belt FIAT PALIO 2003 178 / 1.G India Version Owner's Manual

85
10)Fit the wheel cup in order that
the biggest hole
A-fig. 8is aligned with
the bolt fixing the wheel. When fitting
the wheel cup make sure that the sym-
bol
Y, printed on the internal part of
the cup, is aligned with the inflation
valve.
11)Fit the last three bolts and tight-
en them using the wrench provided,
fig. 9.
12)Wind down the jack to lower
the vehicle and remove the jack.
13)Fasten bolts completely, work-
ing in a criss-cross fashion as shown in
fig. 10. Tightening torque: 86 Nm.
14)Arrange the punctured tyre in
the spare wheel compartment and se-
cure it with the locking device
A-fig.
11
.
fig. 7
P4E01754
15)Lower the carpet.
16)Put back the jack, the operating
handle and the wheel bolt wrench in-
to the tool bag.
17)Secure the tool bag to the in-
ternal boot wall with the relevant re-
taining belts.
fig. 8
P4E02176
fig. 9
P4E02377
IMPORTANT As soon as possible:
have the punctured tyre repaired and
mount it on the car thus limiting the
distance travelled with the spare
wheel.
IMPORTANT Check the inflation
pressure of the tyres and the spare
wheel regularly.
fig. 10
P4E02178
fig. 11
P4E02375
80-103 03/03/2003 06:49 PM Page 85

102
IF ANYONE IS INJURED
– Never leave the injured person
alone. The obligation to provide as-
sistance exists even for those not di-
rectly involved in the accident.
– Do not congregate around the in-
jured person.
– Reassure the injured person that
help is on its way and will arrive soon.
Stay close by to calm him/her down in
case of panic.
– Unfasten or cut seat belts holding
injured parties.
– Do not give an injured person any-
thing to drink.
– Do not move an injured person un-
less the following situation arise.
– Pull out the injured person from
the car only if there is a risk of it catch-
ing fire, sinking in water or is likely to
fall over a cliff or etc. Do not pull
his/her arms or legs, do not bend the
head and, as far as possible, keep the
body horizontal.
IF AN ACCIDENT
OCCURS
– It is important to keep calm.
– If you are not directly involved in
the accident, stop at least ten metres
away from the accident.
– If you are on a motorway, stop
without obstructing the emergency
lane with your car.
– Turn off the engine and turn on the
hazard lights.
– At night, illuminate the scene of the
accident with your headlights.
– Act carefully, you must not risk be-
ing run over.
– If the doors are blocked, do not at-
tempt to smash the windscreen to get
out of the car. It is made of layered
glass and is very hard. Side and rear
windows are much more easily bro-
ken.
– Mark the accident by putting the
red triangle at the regulatory distance
from the car where it can be clearly
seen. – Call for rescue making the infor-
mation you give as accurate as you
can. On the motorway use the special
column-mounted emergency phones.
– In pile-ups on the motorway, par-
ticularly when the visibility is bad,
there is a high risk of other vehicles
running into those already stopped.
Get out of the car immediately and
take refuge behind the guard-rail.
– Remove the ignition keys from the
vehicles involved.
– If you can smell petrol or other
chemicals, do not smoke and make
sure all cigarettes are extinguished.
– Use a fire extinguisher, blanket
sand or earth to put out fires, how-
ever small they may be. Never use wa-
ter
80-103 03/03/2003 06:49 PM Page 102















106
Thousands of kilometers 15 3045 6075 90105 120135 150165 180
SERVICE SCHEDULE
Check of conditions and weariness of tyres
Check front disc brake pad
Check of conditions and weariness of rear drum brake gasket
Visually inspect: underbody protection, pipes
(exhaust - fuel supply - brakes), rubber elements
(guards - sleeves - bushes - etc.), supply and brake system tubing
Voltage check and possible adjustment of trapezoidal belts
and/or poly-V
Inspect conditions of V belts and/or ploy v-belts
Tappet clearance check/adjustment (petrol version)
(excluding the versions with hydraulic tappets)
Check and adjust tappet clearance (diesel version)
Check/adjustment of the stroke of the lever hand brake
Check evaporation system (diesel version)
Visually inspect fuel evaporation system (connections, lines,
containers, seals and filler cap)
Fuel filter replacement (see “important” in the “Additional
interventions” in this chapter) (for diesel version replace the filter
every 7,500 km)
Replace air cleaner cartridge (diesel version) (see “important” in the
“Additional interventions” in this chapter)
Replace air cleaner cartridge (see “Additional checks” in this chapter)
104-127 03/03/2003 06:53 PM Page 106

107
Thousands of Kilometers 15 3045 6075 90105 120135 150165 180









(*) or every 3 years if the car is used in the following harsh conditions:
- Prolonged use in cold/hot climates, sity driving with prolonged lengths of time at idle speed, driving on dusty roads or roads covered with sand/salt.
- or every 5 years regardless of km covered and use conditions.
NOTE: For every 7,500 km service please refer Owner’s Warranty & Service Policy book.
For every 7,500 km or 6 months (whichever is erlier from previous service) replace engine oil and oil filter.
Top up fluids (engine coolant, brakes, power steering, windscreen washer etc.)
Timing command toothed belt check
Timing command toothed belt replacement
Spark plugs replacement, wire control (*)
Engine control system functionality check
(through autodiagnostic socket)
Change gear/differential gear oil level check
Changing engine oil (every 7,500 km or 6 months)
Replace engine oil filter (every 7,500 km or 6 months)
Brake fluid replacement (or every 24 months)
104-127 03/03/2003 06:53 PM Page 107

146
Main beam headlights
- control ..................................... 13-41
- flashing...................................... 13-42
- bulb replacement ................... 88
Maintenance
- Additional interventions ..... 108
- servicing schedule.................. 105
- servicing schedule plan......... 106
Max speeds ................................... 138
Paintwork identification
plate ............................................ 130
Paintwork
- maintenance .......................... 126
- Identification plate ............... 130
Parking ........................................... 67
Passenger compartment air vents 38
Performances ................................ 138
Periodic checks and before
long distances........................... 78
Plate light ...................................... 92
Power steering fluid level ......... 114
Pretensioners ................................ 32
Protecting emission control
devices ....................................... 74Protecting the environment ..... 63
Raising the car .......................... 99
Ready to start ............................... 8
Rear mirror
- rear view mirrors .................. 14-24
- driving mirror ......................... 23
Rear window washer
- control ..................................... 13-43
- fluid level ................................ 114
Rear window wiper
- controls.................................... 13-43
- blades ...................................... 127
- sprayer ..................................... 124
Rev counter................................... 34
Reversing lights
(bulb replacement) ................. 90
Roof rack ....................................... 55
Safe driving
- travelling ................................. 70
- driving with ABS ................... 73
- driving in rain.......................... 71
- driving at night ...................... 71
- driving in the mountains ...... 72- driving in fog ........................... 71
- driving on snow and ice .... 72
- before driving ........................ 69
Seat belts ........................................ 12-24
- general warnings .................... 27
- use ..................................... 12-24-26
- maintenance .......................... 28
- adjusting the height of the
seat belts ................................ 12-25
Seats
- cleaning .................................... 127
- adjustments ............................. 11-22
Side/tail lights
- control .................................... 13-41
- front bulb replacement ...... 89
- rear bulb replacement.......... 90
Side/tail lights
- control ..................................... 13-42
- front bulb replacement ...... 89
- side bulb replacement ......... 89
- rear bulb replacement.......... 90
Snow chains ................................. 77
Sound system ............................... 60
- aerial ......................................... 62
- standard equipment .............. 61
144-152 03/03/2003 07:30 PM Page 146