Electric FIAT CROMA 2006 2.G Owner's Manual

164
WARNING
LIGHTS AND
MESSAGES
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
❒push the bulb holder side tabs C-fig.
23inwards to remove it;
❒remove bulbs slightly pushing them
and turning counterclockwise.The bulbs are arranged inside the light unit
as follows (fig. 23):
Dreversing lights;
Erear fog lights. REAR LIGHT UNITS
Tailgate light unit
To change the bulb, proceed as follows:
❒open the tailgate;
❒push down cover A-fig. 21and re-
move electric connectorB-fig. 22;
fig. 21F0L0083mfig. 22F0L0084mfig. 23F0L0080m

165
WARNING
LIGHTS AND
MESSAGES
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
❒press the bulb holder tab G-fig. 25to
remove it;
❒remove bulbs slightly pushing them
and turning counterclockwise.
The bulbs are arranged inside the light unit
as follows (fig. 25):
Htaillights / brake lights;
Idirection indicators.ADDITIONAL BRAKING LIGHT
(THIRD STOP)
To change the bulb, proceed as follows:
❒open the tailgate;
❒remove the snap-fitted cover A-
fig. 26; Side fixed light unit
To change the bulb, proceed as follows:
❒open the tailgate;
❒loosen the two screws F-fig. 24and
remove the light unit;
❒remove the electrical connector;
fig. 24F0L0085mfig. 25F0L0081mfig. 26F0L0189m

169
WARNING
LIGHTS AND
MESSAGES
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
IF A FUSE BLOWS
GENERAL fig. 37
The fuse is a protective device for the
electric system: it comes into action (i.e.
it cuts off) mainly due to a fault or impro-
per action on the system.
When a device does not work, check the
efficiency of its fuse: the conductor ele-
ment Amust be intact. If not, replace the
fuse with one of the same amp rating (sa-
me colour).
Bundamaged fuse
Cfuse with damaged filament.
To replace a fuse, use the pliers Dhooked
to the fusebox on the dashboard. SIDE REAR CEILING LIGHTS
fig. 36
To change the bulb, proceed as follows:
❒remove the light unit Alevering in the
point shown by the arrow;
❒replace the bulb Breleasing it from
the side contacts making sure that the
new bulb is correctly clamped
between the contacts.
fig. 36F0L0091mfig. 37F0L0092m
Never replace a fuse with me-
tal wires or anything else.
Never change a fuse with
another with a higher amp
rating, DANGER OF FIRE.
WARNING
If a general fuse (MEGA-FU-
SE, MIDI-FUSE, MAXI-FU-
SE) cuts in, do not attempt any repair
and contact Fiat Dealership. Before
changing a fuse, check the ignition
key has been removed and that all
the other electric devices have been
turned off/disabled.
WARNING
If the fuse blows again, ha-
ve the car inspected at Fiat
Dealership.
WARNING

175
WARNING
LIGHTS AND
MESSAGES
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
F 47
F 48
F 49
F 50
F 51
F 52
F 5320
20
7,5
7,5
7,5
15
7,5
USERSFUSE AMPERE
Power for control unit on driver side
Power for control unit on passenger side
+15 Branch point for steering wheel, Connect, rain sensor control unit,
climate control system, diesel fuel heater, volumetric protection control unit,
control unit for moving and warming left front and right front seat,
Hands-free kit control unit, phone presetting, cruise control,
instrument panel dimmer, sunroof curtain
Air bag system
+15 Branch point for electric steering, tyre pressure control unit
Rear window wiper, boot control unit relay coils, cigar lighter
+30 instrument panel

176
WARNING
LIGHTS AND
MESSAGES
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
F 1
F 2
F 3
F 4
F 5
F 6
F 6
F 7
F 7
F 8
F 9
F 10
F 11
F 14
F 15
F 16
F 17
F 18
F 19
F 2060
40
20
40
40
40
50
40
50
40
20
15
15
10
10
7.5
10
7.5
7.5
30 Fuse box in engine compartment
USERSFUSE AMPERE
+30 Dashboard control unit 2
+30 Climate control system fan
+ 30 Electric steering lock branch point
+ 30 Brake branch point (pump)
+ 30 Brake branch point (solenoid valve)
+30 Engine cooling fan low speed (2.2 - Multijet)
+ 30 Engine cooling fan low speed (Multijet a.t.)
+30 Engine cooling fan high speed (2.2 - Multijet)
+ 30 Engine cooling fan high speed (Multijet a.t.)
+30 Manual climate control system fan (excluding Multijet a.t.)
Headlight washer
Horns
Sundry secondary services
Right main beam headlight
Left main beam headlight
E.i. system
E.i. primary services
+30 Engine control unit, automatic transmission control unit and gear lever
Compressor
Diesel fuel filter

179
WARNING
LIGHTS AND
MESSAGES
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
F 70
F 71
F 72
F 73
F150
70
60
80
80 Fuse box near the battery
USERSFUSE AMPERE
Fuse box in engine compartment
Dashboard control unit 1
+ 30 Glow plug control unit (Multijet)
+ 30 Electric power steering branch point (excluding 2.2 petrol)
+ 30 Electric power steering branch point 2.2 petrol version
(set on battery case wall)

CHANGING THE BATTERY
If required, replace the battery with a gen-
uine spare part having the same specifi-
cations.
If a battery with different specifications is
fitted, the service intervals given in the
“Service schedule” in this section will no
longer be valid.
Refer to the instructions provided by the
battery manufacturer.
198
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
fig. 16F0L0191m
BATTERY
The battery is of the “Limited mainte-
nance” type: under normal conditions of
use the electrolyte does not need topping
up with distilled water.
CHECKING THE CHARGE fig. 16
The battery charge may be checked sat-
isfactorily through the inspection slot us-
ing the indicator Aand acting according
to the colour the indicator shows.
Refer to the table below or to the label
Bon the battery.
The liquid in the battery is
poisonous and corrosive.
Avoid contact with eyes and skin. Do
not bring naked flames or possible
sources of sparks near to the battery:
risk of fire and explosion.
WARNING
Running the battery with
low fluid level can damage
the battery beyond repair and could
also cause its explosion.
WARNING
Bright white colourTop up electrolyte Contact Fiat Dealership
Dark colour withoutLow charge level Charge the battery
green area in the centre(advisable to contact
Fiat Dealership)
Dark colour with Electrolyte level and charge No action
green area in the centresufficient
Incorrect fitting of electrical
and electronic accessories can
seriously damage the car. If af-
ter buying the car, you want
to install electric accessories which re-
quire permanent electric supply
(alarm, free-hand phone kit, etc.) con-
tact Fiat Dealership whose qualified
personnel, in addition to suggesting the
most suitable devices, will evaluate the
overall electric absorption, checking
whether the car electric system is ca-
pable of withstanding the load re-
quired, or whether it should be inte-
grated with a more powerful battery.
183-206 Croma TRW GB 20-11-2006 15:03 Pagina 198

199
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
USEFUL ADVICE FOR
LENGTHENING THE LIFE OF
YOUR BATTERY
To avoid draining your battery and length-
en its life, observe the following indica-
tions:
❒when you park the car, ensure the
doors, tailgate and bonnet are closed
properly;
❒the ceiling lights must be off. The car
is however provided with an auto-
matic system for switching off internal
lights;
❒do not keep accessories (e.g.: sound
system, hazard lights, etc.) switched on
for a long time when the engine is not
running;
❒before performing any operation on
the electrical system, disconnect the
battery negative cable;
❒battery terminals shall always be per-
fectly tightened. Batteries contain substances
that are very harmful for the
environment. You are advised
to have the battery changed
at a Fiat Dealership, which is properly
equipped for disposing of used batter-
ies respecting nature and the law.
If the car is left inactive for
long periods at cold, remove
the battery and store it in a warm
place to prevent freezing.
WARNING
When working on the bat-
tery or near it, always wear
the proper goggles.
WARNING
IMPORTANT A battery which is kept at
a charge of less than 50% (optical indica-
tor with dark colour without green area
in the middle) for any length of time will
be damaged by sulphation leading to a re-
duction in cranking power.
Moreover, this might lead to a higher risk
of the battery electrolyte freezing (this
may even occur at -10°C). If the car is in-
active for a long period of time, refer to
“Car inactivity”, in section “Correct use
of the car”.
If after buying the car, you want to install
electric accessories which require per-
manent electric supply (alarm, etc.) con-
tact Fiat Dealership whose qualified per-
sonnel, in addition to suggesting the most
suitable devices, will evaluate the overall
electric absorption, checking whether the
car’s electric system is capable of with-
standing the load required, or whether it
should be integrated with a more power-
ful battery.
183-206 Croma TRW GB 20-11-2006 15:03 Pagina 199

234
WARNING
LIGHTS AND
MESSAGES
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
– "table" setting .................................. 32
Side/taillights
– control ............................................. 54
– front bulb replacement ................. 163
– rear bulb replacement .................. 165
Sunroof.................................................... 70
Smart washing ...................................... 57
Snow chains .......................................... 135
Sound system ....................................... 92
Spark plugs
– type ................................................... 211
Starting the engine
– bump starting ................................. 151
– diesel engines ................................. 121
– ignition switch ................................ 17
– jump starting .................................. 150
– petrol engines ................................ 120
– stopping the engine ...................... 122
– warming up the engine ................ 122
Steering ................................................... 214
Steering column lock .......................... 17
Steering wheel adjustment ................ 35
Storing the car ..................................... 136
Sun visors .............................................. 69
Suspensions ........................................... 214
Symbols .................................................. 7
Table ..................................................... 32
Tailgate ................................................... 76
Technical specifications ....................... 207
Third brake light .................................. 166
Tools ...................................................... 153
Top speeds ............................................ 221
Towing a trailer
– tow hitch installation .................... 132
Towing the car ..................................... 181T.P.M.S. system ..................................... 91
Transmission ........................................ 213
Tyre pressure ......................... 218-219
Tyres
– changing ........................................... 151
– snow tyres ...................................... 134
– standard ........................................... 217
– understanding tyre marking......... 215
Universal Isofix child restraint
system ................................................. 109
Using the manual gearbox ................. 124
Using the automatic gearbox ............ 125
Ventilation ........................................... 39
Volumetric protection ........................ 13
Warning lights and messages........... 137
Weights ................................................. 222
Wheel geometry................................... 215
Wheel replacement ............................ 151
Wheels
– changing ........................................... 151
– spare wheel .................................... 217
Window washing .................................. 57
Windows (cleaning) ............................. 205
Windscreen and rear window
wiper blades ....................................... 202
Windscreen washer
– control ............................................. 57
– fluid level ......................................... 195
Windscreen wipers
– blades ............................................... 202
– control ............................................. 57
– nozzles ............................................. 203
Windscreen/rear window/
headlight washer fluid level ............. 195 Rear ceiling lights
– bulb replacement .......................... 169
– control .............................................. 62
Rear fog lights
– bulb replacement .......................... 164
– control button ............................... 64
Rear window washer
– control ............................................. 59
– fluid level ......................................... 195
Rear window wipers
– blades ............................................... 202
– control ............................................. 59
– nozzles ............................................. 203
Rearview mirrors
– door mirrors .................................. 36
– driving mirror ................................ 36
– electric ............................................. 36
Refuelling ............................................... 224
Rev. counter ......................................... 18
Reversing light ...................................... 164
Rims
– understanding rim marking .......... 215
Roof rack/ski rack ................................ 84
Safety devices ....................................... 99
Seat adjustment ................................... 31
Seat belts
– general warnings ........................... 103
– load limiters ..................................... 102
– maintenance ................................... 104
– use .................................................... 100
Seats
– cleaning ............................................ 205
– electrically adjustable front
seats ................................................... 33
– manually adjustable front seats ... 31
232-240 Croma TRW GB 17-11-2006 11:09 Pagina 234