run flat FIAT FIORINO 2008 Owner handbook (in English)

105
SAFETY
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARDAND CONTROLS
STARTING
AND DRIVING
USING THE GEARBOX
To engage the gears, press the clutch ped-
al fully and shift the gear lever A-fig. 2
into one of the required positions (the di-
agram is shown on the knob fig. 2).
IMPORTANT Reverse may only be en-
gaged when the vehicle is at a standstill.
With the engine running, wait for at least
2 seconds with the clutch pedal fully
pressed before engaging reverse to pre-
vent damage to the gears and grating.
fig. 2F0T0055m
Press the clutch pedal fully
to shift the gears correctly.
For this reason, there must be no ob-
stacles on the floor under the pedals:
make sure that the mats are always
flat and do not interfere with the ped-
als.
WARNING
Do not drive with your hand
resting on the gear lever as
the force exerted, even if
slight, could lead to prema-
ture wear on the gearbox internal com-
ponents over time. The clutch pedal
must be used for gear shift only. Nev-
er drive with the foot resting, even if
slightly, on the clutch pedal. For ver-
sions/markets where applicable the
clutch pedal control electronics can in-
tervene interpreting the wrong drive
style as a fault.
101-110 Fiorino GB 2ed 8-02-2008 15:08 Pagina 105

130
SAFETY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARDAND CONTROLS
STARTING
AND DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
QUICK TYRE REPAIR
KIT AUTOMATIC
FIX & GO
The automatic fast tyre repair kit Fix & Go
is placed in a container in the boot.
The tyre repair kit fig. 14includes:
❒a cylinder A containing sealant which is
fitted with:
– filling tube B;
– an adhesive label Cbearing the words
“max. 80 km/h”, to be attached in an
easy-to-see position for the driver (on
the dashboard) after tyre repair;
❒a compressor Dcomplete with a pres-
sure gauge and connections;
❒an instruction brochure (see fig. 15) to
be utilised for prompt and proper use
of the fast repair kit and to be handed
over to the personnel who will be in
charge of handling the repaired tyre;
❒a pair of safety gloves located in the side
space of the compressor;
❒adapters for inflating different elements.
The Fix & Go kit container also includes
some spare fuses.
fig. 14F0T0129mfig. 15F0T0130m
Give the instruction brochure
to the personnel who will be
in charge of repairing the tyre using
the kit.
WARNING
The kit cannot be used to re-
pair damage to the tyre side-
wall. Do not use the fast repair kit if
the tyre is damaged as the vehicle has
run a flat tyre.
WARNING
If the wheel rim is damaged
(the channel is so deformed
as to cause an air leakage) it cannot
be repaired. Do not remove the for-
eign body (screw or nail) from the tyre.
WARNINGIn the event of a puncture
caused by foreign bodies, it is
possible to repair tyres show-
ing damages on the track or
shoulder up to max 4 mm diameter.
123-154 Fiorino GB 2ed 8-02-2008 15:27 Pagina 130

186
SAFETY
INDEX
DASHBOARDAND CONTROLS
STARTING
AND DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
1.4
1.3 Multijet
COLD TYRE INFLATION PRESSURES (bar)
Add +0.3 bar to the prescribed inflation pressure when the tyres are warm. Recheck pressure value with cold tyres.
With snow tyres, add +0.2 bar to the inflation pressure value prescribed for standard tyres.
When running over 160 km/h, inflate tyres at full load inflation values.
175/70 R14 2.5 2.5 2.5 2.5 2.5 2.5
185/65 R15 2.3 2.5 2.3 2.5 2.3 2.5 Tyre size TYRES SUPPLIED
Loadless Medium load Full load
Front Rear Front Rear Front Rear
VERSIONS RIMS TYRES SPARE WHEEL
(where provided)
In std supply Snow Rim Tyre
51/2J x 14 H2 – ET44 175/70 R14 – 51/2J x 14 H2 – ET44 175/70 R14
5
1/2J x 15 H2 – ET44 185/65 R15 185/65 R15Q (M+S) 51/2J x 15 H2 – ET44 185/65 R15
5
1/2J x 14 H2 – ET44
175/70 R14–51/2J x 14 H2 – ET44 175/70 R14
5
1/2J x 15 H2 – ET44
185/65 R15185/65 R15Q (M+S) 51/2J x 15 H2 – ET44 185/65 R15
177-198 Fiorino GB 2ed 8-02-2008 15:18 Pagina 186

201
WARNING
LIGHTS AND
MESSAGES
DASHBOARDAND CONTROLS
SAFETY
STARTING
AND DRIVING
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
Steering column controls
– left lever ......................................... 49
– right lever ....................................... 51
Steering lock ........................................ 14
Steering wheel ..................................... 38
Sun visors ............................................. 60
Suspensions .......................................... 183
Symbols ................................................. 7
Technical specifications............. 177
Tyres
– inflation pressures ........................ 186
– replacement ................................... 127
– snow tires .............................109-186
– standard .......................................... 186
– tire data .......................................... 184
Towing the vehicle ............................. 154
Trailer towing ...................................... 108
Transmission ........................................ 182
Trip computer ..................................... 31
Trunk
– emergency opening ...................... 67
– extension ........................................ 69
– load restraint ................................. 70
– shelf removal ................................. 68
Turn signal lights
– control ............................................ 50– front bulb replacement ............... 138
– lane change function .................... 50
– rear bulb replacement ................. 140
– side bulb replacement ................. 139
Ventilation .......................................... 41
Warning lights and messages.. 111
Weights ................................................ 190
Wheel (changing) ................................ 125
Wheel geometry ................................. 184
Wheel rims (correct reading) ..........185
Wheels and tyres ......................169-184
Window winders ................................ 66
Windshield washer
– control ............................................ 51
– liquid level ...................................... 164
Windshield wiper
– blades .............................................. 171
– control ............................................ 51
– intelligent wash ............................. 51
– nozzles ............................................ 172
Wiper blades ..............................171-172 – interior ........................................... 39
– power-operated ........................... 40
Refuelling .............................................. 81
Removable roof lamp ........................ 55
Right hand drive versions .......... 197
Roof lights
– bulb replacement
– on/off control ......................53-54-55
Roof struts
– retentions ....................................... 72
Rubber hoses ....................................... 170
Safety.................................................. 83
Saving fuel ............................................. 106
SBR system .......................................... 85
Seat belt pretensioners ..................... 86
Seat belts (use) .................................... 84
Seats
– adjustments .................................... 33
– cleaning ........................................... 176
– foldaway passenger seat .............. 34
– heated ............................................. 33
Snow chains ......................................... 110
Spark plugs (type) ............................... 181
Specifications ....................................... 177
Starting and driving...................... 101
Stationary vehicle ............................... 104
Steering ................................................. 183
199-208 Fiorino GB 2ed 8-02-2008 16:47 Pagina 201

ENGINE OIL CHANGE
1.4-1.3 Multijet
Tank capacity45
Reserve6÷7
Refuel petrol engines with unleaded petrol with octane rating (RON) no lower than 95 only (EN 228 Specifications)
Refuel diesel engines with diesel fuel for motor vehicles only (EN 590 Specifications)
FUEL CAPACITIES (litres)
Fiat Group Automobiles S.p.A. - Customer Services - Technical Services - Service Engineering
Largo Senatore G. Agnelli, 5 - 10040 Volvera - Torino (Italia) - Print n. 603.81.344 - 01/2008 - 2ndediition
Add +0.3 bar to the prescribed inflation pressure when the tyres are warm. Recheck pressure value with cold tyres.
With snow tyres, add +0.2 bar to the inflation pressure value prescribed for standard tyres.
When running over 160 km/h, inflate tyres at full load inflation values.
1.4 1.3 Multijetlitres kg litres kg
Fuel tank 2.7 2.4 3.0 2.6
Engine sump and filter 3.0 2.6 3.2 2.8
COLD TYRE INFLATION PRESSURES (bar)
175/70 R14 2.5 2.5 2.5 2.5 2.5 2.5
185/65 R15 2.3 2.5 2.3 2.5 2.3 2.5 Tyre size TYRES SUPPLIED
Loadless Medium load Full load
Front Rear Front Rear Front Rear
199-208 Fiorino GB 2ed 8-02-2008 16:47 Pagina 208