fuel pump FIAT DOBLO 2009 2.G Owners Manual

112
KNOW
YOUR
VEHICLE
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
SERVICING
AND
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
F0V0086mfig. 109
REFUELLING CAPACITY
To fill the tank completely, top up twice after the pump
switches off. Further top ups could cause faults in the fu-
el supply system. If using/parking the vehicle in mountainous/cold areas for
a long time, you should refuel with locally available diesel.
In this case, it is also advisable to keep the tank over 50% full.
For diesel engines, use only diesel fuel for
motor vehicles in accordance with EN590
European specifications. The use of other
products or mixtures may damage the engine be-
yond repair and consequently invalidate the war-
ranty, depending on the damage caused. If you ac-
cidentally introduce other types of fuel into the
tank, do not start the engine. Empty the tank. If the
engine has run, even for a very short time, you will
need to have the entire fuel supply system emptied
in addition to the tank.
FUEL TANK CAP fig. 109
To open
1) Open the flap A-fig. 109 by pulling it outwards, keep the
cap B still, insert the ignition key in the lock and turn it an-
ticlockwise.
2) Turn the cap anticlockwise and remove it. The cap has
a device C that attaches it to the flap so it cannot be lost.
When refuelling, attach the cap to the flap as illustrated
in the diagram.

184
KNOW
YOUR
VEHICLE
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
SERVICING
AND
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEXPROTECTED DEVICE FUSE AMPS FIGURE
ECM Engine control unit (power supply)
(1.3 Multijet Euro 4, 1.4 BZ, 1.6 Multijet – 2.0 JTD) F17 10 175
ECM Engine control unit, engine control system
management main relay F18 7,5 175
Climate control compressor F19 7,5 175
Heated rear window F20 30 175
Fuel pump on tank F21 15 175
Engine management system primary loads (1.3 Multijet Euro 4, 1.4) F22 15 175
Engine management system primary loads
(1.3 Multijet Euro / Euro 5, 1.6 Multijet – 2.0 JTD) F22 20 175
BSM Braking system ECU (control unit and solenoid unit) F23 20 175
BSM Braking system control unit (supply and key),
steering angle sensor F24 5 175
Fog lights F30 15 175
Glow plug pre-heating control unit
(1.3 Multijet Euro 4, 1.3 Multijet Euro 5, 1.6 Multijet – 2.0 JTD Euro 4 – Euro 5) F81 60 175
Rear window winder passenger’s side
(Doblò/Doblò Combi versions with manual gearbox) F82 20 175
Headlight washer pump F83 20 175

265
KNOW
YOUR
VEHICLE
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
SERVICING
AND
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
Front airbags ......................... 128
– deactivation...................... 130
– driver’s side..................... 129
– passenger’s side.............. 129
Front armrest ......................... 71
Front ceiling light ................... 65
– bulb replacement ........... 178
Front fog lights
– bulb replacement ............ 174
– switching on....................... 70
Front light clusters
– bulb arrangement ........... 172
Front seats............................... 31
– adjusting .......................30-31
– armrest .............................. 71
– cleaning ............................ 216
– headrests ........................... 37
– heating ..........................30-32
Fuel consumption .................249
Fuel cut-off system ................70Fuel economy....................... 137
Fuel flap ................................ 112
Fuel gauge ............................... 13
– type of fuel ............. 111-112
Fuel reserve warning
light ...................................... 150
Fuel reserve ......................... 246
Fuel supply
(technical data) .................. 224
Fuel tank (capacity) ............. 246
Fuel tank cap ....................... 112
Fuel
– at the pump ............ 111-112
– consumption ................... 249
– fuel cut-off system ........... 70
– gauge and reserve
warning light ..................... 13
– opening the flap ............. 112
– refuelling .................111-112
– specifications ..........111-112
– tank cap ........................... 112Fuse boxes
(location) ....................182-186
Fuse list
.......
182-183-184-185-186-187
Fuse replacement
– general information
and warnings.................... 181
– list
......
182-183-184-185-186-187
– location (fuse boxes)
.....................................182-186
Fuse summary table
.....182-183-184-185-186-187
Fuses
.....182-183-184-185-186-187
– general information
and warnings.................... 181
– location (fuse boxes)
...................................182-186
Gear stick.............................. 136
Gearbox................................ 136