checking oil FIAT FIORINO 2008 Owner handbook (in English)

116
SAFETY
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARDAND CONTROLS
STARTING
AND DRIVING
WARNING
LIGHTS AND
MESSAGES
Exhausted oil
(Multijet versions with DPF,
where provided)
The warning light turns on and flashes
along with the message on the display
when the system detects that the engine
oil is exhausted.
After the first indication, at each engine
start-up, the warning light continues to
flash for about 60 seconds and then every
2 hours until the oil is changed.SEAT BELTS
NOT FASTENED
(red)
The warning light in the panel
turns on steadily when the vehicle is not
running and the seat belt on the driver’s
side is not correctly fastened. The warn-
ing light blinks, and a buzzer goes off, when
the vehicle is running and the front seat
belts are not correctly fastened.
The buzzer of the S.B.R. (Seat Belt Re-
minder) system can only be switched off
by a Fiat Dealership.
On some versions the system can be re-
activated from the setup menu.INCOMPLETE
DOOR LOCKING (red)
On certain versions the warning
light turns on when one or more doors or
the tailgate are not properly shut.
On certain versions the dedicated mes-
sage is displayed.
MINIMUM
ENGINE OIL LEVEL
(red)
Turning the ignition key to MARthe
warning light on the panel turns on, but
it should go off after a few seconds.
The warning light goes on in the panel
when the oil level drops below the mini-
mum value. Top up the oil to the correct
level (see “Level checking” in section
“Maintenance and care”).
On certain versions the dedicated mes-
sage is displayed.
<´
k
If warning light vflashes,
contact the Fiat Dealership as
soon as possible to have the
oil changed and the instru-
ment panel warning light turned off.
111-122 Fiorino GB 2ed 8-02-2008 15:08 Pagina 116

161
SAFETY
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARDAND CONTROLS
STARTING
AND DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
PERIODIC CHECKING
Every 1,000 km or before long journeys,
check and top up if required:
❒engine coolant fluid level;
❒brake fluid level;
❒windscreen washer fluid level;
❒tyre pressure and conditions;
❒operation of lights (headlights, direction
indicators, emergency lights, etc.);
❒operation of the windscreen wiper/
washer system, position and wear of
the windscreen and rear window wiper
blades (where provided);
Every 3,000 km check the following and
top-up, if required: engine oil level.
You are recommended to use FL Sele-
niaproducts, designed and produced
specifically for Fiat vehicles (see table “Re-
fuelling” in section “Technical specifica-
tions”).
DEMANDING
VEHICLE USE
Should prevailing use of the vehicle be un-
der one of the following specially heavy
conditions:
❒trailer towing;
❒dusty roads;
❒short repeated distances (less than 7-
8 km) and with external temperatures
below zero;
❒frequently idling engine or long distance
low speed driving (e.g. taxis or door-to-
door deliveries) or in case of a long
term inactivity;
❒urban driving;
perform the following inspections more
frequently than shown on the Scheduled
Servicing Plan:
❒check front disk brake pad conditions
and wear;❒check cleanness of bonnet and boot
locks and lever cleanness and lubrica-
tion;
❒visually inspect the conditions of: the
engine, gearbox, transmission, pipes and
hoses (exhaust - fuel - brakes), rubber
parts (boots, sleeves, bushes, etc.);
❒check the battery and the battery fluid
(electrolyte) (this check must be car-
ried out by skilled personnel only or by
the Fiat Dealership – also refer to the
instructions provided in the “Battery”
paragraph of this section);
❒visually check the various drive belt
conditions;
❒check pollen filter and replace it, if re-
quired;
❒check air cleaner and replace it, if re-
quired.
155-176 Fiorino GB 2ed 8-02-2008 15:10 Pagina 161

162
SAFETY
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARDAND CONTROLS
STARTING
AND DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
CHECKING
FLUID LEVELS
Do not smoke while working
on the engine compartment.
Flammable gases may be present. Risk
of fire.
WARNING
Be careful not to confuse the
various types of fluids while
topping up: they are incom-
patible. For this reason, the
vehicle may be seriously damaged.
fig. 1 - 1.4 version
fig. 2 - 1.3 Multijet versionFF0T0083m
F0T0076m
1 engine oil - 2 battery - 3 brake fluid -
4 window/rear window washer fluid -
5 engine coolant - 6 power steering sys-
tem fluid
155-176 Fiorino GB 2ed 8-02-2008 15:10 Pagina 162

199
WARNING
LIGHTS AND
MESSAGES
DASHBOARDAND CONTROLS
SAFETY
STARTING
AND DRIVING
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
– version coding ............................... 180
Brake lights
– bulb replacement .......................... 140
Brakes..................................................... 185
Bulb replacement ................................ 134
Bulkheads ............................................. 36
Capacities ............................................ 192
Car radio (provision for) .................. 79
Child carriers ....................................... 89
Checking fluid levels ........................... 162
Childproof device ............................... 63
Choke ................................................... 14
Cigar lighter ......................................... 59
Clutch ................................................... 182
CO
2emissions .................................... 196
Controls ............................................... 56
Dashboard and controls............ 4
Dead lock device ................................ 11
Digital display ....................................... 17
Dimensions .......................................... 187
Doors
– centralized lock/unlock ............... 61– childproof safety ........................... 63
– double panel rear doors ............. 64
– sliding side doors .......................... 62
Driver protector ................................ 37
EBD system ........................................ 74
Electrical/electronic
devices installation............................ 80
Engine codes- Engine compartment
(servicing) .......................................... 175
Engine hood ......................................... 70
Engine oil
– consumption .................................. 163
– level check ..................................... 165
Engine starting ...........................102-124
Engine
– fuel system ..................................... 182
– identification codes ...................... 180
– powertrain ..................................... 182
– specification ................................... 181
Environmental protection ................. 82
EOBD system ...................................... 76
Fiat CODE (system) ......................... 7
Fix&Go (device) .................................. 130
ABS (system) ...................................... 74
Air cleaner/anti/pollen ....................... 167
Air outlets ............................................ 42
Airbag
– front ................................................ 96
– side .................................................. 98
Alarm .................................................... 12
Ash tray ................................................ 59
Backlight washer
– control ............................................ 52
– liquid level ...................................... 164
Backlight wiper
– blade ................................................ 172
– control ............................................ 52
– nozzle .............................................. 172
Backup light
– bulb replacement .......................... 140
Battery
– recharging ...................................... 153
– replacement ................................... 167
Body versions ...................................... 180
Body
– maintenance .................................. 173
II I
N N
D D
E E
X X
199-208 Fiorino GB 2ed 8-02-2008 16:47 Pagina 199