace the engine air cleaner. XXXXX
Inspect and replace the PCV
Valve if necessary. X
Replace the spark plugs. ** X
Flush and replace the engine
coolant at 120 months if not done
at 150,000 miles (240,000 km). XX
* The brake fluid change interval is time based only,
mileage intervals do not apply.** The spark plug change interval is mileage based only,
monthly intervals do not apply.
304 MAINTENANCE SCHEDULES

About Your Brakes........................ .203
ABS (Anti-Lock Brake System) .................205
Adding Engine Coolant (Antifreeze) .............277
Adding Fuel ............................. .238
Adding Washer Fluid ....................... .273
Additives, Fuel ........................... .237
Adjust Forward ................................79
Rearward ...............................79
Adjustable Pedals ...........................90
AirBag ..................................38 Advance Front Air Bag .....................38
Air Bag Operation .........................40
Air Bag Warning Light ...................36, 40
Enhanced Accident Response ..............53, 260
Event Data Recorder (EDR) .................260
FrontAirBag ........................ .38, 40
If A Deployment Occurs ....................52
Knee Impact Bolsters .......................50
Maintaining Your Air Bag System ..............54
Transporting Pets .........................64
Air Bag Light ....................... .36, 67, 117
Air Bag Maintenance .........................54
Air Cleaner, Engine (Engine Air Cleaner Filter) ......269Air Conditioner Maintenance
..................271
Air Conditioning Filter ...................... .169
Air Conditioning, Operating Tips ...............168
Air Conditioning Refrigerant ...............271, 272
Air Conditioning System ..................167, 271
Air Pressure, Tires ......................... .221
Alarm (Security Alarm) ......................119
Alarm System (Security Alarm) .................14
Alterations/Modifications, Vehicle ................6
Antenna ................................ .160
Antifreeze (Engine Coolant) ................276, 298
Capacities ............................. .298
Disposal .............................. .278
Anti-Lock Brake System (ABS) .................205
Anti-Lock Warning Light .....................206
Appearance Care .......................... .282
Auto

Down Power Windows ...................22
Automatic Door Locks ........................21
Automatic Headlights ........................84
Automatic Temperature Control (ATC) ...........167
Auto Unlock, Doors .........................21
Auto Up Power Windows .....................23
Auxiliary Electrical Outlet (Power Outlet) .........103
Auxiliary Power Outlet ..................... .103
314 INDEX

Battery.............................. .120, 269
Charging System Light ....................120
Emergency Starting ...................... .256
Jump Starting .......................... .256
Key Fob Battery Replacement .................18
Keyless Key Fob Replacement ................18
Location .............................. .269
Remote Battery Replacement .................18
Saving Feature (Protection) ..................271
Storing Vehicle ......................... .271
Belts, Seat .................................67
Body Mechanism Lubrication ..................272
B-Pillar Location .......................... .215
Brake Control System, Electronic ................205
Brake, Parking ............................ .202
Brake System ......................... .203, 279
Anti-Lock (ABS) ..................... .203, 205
Fluid Check ........................ .280, 300
Master Cylinder ........................ .280
Warning Light ...........................117
Break-In Recommendations, New Vehicle ..........204
Brightness, Interior Lights .....................86
Bulb Replacement ......................... .297
Bulbs, Light ........................... .69, 296Camera, Rear
..............................95
Capacities, Antifreeze (Engine Coolant) ...........298
Capacities, Fluid .......................... .298
Caps, Filler Oil (Engine) ........................... .268
Power Steering ......................... .202
Radiator (Coolant Pressure) .................278
Carbon Monoxide Warning .................66, 238
Car Washes .............................. .282
Chains, Tire ............................. .228
Chart, Tire Sizing ...........................211
Check Engine Light (Malfunction Indicator Light). . . .265
Checking Your Vehicle For Safety ................66
Checks, Safety .............................66
Child Restraint .............................
55
Child Restraints Booster Seats ............................58
Child Restraints ..........................55
Child Seat Installation ......................61
Infants And Child Restraints .................57
Older Children And Child Restraints ...........57
Using The Top Tether Anchorage ..............62
Clean Air Gasoline ........................ .235
Cleaning Wheels ............................... .283
10
INDEX 315

Windshield Wiper Blades...................273
Climate Control ........................... .161
Clutch Fluid ............................. .281
Compact Spare Tire ........................ .224
Contract, Service .......................... .309
Coolant Pressure Cap (Radiator Cap) .............278
Cooling System ........................... .275
Adding Coolant (Antifreeze) .................277
Coolant Capacity ........................ .298
Coolant Level ....................... .275, 278
Disposal Of Used Coolant ..................278
Drain, Flush, And Refill ....................276
Inspection ............................. .278
Points To Remember ..................... .279
Pressure Cap ........................... .278
Radiator Cap .......................... .278
Selection Of Coolant (Antifreeze) ..........276, 298
Corrosion Protection ....................... .282
Cruise Light ............................. .130
Cupholders .............................. .107
Customer Assistance ....................... .308
Daytime Brightness, Interior Lights ...............87
Daytime Running Lights ......................85
Dealer Service ............................ .266Defroster, Rear Window
......................110
Defroster, Windshield ........................67
Delay (Intermittent) Wipers ....................88
Diagnostic System, Onboard ...................264
Dimmer Switch, Headlight .....................86
Dipsticks Power Steering ......................... .202
Disposal Antifreeze (Engine Coolant) .................278
Do Not Disturb ........................... .185
Door Ajar ............................... .122
Door Ajar Light ........................... .122
Door Locks ................................20
Key Fob Emergency Key ....................18
Door

Locks, Automatic .......................21
Door Opener, Garage .........................97
Doors ....................................20
Driving Through Flowing, Rising, Or Shallow Standing
Water ................................ .200
Electrical Outlet, Auxiliary (Power Outlet) .........103
Electric Remote Mirrors .......................76
Electronic Brake Control System ................205
Traction Control System ....................206
316 INDEX

Electronic Speed Control (Cruise Control)..........92
Electronic Stability Control (ESC) ...............207
Electronic Throttle Control Warning Light .........121
Emergency Brake .......................... .202
Emergency, In Case Of Freeing Vehicle When Stuck .................259
Hazard Warning Flasher ...................246
Jump Starting .......................... .256
Overheating ........................... .246
Towing ............................... .260
Emission Control System Maintenance ............265
Engine ................................. .263
Air Cleaner ............................ .269
Checking Oil Level ...................... .267
Compartment .......................... .263
Coolant (Antifreeze) ...................275, 298
Cooling .............................. .275
Exhaust Gas Caution ...................66, 238
Fails To Start ........................... .192
Flooded, Starting ........................ .192
Fuel Requirements ....................235, 298
Oil .............................. .267, 298
Oil Change Interval ...................... .268
Oil Filler Cap .......................... .268
Oil Filter .............................. .269Oil Selection
........................ .268, 298
Overheating ........................... .246
Engine Oil Viscosity .....................268, 298
Enhanced Accident Response Feature ..........53, 260
Ethanol ................................. .235
Exhaust Gas Caution .....................66, 238
Exhaust System ........................ .66, 274
Exterior Lighting ............................83
Exterior Lights .............................69
Filters Air Cleaner ............................ .269
Air Conditioning ........................ .169
Engine

Oil ......................... .269, 298
Engine Oil Disposal ...................... .268
Flashers Hazard Warning ........................ .246
Turn Signal ....................... .69, 85, 129
Flash-To-Pass ..............................86
Flooded Engine Starting ..................... .192
Fluid Capacities ........................... .298
Fluid Leaks ...............................69
Fluid Level Checks Brake ............................. .280, 300
Capacities ............................. .298
10
INDEX 317

Inside Rearview Mirror.......................73
Instrument Cluster .............114,115,119, 122, 129
Instrument Cluster Display Instrument Cluster Display ..................131
Instrument Panel And Controls .................113
Instrument Panel Lens Cleaning ................286
Interior Appearance Care .....................284
Interior Lights ..............................86
Intermittent Wipers (Delay Wipers) ...............88
Introduction ................................4
Jump Starting ............................ .256
KeyFob...................................9 Programming Additional Key Fobs .............13
Remote Battery Replacement .................18
Key Fob Battery Service (Remote Keyless Entry) .....18
Key Fob Programming (Remote Keyless Entry) ......18
Key Fob, Remote Keyless Entry .................16
Key-In Reminder ............................11
Keyless Entry System .......................9,16
Keyless Go .................................9
Key, Replacement ...........................13
Key, Sentry (Immobilizer) ......................12 Lane Change And Turn Signals
.................85
Lap/Shoulder Belts ..........................28
Latches ..................................69
Hood ..................................81
Lead Free Gasoline ........................ .235
Leaks, Fluid ...............................69
Life Of Tires ............................. .227
Liftgate ..................................24
Light Bulbs ................................69
Lights ................................ .69, 83
AirBag...........................36, 67, 117
Anti-Lock ............................. .206
Automatic Headlights ......................84
Brake Warning ..........................117
Bulb Replacement .....................296, 297
Cruise ............................... .130
Daytime Running .........................85
Dimmer Switch, Headlight ................85, 86
Engine Temperature Warning ................119
Exterior ................................69
Hazard Warning Flasher ...................246
Headlights ..............................83
Headlights On Reminder ....................85
Headlights On With Wipers ...............84,
89
Headlight Switch .........................83
10
INDEX 319

Multi-Function Control Lever...................85
Occupant Restraints .........................25
Octane Rating, Gasoline (Fuel) .................235
Oil, Engine ........................... .267, 298
Capacity .............................. .298
Change Interval ........................ .268
Checking ............................. .267
Dipstick .............................. .267
Disposal .............................. .268
Filter ............................. .269, 298
Filter Disposal .......................... .268
Materials Added To ...................... .268
Pressure Warning Light ....................120
Recommendation .....................268, 298
Viscosity .......................... .268, 298
Oil Filter, Change ......................... .269
Oil Filter, Selection ......................... .269
Oil Pressure Light ......................... .120
Onboard Diagnostic System ...................264
Opener, Garage Door (HomeLink) ...............97
Operator Manual (Owner’s Manual) ...............4
Outside Rearview Mirrors .....................75
Overheating, Engine ....................... .246Owner’s Manual (Operator Manual)
............4,311
Paint Care ............................... .282
Panic Alarm ...............................18
Parking Brake ............................ .202
Parking On Hill ........................... .202
Passing Light ..............................86
Pedals, Adjustable ...........................90
Pets .....................................64
Placard, Tire And Loading Information ........215, 216
Power Brakes ............................... .203
Door Locks ..............................20
Mirrors ................................76
Outlet (Auxiliary Electrical Outlet) ............103
Steering ........................... .201, 202
Windows ...............................22
Power

Seats
Forward ................................79
Rearward ...............................79
Pregnant Women And Seat Belts .................33
Pretensioners Seat Belts ...............................33
Programming Key Fobs (Remote Keyless Entry) ......1810
INDEX 321