Seat FIAT DOBLO 2007 1.G Service Manual

173VEHICLE MAINTENANCE
CLEANING SEATS
AND FABRICS
– Remove dust with a soft brush and
vacuum cleaner.
– Brush the seats with a damp
sponge with water and a neutral soap.
PLASTIC PARTS INSIDE THE
VEHICLE
Use appropriate products designed
to preserve the appearance of com-
ponents.
IMPORTANTDo not use alcohol
or petrol to clean the instrument pan-
el.
Do not keep aerosol
cans in the vehicle. There
is the risk they might ex-
plode. Aerosol cans must never
be exposed to a temperature
above 50°C; when the weather
starts to get hot the temperature
inside the vehicle might go well
beyond that figure. INTERIORS
From time to time check that water
has not collected under the mats
(from dripping shoes, umbrellas etc.)
which could cause the steel to rust.
Never use inflammable
products such as petrole-
um ether or petrol to
clean inside the vehicle. The elec-
trostatic charges that are gener-
ated while rubbing to clean could
become a fire risk.
STEERING WHEEL / GEAR
LEVER KNOB WITH
GENUINE LEATHER
COVERING
These components shall only be
cleaned with water and neutral soap.
Never use spirit or alcohol-based
products.
Before using special products for
cleaning interiors, read carefully label
instructions and indications to make
sure they are free from spirit and/or
alcohol-based substances.
If when cleaning the windscreen with
special glass products, some drops fall
on the leather covering of the steer-
ing wheel/gear lever knob remove
them immediately and then clean with
water and neutral soap.
IMPORTANTTake the utmost
care when engaging the steering lock
to prevent scratching the leather cov-
ering.

174TECHNICAL SPECIFICATIONS
VEHICLE IDENTIFICATION
DATA CHASSIS MARKING
fig. 1
It is printed on the passenger com-
partment floor, near the right-hand
front seat.
It can be reached by lifting the spe-
cial flap in the carpeting and includes
the following data:
– vehicle model ZFA 223000;
– chassis number.MODEL PLATE
The plate A-fig. 2-3, is applied to the
front engine crossmember.
T T
E E
C C
H H
N N
I I
C C
A A
L L
S S
P P
E E
C C
I I
F F
I I
C C
A A
T T
I I
O O
N N
S S
fig. 1
F0A0163b
fig. 2 - 1.4 8Vversions
F0A0537b
fig. 3 - Multijet versions
F0A0538b
ENGINE MARKING
The marking is stamped on the cylin-
der block and includes the model and
the serial number.

176TECHNICAL SPECIFICATIONS
ENGINE CODES - BODYWORK VERSIONS
EUROPEAN HOMOLOGATION
Engine Engine code
1.4 8V 350A1000
Versions Bodywork
version code
Cargo 223ZXP1AAX
Cargo high roof 223ZXP1ABX
Cargo extra capacity 223WXP1AAX
Cargo high roof - extra capacity 223WXP1ABX
Cargo small capacity 223ZXP1AAY
Cargo high roof - small capacity 223ZXP1ABY
Cargo Maxi (long wheelbase) 223WXP1AAXL
Cargo Maxi (long wheelbase) - small capacity 223WXP1AAYL
5 seater combi N1 223WXP1AAZ
Panorama 223AXP1A10
Panorama high roof 223AXP1A10B
7 seater family 223AXP1A10C
HOMOLOGATION FOR SPECIFIC MARKETS
Engine Engine code
1.4 8V 350A1000
Versioni Bodywork
version code
Cargo 223ZXP1AXX
Cargo high roof 223ZXP1AXY
Cargo extra capacity 223WXP1AXX
Cargo high roof - extra capacity 223WXP1AXY
Cargo Maxi (long wheelbase) 223WXP1AXXL
5 seater combi N1 223WXP1AXZ
Panorama 223AXP1AXX
Panorama high roof 223AXP1AXXB
7 seater family 223AXP1AXXC

177TECHNICAL SPECIFICATIONS
EUROPEAN HOMOLOGATION
Engine Enginecode
1.3 Multijet 199 A 2000
Versions Bodywork
version code
Cargo 223ZXN1AAX
Cargo high roof 223ZXN1ABX
Cargo extra capacity 223WXN1AAX
Cargo high roof - extra capacity 223WXN1ABX
Cargo small capacity 223ZXN1AAY
Cargo high roof - small capacity 223ZXN1ABY
Cargo Maxi (long wheelbase) 223WXN1AAXL
Cargo Maxi (long wheelbase) - small capacity 223WXN1AAYL
5 seater combi N1 223WXN1AAZ
Engine Engine
code
1.3 Multijet 85 HP 223 A 9000
Versions Bodywork
version code
Cargo 223ZXM1AAX
Cargo high roof 223ZXM1ABX
5 seater combi N1 223ZXM1AAZ
Panorama 223AXM1A08D
Panorama high roof 223AXM1A08B
7 seater family 223AXM1A08E
HOMOLOGATION FOR SPECIFIC MARKETS
Engine Enginecode
1.3 Multijet 199 A 2000
Versions Bodywork
version code
Cargo 223ZXN1AXX
Cargo high roof 223ZXN1AXY
Cargo extra capacity 223WXN1AXX
Cargo high roof - extra capacity 223WXN1AXY
Cargo Maxi (long wheelbase) 223WXN1AXXL
5 seater combi N1 223WXN1AXZ

178TECHNICAL SPECIFICATIONS
EUROPEAN HOMOLOGATION
Engine Engine code
1.9 Multijet 105 HP 223 B 1000
Versions Bodywork
version code
Cargo 223ZXL1AAX
Cargo high roof 223ZXL1ABX
Cargo extra capacity 223WXL1AAX
Cargo high roof - extra capacity 223WXL1ABX
Cargo small capacity 223ZXL1AAY
Cargo high roof - small capacity 223ZXL1ABY
Cargo Maxi (long wheelbase) 223WXL1AAXL
Cargo Maxi (long wheelbase) - small capacity 223WXL1AAYL
5 seater combi N1 223WXL1AAZ
Panorama 223AXL1AA07
Engine Engine
code
1.9 Multijet 100 HP 223 B 2000
Versions Bodywork
version code
Cargo 223ZXR1AAX
Cargo high roof 223ZXR1ABX
Cargo extra capacity 223WXR1AAX
Cargo high roof - extra capacity 223WXR1ABX
Cargo Maxi (long wheelbase) 223WXR1AAXL
HOMOLOGATION FOR SPECIFIC MARKETS
Engine Engine code
1.9 Multijet 105 HP 223 B 1000
Versions Bodywork
version code
Cargo 223ZXL1AXX
Cargo high roof 223ZXL1AXY
Cargo extra capacity 223WXL1AXX
Cargo high roof - extra capacity 223WXL1AXY
Cargo Maxi (long wheelbase) 223WXL1AXXL
5 seater combi N1 223WXL1AXZ
Panorama 223AXL1AXX

179TECHNICAL SPECIFICATIONS
EUROPEAN HOMOLOGATION
Engine Engine code
1.9 Multijet 120 HP 186 A 9000
VersionsBodywork version code
Cargo 223ZXH1AAX
Cargo high roof223ZXH1ABX
Cargo Maxi (long wheelbase)223ZXH1AAXL
5 seater combi N1223ZXH1AAZ
Panorama 223AXH1A06
Panorama high roof223AXH1A06B
7 seater family223AXH1A06C
ENGINE
GENERAL FEATURES1.4 8v
Type code 350A1000
Cycle Otto
Number and layout of cylinders 4 in line
Piston bore and stroke mm 72,0 x 84
Total displacement cm31368
Compression ratio 11,1 : 1
Max power (CEE):
kW 57
HP 77
corresponding ratio rpm 6000
Max torque (CEE):
Nm 115
kgm 11,7
corresponding ratio giri/min 3000
Spark plugs NGK ZKR7A - 10
Fuel Unleaded
petrol
95 RON

185TECHNICAL SPECIFICATIONS
COLD INFLATION PRESSURES (bar)
Versions Size Medium load Full load
Front Rear Front Rear
Passenger Transportation 185/65 R15 88T 2.3 (*) 2.3 (*) 2.3 2.7
Family (7 seater) 185/65 R15 92T 2.3 2.7 2.3 2.7
Cargo standard capacity/Combi N1185/65 R15 92T 2.3 2.7 2.3 2.7
Cargo extra capacity/Long wheelbase 175/75 R14 C99/98T 3.0 3.5 3.0 3.5
Combi N1 exra capacity 175/75 R14 C99/98T 2.8 3.0 3.0 3.5
Passenger Transportation Natural Power 175/70 R14 C95/93S 2.6 3.0 2.6 3.0
Cargo Natural Power 175/70 R14 C95/93S 2.8 3.5 2.8 3.5
With warm tyres the pressure should be +0.3 bar in relation to the prescribed value. Check again the correct pressure when the tyres are cold.
(*) Up to 3 people + 50 kg. Versions Steel Alloy Factory-fitted Alternative Tyre Space-saver
rim rim tyre min. sizes that (*)spare wheel
can be adopted (**)
Passenger Transportation 5,5 J x 15H2-ET32 5,5 J x 15H2-ET32 185/65 R15 88T 185/65 R15 88T185/65 R15 88Q (M+S)125/80 R15 95M
Family (7 seater) 5,5 J x 15H2-ET32 5,5 J x 15H2-ET32185/65 R15 92T 185/65 R15 88T185/65 R15 88Q (M+S) –
Cargo 5,5 J x 15H2-ET32 5,5 J x 15H2-ET32 185/65 R15 92T 175/75 R14 C99/98T185/65 R15 92Q (M+S) –
standard capacity/ (or EXTRA LOAD 175/70 R14 C95/93T
Combi N1or Reinforced)
Cargo 5,5 J x 14H2-ET32 5,5 J x 14H2-ET32 175/75 R14 C99/98T 175/75 R14 95S 175/75 R14 C99/98 Q (M+S) –
exra capacity/175/70 R14 95S
Long wheelbase/
Combi N1(where fitted)
Passenger Transportation 5,5 J x 14H2-ET32 5,5 J x 14H2-ET32 175/70 R14 C95/93S 175/70 R14 88T 175/70 R14 88 Q (M+S) –
Natural Power
Cargo Natural Power 5,5 J x 14H2-ET32 5,5 J x 14H2-ET32 175/70 R14 C95/93S – – –
(*) Tyres with load and speed index equal to or higher than the specified values are admitted
(**) When replacing tyres, you are however recommended to adopt tyres with load and speed ratings equal to or higher than those of the factory-fitted tyres.

186TECHNICAL SPECIFICATIONS
PERFORMANCE
Top admitted speed after running-in,
in km/h:
1.4 .................................................... 148
1.4 high roof................................ 145
1.4 7 plae ...................................... 145
1.3 Multijet 75 HP.................. 146
1.3 Multijet 85 HP.................. 153
1.3 Multijet 85 HP
high roof...................................... 150
1.3 Multijet 85 HP 7 place.... 150
1.9 Multijet 100/105 HP........ 168
1.9 Multijet 120 HP................ 175
1.9 Multijet 120 HP
high roof .................................... 172
1.9 Multijet 120 HP 7 place.. 172
DIMENSIONS
fig. 6
F0A0721b
Dimensions are expressed in mm.
Height is intended on an unladen ve-
hicle
Unladen boot volume (Fiat Doblò
Cargo versions): 3,2 m
3.Unladen boot volume (Fiat Doblò
Passengers Transport versions):
– standard conditions 750 dm
3;
– with rear table seat tilted 3000 dm
3.

198TECHNICAL SPECIFICATIONS
Weights (kg) - Fiat Doblò Passengers Transport versions - 7-seat
(*) If special equipment is fitted (wing window, tow hitch, etc.), the unladen vehicle weight increases, thus reducing the specified payload.
(**) Loads not to be exceeded. The driver is responsible for arranging the loads so that they comply with these limits.
1.4 8V
1320
7p+75
1010
1100
1920
1000
500
–
601.9
120HPMultijet
1430
7p+75
1010
1100
2030
1300
500
–
60
1.3 75HPMultijet
1420
7p+75
1010
1100
2020
1300
500
–
60
Weight empty (including fluids, 90% fuel in the tank and no optional)
Payload including driver (*):
Maximum allowed loads (**)
– front axle:
– rear axle:
– total:
Towable weight:
– Towable weight
– trailer without brakes
Maximum load on roof
Maximum load on ball coupling (trailer with brakes)

204TECHNICAL SPECIFICATIONS
FUEL
CONSUMPTIONIMPORTANT Road and traffic
conditions, weather, driving style,
fittings and accessories, load, roof
racks, special devices and over-
all vehicle conditions can penalise
aerodynamic penetration and in-
Fuel consumption according to European Directive 2004/3/EC
litres x 100 km)
fluence fuel consumption rates
which can be different from the
values shown in the table (see
“Cheap running that respects the
environment”). The fuel consumption figures given in
the table below are determined on the
basis of the homologation tests set
down by specific European Directives.
Consumption values are defined by
means of the following procedures:
– urban cycle:consisting of a cold
start and a simulated drive in city
streets;
– extra-urban cycle:consisting in
frequent accelerations, in all gears,
simulating normal conditions of use.
Speed ranges from 0 to 120 km/h;
– average combined cycle:con-
sisting of 37% urban cycle and 63% ex-
tra-urban cycle.
Urban Extra-urban Combined
1.49.2 6.3 7.4
1.4 high roof9.4 6.5 7.6
1.4 7 seater9.2 6.3 7.4
1.3 Multijet 75 HP6.5 4.7 5.4
1.3 Multijet 85 HP6.3 4.5 5.2
1.3 Multijet 85 HP high roof6.8 4.9 5.6
1.3 Multijet 85 HP 7 seater6.3 4.5 5.2
1.9 Multijet 100/105 HP7.5 4.8 5.8
1.9 Multijet 120 HP7.5 5.2 6.1
1.9 Multijet 120 HP high roof7.7 5.3 6.2
1.9 Multijet 120 HP 7 seater7.5 5.2 6.1