engine coolant FIAT LINEA RHD 2010 1.G User Guide

DEMANDING USE
OF THE CAR
Should prevailing use of the car be under
one of the following specially heavy con-
ditions:
trailer or caravan towing;
dusty roads;
short distances (less than 7-8 km) re-
peated and with external temperatures
below zero;
frequently idling engines or long dis-
tance low speed driving (e.g . taxis or
door-to-door deliveries) or in case of
a long term inactivity;
in cities;
perform the following inspections and
shown on the Service Schedule:

check cleanness of locks, bonnet and
boot and lever cleanness and lubrica-
tion;
visually inspect the conditions of: en-
gine, gearbox, transmission, pipes and
hoses (exhaust - fuel - brakes), rubber
parts (boots, sleeves, bushes, etc.);
check battery charge and liquid level
(electrolyte) (see paragraph “Charge
level check” in chapter “Maintenance
and care”);
visually inspect the accessory drive belt
conditions;
check pollen filter
check air cleaner and replace, if re-
quired.
REGULAR
INSPECTIONS
Every 1,000 km or before long journeys,
check and top up if required:
 engine coolant fluid level; Engine Oil level, every 3,000 km and
brake - clutch fluid level and type;
power steering fluid level;


tyre pressure and conditions;
operation of lights (headlights, direction
indicators, hazard lights, etc.);
143
CAR
MAINTENANCE
CORRECT USE
OF THE CAR
TECHNICAL
INDEX
DASHBOARD
SAFETY
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
SPECIFICATIONS
AND CONTROLS
DEVICES
. If the vehicle is
replacements more frequently than
check front disk brake pad conditions
and wear; frequently than required; replace engine oil and oil filter more
frequently
than required on the service replace spark plugs more
schedules, in particular contact a Fiat
Dealership if a reduction in the
vehicle engine performance is noted;used frequently in dusty or heavily
polluted environments it is
advisable to replace the filtering
elementts more frequently, in
particular it should be replaced if a
reduction of the amount of air
admitted to the passenger
compartment is noted; top up if required;
LINEA Owner HAND BOOK RHD.pdf 143LINEA Owner HAND BOOK RHD.pdf 1438/21/09 2:16:22 PM8/21/09 2:16:22 PM

CHECKING FLUID
fig. 1 - 1.4 16V version
Never smoke while working
in the engine compartment.
Flammable gases may be present.
Risk of fire.
WARNING
Be careful not to confuse the
various types of fluids while
topping up: they are all reci-
procally incompatible and
may severely damage your car.
1.Engine coolant
2.Battery
3.Windscreen washer fluid
4.Brake fluid
5.Engine oil
6.Power steering fluid
F0R0243m
144
CORRECT USE
OF THE CAR
AND CONTROLS
DEVICES
SPECIFICATIONS
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
CAR
MAINTENANCE
INDEX
DASHBOARD
SAFETY
TECHNICAL
LINEA Owner HAND BOOK RHD.pdf 144LINEA Owner HAND BOOK RHD.pdf 1448/21/09 2:16:22 PM8/21/09 2:16:22 PM

fig. 2 - 1 .3 Multijet version
6
F0R0235m
1.Engine oil
2.
Engine coolant
3.Windscreen washer fluid
4.Brake fluid
5.Battery
6.Power steering fluid.
5
3 2 4
1
145
CAR
MAINTENANCE
CORRECT USE
OF THE CAR
TECHNICAL
INDEX
DASHBOARD
SAFETY
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
SPECIFICATIONS
AND CONTROLS
DEVICES
LINEA Owner HAND BOOK RHD.pdf 145LINEA Owner HAND BOOK RHD.pdf 1458/21/09 2:16:27 PM8/21/09 2:16:27 PM

WINDSCREEN WASHING
FLUID fig. 6
To top up, remove the cap A.
Pour a mixture of 10% of fluid SC 35 &
90% of distil led water and check level
through the reservoir.
ENGINE COOLANT fig. 5
The coolant level must be checked when
the engine is cold and must be between
the MINand MAXlines on the vessel.
fig. 5F0R0136mfig. 6
PARAFLU UP antifre eze is
used in the engine cooling sys-
tem .
Use fluid of the sam e
type contained in the cooling
system for top-ups. PARAFLU UP may
not be mixed with other types of fluids.
If this accidentally occurs, do not start
the engine and contact a Fiat Dealer-
ship.
The cooling system is pres-
surised. If required, replace
the cap with an original spare part so
as not to compromise system effi-
ciency. Do not remove the cap from
the vessel
when the engine is hot: risk
of burns.
WARNING
F0R0137m
If the level is low, slowly pour a mixture of
40% PARAFLU UP & 60% deminerali-
zed water through filler A of the vessel un-
til the level approaches the MAXline.
Waste engine oil and oil filters
contains substances which are
dangerous for the environ-
ment. It is advisable to have
oil and filte rs changed by a Fiat
Dealership where they will be dispos-
ed of according to the law.
Always top up using engine oil
of the same types as that al-
ready in the engine.
147
CAR
MAINTENANCE
CORRECT USE
OF THE CAR
TECHNICAL
INDEX
DASHBOARD
SAFETY
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
SPECIFICATIONS
AND CONTROLS
DEVICES
LINEA Owner HAND BOOK RHD.pdf 147LINEA Owner HAND BOOK RHD.pdf 1478/21/09 2:16:34 PM8/21/09 2:16:34 PM

176
CORRECT USE
OF THE CAR
AND CONTROLS
DEVICES WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
SAFETY
Dimensions ........................................ 169
Dipped beam headlights
- control ........................................... 51
- bulb replacement ........................ 122
Direction indicators
- control ........................................... 52
- front bulb replacement ..............
122
- rear bulb replacement ............... 123
- side bulb replacement ................
123
Doors .................................................. 64
Engine
- identification code ...................... 161
- marking ..........................................
160
- technical data ............................... 162
Engine compartment
- washing ..........................................
156
Engine coolant ...................................
147
Engine coolant temperature gauge .. 15
Engine oil
- consumption ................................ 146
- level check .................................... 146
- specifications ................................
173
EOBD system .................................... 72
External lights .................................... 51
Fiat CODE system .......................... 6
Flashing the headlights ..................... 51
Fluid levels ..........................................
146
Fluids and lubricants ........................ 173
Follow me home (device) ............... 52
Front ceiling lights
- bulb replacement ........................ 126
- control ........................................... 54
Front fog lights
- bulb replacement ........................ 123
- control button ............................. 57
Fuel
- level gauge .................................... 15
Fuel cut-off switch ............................ 59
Fuel filler cap ..................................... 76
Fuel level gauge ................................. 15
Fuses (replacement) ........................ 128
Gearbox
- using manual gearbox .................
97
Glass holder - can holder ............... 62
Glove box/oddment compartment .. 60
Handbrake ........................................ 96
Hazard lights ...................................... 57
Head restraints
- front ............................................... 33
- rear .................................................
34
Headlights
- beam adjustment ......................... 70
Heated rear window ....................... 42
Heating and ventilation ................... 37
Identification data ............................ 160
Ignition device ................................... 12
In an emergency ............................... 111
Instrument panel .............................. 13
Instruments ....................................... 14
Interior fittings .................................. 60
Interiors ............................................. 157
Jack ..................................................... 114
jacking the car ...................................
116
LINEA Owner HAND BOOK RHD.pdf 176LINEA Owner HAND BOOK RHD.pdf 1768/21/09 2:16:38 PM8/21/09 2:16:38 PM